Académique Documents
Professionnel Documents
Culture Documents
Issue Issued
1 15-01-10 CM
Installation Guide
Alcatel-Lucent 9100 Multi-Standard Base Station MBO1
DC Crash Installation Guide
Alcatel-Lucent –PROPRIETARY
This document contains proprietary information of Alcatel-Lucent and is not to be disclosed or used
System Design Control except in accordance with applicable contracts or agreements
C C SEE PROPRIETARY AND COPYRIGHT NOTICE ON COVER PAGE
Used on 2009 Alcatel-Lucent All Rights Reserved
Alcatel Lucent 9100 Multi-Standard Base Station MBO1 DC Crash
ALU TIS Alcatel Lucent 9100 Multi-Standard Base Station MBO1 DC
Installation Crash Installation Guide
Guide
W-CDMA
Alcatel-Lucent 04-6201-201 Prelinary
Alcatel-Lucent Preliminary 04-6201-201 Sheet 1Sheet
of 12 1 of 12
1. Mechanical Installation Without Optional Module
Note: Perform the installation step in the correct order: start with
A, followed by B, then C, D and finally E (Optional)
!
Warning Kit OMSE Option Mount Set
Univ: 3BK27277BA
Screw location
E
A
TRDU Subrack :
3JR08814AA
D
TRDU: 3JR21002AA
4 screws
9326 d2U v2
NTYD0608 Kit: Bracket OMK4
3JR08095AC
C
Fixing by 2x3 M6
Self tapping screw SEE PROPRIETARY AND COPYRIGHT NOTICE ON COVER PAGE
4U
2U
PDU3 3JR22039AA
Busbar BOMUE
PDU2
TRDU ICO 1 TRDU
PDU1
X4 J3 TRDU ¼ TRDU1 Power in
X3
J3 TRDU 2/5 TRDU2 Power in
X2
X1 J3 TRDU 3/6 TRDU3 Power in
5
J3 TRDU 3/6 TRDU4 Power in
1
2
DDF
Customer
! 6
Warning
11
10 9
16 3BK27903BA GND M6 1
10 15
9 Kit: dnodeB 2U PCM
Terminal Block
3JR08002AA
6 11
DDF
16 Customer
8 7
O
14
13
Div
Main
Bulkhead View
Zeta
Beta Div Gamma Div
19
5 11 Customer
DC Box -48V
Tx/Rx
14
Alarm
17
15 DDF
18
Torque wrench to 25 Nm
!
# Ref Designation Qty
18 3BK25995HA Blue DC External Power Cables 1 x 1 SEE PROPRIETARY AND COPYRIGHT NOTICE ON COVER PAGE
25 mm² 20m
Alcatel Lucent 9100 Multi-Standard Base Station MBO1 DC Crash
19 3BK05364CA or Jumper Male right angle 2M Up to 8 Installation Guide
3BK05364DA Jumper Male right angle 3M
Alcatel-Lucent Preliminary 04-6201-201 Sheet 8 of 12
8.Pin-Out 3JR22033AA External Alarm Cable 16m
The following pins: 19, 20, 29, 30 and 37 are not connected
. Alcatel Lucent 9100 Multi-Standard Base Station MBO1 DC Crash
Installation Guide
Connect the cable ( pin 2-3, 4-5, 6-7) to the X900 connector
OUTC board
Orange/White
White/Orange
X900 connector Green/White
White/Green