Académique Documents
Professionnel Documents
Culture Documents
Remove the sides of the charger by removing the eight screws on the left and right side. Bend the lower side of the upper half of the
case a bit so it can slip over the lower side of the bottom part of the case. Now the charger is opened. Remove the screws of the LCD.
Carefully bend the LCD backward to be able to reach the SMD resistors that need to be replaced.
Below is the drawing in which you can see which resistors should be exchanged for 0.1% types.
The 18k1 resistor is a series circuit of 16k9 0.1% and 1k2 0.1% (place both upright like /\ )
The 68k3 resistor is a series circuit of 66k5 0.1% en 1k8 1% (place both upright like /\ )
After replacing the resistors work backwards to mount the charger again. Good luck!!
1x 0.1% 16k9
1x 0.1% 66k5
4x 0.1% 100k
2x 0.1% 200k
8x 0.1% 249k
8x 0.1% 499k
1x 0.1% 1k2
1x 1% 1k8