Académique Documents
Professionnel Documents
Culture Documents
27The show ip route command was executed on one of the routers shown in the grap
hic and the following output was displayed:
C 192.168.4.0/24 is directly connected, Serial0/0
R 192.168.5.0/24 [120/1] via 192.168.4.2, 00:00:19, Serial0/0
R 192.168.1.0/24 [120/2] via 192.168.3.1, 00:00:20, Serial0/1
R 192.168.2.0/24 [120/2] via 192.168.3.1, 00:00:20, Serial0/1
C 192.168.3.0/24 is directly connected, Serial0/1
From which router was this command executed?
A
B
C
D
28Refer to the exhibit. Which two sets of commands are required to configure pas
swords for all management ports on a Catalyst 2960 switch? (Choose two.)
ALSwitch(config)# interface vlan 1
ALSwitch(config-if)# password cisco
ALSwitch(config-if)# login
**ALSwitch(config)# line vty 0 4
ALSwitch(config-line)# password cisco
ALSwitch(config-line)# login
ALSwitch(config)# line vty 0 15
ALSwitch(config-line)# password cisco
ALSwitch(config-line)# login
ALSwitch(config)# enable secret class
ALSwitch(config)# enable password cisco
ALSwitch(config)# interface fa0/1
ALSwitch(config-if)# password cisco
ALSwitch(config-if)# no shutdown
**ALSwitch(config)# line cons 0
ALSwitch(config-line)# password cisco
ALSwitch(config-line)# login
29A user reports being able to access the Internet but not being able to downloa
d e-mail from the mail server at the ISP. What should the user check on the user
workstation?
** the POP3 and SMTP server settings in the e-mail application
the patch cable connections at the back of the workstation and at the wall plate
the DHCP settings in the operating system
the IP address, mask, and default gateway values
the NIC drivers
30Refer to the graphic. Which command will configure a static route on Router A
to direct traffic from LAN A that is destined for LAN C?
RouterA(config)# ip route 192.168.4.0 255.255.255.0 192.168.5.2
RouterA(config)# ip route 192.168.4.0 255.255.255.0 192.168.3.2
**RouterA(config)# ip route 192.168.5.0 255.255.255.0 192.168.3.2
RouterA(config)# ip route 192.168.3.0 255.255.255.0 192.168.3.1
RouterA(config)# ip route 192.168.3.2 255.255.255.0 192.168.4.0
31Which subnet masks could be used when subnetting a Class B IP address? (Choose
two.)
255.255.255.240
** 255.255.192.0
** 255.255.0.0
255.192.0.0
240.0.0.0
255.0.0.0
32 Refer to the exhibit. The network administrator has configured the RTA and RT
B interfaces. In order to allow hosts that are attached to RTA to reach the serv
er that is attached to RTB, a static route from RTA to the server LAN and a defa
ult route from RTB back to RTA need to be configured. Which two commands will th
e administrator use to accomplish these tasks on the two routers? (Choose two.)
**RTA(config)# ip route 10.16.10.5 255.255.255.252 10.16.10.6
RTA(config)# ip route 0.0.0.0 0.0.0.0 10.16.10.6
RTA(config)# ip route 10.16.10.96 255.255.255.252 10.16.10.6
RTB(config)# ip route 10.16.10.6 255.255.255.248 10.16.10.6
**RTB(config)# ip route 0.0.0.0 0.0.0.0 S0/0/1
RTB(config)# ip route 0.0.0.0 0.0.0.0 10.16.10.6
33How do port filtering and access lists help provide network security?
**They prevent specified types of traffic from reaching specified network destin
ations.
They alert network administrators to various type of denial of service attacks a
s they occur.
They prevent viruses, worms, and Trojans from infecting host computers and serve
rs.
They enable encryption and authentication of confidential data communications.
34 Refer to the exhibit. The network administrator of the building in the graphi
c needs to choose the type of cable best suited to add ServerB to the network. W
hich cable type is the best choice?
STP
UTP
coaxial
**fiber optic
35What is used by a routing protocol to determine the best path to include in th
e routing table?
Convergence time
Default distance
** Metric
Type of router
36Refer to the exhibit. Which IP addresses could be assigned to the hosts in the
diagram? (Choose two.)
192.168.65.31
192.168.65.32
** 192.168.65.35
** 192.168.65.60
192.168.65.63
192.168.65.64
37Given the network 192.168.25.0 shown in the graphic, which subnet mask would a
ccommodate the number of hosts in each subnet?
