Académique Documents
Professionnel Documents
Culture Documents
Cable Connections
Monitor
CAUTION: RISK OF PRODUCT DAMAGE
Speaker – Output
The DVN 100-NET must be supplied with 12 VDC power. The polarity of the
(Decoder Mode)**
12 VDC must be strictly observed and wired correctly. Reversing polarity will
damage the device.
Loop Terminal (TER) Speaker
Output
Switch (Encoder Mode)*
Microphone – Input
(Encoder Mode)**
Microphone
120/220 VAC
Receive Power Supply
Status LEDs Power Source
(-)
PTZ Camera Network
(Control)
Receive AUX Port PIN Numbering
(+)
15 13 11 9 7 5 3 1
16 14 12 10 8 6 4 2
Analog * You may output the digital video to a monitor
Camera OR Monitor using the Loop connector ONLY when encoding. PIN 1-6 DO NOT CONNECT!
PIN 7-10 GROUND
Analog Camera – Input (Encoder Mode) ** The faceplate of some DVN 100-NET units may PIN 11-14 DO NOT CONNECT! Hub/Switch DVN 5000
Monitor – Output (Decoder Mode) display AUDIO ports labeling that is different from PIN 15 OPEN COLLECTOR OUTPUT
the one described in this manual. However, regardless PIN 16 3.3V TTL INPUT (INTERNAL PULL UP)
of the labeling, functionality of those ports is as
specified in this document.
For more information, refer to the DVN 100-NET Installation and Operation Manual.
Unit Configuration
1. Locate the DVN 100-NET Unit on the Network 2. Change the Unit’s Network Settings
Run the DVN100Browser.exe file on the On the DetailForm page, enter a descriptive name for the 4 On the Insert Password page, do not change the User
1 1
DVN 100-NET software installation CD. DVN 100-NET unit in the Name field. name and Password.
Optional Procedure
Click Search. The application will list all of the 2 Enter a valid IP Address, Subnet Mask, and Gateway. (Default) User name: admin (lower case)
2 Launch Microsoft ® Internet Explorer® and
DVN 100-NET units on the network. (Default) Password: <blank> (no password)
enter the following address:
3 Click Send Config.
http://DVN 100-NET IP Address/setup/index.html
Example:
http://192.168.135.64/setup/index.html
Default The JCI DVN 100 Setup page appears.
IP Address 5 Click OK.
3. Access the JCI DVN100 Setup Page 4. Edit the Configuration Settings, As Needed
1 From the DetailForm page, click Full Setup. Select a category from the left-side of the JCI
1 DVN100 Setup page.
5 When you have finished making changes, click
2 The JCI DVN100 Setup page appears. Save and apply under Setup commands.
2 Edit the data, as necessary.
4 Click Apply.
For more information, refer to the DVN 100-NET Installation and Operation Manual.