Académique Documents
Professionnel Documents
Culture Documents
Over to Fabfender...
Greetings Folks,
Some of you may be are aware that I run the Lesotho Mission team and its
efforts in Lesotho. We have a village that we care for that is extremely
remote (last we took people out there, everybody was screaming that it’s
not even on T4A) However it is magnificently picturesque and the road in
there is spectacularly beautiful. However it is not an extreme 4x4 route,
unless it rains then it can get exciting. Anybody interested in seeing what we
are about can visit our FB page:
https://www.facebook.com/groups/lesothomission
So we are requesting help from the "Action" part of the Action group. We are
looking to plan a trip just to that village - to go and revamp the currently
very broken and dilapidated furniture and buildings as far as possible.
Primarily a bit of woodwork required.
We are looking at R400.00 per vehicle. This money will ALL be used on
supplies for the upgrade of the school. If there is s a big enough demand we
can go the route of organizing shirts etc for the trip.
The trip is planned for 12 -15 March. There will be time for some self drive -
exploratory 4x4ing. We have asked Ben Van Dyck to take care of the
adventure travel stuff. There are no routes, so all routes will have to be
discovered. Hopefully we will be able to discover routes that are worthwhile
and we can make it an annual event akin to the river trips.
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 1/91
3/31/2018 Fabfender's Lesotho Mission
Craig? Achmedfus?
1.
Quote:
True.
I think Fabfender will be running a Thread in the Lesotho section as well.
This is not a 4x4 AG initiative, we are just helping Fabfender promote it.
Quote:
I would like to know what type of material (wood) is needed as I have quite
a few offcuts which is free and in my way.....
NOW - To speak to my bosses and see if I can get this trip sponsored
somehow(Fuel/"entry" fee) - CASH AINT THERE!!! Willingness however -
ANYTIME!!!!
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 2/91
3/31/2018 Fabfender's Lesotho Mission
The view from where we will camp: (If Manny joins, I'll remove the Land
Rover from the view as a matter of respect)
http://www.4x4community.co.za/forum/...1&d=1421141417
Quote:
Alan (All -In -One) assisted with one of these trips and enjoyed it very much
and would have joined immediately with this one too but we already
committed for March and Alan can't get time off from his new job, HOWEVER
we would like to make a donation towards this good cause, pm will follow ;D.
Freddie, if you do another trip later in the year please let us know as we
would really like to assist.
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 3/91
3/31/2018 Fabfender's Lesotho Mission
Quote:
Hi Sue, Pm sent. We will certainly post the other trips here as well.
The idea for this trip, is to go and put new tops on those desks and chairs as
seen in the pics that Ben added, add new chalk boards etc.
Quote:
PM sent
Quote:
Thanks,
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 4/91
3/31/2018 Fabfender's Lesotho Mission
Fabfender's Lesotho Mission
I assume the list of participants will be kept on the Thread in the Lesotho
section?
Need to check the dates with the boss and work, worthy cause and off the
beaten track adventure in one. Something right up my alley. :d
Have you perhaps got sizes and quantities on the table tops and seats?
Quote:
Manny, there is no list in either thread, as we have had interest shown but
nobody indicating that they are going.
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 5/91
3/31/2018 Fabfender's Lesotho Mission
Mike, it would be great to have there.
Quote:
I will take you up on your offer to source the timber, as I have no idea where
to start.
As for finances folks if anybody would like to make a contribution that will be
hugely appreciated - pm me for banking details.
Blessings
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 6/91
3/31/2018 Fabfender's Lesotho Mission
Blessings
Quote:
I am.
those tables look like the standard 600mm x 450mm that are sold as
classroom tables
similar to this.
http://hedcor.co.za/desking/educatio...duct/nest-desk
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 7/91
3/31/2018 Fabfender's Lesotho Mission
The 4x4 Action Group or THE HOUSE DOCTOR will sponsor a board.
Quote:
Quote:
Quote:
;D
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 8/91
3/31/2018 Fabfender's Lesotho Mission
Quote:
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 9/91
3/31/2018 Fabfender's Lesotho Mission
Quote:
Quote:
Quote:
I'm in.
Put name on list.
Will bring some tools.
Same in English;D
Quote:
Updated list
Quote:
I will have a chat to my partners.. Maybe I can attend, bring some tools,
gennis and a carpenter or two with..
PM sent.
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 11/91
3/31/2018 Fabfender's Lesotho Mission
Golfgt- Interested
MikeK - Interested
Higgins - Interested - Hoping to be in the country
Flipside - Interested
Hannes vZ - confirmed
Jannieljoubert - Confirmed - great stuff
OJ- K - confirmed - awesome
Quake - interested.
Ryno B - confirmed
Andrew bin Achmed - confirmed
Rudi Oost - obstacle walker - confirmed
List updated
Quote:
I am still prepared to have everything cut and prepared before the trip - as
mentioned earlier...
So I don't have a 4x4 but I can swing a hammer and work a paintbrush and
screwdriver. Also bring some tools.
If someone requires a co-pilot and "klippakker" for the road, let me know.
Quote:
Fab/ Ben
I know you have done it before..Could we have more info on the trip itself.
Where do we stay/camp?
What day do we plan to be where?
How far is it? IOW where are we going to in Lesotho?
How much time is given to the actual school intervention? (This will dictate
the time for travel)
Quote:
I am putting money away to fund Diesel for my trip (will be using my own
vehicle) - you are MORE than welcome to sit Shotgun in my Suz....
Quote:
Where do we stay/camp?
What day do we plan to be where?
How far is it? IOW where are we going to in Lesotho?
How much time is given to the actual school intervention?
(This will dictate the time for travel)
13 March: We travel to Solane on a very scenic road. Takes about 2-3 hours,
depending on how many "photo" stops.
We set up camp in the field next to the school, after which we start working
the desks.
Possibly an afternoon drive / swim in the river if time allows.
14 March: Finish up the desks (The plan is to finish them on the 13th though
- depending on how many people we are)
Go for an adventure drive, and explore the area.
15 March: Everyone finds their way back home. If you leave early enough it's
possible to go back via Sani Pass, but it will be a VERY long day.
Quote:
Maps?
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 14/91
3/31/2018 Fabfender's Lesotho Mission
13th - 14th: -28.903376, 28.577735
https://www.google.co.za/maps/place/...s0x0:0x0?hl=en
https://www.google.co.za/maps/dir/-2...!4m1!3e0?hl=en
We can also go via Katse dam wall on the way there, or the way back.
Quote:
Ben I agree, but as always time is a factor. Our plan for February is to try
and getting the building up and running. Hoping to have enough building
pro's available to MAKE that happen.
Dates are to be finalised, waiting for confirmation from the guy who is going
to oversee the building operations to confirm.
https://www.google.co.za/maps/dir/Ru...4483!1m0?hl=en
I'm still trying to get my head around it..The last time we drove in Lesotho, it
took us 7 hours for 200km
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 15/91
3/31/2018 Fabfender's Lesotho Mission
Two decent long drops available there, and plenty camping
space.
Quote:
From PTA / JHB we go via Villiers -> Frankfort -> Bethlehem -> Fouriesburg ->
Caledonspoort
Also, nothing (Except leave days available) stopping anyone from staying
longer, or exploring other areas of Lesotho
Quote:
From PTA / JHB we go via Villiers -> Frankfort -> Bethlehem ->
Fouriesburg -> Caledonspoort
ok I'll go
Hi Freddie.
