Académique Documents
Professionnel Documents
Culture Documents
This section covers the in-place analysis and design for the condensate tank shed. The design
was carried out in accordance with BS EN 1993.
Basic Data
Ceiling = 0.075KN/m2
Services = 0.050KN/m2
Total = 0.290KN/m2
= 0.980KN/m
= 2.30KN/m
Wind Loads
v = c +c +v ,
Where:
, = 30m/s (assumed)
v = c +c +v , = 30m/s
For simplification the directional factor and the seasonal factor are in general taken
as 1.0
Where:
Where:
c (z) = c (z ) for z ≤ z
Where:
z = Roughness length
.
k = 0.19 x ( )
,
l = l (z ) For z ≤ z
Where:
Z = 3.687m;
Therefore: z ≤z≤z
.
q (z) = [1 + ( ) (
] x x ρ x [0.19 x ( ) x ln ( ) x 1 x v ] 2
) ,
.
c (z) = 0.19 x ( ) x ln ( )
,
. . .
c (z) = 0.19 x ( ) x ln ( ) = 0.817
. .
c (z) = 1.0
v = 30m/s
l (z) = . = 0.233
( )
.
q (z) = 0.988KN/m2
The wind pressure acting on the external surfaces (w ) is obtained from the following
expression
w = q (z) x c
D: c , = +1..0
E: c , = -0.4
41
Windwa
ard direction
n = 1.0 x 0.9
988 x 0.102
2 = 0.101KN
N/m
onopitch ca
For mo anopy rooff
ngle = 6o
Roof an
Blockag
ge (ϕ) = 0
A: c = -1..1
B: c = -1..7
C: c = -1..8
of = q x c
Wind prressure on canopy roo xc c
Condenssate Tank Sh
hed Design Report
R Page 8 of 9
Wind load on roof external frame = -1.8 x 5.85 x 0.5 = -5.27KN/m
5. Dead Load + Live Load + Wind Load (DL + LL + 0.5WL) Service Load
The structure is analysed as a plane frame in STAAD Pro Structural analysis software. Results
are shown in Appendix A - C.