Académique Documents
Professionnel Documents
Culture Documents
To remove
4.
Remove the bush bolts (A) and move aside the anti-roll bar (B).
Important
5.
Remove and hang the hydraulic body and brake caliper holder to the side as a unit
(A).
7.
Remove the brake disc lock bolt (A). Lift off the brake disc.
Important
10. Press in the drive shaft so to release it from the hub. Use 89 96 951 Drive shaft
puller.
Important
Note
Note the routing of the wheel sensor cable.
11.
Remove the hub (A).
To fit
1. Clean the contact surfaces. Fit the hub (A) and the brake shield with new nuts.
Important
3.
4. Clean the contact surfaces between the hub and the brake disc.
6. Clean the contact surfaces between the brake caliper holder and the steering swivel
member.
7.
8. Fit the hydraulic body and brake caliper holder using Thread locking adhesive, Loctite
242.
9.
Bend up the anti-roll bar (B) and fit the bush bolts (A).