Académique Documents
Professionnel Documents
Culture Documents
Disposal: Dispose in accordance with local, state and federal regulations. To the
best of our knowledge this product is not a hazardous waster under RCRA.
See Section 8 for Exposure Controls / Exposure Limits / Personal Protection Information
Page 1 of 4, 07272
Section 4. First Aid Measures
Eye Contact Molten Adhesive – Immediately cool the eyes(s) by running under cold water for at
least 5 minutes. Obtain medical attention at once. Do not attempt to remove the
solidified adhesive.
Solid Adhesive - Immediately flush the contaminated eye(s) with lukewarm, gently
flowing water for 15 minutes, while holding the eyelid(s) open. Obtain medical advice.
Skin Contact Molten Adhesive - Immediately cool the affected area by running under cold water for
at least 5 minutes. Obtain medical attention at once. Do not attempt to remove the
solidified adhesive.
Solid Adhesive - Immediately wash with water and soap, until all adhesive is removed.
If irritation persists, flush with lukewarm water for 15 minutes and obtain medical
advice.
Thoroughly decontaminate clothing, shoes and leather goods before reuse or discard
the contaminated materials.
Inhalation If symptoms are experienced, remove source of contamination or move victim to fresh
air, and obtain medical advice.
Ingestion If irritation or discomfort occurs, obtain medical advice immediately. Never give
anything by mouth if victim is rapidly losing consciousness, is unconscious or is
convulsing.
Notes to Physician None.
Page 2 of 4, 07272
Section 8. Exposure Controls / Personal Protection
Engineering Controls Provide adequate ventilation for proper air circulation.
Personal Protection
Eye / Face Wear safety goggles when working around molten adhesive.
Skin Wear protective, heat-resistant gloves, when working around molten adhesive.
Respiratory None required.
General Normal cleanliness should be observed.
Chemical Name or Product Name CAS # OSHA PEL ACGIH TLV
Exposure limits have not been
established for this mixture.
NOTE: The 1989 OSHA PELS were vacated in 1993 and are not currently enforceable by Federal OSHA. However, some state OSHA
programs may still enforce the 1989 limits.
Page 3 of 4, 07272
Section 14. Transport Information
DOT Classification This product is not regulated under the U.S. Department of Transportation.
Special Provisions for None.
Transport
Additional Shipping National Motor Freight Classification – 4620
Information
International Not Established
Transportation
Regulations
Page 4 of 4, 07272