Académique Documents
Professionnel Documents
Culture Documents
ISSN: 2007-0934
revista_atm@yahoo.com.mx
Instituto Nacional de Investigaciones
Forestales, Agrícolas y Pecuarias
México
Limón Ortega, Agustin; Pelaez Cruz, Deyxi; Leyva Mir, Gerardo; Espinosa Barreto,
Catalina
Efecto de la dosis de N en la incidencia de Fusarium spp. en raíces de trigo bajo camas
permanentes
Revista Mexicana de Ciencias Agrícolas, vol. 7, núm. 5, junio-agosto, 2016, pp. 1155-
1165
Instituto Nacional de Investigaciones Forestales, Agrícolas y Pecuarias
Estado de México, México
Resumen Abstract
La aplicación de sistemas de labranza de conservación The application of conservation tillage systems like
como el de camas permanentes tiene ventajas importantes permanent beds has important advantages over the production
sobre la producción de cultivos. Sin embargo, los residuos of crops. However, crop residues are left on the ground
de cultivo que se dejan sobre el suelo promueven el promote disease development. In this study the incidence of
desarrollo de enfermedades. En este estudio se evaluó la fungi in the root of wheat was evaluated with four doses of
incidencia de hongos en la raíz de trigo con cuatro dosis N (0, 20, 40 and 60 kg ha-1) in rotation with maize in three
de N (0, 20, 40 y 60 kg ha-1) en rotación con maíz en tres doses of N (0, 60 and 120 kg ha-1) under permanent beds. The
dosis de N (0, 60 y 120 kg ha-1) bajo camas permanentes. identification was made by direct microscopic observation
La identificación se realizó por observación microscópica was found seven species of Fusarium and Helminthosporium
directa encontrándose siete especies de Fusarium y tres three. The incidence of most of these were affected by the
de Helminthosporium. La incidencia de la mayoría de application of N. The incidence of Fusarium moniliforme
estas se afectó por la aplicación de N. La incidencia de was negatively related to performance spikes per m2 and total
Fusarium moniliforme se relacionó negativamente con absorption of N. The reduction rate (slope) of each of these
rendimiento, espigas por m2 y absorción total de N. La tasa parameters and their effect low incidence (intercept) dose
de reducción (pendiente) de cada uno de estos parámetros dependent N. The effect of these parameters on the incidence
y su efecto a baja incidencia (intercepto) dependió de la was lower for the application of 40 kg N ha-1 to 60 kg N ha-
dosis de N. El efecto de la incidencia en estos parámetros 1
. The rest of the identified species did not show a definite
fue menor para la aplicación de 40 kg N ha-1 que para pattern. Moreover, the differential normalized vegetation
60 kg N ha-1. El resto de las especies identificadas no index (NDVI) collected in treatments with the application
presentaron un patrón definido. Por otra parte, el índice of 60 kg N ha-1 in three stages of development presented
diferencial normalizado de vegetación (NDVI) colectado a negative association with the incidence of Fusarium
en tratamientos con la aplicación de 60 kg N ha-1 en tres moniliforme. These results indicate the importance of proper
etapas de desarrollo presentó una asociación negativa con application of N to reduce the effect of impact on plants. The
la incidencia de Fusarium moniliforme. Estos resultados NDVI readings proved to be a potential tool for indirect
indican la importancia de la aplicación adecuada de N para detection of disease at the root.
reducir el efecto de la incidencia en plantas. Las lecturas Keywords: nitrogen, NDVI, permanent beds, root diseases,
NDVI demostraron ser una herramienta potencial para la wheat.
detección indirecta de enfermedades en la raíz.
de cultivo (Leplat et al., 2013). En contraste, el sistema Other factors may also handling promote or inhibit the
de siembra en camas permanentes o camas con labranza development of specific communities Fusarium spp. is weed
convencional presentan una marcada reducción en algunas control herbicide glyphosate and source of N fertilizer (Leplat
enfermedades foliares como posible consecuencia de las et al., 2013). Moreover, some studies have reported that the
condiciones micro climáticas que resultan del cambio en la assessment of NDVI from reflectance measurements at
orientación de las plantas (Sayre y Hobbs, 2004). different stages of development using the GreenSeeker sensor
is related to the concentration of N and final performance
Otros factores de manejo que también pueden promover o (Teal et al., 2006). As a result, the potential wheat yields have
inhibir el desarrollo de comunidades específicas de Fusarium been predicted from the early stage of development in order
spp. es el control de malezas herbicidas a base de glifosato y to maximize the efficiency of applications based fertilizer N
fuente de N como fertilizante (Leplat et al., 2013). Por otra (Teal et al., 2006; Martin et al., 2007). However, no reports of a
parte, algunos estudios han reportado que la evaluación del direct relationship between NDVI readings and root diseases.