Will be in SA, just need to see if Swambo will be ok after neck operation she
is going in for the end of this month. If all ok....we in!!!
Will make sure I pack the tent poles in this time. ;D
Quote:
What will be the best for the trip, Rubicon or Amarok? Methinks the Amarok
will have more loading space, but how wide is that last piece of road to
Solane
Quote:
What will be the best for the trip, Rubicon or Amarok? Methinks
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 17/91
3/31/2018 Fabfender's Lesotho Mission
the Amarok will have more loading space, but how wide is that
last piece of road to Solane
Quote:
Quote:
Quote:
It will make it, but you will miss the patrol once we start playing ;D
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 18/91
3/31/2018 Fabfender's Lesotho Mission
Quote:
Quote:
Quote:
No..
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 19/91
3/31/2018 Fabfender's Lesotho Mission
Quote:
Phixed
Quote:
Bwahahahaaa!!!
Quote:
We normally fill up at Bethlehem, and have plenty left when we get back
there.
Depends how big your tank is ;D
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 20/91
3/31/2018 Fabfender's Lesotho Mission
:)
Quote:
Who's Rubi?
Quote:
Would have loved to go with from here. Have been on several of these trips
with Freddie, some reccie as well. Ben and I have done some interesting
"expeditions" up there. The mud and river is something to revel in >:D
If ever you have the opportunity, please go with these guys, man it is worth
every second. Especially if there is a little time to kill and some keen
volunteers to go scout some new places and routes. Ben is always keen
though.... >:D
Quote:
Guess
I will have to complete the Kitchen, mow the lawn, go on my knees and beg.
>:D>:D
Did not mention the sky light and the indoor playroom did I? >:D>:D>:D
If still no! I will have to buy jewelry, marry, buy expensive gifts and the
answer will be????? :eek::eek:
But taking that baster's consumption in mind I will start the Amarok and go
in style ;D;D;D
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 21/91
3/31/2018 Fabfender's Lesotho Mission
Post a picture...
Quote:
Ja asb, dan kan julle nou bietjie ophou strooi praat op die thread, get a
room...
Manny
For your eyes only!
Attachment 330782
If I have missed anybody, sorry! But please just add your name to the list.
Guys...
At 600 x 450 for the desk tops we will need 3 SHEETS of MDF
For the seats and ancillaries(maybe a small bookshelf::)) we can easily add
another 2 SHEETS....
7/ Thinners - 15 Ltr
I will bring the following along: (So we do not have 10 of each there)
- Gennie (2.5kva)
- Compressor
- 2 x Spray Guns
- Fine sandpaper
- Router
- Table saw
- Skillsaw
- Screws / Hiltis / Drillbits
- Drilling machines
........
I will however need someone to help getting everything there - Wood alone
is appx 600kg....
There will be space in my car. I'm in Pretoria but we'll make a plan.
Hi Freddie
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 23/91
3/31/2018 Fabfender's Lesotho Mission
My brother (Deon) and I (Andre) will join. 99% sure unless something
unexpected happens.
Will bring:
5KVA Generator
Power Tools
Working Hands + Willingness to help
My boet is good with his hands & machinery :D, I can drive and swing a paint
brush ;D
Quote:
Quote:
Please remove my name then from the list,need to spend time with her.
Know you will understand my circumstances.
Catch you another time.;)
So little interest?
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 24/91
3/31/2018 Fabfender's Lesotho Mission
Quote:
Guys, sorry work and life have just got a bit frantic at the moment so I have
only now updated, the list ti include Avaneeden.
Let me start by saying a huge thank you to all that have already, put your
names down and committed to making this trip happen, it is hugely
appreciated. To Nutsman that has taken on responsibility of sourcing and
prepapring the materials etc - I am truly grateful.
This is going to be an amazing trip. I will be going to Lesotho from the 12-
15th of Feb, we will then go measure the desks in Solane' and report back
with actual info.
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 25/91
3/31/2018 Fabfender's Lesotho Mission
etc - I am truly grateful.
Hi Guys
Doesnt look like I can get off work.. Very very hectic at the moment..
Im sorry
Quote:
At 600 x 450 for the desk tops we will need 3 SHEETS of MDF
7/ Thinners - 15 Ltr
- Gennie (2.5kva)
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 26/91
3/31/2018 Fabfender's Lesotho Mission
- Compressor
- 2 x Spray Guns
- Fine sandpaper
- Router
- Table saw
- Skillsaw
- Screws / Hiltis / Drillbits
- Drilling machines
........
Would absolutely love to go with, but it's a bit of a long haul from Gaborone
for a weekend. Combining 2 of my passions, 4x4 and woodwork on one
weekend plus it's for a brilliant cause!
Quote:
I partly agree with you, BUT to achieve a good finish on the pine ply will not
be as easy or "cheap" (Shutterboard is made rough - as the name implies -
used for construction / shutters, etc )
Fair enough. I suppose it's because it's in my nature to watch the pennies,
that I don't mind the extra elbow grease to get the finish right. I had to build
my bar counter in Plett with shutter board when we first opened and once
we'd made some money, we replaced it with a nice thick sleeper top. Some
of the tables are still in service 17 years later.
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 27/91
3/31/2018 Fabfender's Lesotho Mission
I am working on getting some more folk to join in. So far we are quite a small
group going.
When will we see some more detailed plans of the trip? Maybe that will
attract more interest :D
Quote:
When will we see some more detailed plans of the trip? Maybe
that will attract more interest :D
Quote:
Thanks! ;D
If I am in SA I will like to join it will be awesome and the Ranger can help
with some towing as well
Hi Guys,
I'm keen to help out, but cant find the details for this trip...
When, Where, What, Who?
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 28/91
3/31/2018 Fabfender's Lesotho Mission
Thanks,
B
Quote:
Over to Fabfender...
Greetings Folks,
Some of you may be are aware that I run the Lesotho Mission
team and its efforts in Lesotho. We have a village that we care
for that is extremely remote (last we took people out there,
everybody was screaming that it’s not even on T4A) However
it is magnificently picturesque and the road in there is
spectacularly beautiful. However it is not an extreme 4x4
route, unless it rains then it can get exciting. Anybody
interested in seeing what we are about can visit our FB page:
https://www.facebook.com/groups/lesothomission
The trip is planned for 12 -15 March. There will be time for
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 29/91
3/31/2018 Fabfender's Lesotho Mission
some self drive - exploratory 4x4ing. We have asked Ben Van
Dyck to take care of the adventure travel stuff. There are no
routes, so all routes will have to be discovered. Hopefully we
will be able to discover routes that are worthwhile and we can
make it an annual event akin to the river trips.
Quote:
Quote:
I'm keen to help out, but cant find the details for this trip...
When, Where, What, Who?
Thanks,
B
Hi Barend,
These posts contain the bulk of the info dates, plans etc.
I am heading to Lesotho on Thursday and will then report back with more
detailed info.
Thanks for the feedback. I've joined the missions Fb group and will definitely
try to join the trip.
I grew up in Ficksburg, and the Lesotho mountains with the spectacular
views have always been ranked amongst my favorite trips!
Quote:
The school itself is missing a door, they say they have one but dont know
how to hang it. So we need necessary tools to cut and hang the door.
We have been asked if we can help to throw a thin concrete screed on the
school floor. Not sure if we will have time to do this, if not if we supply 5
bags of cement they will do it.
So we need to provide 5 bags of cement, and tools to do the job? They will
get river sand from the river.
