Académique Documents
Professionnel Documents
Culture Documents
Q.2 The outline of the part in figure is to be profile milled, using a 20 mm diameter end mill with two teeth. The part is 10
mm thick. Cutting speed = 125 mm/min and feed = 0.10 mm/teeth. Use the lower left corner of the part as the origin in
the x-y axis system. Write the part program in the manual part programming. Use absolute positioning. (5.0)
Q.2 The outline of the part in figure is to be profile milled, using a 20 mm diameter end mill with two teeth. The part is 10
mm thick. Cutting speed = 125 mm/min and feed = 0.10 mm/teeth. Use the lower left corner of the part as the origin in
the x-y axis system. Write the part program in the manual part programming. Use absolute positioning. (5.0)
Q.2 The outline of the part in figure is to be profile milled, using a 20 mm diameter end mill with two teeth. The part is 10
mm thick. Cutting speed = 125 mm/min and feed = 0.10 mm/teeth. Use the lower left corner of the part as the origin in
the x-y axis system. Write the part program in the manual part programming. Use absolute positioning. (5.0)
Q.2 The outline of the part in figure is to be profile milled, using a 20 mm diameter end mill with two teeth. The part is 10
mm thick. Cutting speed = 125 mm/min and feed = 0.10 mm/teeth. Use the lower left corner of the part as the origin in
the x-y axis system. Write the part program in the manual part programming. Use absolute positioning. (5.0)