Vous êtes sur la page 1sur 3

1. Setup a Voltage Buffer circuit.

Draw its frequency Response

2. Design an amplifier for the following requirements


 Gain 30dB
 Max. output Swing: 12Vpp
 Input Impedance: between 100Ω and 50KΩ

3. Design a JFET Amplifier of voltage gain 10. Take 100Hz as the lower cut-off Frequency.

4. Design a circuit to amplify the signal from a device. The signal frequency varies between
200Hz and 1MHz

5. Design a circuit to interface between a microphone and an audio detector circuit. The
Audio detector requires 2.5Vpp as input. But the microphone delivers the signal having
50mV signal Strength. By observations, find the Frequency range at which the circuit
detects the audio signal.

6. Design a signal to strengthen a signal having Frequency range 100Hz-1MHz. Specifications


are below.
 Gain 25dB

7. Design an impedance matching Circuit using BJT, for an Amplifier. Draw the frequency
Response.
 Gain 1, input Voltage: 1Vpp

8. Set up an Oscillator to get 10V peak to peak sine wave of 1KHz Freaquency.

9. Obtain the Following Wave Form. F = 500KHz


10V

-10V

10. Obtain the Following Wave Form. F =


10V

-10V
11. Obtain the Following Wave Form. T =
10V

-10V

12. Obtain the Following Wave Form. T=


10V

-10V

13. Design and Set up the circuit get following Transfer Characteristics
Vout

10 V

+ Vin

14. Design and Set up the circuit get following Transfer Characteristics
Vout

6V

+ Vin

15. Design a circuit regulated DC Supply, with adjustment of 6-10 V. Input Voltage Range 10-15
V

16. Design Regulated DC Supply with short circuit Protection. VOUT=10V dc. Input 10-15 Vdc.
Max out Load Current 300mA

17. Design and Set up a UJT Relaxation Oscillator of Frequency 2KHz

18. Design and set up a cascade amplifier of gain 20


19. Design and setup a Frequency Selector circuit, for 455KHz

20. Obtain a Wave sine wave of frequency 455KHz

21. Design a circuit to generate a Sweep wave form of frequency, 1KHz

22. Design and set an Amplifier to drive a loud 8Ω ½W Speaker. Input signal have 3Vpp signal
strength.

23. Find the intrinsic standoff ratio of given UJT

24. Find the Load Regulation of a 12V dc regulator with short circuit protection at 200mA

25. Find the input impedance of a BJT Amplifier of AV=30 in Audio Frequency Range. Use BC
107

26. Design a BJT amplifier for the following requirements


 Gain 30dB
Find the input Impedance theoretically

27. Design and set up Heartly Oscillator to get 100Hz signal

28. Design and setup a Colpitts Oscillator for frequency 450 KHz

Vous aimerez peut-être aussi