Académique Documents
Professionnel Documents
Culture Documents
AIM: -
1. To study the voltage gain, frequency response, and Bandwidth of a Voltage shunt feed-
back amplifier with and without feedback.
CIRCUIT DIAGRAM:
VCC
12V
C1 R2
R3
4.7k?
33k? XSC1
10µF C3
R6
10k? CRO
Ext Trig
10µF
Q1 +
R5 C4 A _
A B
+ _ + _
1k? B
10µF
BC107BP R8 C6
XFG1 R4
2.2k? 0.001µF
5.6k?
R1
C5
1.8k?
100µF
PROCEDURE: -
1. Connect the circuit diagram as shown in figure. Adjust input signal amplitude
50mV, 1 KHz in the function generator and observe an amplified voltage at the output
without distortion.
2. By keeping input signal voltage, constant 50mV, vary the input signal frequency from
1 to 1MHz in steps as shown in tabular column and note the corresponding output
voltages. By keeping feed- back terminals open and calculate the Bandwidth from the graph.
3. Connect the Feedback short A and B terminal and now vary the input signal frequency
from 1 to 1MHz in steps as shown in tabular column and note the corresponding
output voltage
4. Calculate the Bandwidth with feed- back from the plot of graph.
PRECAUTIONS:
1. Avoid loose connections and give proper input Voltage
20
40
80
100
1K
10k
50k,100K
1M
RESULT: - With feed-back, gain decreases and band width increases
1. Frequency response of amplifier is plotted.
2. Gain = _______dB (maximum).without Feed-back.
3 Gain = _______dB (maximum).with Feed-back.
4. Bandwidth= fH--fL = _________Hz. without Feed-back.
5. Bandwidth= fH--fL = _________Hz. with Feed-back.
EXPECTED GRAPH: