Académique Documents
Professionnel Documents
Culture Documents
Trucks
Group37
Wiring Diagram
FL12 LHD
TSP23687/1
Foreword
The descriptions and service procedures contained in this manual are based on design
and method studies placed up to March 1995.
The products are under continuous development. Vehicles and components produced
after the above date may therefore have different specifications and repair methods.
When this is judged to have a significant bearing on this manual, supplementary service
bulletins will be issued to cover the changes.
Service procedures which do not include an operation number in the title are for general
information and no reference is made to V.S.T.
The following levels of observations, cautions and warnings are used in this Service
Documentation:
Caution: Indicates a potentially hazardous situation which, if not avoided, may result in
minor or moderate injury or damage to property.
Warning: Indicates a potentially hazardous situation which, if not avoided, could result
in death, serious injury or major damage to property.
Danger: Indicates an imminently hazardous situation which, if not avoided, will result in
death or serious injury.
Abbreviations ....................................................................................... 22
Feedback
1
Group 37 Wiring Diagram FL12 LHD Component wiring diagram index
Unit injector, engine brake, exhaust pressure reg. ............................. See Foldout A
2
Group 37 Wiring Diagram FL12 LHD Component wiring diagram index
Windscreen wipers and washers, headlamp wipers and washers .... See Foldout C
Electrically heated rearview mirror, heated seat, air dryer ................ page 90
3
Group 37 Wiring Diagram FL12 LHD Component wiring diagram index
Bogie lift (hydraulic), with axle load limiter ........................................ See Foldout H
Bogie lift (air-operated), with axle load limiter ................................... page 101
4
Group 37 Wiring Diagram FL12 LHD Cable harness illustration index
5
Group 37 Wiring Diagram FL12 LHD Cable harness illustration index
T3007776
6
Group 37 Wiring Diagram FL12 LHD Cable harness illustration index
T3007775
7
Group 37 Wiring Diagram FL12 LHD Circuit board (32) electrical centre
T3007730
8
Group 37 Wiring Diagram FL12 LHD Circuit board (32) electrical centre
T3007748
9
Group 37 Wiring Diagram FL12 LHD Relays on circuit board (32) electrical centre
14 Switch extra equipment ...................... (XD14) 33 Heated mirror, heated seat ................ (HG7)
15 Full beams, relay extra equipment ..... (BB29) 34 Heater fan ........................................... (HA18)
(HA46)
16 Safety belts, dir. ind. .......................... (CN2) (HA73)
17 Diff lock, PTO, range inhibitor, instru- 35 Headlight wiper and washer ............... (GA28)
ment .................................................... (LG11)
36 Cig. lighter .......................................... (EV4)