2 x 255 x 285
1 x 435 x 285
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 31/91
3/31/2018 Fabfender's Lesotho Mission
3 x 438 x 275
1 x 290 x 465
The WFP is currently building new kitchens for all the schools in the area. So
the folk at Solane want to change their existing 3x3 building into a class
room when the new kitchen is finished.
It will require:
Not sure if it is possible, but if we have enough hands we can paint the
inside of the school white. i figure a cheap 25litre PVA should do the job. It is
built with rock and mud.
Good to see. Where can we deposit our "entry fee"? I'm guessing things
need to be bought now?
I will do / help with the following to complete the things I will take
responsibility for:
To do:
Order and cut all table and seat tops from 22mm Supawood. (5 x boards @
R930.00/board = R 4 650.00)
Router all edges round to minimise sharp edges and subsequent easy
damage.
To help:
I will bring tools to finish the tops and seats (Drill, Router, Sanders)
I will bring a electric planer, chisel, drill bits and contractors saw for door
fitments
Sandpaper
Generator
100ltr Compressor
Fuel for generator
Odds and ends tools and ancillaries we may need.
NEEDED:
Quote: 8 Attachment(s)
Quote:
To do:
Order and cut all table and seat tops from 22mm Supawood.
(5 x boards @ R930.00/board = R 4 650.00)
Router all edges round to minimise sharp edges and
subsequent easy damage.
To help:
I will bring tools to finish the tops and seats (Drill, Router,
Sanders)
I will bring a electric planer, chisel, drill bits and contractors
saw for door fitments
Sandpaper
Generator
100ltr Compressor
Fuel for generator
Odds and ends tools and ancillaries we may need.
NEEDED:
Nutsman, send me your banking details I will send the money you require for
the wood etc. Thank you again for running with us, it really is appreciated.
These are just some pics of the scenes along the way - just a lus maker.
Thanks, paid.
Will keep an eye on the thread if more is needed.
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 33/91
3/31/2018 Fabfender's Lesotho Mission
Thanks, paid.
Will keep an eye on the thread if more is needed.
Thank you.
I will also bring tools - is there any specific tools that may be required?
Quote: 5 Attachment(s)
Quote:
We meet up at Rampai Village at the hall that we always use. ( Rampai 001
S29 00.807 E28 32.480 2218 m )
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 34/91
3/31/2018 Fabfender's Lesotho Mission
I will be leaving Kempton at 5.00am so if anybody wants to meet up along
the way and travel in convoy, please let me know.
Set up camp and get busy with the work that needs to be done.
That night we will kuier around the fire. If each vehicle can bring 2 bags of
wood I figure we will should have enough.
There is a lake close by, so those that are so inclined can attempt some
fishing.
There is currently water in the village, so we should be okay for water and
we are close to a river that is flowing strongly at the moment.
I would definitelty like to travel the last part in Lesotho in convoy. Are you
going over Clarens? We might meet up there somewhere?
I have spoken to our local Jacks Paint, whom I must add, support greatly....
Door
2 x Locksets
2 x Hinge sets
Gutter bolts - 300(for the desks)
25ltr White PVA
Brushes & Rollers
5 x Cement
NOW: I will knowby week-end if they, and this is a good possibility, WILL
SPONSOR the quote all together or at least a portion of it....
HOLD THUMBS!!!!!!
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 35/91
3/31/2018 Fabfender's Lesotho Mission
Door
2 x Locksets
2 x Hinge sets
Gutter bolts - 300(for the desks)
25ltr White PVA
Brushes & Rollers
5 x Cement
HOLD THUMBS!!!!!!
Here's to holding thumbs. Thanks for your effort.
Quote:
But I suspect Ben and I may travel together, from Kempton so you are
welcome to join us from here.
I am keen to join you for the convoy. We will be leaving from Springfield
(Turfontein area), so can probably meet up close to Villiers One-Stop if you
go past that way. Anyone with UHF radios? They come in handy, especially in
convoy.
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 36/91
3/31/2018 Fabfender's Lesotho Mission
Freddie. Send me a pm with bank details please. I know you posted it.
Swambo needs it. I can sponsor something . You decide what. Even if its
part of Nutsmans fuel >:D
Quote:
Quote:
Quote:
PM sent
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 37/91
3/31/2018 Fabfender's Lesotho Mission
PM sent
Thanks. Got it . Swambo will do her thing Friday morning and send you a PM.
Quote:
That will be perfect. What time do you expect to be there? I will calculate my
travel time accordingly.
Quote:
Heksie:)
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 38/91
3/31/2018 Fabfender's Lesotho Mission
Randfontein, Sasolburg, Heilbron, Petrus Steyn, Reitz, Bethlehem - hier kry
ons die balans van die malles....
Ryno,
Quote:
Heksie:)
Baie dankie.
Quote:
Ryno,
[QUOTE=Fabfender;2662950
Quote:
Perfect, we will meet up with you at the Petroport, then Convoy from there
on.
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 39/91
3/31/2018 Fabfender's Lesotho Mission
Quote:
It's been a while since I posted the list, can I ask that you please update the
list add your name & passengers names.
For those that still need to pay our banking details are:
Fuel : you need to have sufficient fuel for around 600km's including low
range travelling.
Braai's: Folks if at all possible we need to braai off the ground, so if you have
portable braai's please bring it with. Otherwise we make one communal fire
and braai from there.
You forgot to mention that there are no showers. I'll be taking my portable
one with, which will be available for use, but if you have one pack it.
We can get water for it from the river.
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 40/91
3/31/2018 Fabfender's Lesotho Mission
Hi Fredie. Kan my naam opsit as belangstellend. Kyk net of dit gaan uitwerk.
Stem saam, as mens die borde kla kan sny en router, sal baie makliker wees
as om daai borde te vervoer. Kan n bord of 2 skenk. Sal jou kontak.
Updated:
<O:p</O:p
Damn you Freddie, you are really rubbing it in. Such a pity that we had
already booked for the GGW. To everyone going, may you all travel safely,
have fun, but above all, deliver the WORD.
Quote:
For those that still need to pay our banking details are:
Quote:
For those that still need to pay our banking details are:
Quote:
<o:p</o
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 42/91
3/31/2018 Fabfender's Lesotho Mission
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 43/91
3/31/2018 Fabfender's Lesotho Mission
Andre van Eeden + Deon van Eeden – confirmed
Hendrick – Interested
Quote:
Quote:
Door
2 x Locksets
2 x Hinge sets
Gutter bolts - 300(for the desks)
25ltr White PVA
Brushes & Rollers
5 x Cement
HOLD THUMBS!!!!!!
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 44/91
3/31/2018 Fabfender's Lesotho Mission
How is the work coming along? Any help needed? The finances sorted?
Quote:
The timber & varnish etc has been ordered and paid for.
Still waiting to hear about the paint etc.
Nutsman is currently in PE with his mother who is having heart surgery.
Please keep him in your prayers.
Quote:
I am in communication with Jacks Paint to see if they can help, if in the least,
it will still help.....
I will prolly be back in Jhb on Sat, pick up the wood and start working on that
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 45/91
3/31/2018 Fabfender's Lesotho Mission
Quote:
Ryno,
With the Generator loaded (if still required to bring? 5KV) in the Pajero I am
sure I will still have plenty additional space. Let me know if there is anything
I can collect from anyone to take along. I can meet up the weekend before
we go through and load up some stuff.
Quote:
Ryno,
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 46/91
3/31/2018 Fabfender's Lesotho Mission
Quote:
Folks just a reminder to those that have not confirmed yet, please let me
know if you are able to join us.
