Académique Documents
Professionnel Documents
Culture Documents
User manual
1
Foreword
This manual is the operating instructions of the CT-4000P jammer (referred to as the “unit” in this
manual). The CT-4000P jammer is a jamming device intended to prevent communications Drones. The
unit outputs 2-10W for each of the Four bands 2400-2500MHz: 8W, 5.7-5.9GHz:2W, GPS L1
1570-1620MHz: 10W, 2400-2500MHz 8W
CH1: 2400-2500MHz:8W
CH2: 5.7-5.9GHz:2W
CH3: GPS L1 + Glonass L1: 1570-1620MHz 10W
CH4: 2400-2500MH: 8W
Safety guidelines
Read the following guidelines before using the unit. Failure to comply with these guidelines
may be dangerous or illegal. In any event of doubt, consult your local distributor or Vendor’s
support staff before use.
Environmental conditions
Do not place the unit near heat sources. The unit dissipates a lot of heat. Never block its
ventilation holes and do not insert any objects through them.
Qualified service
Only trained service personnel qualified by Vendor are allowed to diagnose and maintain the unit in
accordance with established safety practices and standards.
2
Features
Jamming frequency
CH1: 2400MHz – 2500MHz:8W WiFi
CH2: 5.7GHz – 5.9GHz : 2W
Ch3: GPS L1 + Glonass L1 1570-1620MHz :10W
CH4: 2400MHz –2500MHz:8W
Mechanical Specifications
Dimensions 255*255*45mm
Weight 1.1kg
3
Electrical Specifications CT-4000P
Frequency Range 1575-1620MHz 2400-2500MHz 2400-2500MHz 5150-5875MHz
Mechanical Specifications
Dimensions 210*94*34mm
The Conditions in the system are indicated by the LEDs. The input power applied from 110V or 220V AC.
4
General Description
CH1:2.4GHz
Each Band
CH2:5.8GHz
Power Switch
CH4:2.4GHz
Battery Status
CH1:2.4GHz
CH2:5.8GHz
CH3:GPS L1
Main Power Battery Charger
CH4:2.4GHz
***NOTE***:
Before you turn on the jammer, please………..
Make sure connect all Antennas to the jammer
5
Quick Installation:
Step 1:
TURN ON “Main Power”… “BLUE ON”
Step 2:
Turn Each Band “ Power” ON……. “GREEN ON”
6
Charging
Use Battery Charge to charge the CT-4000P Jammer
When battery is low, plug the Battery AC cable, one side to Charging In another side to AC 110 or 220V.
U U
The Battery LED Status of Charging (Green Background) will turn on , device is in charging state.
U U