Académique Documents
Professionnel Documents
Culture Documents
: LSGS-10-PO0110
User / Customer : Ha Noi PC Page No, : I of I
Project'iitle
DocumentTitle :
$BeGifiGation
I
for
Ganped Super Thermat Resistant Aluminum Allov Gonductor.
Steel Reinforced
(GZTACSR 150mm2)
,\-'i
7 Jan. 31, 2011 Add Ampacity and Sag Tension sheet K, H. SEO J. S. GIL K. I. SOHN
Y
FS cahre
@
ffi
Effi ffiBafi'
eahae
Ref. No. : LSGS-10-PO0110
Rev. No. : 1
Page No. : 2 of B
1, Scope
This specification covers design, manufacture and tests of 2100C grade concentric.lay-strand gapped
super thermal-resistant aluminum-alloy conductor, steel reinforced, i.e, GZI'ACSR for use on overhead
electric utility power lines.
2. General requirements
2-1 Applicable standard
IEC 61089 Round wire concentric lay.overhead electrical stranded conductors
IEC 60888 Zinc-coated steel wires for stranded conductors
IEC 62004 Thermal-resistant aluminum alloy wire for overhead line conductor
2'2.In case the numerical values in this specification and the applicable standard values are different, the
numerical lralues in this specificaUon have priority. Furthermore, items other than specified in this
, .-
.J
) specification shall be subjected to prior approval.
. (2) Quatity
Super thermal-resistant aluminum.alloy wire shall be uniform in quality and smooth in surhce and
free from practically harmful defects such as flaw, rust, cnck, etc.
(3) The properties of super thermal-resistant aluminum-alloy wire shall be specified in Table 1.
--
stranding.
(1) Material
ThesteelcorewireusedshallmeettherequirementsofstandardIEc608B8.
(2) Quality
Steel wlre shall be uniform in quality and smooth in surface and free from practically harmful
defects such as flaw, rust, crack, etc
(3) The propefties of steel wire and heat resistant grease shall be specified in Table 2 and Table 3,
3-4. Joints
There shall be no joinis of any kind made in the finished steel wires.
Slectric butt welding or cold-pressure welds in the finished individual aluminum wires composing the
e 5l Tesj and
t
ADDearance o o
Diameter o o
E'! c: Tensile strenqth
No€)
o o
o=> Elonqation o 0
Prv>x
k?-9 D.C. resistance/ Conductivitv o o
K6E Thermal resistance test for 400h o
,i.a
E
Thermal resistance test for th o o
Wraooinq o o
) Aooearance o o
Diameter o o
.=
o Tensile strenqth "oq o o
Elongation o o
=
o,
0, Torsion o o
tn o
Wrappinq o
Zinc Mass o o
coatinq Adherence o o
Heat resistant qrease Droo ooint temoerature o
ADoearance o o
Stranded
Structure o o
conductor
Lay ratio and direction of lay o o
x Note: If tensile strength tests after stranding are requested by purchaser, tensile strengths of the wires
removed from the completed conductors shall not be less than 95% of the minimum tensile
strength specified for the wire before stranding,
Heat-resistant Grease
I
Aonendix B Cross-sectional view of steel reel
1
i...,