For those that haven't yet pay please could you do it as soon as possible.
Quote:
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 47/91
3/31/2018 Fabfender's Lesotho Mission
Paid
Was bietjie doenig....my router en home made Randfontein special idees het
darm gehelp....lol.
http://tapatalk.imageshack.com/v2/15...499a135a8b.jpghttp://tapatalk.imageshack.com/v2/15...e055a1a3aa.jpg
Pieter , daardie goed moes al klaar gewees het !! Klim van die forum af en
gaan werk :p:p:p>:D>:D>:D
Wow netjies!
Hi All,
Quote:
Paid
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 48/91
3/31/2018 Fabfender's Lesotho Mission
Quote:
Thank you
Rudi.oost kom more gou oor....hy kom logistiek bespreek...so dink hy....ek
gaan hom leer skuur en spray pappie....daai supa is dors, het vandag 5 ltr
Sanding sealer gaan koop en gebruik.....
Quote:
En dit my maat is die rede waarom ek dit hier doen....die finale laag en
skuurwerk sal nogsteeds daar gedoen word.....
Dit is nie te se omdat iemand iets verniet kry, hulle maar net ja en amen
moet se vir substandaard nie.....so iok dienooreenkomstig....die mense wat
hiervoor betaal.....ek wil verseker nie gelable word as n kansvatter of
geldvermorser nie.....
Dankie Rudi vir die hulp vandag....ons het darm so vinnig kon weg glip
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 49/91
3/31/2018 Fabfender's Lesotho Mission
Droogeheuwel toe om op die hope en gate te gaan speel....15jarige lady-
suz gaan die trip kan maak.....
http://i1142.photobucket.com/albums/...308_112611.jpg
Net bewys dat Nutsman ook iets gedoen het. En daar is baie wat moet saam
gaan.
http://i1142.photobucket.com/albums/...308_112622.jpg
Quote:
Quote:
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 50/91
3/31/2018 Fabfender's Lesotho Mission
Haha - omtrent!!
http://www.4x4community.co.za/forum/...1&d=1425885268
Manne daai werk lyk stunning! Hell dit gaan beter lyk as ons local skool
bankies! :)
As ek so na daai weer kyk smaak dit my ons is in vir 'n lekker sessie. Met
daai water daar bo kom die koue ook saam, aande gaan koud wees (so
2mm koud). brrrrrrrrr.
This trip is going to be amazing. Really looking forward to sharing this trip
with each of you.
You really need to be prepared for temps of around -5. Then chuck in some
protection for wet weather. If you have gumboots and you have place, take
them with, you can thank me later.
I will post an update on the trip tomorrow, still waiting to hear from one
other vehicle if they are joining us.
Ek hoop nie ek het al daardie moeite gedoen met 'n dual battery system om
die yskas aan die gang te hou, as dit so koud gaan wees dat 'n yskas nie
nodig is nie..;D
Anyway, is daar enigiets waarmee ek nog kan help? Ek behoort nog bietjie
plek agter in die bakkie beskikbaar te hê indien benodig? Ek het net 'n
seiltjie wat nie goed seel nie, so hout kan dalk nat word..
Quote:
As dit bewolk is, is dit gewoonlik bietjie warmer as wanneer dit oopgetrek is
Quote:
Waar wat jy se daar. Maar of dit nou -1 of -5 is bly dit nogsteeds damn koud
;D
Quote:
Ekt al vantevore daar in -16 gekamp langs 'n rivier. Dit raak nogal
interessant ;)
Quote:
Hi Freddie
Can you maybe give an idea of communication around there as well?
Thanks
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 52/91
3/31/2018 Fabfender's Lesotho Mission
Quote:
Quote:
Dit was in 'n Junie maand, en in 'n ander area as die, en reg langs 'n rivier ;D
Quote:
Ockert, looks like we will have enough radios for each vehicle in convoy.
Cell signal is sporadic but available in Rampai. Roaming rates apply. In
Solane there is no cell signal as far as I am aware. But Ben normally has a
sat phone, if required for emergencies.
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 53/91
3/31/2018 Fabfender's Lesotho Mission
reception very close to the village.
3. I'm taking a sat phone with, so you are welcome to use it.
4. Very few of the locals can speak English. But we have interpreters. (And
most of the teachers at the school can speak some broken English
Quote:
In daai geval sal ek maar 2 kortbroeke moet aan trek. Het laas jaar julie afri
ski gedoen met 'n kortbroek en dit was -10°C
Quote:
Quote:
Nee wat, ek is nou nie so kouerig nie, sal maar net 2 onderbroeke aantrek
;D;D
Ek hoop net Freddie gee ons 'n kansie om darm so tussen die werk deur
ietsie te peusel - bleddie slawedrywer....
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 54/91
3/31/2018 Fabfender's Lesotho Mission
Quote:
Yes, absolutely. Will leave the phone on the whole time. They can also SMS
to it for free from the website. (<!--[if gte mso 9]><xml>
<w:WordDocument> <w:View>Normal</w:View> <w:Zoom>0</w:Zoom>
<w:TrackMoves/> <w:TrackFormatting/> <w:PunctuationKerning/>
<w:ValidateAgainstSchemas/>
<w:SaveIfXMLInvalid>false</w:SaveIfXMLInvalid>
<w:IgnoreMixedContent>false</w:IgnoreMixedContent>
<w:AlwaysShowPlaceholderText>false</w:AlwaysShowPlaceholderText>
<w:DoNotPromoteQF/> <w:LidThemeOther>EN-ZA</w:LidThemeOther>
<w:LidThemeAsian>X-NONE</w:LidThemeAsian>
<w:LidThemeComplexScript>X-NONE</w:LidThemeComplexScript>
<w:Compatibility> <w:BreakWrappedTables/> <w:SnapToGridInCell/>
<w:WrapTextWithPunct/> <w:UseAsianBreakRules/> <w:DontGrowAutofit/>
<w:SplitPgBreakAndParaMark/> <w:EnableOpenTypeKerning/>
<w:DontFlipMirrorIndents/> <w:OverrideTableStyleHps/> </w:Compatibility>
<w:BrowserLevel>MicrosoftInternetExplorer4</w:BrowserLevel>
<m:mathPr> <m:mathFont m:val="Cambria Math"/> <m:brkBin
m:val="before"/> <m:brkBinSub m:val="--"/> <m:smallFrac
m:val="off"/> <m:dispDef/> <m:lMargin m:val="0"/> <m:rMargin m:val="0"/>
<m:defJc m:val="centerGroup"/> <m:wrapIndent m:val="1440"/> <m:intLim
m:val="subSup"/> <m:naryLim m:val="undOvr"/> </m:mathPr>
</w:WordDocument> </xml><![endif]-->www.iridium.com)<!--[if gte mso 9]>
<xml> <w:LatentStyles DefLockedState="false"
DefUnhideWhenUsed="false" DefSemiHidden="false" DefQFormat="false"
DefPriority="99" LatentStyleCount="371"> <w:LsdException Locked="false"
Priority="0" QFormat="true" Name="Normal"/> <w:LsdException
Locked="false" Priority="9" QFormat="true" Name="heading 1"/>
<w:LsdException Locked="false" Priority="9" SemiHidden="true"
UnhideWhenUsed="true" QFormat="true" Name="heading 2"/>
<w:LsdException Locked="false" Priority="9" SemiHidden="true"
UnhideWhenUsed="true" QFormat="true" Name="heading 3"/>
<w:LsdException Locked="false" Priority="9" SemiHidden="true"
UnhideWhenUsed="true" QFormat="true" Name="heading 4"/>
<w:LsdException Locked="false" Priority="9" SemiHidden="true"
UnhideWhenUsed="true" QFormat="true" Name="heading 5"/>
<w:LsdException Locked="false" Priority="9" SemiHidden="true"
UnhideWhenUsed="true" QFormat="true" Name="heading 6"/>
<w:LsdException Locked="false" Priority="9" SemiHidden="true"
UnhideWhenUsed="true" QFormat="true" Name="heading 7"/>
<w:LsdException Locked="false" Priority="9" SemiHidden="true"
UnhideWhenUsed="true" QFormat="true" Name="heading 8"/>
<w:LsdException Locked="false" Priority="9" SemiHidden="true"
UnhideWhenUsed="true" QFormat="true" Name="heading 9"/>
<w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="index 1"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="index
2"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="index 3"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="index
4"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="index 5"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="index