NDVI a partir de mediciones de reflectancia a diferentes
etapas de desarrollo empleando el sensor GreenSeeker, está Because of the devastating nature of Fusarium spp., is essential
relacionado con las concentración de N y rendimiento final for producers to have strategies to mitigate yield losses by this
(Teal et al., 2006). Como resultado, el rendimiento potencial pathogen. These strategies include a combination of cultural
de trigo se ha podido predecir desde la etapa tempranas practices such as N management, planting resistant or tolerant
de desarrollo con la finalidad de maximizar la eficiencia varieties, chemical and biological control, use of forecasting
de las aplicaciones de fertilizante a base de N (Teal et al., systems and harvesting strategies. Therefore, the objective of
2006; Martin et al., 2007). Sin embargo, no hay reportes this study was to assess the incidence of fungal populations
que indiquen una relación directa entre lecturas NDVI y in wheat roots under permanent bed planting and doses of
enfermedades en la raíz. N and its influence on wheat yield, yield components and
absorption of N.
Debido a la naturaleza devastadora de Fusarium spp., es
esencial para los productores contar con estrategias para
mitigar las perdidas en rendimiento por este patógeno. Estas Materials and methods
estrategias incluyen una combinación de prácticas culturales
tales como manejo de N, siembra de variedades resistentes o
tolerantes, control químico y biológico, empleo de sistemas The wheat plant roots were collected in the 2014 cycle in a
de pronóstico y estrategias de cosecha. Por tanto, el objetivo field trial under permanent bed planting cycle established in
de este trabajo fue valorar la incidencia de poblaciones de 2008, after nine agricultural cycles in the experimental field
hongos en raíces de trigo bajo siembra en camas permanentes "Valle de Mexico" (CEVAMEX) of INIFAP. The incidence of
y dosis de N y su influencia en el rendimiento de trigo, disease was estimated in samples collected four plants roots 15,
componentes de rendimiento y absorción de N. 30, 60, 90 and 120 days after the emergency treatment and four
N (0, 20, 40 and 60 kg ha-1). Each of these treatments was nested
within three doses of N (0, 60, 120 kg ha-1) applied to corn in the
Materiales y métodos previous cycle which resulted in a total of nine experimental
units per dose of N applied to wheat. The incidence of each
species was determined as the number of infected roots
Se colectaron raíces de plantas de trigo en el ciclo 2014 en through sampling. To identify the species present, the roots
un ensayo de campo bajo siembra en camas permanentes were rinsed after sampling with distilled water, dipped in a
establecidas en el ciclo 2008, después de nueve ciclos solution of 5% NaOCl for 30 s and rinsed again for a time
agrícolas en el campo experimental “Valle de México” equal in distilled water. The samples were dried in sterile filter
(CEVAMEX) del INIFAP. La incidencia de enfermedades paper and placed in Petri dishes in a medium with PCNB agar
se estimó en muestras de raíces colectadas de cuatro plantas 50 mg streptomycin sulfate and 18 g per liter of abamectin
a los 15, 30, 60, 90 and 120 días después de la emergencia y (AgrimecTM) within growth chambers. After six days, the
cuatro tratamientos de N (0, 20, 40 and 60 kg ha-1). Cada uno Petri dishes were examined when fungus species could be
de estos tratamientos estuvo anidado dentro de tres dosis de identified by direct microscopic observation according to the
N (0, 60, 120 kg ha-1) aplicadas a maíz en el ciclo anterior lo morphological description of Zyllinsky (1984).
