Académique Documents
Professionnel Documents
Culture Documents
CRS No: 1
Rev No: 1
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
Prepared by:
As per intrepretation from Piping Design Code ASME B31.3, thickness that not e
Table 331.1.3 below. For thickness of flangeolet as per Isometric Drawing, refer
As per Baram Isometric drawing, the maximum thickness of flangeolets is 7.62m
note that NPS 10" and 16" not subject to any butt welding.
retation from Piping Design Code ASME B31.3, thickness that not exceeding 25mm doesn’t require for PWHT. Refer
below. For thickness of flangeolet as per Isometric Drawing, refer the summary table.
Isometric drawing, the maximum thickness of flangeolets is 7.62mm. Therefore the WPS and WQT qualified. Please
S 10" and 16" not subject to any butt welding.
Isometric drawing, the maximum thickness of flangeolets is 7.62mm. Therefore the WPS and WQT qualified. Please
S 10" and 16" not subject to any welding.
st is done as per TW-PQR-ASME-02 (as attached in email). Snapshot of PQR toughness test as below :
st is done as per TW-PQR-ASME-02 Rev 1(as attached in email). Snapshot of PQR toughness test as below :
Piping Components Piping Spec Wall Thickness (mm)
Flangeolet NPS 3" SCH 80 7.62
Flangeolet NPS 2" SCH 80 5.54
Flangeolet NPS 1 1/2" SCH 160 7.14
Flangeolet NPS 1/2" SCH 160 4.78
*Note: Only flangeolet (new) will be welded on top of existing pipe