Académique Documents
Professionnel Documents
Culture Documents
REFERENCES
Ahlvin, R. G., and Ulery, H. H. (1962). “Tabulated Values of Determining the Composite
Pattern of Stresses, Strains, and Deflections Beneath a Uniform Load on a Homogeneous
Half Space,” Highway Research Board Bulletin 342, pp. 1-13.
American Society for Testing and Materials (1982). Annual Book of ASTM Standards,
Part 19, Philadelphia.
Binquet, J., and Lee, K. L. (1975a). “Bearing Capacity Tests on Reinforced Earth Mass,”
Journal of the Geotechnical Engineering Division, American Society of Civil Engineers,
Vol. 101, No. GT12, PP. 1241-1255.
Binquet, J., and Lee, K. L. (1975b) “Bearing Capacity Analysis of Reinforced Earth
Slabs,” Journal of the Geotechnical Engineering Division, American Society of Civil
Engineers, Vol. 101, No. GT12, PP. 1257-1276.
Bowles, J. E. (1977). Foundation Analysis and Design, 2nd, ed., McGraw-Hill, New
York.
Christian, J. T., and Carrier, W. D. (1978) “Janbu, Bjerrum and Kjaernsli’s Chart
Reinterpreted,” Canadian Geotechnical Journal, Vol. 15, pp. 124-128.
Das, B. (1997). Advanced Soil Mechanics, 2nd ed., Taylor and Francis, Washington, D. C.
Griffiths, D. V. (1984). “A Chart for Estimating the Average Vertical Stress Increase in
an Elastic Foundation Below a Uniformly Loaded Rectangular Area,” Canadian
Geotechnical Journal, Vol. 21, No. 4, 710-713.
Janbu, N., Bjerrum, L., and Kjaernsli, B. (1956). “Veiledning ved losning av
fundamentering-soppgaver,” Publication No. 16, Norwegian Geotechnical Institute, pp.
30-32.
Liao, S. S. C., and Whitman, R. V. (1986). “Overburden Correction Factors for SPT in
Sand,” Journal of Geotechnical Engineering, American Society of Civil Engineers, Vol.
112, No. 3, pp. 373-377.
Mandel, J., and Salencon, J. (1972). “Force portante d’un sol sur une assise rigide (etude
theorizue),” Geotechnique, Vol. 22, No. 1, pp. 79-93.
Mitchell, J. K., and Gardner, W. S. (1975). “In Situ Measurement of Volume Change
Characteristics,” Proceedings, Specialty Conference, American Society of Civil
Engineers, Vol. 2, pp. 279-345.
Pfeifle, T. W., and Das, B. M. (1979). “Bearing Capacity of Surface Footings on Sand
Layer Resting on a Rigid Rough Base,” Soil and Foundations, Vol. 19, No. 1, pp. 1-11.
Steinbrenner, W. (1934). “Tafeln zur Setzungsberechnung,” Die Strasse, Vol. 1, pp. 121-
124.
Terzaghi, K., and Peck, R. B. (1967). Soil Mechanics in Engineering Practice, 2nd, ed.,
Wiley New York.