a. Self accelerated; b. Gradual; c. spontaneous 2. The class Ca/b means: a. a-compressive strength on cylinder, b -compressive strength on cube b. a-tensile strength on cylinder, b -compressive strength on cube c. a-compressive strength on cylinder, b –tensile strength on cube 3. At failure, the tensioned concrete has: a. Crack perpendicular to the force direction b. Crack parallel to the force direction c. Crack parallel to the both sides 4. The split tensile strength is: a. Compressive strength b. Principal tensile strength c. Tensile strength 5. Flexural strength is determined on: a. cube b. prism c. cylinder 6. The relation for determining the flexural strength is: a. Rti= 6M/h2 b. Rti=6M/bh2 c. Rti= M/bh2 7. Breaking of concrete in pure shear occurs under: a. Principal tensile stresses b. Principal compressive stresses c. compressive stresses 8. The crushing of concrete under local compression is: a. In the entire cube b. With cracks parallel with the force c. Produced in a nucleus that is completely destroyed 9. The relation for determining the modulus of elasticity is: a. Eb= tgα b. Eb= tgαo c. Ebp= tgαr 10. The transversal elasticity modulus G is: a. Gb=0,2 Eb; b. Gb=0,3 Eb c. Gb=0,4 Eb 11. Depending on chemical composition the types of steel are: a. Soft, medium and hard steel b. Soft, and hard steel c. Soft and hard steel 12. For prestressed reinforcement the steel is type:: a. Wire and mesh b. wire c. mesh 13. The diagram σp-εp for prestressing steel has: a. Visible yielding limit b. Reduced yielding limit plateau c. Conventional yielding limit 14. For axial tensioned reinforced concrete members in the 3rd stage the failure is produced by: a. Yielding of reinforcement b. Yielding of reinforcement and crushing of concrete c. partial cracking of concrete 15. In the second stage of working the cracks in a beam occur: a. In both zone- b. In the compressed zone c. In the tensioned zone 16. The crushing of compressed concrete in a beam is produced by: a. normal cracks b. horizontal cracks c. inclined cracks- 17. Designing of beams is made in: a. Second stage of working b. 3rd stage of working c. First stage 18. The relation for fs is: a. fs=fyk/γs b. fs=afyk/γs c. fs=fyd/γs 19. The distribution of compressive stresses can be: a. Parabolic-rectangular b. Bi-linear c. Parabolic-rectangular, Bi-linear or rectangular 20. How many equations can be used for designing the steel Aa for a rectangular singly reinforced section: a. 2 equations b. 3 equations c. 4 equations-