Académique Documents
Professionnel Documents
Culture Documents
This document contains information and instructions for installation of OR Cart Mounting Kit, P/N 016-0376-00 to the
90485 Module Housing (single or dual table mount versions) and its subsequent installation to a variety of OR carts.
CAUTION:
Printed circuit boards in this equipment contain static sensitive devices; only handle at a
static-safe workstation.
Kit Contents
The following parts are contained in the kit. Please verify that all parts are available before beginning installation of
the kit.
Tools Required
!
These instructions assume that the 016-0365-00 Single Table Mount Kit has been previously
added to the 90485 Module Housing.
1. Remove and discard the four (4) screws that hold the pedestal in place.
2. Place the mounting bracket (Item 5) against the bottom of the pedestal as shown in Figure 1 on page 3. Make
sure the countersunk holes in the bracket face away from the pedestal.
075-0082-00 Rev. D 1
3. Secure the bracket and pedestal in place using four (4) 8-32 flat head screws (Item 3). The screws must be
positioned in the four outer holes of the eight hole pattern in the bracket.
!
These instructions assume that the 016-0364-00 Dual Table Mount Kit has been previously added
to the 90485 Module Housing.
1. Remove and discard the four (4) screws that hold the pedestal in place.
2. Place the mounting bracket (Item 5) against the bottom of the pedestal as shown in Figure 2 on page 4. Make
sure the countersunk holes in the bracket face away from the pedestal.
3. Secure the bracket & pedestal in place using four (4) 8-32 flat head screws (Item 3). The screws must be
positioned in the four inner holes of the eight hole pattern in the bracket.
1. With a pencil or scribe, layout the 1:1 hole pattern provided in Figure 3 on page 5 on the cart shelf where the
90485 is to reside. Ensure that unit placement on the cart shelf does not impede unit cable routing.
2. Using a hand drill and 1/4 inch diameter bit, drill four (4) holes where marked in step 1. Deburr the holes if
necessary.
3. Set the 90485 with mounting bracket on the cart shelf, aligning the drilled holes to the four (4) floating nuts
pressed in the mounting bracket. Refer to Figure 4 on page 6. The Module Housings connector panel should
be positioned towards the rear of the cart.
4. Place a split-lock washer (Item 1) and a flat washer (Item 2) on to a wing screw (Item 4). Direct the wing
screw up through one of the holes drilled in the cart shelf and thread into the brackets floating nut. The wing
screw only needs to be hand tight. Refer to Figure 4 on page 6.
!
If the cart shelf is too thick, the supplied wing screws will not be of adequate length. Discard the
wing screws and procure the appropriate length 10-32 screw for your application.
2 075-0082-00 Rev. D
pedestal
4x
075-0082-00 Rev. D 3
pedestal
4x
Figure 2: Bracket to pedestal attachment for dual module housing
4 075-0082-00 Rev. D
6.750
6.750
075-0082-00 Rev. D 5
4x
4x
4x
6 075-0082-00 Rev. D