Vous êtes sur la page 1sur 3

Institute of Civil Engineering

College of Engineering
University of the Philippines - Diliman

Submitted by:
Beconado, Eartha
Buen, Marie Antoinette
Del Rosario, Carl
Francisco, Dianne
Tisang, Jomalyn

Submitted to:
Dr. Antonio, Oscar Victor Jr.

CE 157 Design of Reinforced Concrete Members


1st Semester AY 2017-2018
Purpose

Location
The proposed school building will be situated at Lumbac Madaya, Marawi City in Lanao
del Sur, Philippines.
Dimensions

Load Definitions and Load Combinations

Deflection Limits
Type of member Deflection to be considered Deflection limitation
Flat roofs not supporting or attached to
nonstructural elements likely to be Immediate deflection due to live load L 𝑙⁄
180*
damaged by large deflections
Floors not supporting or attached to
nonstructural elements likely to be Immediate deflection due to live load L 𝑙⁄
360
damaged by large deflections
Roof or floor construction supporting or
That part of the total deflection occurring 𝑙⁄
attached to nonstructural elements likely to 480^
after attachment of nonstructural elements
be damaged by large deflections
(sum of the long-term deflection due to all
Roof of floor construction supporting or
sustained loads and the immediate 𝑙⁄
attached to nonstructural elements not 240^^
deflection due to any additional live load)**
likely to be damaged by large deflections
Table 1. Maximum permissible computed deflections (Table 9.5b, ACI 318-11)

Notes: *Limit not intended to safeguard against ponding. Ponding should be checked by suitable calculations of
deflection due to ponded water, and considering long-term effects of all sustained loads, camber, construction
tolerances, and reliability of provisions for drainage.

**Long-term deflection shall be determined in accordance with 9.5.2.5 or 9.5.4.3 (ACI 318-11), but may be reduced
by amount of deflection calculated to occur before attachment of nonstructural elements. This amount shall be
determined on basis of accepted engineering data relating to time-deflection characteristics of members similar to
those being considered.

^Limit may be exceeded if adequate measures are taken to prevent damage to supported or attached elements.

^^Limit shall not be greater than tolerance provided for nonstructural elements. Limit may be exceeded if camber
is provided so that total deflection minus camber does not exceed limit.

Foundation Design Limits


Codes and References

Building Code Requirements for Structural Concrete (ACI 318-11) and Commentary.
2011. ACI Committee 318, American Concrete Institute.

National Structural Code of the Philippines, 6th Ed. 2010. Association of Structural
Engineers of the Philippines.

Vous aimerez peut-être aussi