6"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="index 7"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="index
8"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="index 9"/> <w:LsdException
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 55/91
3/31/2018 Fabfender's Lesotho Mission
Locked="false" Priority="39" SemiHidden="true" UnhideWhenUsed="true"
Name="toc 1"/> <w:LsdException Locked="false" Priority="39"
SemiHidden="true" UnhideWhenUsed="true" Name="toc 2"/>
<w:LsdException Locked="false" Priority="39" SemiHidden="true"
UnhideWhenUsed="true" Name="toc 3"/> <w:LsdException Locked="false"
Priority="39" SemiHidden="true" UnhideWhenUsed="true" Name="toc 4"/>
<w:LsdException Locked="false" Priority="39" SemiHidden="true"
UnhideWhenUsed="true" Name="toc 5"/> <w:LsdException Locked="false"
Priority="39" SemiHidden="true" UnhideWhenUsed="true" Name="toc 6"/>
<w:LsdException Locked="false" Priority="39" SemiHidden="true"
UnhideWhenUsed="true" Name="toc 7"/> <w:LsdException Locked="false"
Priority="39" SemiHidden="true" UnhideWhenUsed="true" Name="toc 8"/>
<w:LsdException Locked="false" Priority="39" SemiHidden="true"
UnhideWhenUsed="true" Name="toc 9"/> <w:LsdException Locked="false"
SemiHidden="true" UnhideWhenUsed="true" Name="Normal Indent"/>
<w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="footnote text"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true"
Name="annotation text"/> <w:LsdException Locked="false"
SemiHidden="true" UnhideWhenUsed="true" Name="header"/>
<w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="footer"/> <w:LsdException Locked="false"
SemiHidden="true" UnhideWhenUsed="true" Name="index heading"/>
<w:LsdException Locked="false" Priority="35" SemiHidden="true"
UnhideWhenUsed="true" QFormat="true" Name="caption"/>
<w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="table of figures"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true"
Name="envelope address"/> <w:LsdException Locked="false"
SemiHidden="true" UnhideWhenUsed="true" Name="envelope return"/>
<w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="footnote reference"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true"
Name="annotation reference"/> <w:LsdException Locked="false"
SemiHidden="true" UnhideWhenUsed="true" Name="line number"/>
<w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="page number"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true"
Name="endnote reference"/> <w:LsdException Locked="false"
SemiHidden="true" UnhideWhenUsed="true" Name="endnote text"/>
<w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="table of authorities"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true"
Name="macro"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="toa heading"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="List"/>
<w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="List Bullet"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="List
Number"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="List 2"/> <w:LsdException Locked="false"
SemiHidden="true" UnhideWhenUsed="true" Name="List 3"/>
<w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="List 4"/> <w:LsdException Locked="false"
SemiHidden="true" UnhideWhenUsed="true" Name="List 5"/>
<w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="List Bullet 2"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="List
Bullet 3"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="List Bullet 4"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="List
Bullet 5"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="List Number 2"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="List
Number 3"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="List Number 4"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="List
Number 5"/> <w:LsdException Locked="false" Priority="10" QFormat="true"
Name="Title"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Closing"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true"
Name="Signature"/> <w:LsdException Locked="false" Priority="1"
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 56/91
3/31/2018 Fabfender's Lesotho Mission
SemiHidden="true" UnhideWhenUsed="true" Name="Default Paragraph
Font"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Body Text"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Body
Text Indent"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="List Continue"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="List
Continue 2"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="List Continue 3"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="List
Continue 4"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="List Continue 5"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true"
Name="Message Header"/> <w:LsdException Locked="false" Priority="11"
QFormat="true" Name="Subtitle"/> <w:LsdException Locked="false"
SemiHidden="true" UnhideWhenUsed="true" Name="Salutation"/>
<w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Date"/> <w:LsdException Locked="false"
SemiHidden="true" UnhideWhenUsed="true" Name="Body Text First
Indent"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Body Text First Indent 2"/>
<w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Note Heading"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Body
Text 2"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Body Text 3"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Body
Text Indent 2"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Body Text Indent 3"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Block
Text"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Hyperlink"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true"
Name="FollowedHyperlink"/> <w:LsdException Locked="false" Priority="22"
QFormat="true" Name="Strong"/> <w:LsdException Locked="false"
Priority="20" QFormat="true" Name="Emphasis"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true"
Name="Document Map"/> <w:LsdException Locked="false"
SemiHidden="true" UnhideWhenUsed="true" Name="Plain Text"/>
<w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="E-mail Signature"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="HTML
Top of Form"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="HTML Bottom of Form"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Normal
(Web)"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="HTML Acronym"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="HTML
Address"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="HTML Cite"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="HTML
Code"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="HTML Definition"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="HTML
Keyboard"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="HTML Preformatted"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="HTML
Sample"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="HTML Typewriter"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="HTML
Variable"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Normal Table"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true"
Name="annotation subject"/> <w:LsdException Locked="false"
SemiHidden="true" UnhideWhenUsed="true" Name="No List"/>