18 Windscreen and headlight washers ... (GA34)
10
Group 37 Wiring Diagram FL12 LHD 6–unit fuse holder
11
Group 37 Wiring Diagram FL12 LHD List of connectors
List of connectors
A (LO33) BA5 (LJ12)
AA1 (AA13) BA5 (MA23)
AA2 (AA10) BA5 (MD38)
AA3 (EA3) BA7 (MA23)
AA3 (LJ18) BA7 (MD38)
AA4 (AA19) BB1 (MA18)
AA6 (ND14) BB1 (MD22)
AA7 (NA17) BB2 (MA15)
AA8 (ND2) BB2 (MD19)
AA9 (BB14) BB3 (MA22)
AB3 (LP37) BB3 (MD27)
AB4 (LP54) BB4 (MA21)
AB5 (LP58) BB4 (MD25)
AB8 (LP11) BB5 (MA13)
ABS TEST:1 (OA10) BB5 (MD21)
ABS TEST:2 (OA46) BC (NG40)
ABS TEST:3 (OA50) BD1 (MD30)
ABS TEST:4 (OA42) BD1 (MK19)
ABS TEST:8 (OA3) BD2 (MD32)
AD1 (XD11) BD2 (MK21)
AD2 (LD6) BD3 (MD33)
AF1 (LO8) BD3 (MK22)
AF1 (NA39) BG1 (MY35)
AF2 (LO10) BH (MY25)
AF2 (NA33) BH (MY27)
AF3 (LO11) BH (MY29)
AF3 (NA35) BH (MY31)
AF5 (NA15) BL1 (EN4)
AF8 (LO13) BL1 (EN6)
AF8 (NA14) BL2 (XD5)
AGSA1 (LO56) BL2 (XD8)
AGSA2 (LO58) BM1 (MR15)
AGSA3 (LP37) BM3 (MR32)
AGSA4 (LP44) BM8 (MR42)
AGSA5 (LO53) BM9 (MR44)
AGSA6 (LO55) BN1 (MN20)
AGSA8 (LO62) BN1 (MR48)
AGSA9 (LO59) BN2 (MN19)
AGSA:3 (LO94) BN2 (MR49)
AGSA:4 (LO94) BN3 (MN21)
AGSA:7 (LO5) BN3 (MR41)
AS1 (CK10) BN4 (MN22)
AS2 (XA9) BN4 (MR49)
AS3 (ND8) BN6 (MR41)
AS4 (ND27) BN8 (MR49)
AS5 (CK13) BN9 (MN14)
AS6 (ND26) BO1 (MN34)
B (LO35) BO2 (MN33)
BA1 (LJ10) BO3 (MN34)
BA1 (MA16) BP1 (MN39)
BA1 (MD17) BP1 (MR53)
BA1 (MG4) BP2 (MN39)
BA1 (MK3) BP2 (MR53)
BA2 (LJ16) BS1 (MR41)
BA2 (MG7) BS2 (MR43)
BA2 (MK6) BS3 (MR41)
BA3 (LJ23) BT1 (MP22)
BA3 (MA17) BT1 (MR21)
BA3 (MD18) BT1 (MS13)
BA3 (MG10) BT2 (MP21)
BA3 (MK10) BT2 (MR20)
BA4 (LJ5) BT2 (MS12)
BA4 (MA5) BT3 (MP2)
BA4 (MD7) BT3 (MR7)
12
Group 37 Wiring Diagram FL12 LHD List of connectors
16
Group 37 Wiring Diagram FL12 LHD List of components
List of components
26 Connector, gearbox (LP16) 42 J Joint sleeve (XD28)
30 A Battery (AA4) 42 K Joint sleeve (CE10)
30 B Battery (AA4) 42 K Joint sleeve (ED8)
33 Circuit card, indicator/warning lights (ND4) 42 K Joint sleeve (EN10)
34 Connector (AA7) 42 L Joint sleeve (CE29)
36 Connector, tail lamp junction box (CE3) 42 L Joint sleeve (ED7)
36 Connector, tail lamp junction box (CE36) 42 L Joint sleeve (EN10)
36 Connector, tail lamp junction box (CE5) 42 L Joint sleeve (ER13)
36 Connector, tail lamp junction box (CK13) 42 L Joint sleeve (HC9)
36 Connector, tail lamp junction box (CK8) 42 L Joint sleeve (LO39)
36 Connector, tail lamp junction box (CN13) 42 M Joint sleeve (HK6)
36 Connector, tail lamp junction box (CN16) 42 M Joint sleeve (NG40)
36 Connector, tail lamp junction box (CN6) 42 M Joint sleeve (XA16)
36 Connector, tail lamp junction box (CN9) 42 MA Joint sleeve (BB12)
36 Connector, tail lamp junction box (EA14) 42 MA Joint sleeve (NA51)
36 Connector, tail lamp junction box (EA7) 42 MB Joint sleeve (EA5)
36 Connector, tail lamp junction box (EG8) 42 MB Joint sleeve (NA8)
36 Connector, tail lamp junction box (EN3) 42 MB Joint sleeve (ND32)