1158 Rev. Mex. Cienc. Agríc. Vol.7 Núm. 5 30 de junio - 13 de agosto, 2016 Agustin Limón Ortega et al.
cual resultó en un total de nueve unidades experimentales The field experiment consisted of planting wheat after corn
por cada dosis de N aplicadas a trigo. La incidencia de cada on a biannual rotation under rainfed conditions under the
especie fue determinada como el número de raíces infectadas system of permanent bed planting with residue of both
a través de los muestreos. Para identificar las especies crops and stubble on the surface. The granular urea (46-
presentes, las raíces fueron enjuagadas después del muestreo 0-0) was used as a source of N. The N treatments were
con agua destilada, sumergidas en una solución de NaOCl maintained in the same plot each year and applied in-band
al 5% durante 30 s y enjuagadas nuevamente por un tiempo over the beds and incorporated partially during the seeding
igual en agua destilada. Posteriormente, las muestras fueron operation. For weed control before planting annually it
secadas en papel filtro estéril y puestas en cajas Petri en un applied herbicide glyphosate. Postemergence control
medio agar PCNB con 50 mg de sulfato de estreptomicina y of broadleaf and grass tillering was conducted during
18 g por litro de abamectina (AgrimecTM) dentro de cámaras the application of 10 g ha-1 of prosulfuron (sulfunilurea)
de crecimiento. Después de seis días, las cajas Petri fueron and 300 g ha-1 clodinafop (aryloxyphenoxypropionates),
examinadas cuando las especies de hongo pudieron ser respectively.
identificadas por observación microscópica directa de
acuerdo con la descripción morfológica de Zyllinsky (1984). The grain yield estimate was performed by harvesting the
two central beds. The total N uptake was estimated at 50
El experimento de campo consistió en la siembra de trigo stalks randomly collected in each treatment. These samples
después de maíz en una rotación bianual en condiciones de were dried and threshed to determine the percentage of N in
temporal bajo el sistema de siembra en camas permanentes grain and straw with NIR 6500's spectrophotometer (FOSS,
con los residuos de ambos cultivos como rastrojo sobre la Denmark). The reflectance of the plants was evaluated in
superficie. Se empleó urea granular (46-0-0) como fuente de three stages of development (boot stage, anthesis and grain
N. Los tratamientos de N se mantuvieron en la misma parcela filling) using the optical sensor GreenSeekerTM (NTech
cada año y se aplicó en banda sobre las camas e incorporado Industries Inc.) to estimate the NDVI. Readings were taken
parcialmente durante la operación de siembra. Para el control on two central beds at a height of 0.9 m on plants and oriented
de maleza antes de la siembra se aplicó anualmente un perpendicular to the rows of plants.
herbicida a base de glifosato. En posemergencia el control
de hoja ancha y pastos se realizó durante el amacollamiento The data were analyzed using the SAS program. The
con la aplicación de 10 g ha-1 de prosulfuron (sulfunilurea) estimated incidence relations with measurements in plants
y 300 g ha-1 de clodinafop (ariloxifenoxipropionatos), and NDVI readings were analyzed using the PROC MIXED
respectivamente. option and were considered significant when p< 0.05.
Los datos se analizaron empleando el programa SAS. Las The 14 species of fungi (Table 1) were identified; ten
relaciones estimadas entre incidencia con las mediciones of these were pathogens patógenos (Fusarium spp. and
en plantas y lecturas NDVI fueron analizadas empleando Helminthosporium spp.) and four saprophytes (Alternaria,
la opción PROC MIXED y se consideraron significativas Rhizopus, Verticillium y Penicillium). Among the pathogenic
cuando p< 0.05. species that had the highest incidence was found mainly
Efecto de la dosis de N en la incidencia de Fusarium spp. en raíces de trigo bajo camas permanentes 1159
Cuadro 1. Incidencia total de 14 especies de hongos identificados en las raíces de trigo bajo siembra en camas permanentes
en rotación con maíz.
Table 1. Total Incidence of 14 identified species of fungi in the roots of wheat under permanent bed planting in rotation
with corn.