<w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Outline List 1"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Outline
List 2"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Outline List 3"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
Simple 1"/> <w:LsdException Locked="false" SemiHidden="true"
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 57/91
3/31/2018 Fabfender's Lesotho Mission
UnhideWhenUsed="true" Name="Table Simple 2"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
Simple 3"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table Classic 1"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
Classic 2"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table Classic 3"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
Classic 4"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table Colorful 1"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
Colorful 2"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table Colorful 3"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
Columns 1"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table Columns 2"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
Columns 3"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table Columns 4"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
Columns 5"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table Grid 1"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
Grid 2"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table Grid 3"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
Grid 4"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table Grid 5"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
Grid 6"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table Grid 7"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
Grid 8"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table List 1"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
List 2"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table List 3"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
List 4"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table List 5"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
List 6"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table List 7"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
List 8"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table 3D effects 1"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
3D effects 2"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table 3D effects 3"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
Contemporary"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table Elegant"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
Professional"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table Subtle 1"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
Subtle 2"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table Web 1"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Table
Web 2"/> <w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table Web 3"/> <w:LsdException
Locked="false" SemiHidden="true" UnhideWhenUsed="true" Name="Balloon
Text"/> <w:LsdException Locked="false" Priority="39" Name="Table Grid"/>
<w:LsdException Locked="false" SemiHidden="true"
UnhideWhenUsed="true" Name="Table Theme"/> <w:LsdException
Locked="false" SemiHidden="true" Name="Placeholder Text"/>
<w:LsdException Locked="false" Priority="1" QFormat="true" Name="No
Spacing"/> <w:LsdException Locked="false" Priority="60" Name="Light
Shading"/> <w:LsdException Locked="false" Priority="61" Name="Light
List"/> <w:LsdException Locked="false" Priority="62" Name="Light Grid"/>
<w:LsdException Locked="false" Priority="63" Name="Medium Shading 1"/>
<w:LsdException Locked="false" Priority="64" Name="Medium Shading 2"/>
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 58/91
3/31/2018 Fabfender's Lesotho Mission
<w:LsdException Locked="false" Priority="65" Name="Medium List 1"/>
<w:LsdException Locked="false" Priority="66" Name="Medium List 2"/>
<w:LsdException Locked="false" Priority="67" Name="Medium Grid 1"/>
<w:LsdException Locked="false" Priority="68" Name="Medium Grid 2"/>
<w:LsdException Locked="false" Priority="69" Name="Medium Grid 3"/>
<w:LsdException Locked="false" Priority="70" Name="Dark List"/>
<w:LsdException Locked="false" Priority="71" Name="Colorful Shading"/>
<w:LsdException Locked="false" Priority="72" Name="Colorful List"/>
<w:LsdException Locked="false" Priority="73" Name="Colorful Grid"/>
<w:LsdException Locked="false" Priority="60" Name="Light Shading Accent
1"/> <w:LsdException Locked="false" Priority="61" Name="Light List Accent
1"/> <w:LsdException Locked="false" Priority="62" Name="Light Grid Accent
1"/> <w:LsdException Locked="false" Priority="63" Name="Medium Shading
1 Accent 1"/> <w:LsdException Locked="false" Priority="64" Name="Medium
Shading 2 Accent 1"/> <w:LsdException Locked="false" Priority="65"
Name="Medium List 1 Accent 1"/> <w:LsdException Locked="false"
SemiHidden="true" Name="Revision"/> <w:LsdException Locked="false"
Priority="34" QFormat="true" Name="List Paragraph"/> <w:LsdException
Locked="false" Priority="29" QFormat="true" Name="Quote"/>
<w:LsdException Locked="false" Priority="30" QFormat="true"
Name="Intense Quote"/> <w:LsdException Locked="false" Priority="66"
Name="Medium List 2 Accent 1"/> <w:LsdException Locked="false"
Priority="67" Name="Medium Grid 1 Accent 1"/> <w:LsdException
Locked="false" Priority="68" Name="Medium Grid 2 Accent 1"/>
<w:LsdException Locked="false" Priority="69" Name="Medium Grid 3 Accent
1"/> <w:LsdException Locked="false" Priority="70" Name="Dark List Accent
1"/> <w:LsdException Locked="false" Priority="71" Name="Colorful Shading
Accent 1"/> <w:LsdException Locked="false" Priority="72" Name="Colorful
List Accent 1"/> <w:LsdException Locked="false" Priority="73"
Name="Colorful Grid Accent 1"/> <w:LsdException Locked="false"
Priority="60" Name="Light Shading Accent 2"/> <w:LsdException
Locked="false" Priority="61" Name="Light List Accent 2"/> <w:LsdException
Locked="false" Priority="62" Name="Light Grid Accent 2"/> <w:LsdException
Locked="false" Priority="63" Name="Medium Shading 1 Accent 2"/>
<w:LsdException Locked="false" Priority="64" Name="Medium Shading 2
Accent 2"/> <w:LsdException Locked="false" Priority="65" Name="Medium
List 1 Accent 2"/> <w:LsdException Locked="false" Priority="66"
Name="Medium List 2 Accent 2"/> <w:LsdException Locked="false"
Priority="67" Name="Medium Grid 1 Accent 2"/> <w:LsdException
Locked="false" Priority="68" Name="Medium Grid 2 Accent 2"/>
<w:LsdException Locked="false" Priority="69" Name="Medium Grid 3 Accent
2"/> <w:LsdException Locked="false" Priority="70" Name="Dark List Accent
2"/> <w:LsdException Locked="false" Priority="71" Name="Colorful Shading
Accent 2"/> <w:LsdException Locked="false" Priority="72" Name="Colorful
List Accent 2"/> <w:LsdException Locked="false" Priority="73"
Name="Colorful Grid Accent 2"/> <w:LsdException Locked="false"
Priority="60" Name="Light Shading Accent 3"/> <w:LsdException
Locked="false" Priority="61" Name="Light List Accent 3"/> <w:LsdException
Locked="false" Priority="62" Name="Light Grid Accent 3"/> <w:LsdException
Locked="false" Priority="63" Name="Medium Shading 1 Accent 3"/>
<w:LsdException Locked="false" Priority="64" Name="Medium Shading 2
