Académique Documents
Professionnel Documents
Culture Documents
Filling blow holes prior to overcoating Clean the surface and remove any dust, unsound material,
plaster, oil, paint, grease, corrosion deposits or algae.
Filling shrinkage cracks in concrete
Roughen the surface to remove any laitance and expose the
General reprofiling over large areas fine aggregate by light scabbling or sweep blasting.
Reprofiling, in association with other Renderoc mortars Oil and grease deposits should be removed by steam
cleaning, detergent scrubbing or the use of a proprietary
Advantages degreaser. The effectiveness of decontamination should then
be assessed by a pull-off test.
Cost effective/ time saving - no independent primer or
curing agents required The cleaned areas should be blown clean with oil-free
compressed air before continuing. All prepared areas should
High performance - excellent bond to substrate
be thoroughly soaked with clean water immediately prior to
User friendly - gauging liquid supplied to overcome the application of Renderoc BF2. Any residual surface water
mixing problems, ideal for remote locations should be removed prior to commencement.
Cost effective - allows part mixing Mixing
ambient substrate temperatures and wind speed. be allowed to partly set before finally trowelling to a smooth
finish. If a very smooth finish is required, a small amount of
water may be flicked on to the surface of the Renderoc BF2
with a paint brush prior to final trowelling.
Fosroc Renderoc BF2
Curing Limitations
Curing is not generally required. However, under extreme - Renderoc BF2 should not be used when the temperature
conditions - high temperatures and drying winds - use is below 5°C and falling.
Nitobond AR*† as a curing agent, or cover the surface with - Do not proceed with the application when rainfall is
polythene sheeting, taped down at the edges. imminent unless in a sheltered or protected
situation.
Nitobond AR does not require mechanical removal prior to
overcoating with Dekguard system. - If any doubts arise concerning temperature or substrate
conditions, consult the local Fosroc office.
Cleaning
- If Renderoc BF2 is subjected to conditions of water
Renderoc BF2 should be removed from tools, equipment immersion allow a minimum cure of 7days @ 250C.
and mixers with clean water immediately after use. Cured Permanent immersion may result in a colour change
material can only be removed mechanically. which does not affect barrier properties.
Fire
†
See separate data sheet
Important note
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions for
the Supply of Goods and Service. All Fosroc datasheets are updated on a regular basis. It is the user’s responsibility to
obtain the latest version.
Head Office
telephone: (+9714) 2039699 fax: (+9714) 2859649 email: agf@fosroc.com
Al Gurg Fosroc LLC
Regional offices
Post Box 657, Dubai Abu Dhabi, Al Gurg Fosroc telephone: 673 1779 fax: 673 1449 email: abudhabi@fosroc.com
United Arab Emirates Bahrain, YBA Kanoo telephone: 17738200 fax: 17732828 email: bahrain@fosroc.com
Kuwait, Boodai telephone: 4817618 fax: 4832124 email: kuwait@fosroc.com
www.fosroc.com
Oman, Al Amana telephone: 24815080 fax: 24817554 email: oman@fosroc.com
Qatar, Tadmur telephone: 4432365 fax: 4419517 email: qatar@fosroc.com
UAE/0189/12/H