36 Connector, tail lamp junction box (NA22) 42 MC Joint sleeve (BB12)
36 Connector, tail lamp junction box (ND45) 42 N Joint sleeve (CE31)
42 A Joint sleeve (CE13) 42 O Joint sleeve (GA40)
42 A Joint sleeve (CH11) 42 P Joint sleeve (AA23)
42 AA Joint sleeve (BL35) 42 P Joint sleeve (ND35)
42 AA Joint sleeve (BL56) 42 R Joint sleeve (LG12)
42 AA Joint sleeve (ND13) 42 R Joint sleeve (NA18)
42 AB Joint sleeve (AA16) 42 R Joint sleeve (NG17)
42 AB Joint sleeve (BB6) 42 S Joint sleeve (BB26)
42 AB Joint sleeve (ND14) 42 S Joint sleeve (NA47)
42 AP Joint sleeve (LP54) 42 S Joint sleeve (ND37)
42 AP Joint sleeve (LP9) 42 T Joint sleeve (EV4)
42 AP Joint sleeve (NA41) 42 T Joint sleeve (ND28)
42 AS Joint sleeve (LO10) 42 T Joint sleeve (NG46)
42 AS Joint sleeve (LO62) 42 T Joint sleeve (XD46)
42 AS Joint sleeve (LO87) 42 U Joint sleeve (NA25)
42 AS Joint sleeve (LO99) 42 U Joint sleeve (ND38)
42 AT Joint sleeve (LO15) 42 V Joint sleeve (HA11)
42 AT Joint sleeve (LO43) 42 V Joint sleeve (HA39)
42 AT Joint sleeve (LO78) 42 V Joint sleeve (HA66)
42 B Joint sleeve (CH11) 42 V Joint sleeve (NA17)
42 D Joint sleeve (GA27) 42 V Joint sleeve (NA63)
42 D Joint sleeve (HD5) 42 V Joint sleeve (NG16)
42 D Joint sleeve (LG27) 42 X Joint sleeve (ER23)
42 D Joint sleeve (ND33) 42 X Joint sleeve (NA14)
42 D Joint sleeve (PA9) 42 X Joint sleeve (NG15)
42 F Joint sleeve (CE53) 42 Y Joint sleeve (CE55)
42 F Joint sleeve (CG8) 42 Y Joint sleeve (NA12)
42 F Joint sleeve (EG9) 44 Circuit card, gear lever carrier, Geartronic (LO43)
42 F Joint sleeve (NG21) 56 Fuse holder, 6–unit (XA12)
42 G Joint sleeve (CE52) 56 Fuse holder, 6–unit (XA14)
42 G Joint sleeve (CG8) 56 Fuse holder, 6–unit (XA16)
42 G Joint sleeve (EG9) 56 Fuse holder, 6–unit (XA18)
42 G Joint sleeve (NG49) 56 Fuse holder, 6–unit (XA2)
42 G Joint sleeve (XD17) 56 Fuse holder, 6–unit (XA4)
42 H Joint sleeve (HG13) 56 B Fuse holder 6-unit (OA11)
42 H Joint sleeve (LD12) 56 B Fuse holder 6-unit (OA14)
42 H Joint sleeve (ND41) 56 B Fuse holder 6-unit (OA2)
42 J Joint sleeve (BL63) 56 B Fuse holder 6-unit (OA5)
42 J Joint sleeve (CE20) 56 B Fuse holder 6-unit (OA8)
42 J Joint sleeve (EV6) 56 F Fuse holder, 6–unit (AA17)
42 J Joint sleeve (HG13) 56 F Fuse holder, 6–unit (LO68)
42 J Joint sleeve (LD12) 56 F Fuse holder, 6–unit (LP40)
42 J Joint sleeve (LG19) 63 Fuse holder 36-unit (AA8)
42 J Joint sleeve (NG36) 63 Fuse holder 36-unit (BB29)
42 J Joint sleeve (XA18) 63 Fuse holder 36-unit (CE12)
17
Group 37 Wiring Diagram FL12 LHD List of components
223 Slip contact, horn (FA7) 3017 Time relay, axle-load limiter (MD30)
228 L Closing contact, cab lock (ND21) 3017 Time relay, axle-load limiter (MP2)
228 R Closing contact, cab lock (ND24) 3017 Time relay, axle-load limiter (MR2)
232 Break contact, warning light, air conn., trailer 3017 Time relay, axle-load limiter (MS13)
(NA18) 3024 1 Relay, solenoid control valve, ABS (OA14)