Accent 3"/> <w:LsdException Locked="false" Priority="65" Name="Medium
List 1 Accent 3"/> <w:LsdException Locked="false" Priority="66"
Name="Medium List 2 Accent 3"/> <w:LsdException Locked="false"
Priority="67" Name="Medium Grid 1 Accent 3"/> <w:LsdException
Locked="false" Priority="68" Name="Medium Grid 2 Accent 3"/>
<w:LsdException Locked="false" Priority="69" Name="Medium Grid 3 Accent
3"/> <w:LsdException Locked="false" Priority="70" Name="Dark List Accent
3"/> <w:LsdException Locked="false" Priority="71" Name="Colorful Shading
Accent 3"/> <w:LsdException Locked="false" Priority="72" Name="Colorful
List Accent 3"/> <w:LsdException Locked="false" Priority="73"
Name="Colorful Grid Accent 3"/> <w:LsdException Locked="false"
Priority="60" Name="Light Shading Accent 4"/> <w:LsdException
Locked="false" Priority="61" Name="Light List Accent 4"/> <w:LsdException
Locked="false" Priority="62" Name="Light Grid Accent 4"/> <w:LsdException
Locked="false" Priority="63" Name="Medium Shading 1 Accent 4"/>
<w:LsdException Locked="false" Priority="64" Name="Medium Shading 2
Accent 4"/> <w:LsdException Locked="false" Priority="65" Name="Medium
List 1 Accent 4"/> <w:LsdException Locked="false" Priority="66"
Name="Medium List 2 Accent 4"/> <w:LsdException Locked="false"
Priority="67" Name="Medium Grid 1 Accent 4"/> <w:LsdException
Locked="false" Priority="68" Name="Medium Grid 2 Accent 4"/>
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 59/91
3/31/2018 Fabfender's Lesotho Mission
<w:LsdException Locked="false" Priority="69" Name="Medium Grid 3 Accent
4"/> <w:LsdException Locked="false" Priority="70" Name="Dark List Accent
4"/> <w:LsdException Locked="false" Priority="71" Name="Colorful Shading
Accent 4"/> <w:LsdException Locked="false" Priority="72" Name="Colorful
List Accent 4"/> <w:LsdException Locked="false" Priority="73"
Name="Colorful Grid Accent 4"/> <w:LsdException Locked="false"
Priority="60" Name="Light Shading Accent 5"/> <w:LsdException
Locked="false" Priority="61" Name="Light List Accent 5"/> <w:LsdException
Locked="false" Priority="62" Name="Light Grid Accent 5"/> <w:LsdException
Locked="false" Priority="63" Name="Medium Shading 1 Accent 5"/>
<w:LsdException Locked="false" Priority="64" Name="Medium Shading 2
Accent 5"/> <w:LsdException Locked="false" Priority="65" Name="Medium
List 1 Accent 5"/> <w:LsdException Locked="false" Priority="66"
Name="Medium List 2 Accent 5"/> <w:LsdException Locked="false"
Priority="67" Name="Medium Grid 1 Accent 5"/> <w:LsdException
Locked="false" Priority="68" Name="Medium Grid 2 Accent 5"/>
<w:LsdException Locked="false" Priority="69" Name="Medium Grid 3 Accent
5"/> <w:LsdException Locked="false" Priority="70" Name="Dark List Accent
5"/> <w:LsdException Locked="false" Priority="71" Name="Colorful Shading
Accent 5"/> <w:LsdException Locked="false" Priority="72" Name="Colorful
List Accent 5"/> <w:LsdException Locked="false" Priority="73"
Name="Colorful Grid Accent 5"/> <w:LsdException Locked="false"
Priority="60" Name="Light Shading Accent 6"/> <w:LsdException
Locked="false" Priority="61" Name="Light List Accent 6"/> <w:LsdException
Locked="false" Priority="62" Name="Light Grid Accent 6"/> <w:LsdException
Locked="false" Priority="63" Name="Medium Shading 1 Accent 6"/>
<w:LsdException Locked="false" Priority="64" Name="Medium Shading 2
Accent 6"/> <w:LsdException Locked="false" Priority="65" Name="Medium
List 1 Accent 6"/> <w:LsdException Locked="false" Priority="66"
Name="Medium List 2 Accent 6"/> <w:LsdException Locked="false"
Priority="67" Name="Medium Grid 1 Accent 6"/> <w:LsdException
Locked="false" Priority="68" Name="Medium Grid 2 Accent 6"/>
<w:LsdException Locked="false" Priority="69" Name="Medium Grid 3 Accent
6"/> <w:LsdException Locked="false" Priority="70" Name="Dark List Accent
6"/> <w:LsdException Locked="false" Priority="71" Name="Colorful Shading
Accent 6"/> <w:LsdException Locked="false" Priority="72" Name="Colorful
List Accent 6"/> <w:LsdException Locked="false" Priority="73"
Name="Colorful Grid Accent 6"/> <w:LsdException Locked="false"
Priority="19" QFormat="true" Name="Subtle Emphasis"/> <w:LsdException
Locked="false" Priority="21" QFormat="true" Name="Intense Emphasis"/>
<w:LsdException Locked="false" Priority="31" QFormat="true"
Name="Subtle Reference"/> <w:LsdException Locked="false" Priority="32"
QFormat="true" Name="Intense Reference"/> <w:LsdException
Locked="false" Priority="33" QFormat="true" Name="Book Title"/>
<w:LsdException Locked="false" Priority="37" SemiHidden="true"
UnhideWhenUsed="true" Name="Bibliography"/> <w:LsdException
Locked="false" Priority="39" SemiHidden="true" UnhideWhenUsed="true"
QFormat="true" Name="TOC Heading"/> <w:LsdException Locked="false"
Priority="41" Name="Plain Table 1"/> <w:LsdException Locked="false"
Priority="42" Name="Plain Table 2"/> <w:LsdException Locked="false"
Priority="43" Name="Plain Table 3"/> <w:LsdException Locked="false"
Priority="44" Name="Plain Table 4"/> <w:LsdException Locked="false"
Priority="45" Name="Plain Table 5"/> <w:LsdException Locked="false"
Priority="40" Name="Grid Table Light"/> <w:LsdException Locked="false"
Priority="46" Name="Grid Table 1 Light"/> <w:LsdException Locked="false"
Priority="47" Name="Grid Table 2"/> <w:LsdException Locked="false"
Priority="48" Name="Grid Table 3"/> <w:LsdException Locked="false"
Priority="49" Name="Grid Table 4"/> <w:LsdException Locked="false"
Priority="50" Name="Grid Table 5 Dark"/> <w:LsdException Locked="false"
Priority="51" Name="Grid Table 6 Colorful"/> <w:LsdException
Locked="false" Priority="52" Name="Grid Table 7 Colorful"/>
<w:LsdException Locked="false" Priority="46" Name="Grid Table 1 Light
Accent 1"/> <w:LsdException Locked="false" Priority="47" Name="Grid Table
2 Accent 1"/> <w:LsdException Locked="false" Priority="48" Name="Grid
Table 3 Accent 1"/> <w:LsdException Locked="false" Priority="49"
Name="Grid Table 4 Accent 1"/> <w:LsdException Locked="false"
Priority="50" Name="Grid Table 5 Dark Accent 1"/> <w:LsdException
Locked="false" Priority="51" Name="Grid Table 6 Colorful Accent 1"/>
<w:LsdException Locked="false" Priority="52" Name="Grid Table 7 Colorful
Accent 1"/> <w:LsdException Locked="false" Priority="46" Name="Grid Table
1 Light Accent 2"/> <w:LsdException Locked="false" Priority="47"
Name="Grid Table 2 Accent 2"/> <w:LsdException Locked="false"
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 60/91
3/31/2018 Fabfender's Lesotho Mission
Priority="48" Name="Grid Table 3 Accent 2"/> <w:LsdException
Locked="false" Priority="49" Name="Grid Table 4 Accent 2"/>
<w:LsdException Locked="false" Priority="50" Name="Grid Table 5 Dark
Accent 2"/> <w:LsdException Locked="false" Priority="51" Name="Grid Table
6 Colorful Accent 2"/> <w:LsdException Locked="false" Priority="52"
Name="Grid Table 7 Colorful Accent 2"/> <w:LsdException Locked="false"
Priority="46" Name="Grid Table 1 Light Accent 3"/> <w:LsdException
Locked="false" Priority="47" Name="Grid Table 2 Accent 3"/>
<w:LsdException Locked="false" Priority="48" Name="Grid Table 3 Accent
3"/> <w:LsdException Locked="false" Priority="49" Name="Grid Table 4
Accent 3"/> <w:LsdException Locked="false" Priority="50" Name="Grid Table
5 Dark Accent 3"/> <w:LsdException Locked="false" Priority="51"
Name="Grid Table 6 Colorful Accent 3"/> <w:LsdException Locked="false"