255.255.0.0
255.255.224.0
255.255.255.0
** 255.255.255.224
255.255.255.240
255.255.255.248
38 Which two protocols allow network devices to report their status and events t
o a centralized network management device? (Choose two.)
** Syslog
Telnet
HTTP
HTTPS
** SNMP
39What is true regarding the differences between NAT and PAT?
PAT uses the word "overload" at the end of the access-list statement to share a
single registered address.
Static NAT allows an unregistered address to map to multiple registered addresse
s.
Dynamic NAT allows hosts to receive the same global address each time external a
ccess is required.
**PAT uses unique source port numbers to distinguish between translations.
40Refer to the exhibit. The graphic shows the output of a command issued on rout
er RTB. According to the output, what two statements are true of router RTB? (Ch
oose two.)
**The router is connected to a router named Boise.
Router RTB is connected to a Cisco 1841 router.
Router RTB is directly connected to two other routers.
**The IP address of the router interface connected to router RTB is 192.168.2.6
.
The RTB router is connected to two Cisco devices by Fast Ethernet links.
41Refer to the exhibit. The network administrator uses the command below to conf
igure a default route to the ISP network :
RTB(config)# ip route 0.0.0.0 0.0.0.0 10.1.1.6
A ping issued from the ISP is successful to router RTB. However, ping echo reque
st packets arrive at a host that is attached to the Fa0/0 interface of RTB, and
the replies do not make it back to the ISP router. What will fix this problem?
The ISP must be configured to forward packets from the 192.168.1.0 network.
**The ip route command needs to be edited so that the next hop address is 10.1.1
.5.
The ip route command needs to be edited so that the 192.168.1.1 address is the n
ext hop address.
The ip route command should be removed from the RTB router configuration.
42 A network technician is using a network management station to gather data abo
ut the performance of devices and links within the ISP. Which application layer
protocol makes this possible?
**SNMP
FTP
DHCP
SMTP
43What are two purposes of DNS? (Choose two.)
to dynamically assign IP addressing information to network hosts
to simplify the administration of host and default gateway addressing on client
computers
to assign TCP port numbers to hosts as part of the data transfer process
**to resolve human-readable domain names to numeric IP addresses
**to replace the static HOSTS file with a more practical dynamic system
44A hacker attempts to reach confidential information that is stored on a server
inside the corporate network. A network security solution inspects the entire p
acket, determines that it is a threat, and blocks the packet from entering the i
nside network. Which security measure protected the network?
an IDS
**an IPS
a host-based firewall
Anti-X software
45 How many host addresses may be assigned on each subnetwork when using the 130
.68.0.0 network address with a subnet mask of 255.255.248.0?
30
256
**2046
2048
4094
4096
46In an IPv4 environment, what information is used by the router to forward data
packets from one interface of a router to another?
**destination network address
source network address
source MAC address
well known port destination address
47 A small tire retailer requires a low-cost WAN connection to its headquarters
in order to manage its inventory and process customer sales in real time. Which
WAN connection type is best suited to its needs?
Sonet
T3
**dialup
DSL
leased line
48The command copy tftp running-config has been entered on the router. What will
this command do?
copy the configuration in RAM to a server
**copy the configuration file from a server to RAM
copy the configuration file in NVRAM to RAM
copy the configuration file in NVRAM to a server
copy the configuration file from a server to NVRAM
49Refer to the exhibit. The network administrator needs to configure the Fa0/0 i
nterface of RTB so that hosts from RTA can connect to the server that is attache
d to RTB. Which two commands will the administrator use to accomplish this task?
(Choose two.)
RTB# ip address 192.168.102.98 255.255.255.248
RTB(config-if)# ip address 192.168.102.99 255.255.255.252
RTB(config)# ip address 192.168.102.97 255.255.255.252
RTB(config)# no shutdown
**RTB(config-if)# no shutdown
**RTB(config-if)# ip address 192.168.102.97 255.255.255.252
50Refer to the exhibit. A NOC technician at an ISP enters the command shown. Wha
t are two reasons to use this command? (Choose two.)
to map the path to 192.168.1.7
**to test reachability to 192.168.1.7
to locate connectivity problems along the route to 192.168.1.7
to identify the ISPs that interconnect the NOC with the remote host with the add
ress 192.168.1.7
**to measure the time that packets take to reach 192.168.1.7 and return to the t
echnician's workstation