SIEMENS
Rewiring a User Program
a
Sacle gaa Fi eee
Contents Page
2
4
Rewiring Results 5
Rewiring with "Leading S) 6
mbol Table: Adapting Avsolu 7
Rewiring with the LADIFBDISTL Eeitor 8
Rewinng with the "Check Block C Function 8
Comparing Blocks (1) 10
Comparing Blucks "
12
ger 13
Exercise 4 Comparing Blocks 15
SITRAIN Training tor ST-SERV1
on ang Orves Page 1 Rewiring a User ProgramSiEMENS,
Objectives
Upon completion of the chapter the participant will ...
know functions and how to apoly it
be able to carry out a rewiring using the SIMATIC Manager
i bbe able to carry out @ rewiting using the symbol table
("Leading Symbols")
be able 10 compare S7 biocks oniine-offiine and offiine-offiine
wi Ses
SIMATIC S7 -
SITRAIN Train
Automation and Brves Page 2
ST-SERV?
Rewiring a User ProgramSUEMENS
Areas of Use
a" program new" program
aa Conveyor modes Arse Conveyor model
wired to central iO z wired to distributed /0
| oes
|=a85 =Q05
[Rewng witn
| the SIMATIC Manager > |
| 1c" program new" program
atte Operate using AM303 Operate using
! Simulator e178
|————___I Am 30.4
lon Rewiring with |
| ieaging symbois” > |
|
SIMATIC $7 Fee
‘Areas of Use For the exercises, you are to use the Rewiring function to:
+ change the addresses in the program so that the conveyor model can be
connected to the distributed 1/0 instead of the central iO
+ adapt the program so that the conveyor model can be operated completely
from the touch panel. For this, the simulator inputs are rewired to bit
memories that are set and reset from the TP170B,
Rewiring In eacn case. the program must be adapted to the new conditions by rewiring
nsering the new adaresses in the program).
‘There are three ways of rewiring a user program (adapting to new addresses):
+ Rewiring with the SIMATIC" Manager
(This method does not require 2 symbol table)
+ Rewiring with 2 symbol table using "Leading Symbols"
+ with the LADFBOISTL Editor
+ with the Check Block Consistency function
Rewiring using s source program
SITRAIN Trang for ST-SERV1
‘Automation ane Page 3 Rewiring a User Program