Hongo Incidencia total (conteo)
Cochliobolus sativus (Helminthosporium sativum) 252
Helminthosporium turcicum 43
Pyrenophora avenae (Helminthosporium avenae) 2
Fusarium moniliforme 150
Fusarium oxysporum 90
Gibberella zeae (Fusarium graminearum) 21
Fusarium equiseti 8
Fusarium poae 8
Gibberella avenacea (Fusarium avenaceum) 7
Fusarium nivale 7
Alternaria 105
Rhizopus 16
Verticillium 5
Penicillium 6
1160 Rev. Mex. Cienc. Agríc. Vol.7 Núm. 5 30 de junio - 13 de agosto, 2016 Agustin Limón Ortega et al.
Incidencia, conteos
ninguna de ellas (Cuadro 2). Sin embargo, la incidencia de la
4
mayoría de estos hongos a través de las dosis de N aplicada a
trigo fue inconsistente, excepto para Fusarium moniliforme y 3
F. oxysporum. Para el caso de la primera, la incidencia aumentó 2
con la aplicación de N de 0 a 40 kg ha-1 y declinó de 40 a 60 kg
1
ha-1 (Figura 1). De manera inversa, la incidencia de Fusarium
oxysporum se redujo consistentemente en la medida que la dosis 0
0 20 40 60
de N se aumentó de 0 a 60 kg ha-1 lo cual coincide con el reporte
Dosis de N (kg ha-1)
de Warren y Kommendahl (1972). Estos resultados indican
Figura 1. Incidencia de Fusarium moniliforme y F. oxysporum
que la fuente de N no es el único factor de manejo que afecta la
en trigo en rotación con maíz como respuesta
comunidad de Fusarium spp. (Leplat et al., 2013) sino también a la aplicación de cuatro dosis de N bajo camas
la dosis de N que se aplica en forma de urea. Por otra parte, la permanentes.
irregularidad en la incidencia a través de las dosis de N para Figure 1. Incidence of Fusarium moniliforme and F. oxysporum
el resto de las especies identificadas indicó que ésta depende on wheat in rotation with maize in response to the
de factores distintos a la cantidad de fertilizante que se aplica. application of four doses of N under permanent beds.
Cuadro 2. Valores de P del análisis de varianza aplicado a cinco especies de patógenos en trigo bajo rotación con maíz
afectados por dosis de N.
Table 2. Values of P variance analysis applied to five species of pathogens in wheat under rotation with corn affected by
doses of N.
Fuente de variación Helminthosporium Fusarium
sativum turcicum moniliforme oxysporum graminearum
Rep 0.0005 0.063 0.074 0.228 0.157
Dosis N a trigo <0.0001 0.004 <0.0001 0.064 0.015
Dosis de N a maíz en 0.089 0.274 0.631 0.886 0.857
ciclo anterior
Interacción 0.478 0.133 0.147 0.922 0.384
Con el propósito de identificar el efecto sobre el rendimiento In order to identify the effect on the performance of these
de estas dos especies, Fusarium moniliforme y F. oxysporum, two species, Fusarium moniliforme and F. oxysporum,
se realizó un análisis de regresión entre estas variables para a regression analysis of these variables for each dose
cada dosis de N. Los resultados con Fusarium moniliforme of N. The results Fusarium moniliforme was conducted
indicaron en general una diferencia significativa para they indicated generally a significant difference for the
el coeficiente de intercepción y pendientes entre dosis intercept coefficient and slopes between doses of N (Table
de N (Cuadro 3). Lo opuesto se obtuvo para Fusarium 3). The opposite was obtained for Fusarium oxysporum
oxysporum cuya incidencia no se relacionó con ninguno de whose incidence was not related to any of the parameters
los parámetros de planta evaluados. Esta falta de relación, evaluated plant. This lack of relationship, including
incluyendo la incidencia de F. graminearum que ha sido the incidence of F. graminearum has been reported as
reportada como patógeno devastador (Wegulo et al., 2015), devastating pathogen (Wegulo et al., 2015) suggests that
sugiere que el N y las condiciones ambientales del ciclo no the N and cycle environmental conditions were not factors
fueron factores que promovieran la incidencia de estas dos that promote the occurrence of these two species. Another
especies. Otra sugerencia es que el efecto del sistema se suggestion is that the effect of the system is planted in
siembra en la reducción de la incidencia (Govaerts et al., reducing the incidence (Govaerts et al., 2006) is specific
2006) es específico solo para algunas especies. only for some species.