239 Break contact, thermal (BL62) 3024 2 Relay, solenoid control valve, ABS (OA22)
239 Break contact, thermal (HC37) 3025 Relay, indicator lamp, ABS (OA30)
239 Break contact, thermal (HD5) 3025 B Relay, indicator lamp, ABS (OA11)
241 Break contact, warning light, emergency air, trailer 3025 C Relay, indicator lamp, ABS (OA7)
(NA26) 3035 Relay, start solenoid (LO79)
247 Closing contact, climate system (air conditioning) 3035 Relay, start solenoid (LP58)
(HA29) 3036 Relay, indicator lamp, air suspension (MS3)
247 Closing contact, climate system (air conditioning) 3036 A Relay, indicator lamp, air suspension (MR35)
(HA3) 3036 B Relay, indicator lamp, air suspension (MR9)
247 Closing contact, climate system (air conditioning) 3048 Relay, dim-dip (CE48)
(HA58) 3058 Relay box, automatic transmission (LP58)
258 Break contact, thermal, bogie lift (MA23) 3061 Relay, retarder (BL60)
258 Break contact, thermal, bogie lift (MD38) 3062 Relay, unloading (LP41)
2002 Flame sensor, parking heater (HC29) 3066 Combination relay, several functions (BB6)
2007 Break contact, clutch pedal (BL18) 3066 Combination relay, several functions (GA32)
2008 Break contact, brake pedal (BL21) 3070 A Relay, locking, 3rd axle (LJ18)
2009 Breake contact, low split (LO43) 3070 B Relay, locking, 3rd axle (LJ26)
2010 Breake contact, hight split (LO41) 3073 Relay, Geartronic 1 (LO71)
2011 Breake contact, neutral (LO35) 3074 Relay, Geartronic 2 (LO65)
2012 Breake contact, gear engaged (LO33) 3092 Relay, height limiter (MN25)
2013 Breake contact, range OK (LO39) 3095 Relay, pressure monitor (MY31)
2014 Breake contact, high range (LO37) 3096 Relay, set, pusher axle lift (MY23)
2018 Break contact, oil pressure, power steering (ND33) 3097 Relay, reset, pusher axle lift (MY25)
2054 L Closing contact, grille locking (ND35) 3098 Relay, pusher axle lift (MY9)
2054 R Closing contact, grille locking (ND38) 3101 Relay, interior lighting (ER13)
2064 Closing contact, clutch disengaged (LO45) 400 L Bulb, full beams and dipped beams (CE39)
2067 Closing contact, indicator light/air pressure (LO97) 400 R Bulb, full beams and dipped beams (CE43)
301 Relay, fog lights (CG5) 401 L Bulb, fog lights (CG11)
302 Relay, spot lights (CE60) 401 R Bulb, fog lights (CG12)
305 Relay, reversing lights (EA5) 402 L Bulb, spot lights (CE60)
306 Relay, full beams (CE28) 402 R Bulb, spot lights (CE63)
308 Relay, brake lights (CK5) 403 Bulb, loading light (ED5)
308 B Relay, brake lights (OA4) 404 Bulb, fifth wheel light (ED10)
309 Relay, parking lights (CE9) 405 Bulb, reversing lights (EA10)
312 Relay, starting heater (BB4) 405 Bulb, reversing lights (EA11)
313 Relay, bogie lift motor (MA23) 408 Bulb, parking light, left front (CE13)
313 Relay, bogie lift motor (MD38) 409 Bulb, parking light, right front (CE31)
314 Relay, bogie lift (MP11) 410 Bulb, brake light, left (CK7)
314 Relay, bogie lift (MS7) 411 Bulb, brake light, right (CK10)
