Académique Documents
Professionnel Documents
Culture Documents
_______________________________________________________________________________________________
m = 4.16 mm
Step 2 :- Selection of module.
The first preference value of the module is 5mm.
Trial 1.
m = 5 mm
Diameter of Pinion (d′p ) :-
Fig.1 Spur Gear
d′p = m.Zp = 5×18 = 90 mm
Step 1= Estimation of module based on beam strength.
Diameter of Gear (d′g ) :-
Since, both the gears are made of the same materials, the
pinion is weaker than the gear. The minimum number of d′g = m.Zg = 5×72 = 360 mm
teeth for 20° pressure angle is 18. Therefore,
b = 10 m = 10×5 = 50 mm
Zp = 18,
_______________________________________________________________________________________________
ISSN (Print): 2319-3182, Volume -6, Issue-1-2, 2017
2
International Journal on Theoretical and Applied Research in Mechanical Engineering (IJTARME)
_______________________________________________________________________________________________
The design is satisfactory and module should be 5 mm. [3] Sarfaraz Ali N. Quadri, Dhananjay R.
Dolas,”Contact Stress Analysis of Involute Spur
Hertzian Contact stress (σc ) :- gear under Static loading”, International Journal
1 1 of Scientific Research Engineering &
P t ×( + )
Rp Rg Technology, Vol. 4, Issue 5, pp. 593-596,
σc = (1−μ ) (1−μ2 )
2
b×π×
E1
+
E2
May2015.
_______________________________________________________________________________________________
ISSN (Print): 2319-3182, Volume -6, Issue-1-2, 2017
3