Efecto de la dosis de N en la incidencia de Fusarium spp. en raíces de trigo bajo camas permanentes 1161
Cuadro 3. Diferencias entre intercepto y pendiente de According to regression analysis, the slope between the
cuatro líneas de regresión (0, 20, 40 y 60 kg incidence of Fusarium moniliforme and performance
N ha-1) para la incidencia entre Fusarium indicated that the cup this reduction was greater for the
moniliforme y rendimiento de trigo, espigas dose of 60 kg N ha-1 (Figure 2). It is also important to
por m2 y absorción total de N. note that although the dose of 40 kg N ha-1 resulted in a
Table 3. Differences between four intercept and slope of higher incidence of this pathogen, its effect on the yield
regression lines (0, 20, 40 and 60 kg N ha-1) for the was virtually null. Coincidentally, the last dose of N has
incidence among Fusarium moniliforme and yield been previously reported as adequate to obtain acceptable
of wheat spikes per m2 and total absorption of N.
yields of rainfed wheat in Valles Altos de Mexico (Limón-
Parámetro Intercepto Pendiente Ortega and Sayre 2012). Therefore, strategies to address
Valor F P > F† Valor F P > F† some of the root diseases caused by Fusarium spp. should
Rendimiento 13.4 0.001 3.9 0.02 include cultural practices (Wegulo et al., 2015) such as N
management (Lori et al., 2009).
Espigas por m2
8.36 0.007 1.5 0.24
Absorción total de N 10.3 0.003 2.5 0.07 2500
†
Probabilidad de un valor mayor a F.
2000
alta precipitación y bajas temperaturas promedio, pudieron the incidence greater or lesser degree, depending on the
haber sido las condiciones que promovieron la incidencia en dose of N of Fusarium species identified (Steinkellner and
mayor o menor grado, según la dosis de N, de las especies Langer 2004).
de Fusarium identificadas (Steinkellner y Langer 2004).
Moreover, the association between the incidence of
Por otra parte, la asociación entre la incidencia de Fusarium Fusarium moniliforme and NDVI readings collected at
moniliforme y las lecturas NDVI colectadas en tres etapas de three stages of development (boot stage, flowering and
desarrollo (embuche, floración y llenado de grano), indicó grain filling) indicated that it is feasible to predict the
que es factible pronosticar la presencia de esta patógeno a presence of this pathogen from the reflectance of the
partir de la reflectancia del cultivo. Este resultado se observó crop. This result was observed for treatment only 60 kg
únicamente para el tratamiento con 60 kg N ha-1 (Figura 5) N ha-1 (Figure 5) with significant differences only in the
con diferencias significativas únicamente en el coeficiente intercept coefficient (Table 4). In general, to the extent
de intercepción (Cuadro 4). En general, en la medida en que that reflectance readings were greater, the incidence of
las lecturas de reflectancia fueron mayores, la incidencia de this pathogen was lower. However, although generally the
este patógeno fue menor. Sin embargo, aunque generalmente NDVI readings have been used to monitor the status of N
las lecturas NDVI se han empleado para monitorear el estatus in plants and forecast performance (Raun et al., 2005), the
de N en las plantas y pronosticar el rendimiento (Raun et al., results of this study indicate that the reflectance evaluated
2005), los resultados de este estudio indican que la reflectancia as NDVI crop can also be used to be associated with the
evaluada como NDVI del cultivo también puede ser empleada incidence of pathogens in the root when the dose of N is
para asociarla con la incidencia de hongos patógenos en las excessive.
raíz cuando la dosis de N sea excesiva.
Cuadro 4. Diferencias entre intercepto y pendiente en
7 tres líneas de regresión (embuche, floración
y llenado de grano) para la incidencia entre
Incidencia F. moniliforme (conteos)
6
Fusarium moniliforme y lecturas NDVI en
5
tratamiento con 60 kg N ha-1.
Table 4. Differences between intercept and slope in three
4 regression lines (boot stage, f lowering and
grain filling) for incidence between Fusarium
3 moniliforme and NDVI readings treated with 60
kg N ha-1.
2
Espigamiento
Parámetro Intercepto Pendiente
1
Floración
Llenado de grano Valor F P>F †
Valor F P > F†
0
0.4 0.45 0.5 0.55 0.6 0.65 0.7 0.75
NDVI 17.6 0.0004 0.04 0.96
Lecturas NDVI
†
Probabilidad de un valor mayor a F.