314 A Relay, bogie lift (MK12) 412 Bulb, tail light, left (CE19)
314 B Relay, bogie lift (MK19) 413 Bulb, tail light, right (CE22)
314 D Relay, bogie lift (MD25) 416 L Bulb, side marker light, left centre (CH5)
314 A Relay, bogie lift (LJ4) 416 LR Bulb, side marker light, left centre (CH9)
314 A Relay, bogie lift (MR41) 417 R Bulb, side marker light, right centre (CH13)
314 B Relay, bogie lift (LJ11) 417 RR Bulb, side marker light, right centre (CH17)
314 B Relay, bogie lift (MR47) 420 Bulb, position light, roof, left (CE29)
315 Relay, starting switch (XD4) 421 Bulb, position light, roof, right (CE11)
317 Relay, headlight wiper (GA20) 422 Bulb, direction indicator, left front (CN10)
323 Relay, flasher unit (CN5) 423 Bulb, direction indicator, right front (CN11)
326 Relay, extra fuse holder (XA8) 426 Bulb, direction indicator, left rear (CN14)
345 Relay, start inhibitor (LO86) 427 Bulb, direction indicator, right rear (CN15)
364 Operating controls, bogie lift (MA15) 428 Bulb, rotating warning light (EN8)
364 Operating controls, bogie lift (MD19) 429 Bulb, cigarette lighter lighting (EV6)
375 Relay, day running lights (CE33) 430 Bulb, licence plate light (CE17)
379 Relay, injection pump (BL25) 430 Bulb, licence plate light (CE25)
380 Relay, warning light, service brake (NA33) 433 L Bulb, instep light (ER4)
3001 Time relay, air-operated bogie (MK20) 433 R Bulb, instep light (ER23)
3004 A Relay, parking heater (HC10) 434 C Bulb, instep light (ER17)
3004 B Relay, parking heater (HC18) 435 L Bulb, bunk light (ER9)
3005 Alternator-controlled relay (AA26) 435 R Bulb, bunk light (ER13)
3016 Relay, control device, bogie lift with axle-load limiter 437 C Bulb, identification light, front (CE8)
(MD23) 437 L Bulb, identification light, front (CE8)
19
Group 37 Wiring Diagram FL12 LHD List of components
437 R Bulb, identification light, front (CE8) 606 Solenoid valve, bogie lift, up (MA6)
451 Bulb, rear fog light, left (EG4) 606 Solenoid valve, bogie lift, up (MD7)
452 Bulb, rear fog light, right (EG5) 606 Solenoid valve, bogie lift, up (MG10)
4002 L Bulb, position light at mirror (CF4) 606 Solenoid valve, bogie lift, up (MK10)
4002 R Bulb, position light at mirror (CF7) 607 Solenoid valve, bogie lift, down (MG4)
4056 Lighting, switches (KA23) 607 Solenoid valve, bogie lift, down (MK3)
4056 Lighting, switches (KA8) 614 Solenoid valve, range inhibitor (BB17)
500 Indicator light, dir. indicator, tractor (NA9) 626 Solenoid valve, exhaust pressure governor (BB12)
501 Indicator light, dir. indicator, trailer 1 (NA11) 627 Solenoid valve, kick down (LD6)
503 Warning light, oil pressure, engine (ND15) 640 Solenoid valve, horn (FA3)
504 Indicator lights, full beams (NA12) 646 Solenoid valve, 3rd axle lock (LJ23)
505 Warning light, battery charging (ND35) 648 Solenoid valve, air-operated bogie (MR26)
507 Warning lights, service brakes (ND38) 648 Solenoid valve, air-operated bogie (MS23)
