Académique Documents
Professionnel Documents
Culture Documents
Pluronic® F 108 NF
Revision date : 2008/09/23 Page: 1/6
Version: 2.1 (30089185/MDS_GEN_US/EN)
2. Composition/information on ingredients
CAS Number Content (W/W) Chemical name
128-37-0 BHT
9003-11-6 100.0 % Methyl-oxirane polymer with oxirane
3. Hazard identification
Emergency overview
4. First-aid measures
General advice:
Remove contaminated clothing.
If inhaled:
Remove the affected individual into fresh air and keep the person calm. Seek medical attention.
If on skin:
Wash thoroughly with soap and water.
If in eyes:
Wash affected eyes for at least 15 minutes under running water with eyelids held open.
If swallowed:
Rinse mouth and then drink plenty of water. Do not induce vomiting. Immediate medical attention required.
Note to physician
Treatment: Treat according to symptoms (decontamination, vital functions), no known
specific antidote.
5. Fire-fighting measures
Flash point: approx. 257 °C (ASTM D92)
Autoignition: No data available.
Further information:
Contaminated extinguishing water must be disposed of in accordance with official regulations.
Environmental precautions:
Do not discharge into drains/surface waters/groundwater.
Cleanup:
Avoid raising dust.
For large amounts: Contain with dust binding material and dispose of.
Safety data sheet
Pluronic® F 108 NF
Revision date : 2008/09/23 Page: 3/6
Version: 2.1 (30089185/MDS_GEN_US/EN)
Storage
General advice:
Keep container tightly closed and dry; store in a cool place.
Hand protection:
Chemical resistant protective gloves
Eye protection:
Safety glasses with side-shields.
Body protection:
Body protection must be chosen based on level of activity and exposure.
Substances to avoid:
No substances known that should be avoided.
Hazardous reactions:
No hazardous reactions when stored and handled according to instructions.
The product is chemically stable.
Decomposition products:
Hazardous decomposition products: No hazardous decomposition products if stored and handled as
prescribed/indicated.
Corrosion to metals:
No corrosive effect on metal.
Oral:
LD50/rat: > 2,000 mg/kg
Skin irritation:
rabbit: non-irritant
Eye irritation :
rabbit: non-irritant
Biodegradation:
Evaluation: Moderately/partially eliminated from water.
Environmental toxicity
Toxicity to microorganisms:
Inhibition of degradation activity in activated sludge is not to be anticipated during correct introduction of low
concentrations.
Analogous: Assessment derived from products with similar chemical character.
Safety data sheet
Pluronic® F 108 NF
Revision date : 2008/09/23 Page: 5/6
Version: 2.1 (30089185/MDS_GEN_US/EN)
Other ecotoxicological advice:
The product has not been tested. The statement has been derived from products of a similar structure and
composition.
Container disposal:
Dispose of in a licensed facility. Recommend crushing, puncturing or other means to prevent unauthorized use
of used containers.
Land transport
USDOT
Not classified as a dangerous good under transport regulations
Sea transport
IMDG
Not classified as a dangerous good under transport regulations
Air transport
IATA/ICAO
Not classified as a dangerous good under transport regulations
Registration status:
TSCA, US released / listed
State regulations
State RTK
CA Prop. 65:
THIS PRODUCT CONTAINS A CHEMICAL(S) KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER AND BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
Safety data sheet
Pluronic® F 108 NF
Revision date : 2008/09/23 Page: 6/6
Version: 2.1 (30089185/MDS_GEN_US/EN)
HMIS uses a numbering scale ranging from 0 to 4 to indicate the degree of hazard. A value of zero means that the substance
possesses essentially no hazard; a rating of four indicates high hazard.