Figura 5. Relación entre lecturas NDVI colectadas en tres
etapas de desarrollo (embuche, floración y llenado
de grano) con la incidencia de Fusarium moniliforme Conclusion
a 60 kg N ha-1.
Figure 5. Relationship between NDVI readings collected at
three stages of development (boot stage, flowering Pathogen species were identified most frequently correspond
and grain filling) with the incidence of Fusarium to Fusarium spp. and Helminthosporium spp. The incidence
moniliforme to 60 kg N ha-1. in most species are affected by the application of N, however,
only a regular consistency was observed across the dose of
Conclusión N in the species of Fusarium moniliforme and F. oxysporum.
The incidence of the first species is maximized at the dose of
40 kg N ha-1 but this issue did not have substantial effects on
Las especies de patógenos que se identificaron con mayor performance, spikes per m2 or absorption of N. According
frecuencia corresponden a los géneros Fusarium spp. y to previous studies, this dose of N has been considered the
Helminthosporium spp. La incidencia en la mayoría de las right to obtain acceptable yields of rainfed wheat in Valles
1164 Rev. Mex. Cienc. Agríc. Vol.7 Núm. 5 30 de junio - 13 de agosto, 2016 Agustin Limón Ortega et al.
especies se afectó por la aplicación de N, sin embargo, solo Altos. The negative effects on the incidence of Fusarium
se observó una consistencia regular a través de las dosis de moniliforme on these variables in plants were observed
N en las especies de Fusarium moniliforme y F oxysporum. at the dose of 60 kg N ha-1 indicating the importance of N
La incidencia de la primera especie se maximizo a la management as a factor to reduce the effect of impact on
dosis de 40 kg N ha-1 pero esta incidencia no tuvo efectos performance. In contrast to this species, the incidence of
substanciales en rendimiento, espigas por m2 o absorción Fusarium oxysporum was reduced to the extent that the N
de N. De acuerdo a trabajos previos, esta dosis de N se ha rate increased from 0 to 60 kg ha-1 without presenting any
considerado como la adecuada para obtener rendimientos substantial effect on performance, spikes per m2 or total
aceptables de trigo de temporal en Valles Altos. Los efectos absorption of N.
negativos por la incidencia de Fusarium moniliforme
sobre estas variables en plantas se observaron a la dosis Moreover, this study demonstrated that the incidence of
de 60 kg N ha-1 indicando la importancia del manejo de N Fusarium moniliforme to high doses of N reduces the total
como factor para reducir el efecto de la incidencia sobre absorption of this element which can be a cause of the low
el rendimiento. En contraste a esta especie, la incidencia efficiency of use of N. Moreover, the collection of readings
de Fusarium oxysporum se redujo en la medida que la NDVI at different stages of development and high doses
dosis de N se incrementó de 0 a 60 kg ha-1 sin presentar of N proved to be a promising tool to detect pathological
algún efecto substancial en rendimiento, espigas por m2 o problems in the root system.
absorción total de N.
End of the English version
Sayre, K. D. and Hobbs, P. R. 2004. The raised-bed system of cultivation Steinkellner, S. and Langer, I. 2004. Impact of tillage on the incidence of
for irrigated production conditions. In: sustainable agriculture Fusarium spp. in soil. Plant and Soil. 267:13-22.
and the rice-wheat system. Lal, R.; Hobbs, P.; Uphoff, N. and Wegulo, S. N.; Baenziger, P. S.; Nopsa, J. H.; Bockus, W. W. and Hallen-
Hansen, D. O. (Eds.). Ohio State University, Columbus. 337- Adams, H. 2015. Management of Fusarium head blight of wheat
355 pp. and barley. Crop Protection. 73:100-107.
Sommer, R.; Thierfelder, C.; Tottonell, P.; Hove, L.; Mureithi, J. and Zyllinsky, F. J. 1984. Guía para la identificación de enfermedades
Mkomwa, S. 2014. Fertilizer use should not be a fourth en cereales de grano pequeño. Centro Internacional de
principle to define conservation agriculture. Field Crops Res. Mejoramiento de Maíz y trigo. CIMMYT. Texcoco, Estado de
169:145-148. México, D. F. 141 p.