Académique Documents
Professionnel Documents
Culture Documents
A. ultrasonic testing
B. Fatigue testing
C. Eddy current testing
D. Radiographic testing
2. At any given instant a spinning probe eddy current instrument should be inspecting
4. The region around a magnet which attracts other pieces of iron or steel is called
A. a Maxwell
B. the magnetic field
C. retentivity
D. alternating current
5. A term used to define one or more turns or loops of a conductor wound in such a
manner as to produce an axial magnetic field when current passes through the conductor
is
A. a coil
B. a resistor
C. a capacitor
D. an oscillator
6. Spinning probe type eddy current instruments are most useful in the detection of
A. permeability
B. Conductivity
C. Diameter
D. Frequency
8. Which of the following frequencies will provide the greatest eddy current penetration
in aluminium
A. 1 Khz
B. 10 Khz
C. 3 Khz
D. 300 Hz
9. Metals which do not react only slightly to magnetic fields are called
A. diamagnetic metals
B. paramagnetic metlas
C. nonmagnetic metals
D. any of the above might be used
A. mew
B. sigma
C. Inductive reactance
D. Resistance
A. mew
B. sigma
C. inductive reactance
D. Resistance
12. The method used to generate eddy currents in a test specimen by means of a coil can
most closely be compared with the action of a :-
A. transformer
B. capacitor
C. storage battery
D. generator
13. A term used to define testing that requires that the test article be loaded and or
sectioned to verify and/ or establish mechanical or physical properties is
A.impedance testing
B. Phase analysis testing
c. Destructive testing
D. Non destructive testing
14. The fill factor when a ½ inch diameter bar is inserted in a 1-inch diameter coil is
A. 50%
B. 75%
C. 100%
D. 25%
15. Which of the following could be used to suppress unwanted high frequency
harmonics?
16. The term used to define the difference between actual instrument output and expected
output as defined by a straight line calibration curve is
A. phase shift
B. nonlinearity
C. lift off
D. skin effect
A.magnetostriction
B. electromagnetic induction
c. Piezo electric effect
D. Magnetomotive force
A. U-shaped coils
B. Gap coils
C. Encircling coils
D. None of the above
19. A term used to define any change in a sinusoidal signal when the output is not a linear
reproduction of the input is
A. distortion
B. linearity
C. phase shifting
D. dynamic range
20. The major problem associated with the eddy current test method is the