Priority="52" Name="Grid Table 7 Colorful Accent 3"/> <w:LsdException
Locked="false" Priority="46" Name="Grid Table 1 Light Accent 4"/>
<w:LsdException Locked="false" Priority="47" Name="Grid Table 2 Accent
4"/> <w:LsdException Locked="false" Priority="48" Name="Grid Table 3
Accent 4"/> <w:LsdException Locked="false" Priority="49" Name="Grid Table
4 Accent 4"/> <w:LsdException Locked="false" Priority="50" Name="Grid
Table 5 Dark Accent 4"/> <w:LsdException Locked="false" Priority="51"
Name="Grid Table 6 Colorful Accent 4"/> <w:LsdException Locked="false"
Priority="52" Name="Grid Table 7 Colorful Accent 4"/> <w:LsdException
Locked="false" Priority="46" Name="Grid Table 1 Light Accent 5"/>
<w:LsdException Locked="false" Priority="47" Name="Grid Table 2 Accent
5"/> <w:LsdException Locked="false" Priority="48" Name="Grid Table 3
Accent 5"/> <w:LsdException Locked="false" Priority="49" Name="Grid Table
4 Accent 5"/> <w:LsdException Locked="false" Priority="50" Name="Grid
Table 5 Dark Accent 5"/> <w:LsdException Locked="false" Priority="51"
Name="Grid Table 6 Colorful Accent 5"/> <w:LsdException Locked="false"
Priority="52" Name="Grid Table 7 Colorful Accent 5"/> <w:LsdException
Locked="false" Priority="46" Name="Grid Table 1 Light Accent 6"/>
<w:LsdException Locked="false" Priority="47" Name="Grid Table 2 Accent
6"/> <w:LsdException Locked="false" Priority="48" Name="Grid Table 3
Accent 6"/> <w:LsdException Locked="false" Priority="49" Name="Grid Table
4 Accent 6"/> <w:LsdException Locked="false" Priority="50" Name="Grid
Table 5 Dark Accent 6"/> <w:LsdException Locked="false" Priority="51"
Name="Grid Table 6 Colorful Accent 6"/> <w:LsdException Locked="false"
Priority="52" Name="Grid Table 7 Colorful Accent 6"/> <w:LsdException
Locked="false" Priority="46" Name="List Table 1 Light"/> <w:LsdException
Locked="false" Priority="47" Name="List Table 2"/> <w:LsdException
Locked="false" Priority="48" Name="List Table 3"/> <w:LsdException
Locked="false" Priority="49" Name="List Table 4"/> <w:LsdException
Locked="false" Priority="50" Name="List Table 5 Dark"/> <w:LsdException
Locked="false" Priority="51" Name="List Table 6 Colorful"/>
<w:LsdException Locked="false" Priority="52" Name="List Table 7
Colorful"/> <w:LsdException Locked="false" Priority="46" Name="List Table
1 Light Accent 1"/> <w:LsdException Locked="false" Priority="47"
Name="List Table 2 Accent 1"/> <w:LsdException Locked="false"
Priority="48" Name="List Table 3 Accent 1"/> <w:LsdException
Locked="false" Priority="49" Name="List Table 4 Accent 1"/>
<w:LsdException Locked="false" Priority="50" Name="List Table 5 Dark
Accent 1"/> <w:LsdException Locked="false" Priority="51" Name="List Table
6 Colorful Accent 1"/> <w:LsdException Locked="false" Priority="52"
Name="List Table 7 Colorful Accent 1"/> <w:LsdException Locked="false"
Priority="46" Name="List Table 1 Light Accent 2"/> <w:LsdException
Locked="false" Priority="47" Name="List Table 2 Accent 2"/>
<w:LsdException Locked="false" Priority="48" Name="List Table 3 Accent
2"/> <w:LsdException Locked="false" Priority="49" Name="List Table 4
Accent 2"/> <w:LsdException Locked="false" Priority="50" Name="List Table
5 Dark Accent 2"/> <w:LsdException Locked="false" Priority="51"
Name="List Table 6 Colorful Accent 2"/> <w:LsdException Locked="false"
Priority="52" Name="List Table 7 Colorful Accent 2"/> <w:LsdException
Locked="false" Priority="46" Name="List Table 1 Light Accent 3"/>
<w:LsdException Locked="false" Priority="47" Name="List Table 2 Accent
3"/> <w:LsdException Locked="false" Priority="48" Name="List Table 3
Accent 3"/> <w:LsdException Locked="false" Priority="49" Name="List Table
4 Accent 3"/> <w:LsdException Locked="false" Priority="50" Name="List
Table 5 Dark Accent 3"/> <w:LsdException Locked="false" Priority="51"
Name="List Table 6 Colorful Accent 3"/> <w:LsdException Locked="false"
Priority="52" Name="List Table 7 Colorful Accent 3"/> <w:LsdException
Locked="false" Priority="46" Name="List Table 1 Light Accent 4"/>
<w:LsdException Locked="false" Priority="47" Name="List Table 2 Accent
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 61/91
3/31/2018 Fabfender's Lesotho Mission
4"/> <w:LsdException Locked="false" Priority="48" Name="List Table 3
Accent 4"/> <w:LsdException Locked="false" Priority="49" Name="List Table
4 Accent 4"/> <w:LsdException Locked="false" Priority="50" Name="List
Table 5 Dark Accent 4"/> <w:LsdException Locked="false" Priority="51"
Name="List Table 6 Colorful Accent 4"/> <w:LsdException Locked="false"
Priority="52" Name="List Table 7 Colorful Accent 4"/> <w:LsdException
Locked="false" Priority="46" Name="List Table 1 Light Accent 5"/>
<w:LsdException Locked="false" Priority="47" Name="List Table 2 Accent
5"/> <w:LsdException Locked="false" Priority="48" Name="List Table 3
Accent 5"/> <w:LsdException Locked="false" Priority="49" Name="List Table
4 Accent 5"/> <w:LsdException Locked="false" Priority="50" Name="List
Table 5 Dark Accent 5"/> <w:LsdException Locked="false" Priority="51"
Name="List Table 6 Colorful Accent 5"/> <w:LsdException Locked="false"
Priority="52" Name="List Table 7 Colorful Accent 5"/> <w:LsdException
Locked="false" Priority="46" Name="List Table 1 Light Accent 6"/>
<w:LsdException Locked="false" Priority="47" Name="List Table 2 Accent
6"/> <w:LsdException Locked="false" Priority="48" Name="List Table 3
Accent 6"/> <w:LsdException Locked="false" Priority="49" Name="List Table
4 Accent 6"/> <w:LsdException Locked="false" Priority="50" Name="List
Table 5 Dark Accent 6"/> <w:LsdException Locked="false" Priority="51"
Name="List Table 6 Colorful Accent 6"/> <w:LsdException Locked="false"
Priority="52" Name="List Table 7 Colorful Accent 6"/> </w:LatentStyles>
</xml><![endif]--><!--[if gte mso 10]> <style> /* Style Definitions */
table.MsoNormalTable {mso-style-name:"Table Normal"; mso-tstyle-
rowband-size:0; mso-tstyle-colband-size:0; mso-style-noshow:yes; mso-
style-priority:99; mso-style-parent:""; mso-padding-alt:0cm 5.4pt 0cm 5.4pt;
mso-para-margin:0cm; mso-para-margin-bottom:.0001pt; mso-
pagination:widow-orphan; font-size:10.0pt; font-family:"Times New
Roman",serif;} </style> <![endif]-->
Quote:
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 69/91
3/31/2018 Fabfender's Lesotho Mission
Where we are staying the 1st night (Rampai) there is definitely normal cell
phone reception.
They have recently added more towers to the area
Quote:
Die License free Varkies is UHF, hulle sal nie werk saam met die VHF Radio's
nie. Ek het self 4x Varkies. Ek vat maar 2x van myne saam uit habbit. Jy kry
VHF Varkies, maar hulle is Licensed. Jy kan kyk binne op die antenna as jy
hom af skroef, of agter die battery. Sal se VHF of UHF. [EDIT:] UHF kan ook
Licensed wees, net voor iemand my 'n strafdop gee vir leuns vertel. Maar oor
die algemeen verkoop hulle as License Free, limited tot 5mW IPV
5W(Licensed)
Quote:
Pieter, sorry wou jou nie 22:00 bel gisteraand toe ek eers kon nie.
Gaan ons Locktite saamvat om die boutjies vas te maak dat hulle nie dalk los
kom nie?
My deepfreeze het nou heelemal gedood so ons sal moet plan sien wat om
te doen.
Ok lyk my ek gaan saam , laat weet my net wat ek moet saambring , Ek het
gereedskap 'n Defender 130 en is gewillig om te help .
O ja en ook 'n VHF radio met die ORRA kanale
http://www.4x4community.co.za/forum/printthread.php?t=209289&pp=200 91/91