Vous êtes sur la page 1sur 3

Activity Title: Prelim Exam

Name: Garcia, Mark Andrei L. Submission Date: July 31, 2018

Subj- Sec: COMP 411-1 Rating:

Instr: Engr. Sherman Tupas

I. Objective
 To perform from what we had learn in the past meetings using the basic commands
in Solidworks to make a 3D figure with the given dimensions and views.

II. Procedures
1. First we make a rectangle having the dimensions of L=85 and W=6 from the top
view. Then extrude the rectangle with a height of 12.
2. Sketch and create a constructions line on the back surface of front view.
3. Make a rectangle with a length of 64 and height of 50.
4. Then extrude it to the left with a width of 15, go back to front view again.
5. From the midpoint of the base make a line with a measure of 30.
6. From the 30 long line make another line diagonally connecting to it.
7. The dimensions must be the same from the projected one having an angle of 60
degrees.
8. Close the 3 lines by making another line connecting them making an inverted
trapezoid shape at the bottom. Then extrude cut it until it reaches the back part of
the figure.
9. Create a construction line at the middle with a height of 16. From that, create a
center line with a length of 32.
10. Connect both ends to the rectangle where it is constructed.
11. To be able to extrude boss or base it, it must be solid, so connect all line creating a
trapezoid shape. And then we extrude it.
12. Create 2 rectangles with the use of construction lines at both ends with the length
of 70 and a width of 12.
13. In the remaining area where the two rectangles are made, create a T-shape using
lines.

Page 1 of 3 Pages

14. Extrude boss/base the figure with a height of 10.


15. Create a line, starting from the right corner part of the upper horizontal rectangle
going to the vertical rectangle with a height of 40, from the reference point.
16. Extrude boss/ base the line up to the surface of the vertical rectangle.
17. Then going to the front view, click the upper surface then sketch.
18. Make a construction line at the middle
19. Make a circle, with a diameter of 16, having a 40x18 distance from the reference
point starting at the left side of the figure.
20. Mirror the entity making 2 same circles at both sides.
21. Extrude cut it in the figure with a length of 10.
22. From that point of the circle, sketch another circle.
23. Sketch another circle with a diameter of 10.
24. Then mirror it again having 2 same circles on the extruded circle.
25. Extrude cut it by making a hole with a length of 15.
26. Save the image after finishing all of it.er
27. Render the image and capture the rendered image for documentation purposes.
28. Create three views of the image.
29. And save it again as a pdf.

III. Drawing File

Page 2 of 3 Pages
IV. Isometric View

V. Conclusion

Making this figure made me excited because I want making this kind of figures. Because
it tests my intelligence and my knowledge about AutoCad and SolidWorks. Making this
figure must have some patience because it is a time consuming for me but I like it because
we can make different figures by the use of the basic commands being taught to us by a
great professor.

Page 3 of 3 Pages

Vous aimerez peut-être aussi