508 Warning light, parking brake (NA5) 650 Windscreen wiper motor (GA35)
509 Warning light, coolant (ND20) 651 Windscreen washer motor (GA12)
510 Indicator light, diff. lock, rear wheels (LG18) 651 Windscreen washer motor (GA16)
513 Indicator light, bogie lift (LJ15) 652 L Headlight wiper motor (GA21)
513 Indicator light, bogie lift (MA9) 652 R Headlight wiper motor (GA27)
513 Indicator light, bogie lift (MD10) 653 Headlight washer motor (GA3)
513 Indicator light, bogie lift (MG8) 653 Headlight washer motor (GA7)
513 Indicator light, bogie lift (MK8) 654 Starter motor (AA9)
513 Indicator light, bogie lift (MP16) 656 Bogie lift motor (MA23)
513 Indicator light, bogie lift (MR16) 656 Bogie lift motor (MD38)
513 Indicator light, bogie lift (MS27) 658 Alternator, extra (AA21)
514 Indicator light, overdrive (NA8) 660 Alternator with charging regulator (AA16)
515 Indicator light, hazard warning lights (ND40) 661 Window winder motor (KA19)
517 Indicator light, power take-off, side (LD11) 661 Window winder motor (KA4)
518 Indicator light, power take-off, rear (LD11) 6003 Solenoid valve, level control (MR48)
520 Indicator light, fog light, front (CG7) 6004 Solenoid valve, level control (MR48)
521 Indicator light, spot light (CE55) 6008 Water valve, parking heater (HC15)
524 Indicator light, air cleaner (ND31) 6011 Solenoid valve, blocking trailing axle (MR20)
528 Indicator light, preheating (ND11) 6012 Solenoid valve, draining trailing axle (MR21)
530 Indicator light, heated rearview mirror (HG12) 6013 LF Solenoid control valve, ABS (OA38)
531 Indicator light, loading light (ED7) 6013 LR Solenoid control valve, ABS (OA54)
536 Indicator light, rear fog light (EG8) 6013 RF Solenoid control valve, ABS (OA46)
547 R Central warning for indicator and warning lights 6013 RR Solenoid control valve, ABS (OA62)
(NA36) 6019 L Solenoid valve, drive axle load-increase (MV5)
547 Y Central warning for indicator and warning lights 6019 R Solenoid valve, drive axle load-increase (MV11)
(NA38) 6019 L Solenoid valve, drive axle load-increase (MY8)
550 Warning light, cab lock (ND22) 6019 R Solenoid valve, drive axle load-increase (MY4)
555 Indicator light, coolant level (ND25) 6024 Solenoid valve, pto (LP11)
563 Indicator lamp, pusher axle (MY13) 6025 Solenoid valve, low range (LO68)
5004 Indicator lamp, rotating warning light (EN9) 6026 Solenoid valve, high range (LO70)
5007 Indicator lamp, bogie press (ND5) 6027 Solenoid valve, clutch disengaged, slow (LO80)
5008 Indicator lamp, air suspension, manual position 6028 Solenoid valve, clutch disengaged, fast (LO76)
(ND29) 6029 Solenoid valve, clutch engaged, fast (LO78)
5009 Indicator lamp, vehicle, ABS (ND8) 6030 Solenoid valve, neutral (LO56)
5010 Indicator lamp, trailer, ABS (ND28) 6031 Solenoid valve, 1st (LO62)
5011 Indicator lamp, grille lock (ND34) 6032 Solenoid valve, 2nd (LO61)
5017 Indicator lamp, trailer, ABS information (ND26) 6033 Solenoid valve, 3rd (LO64)
5018 Indicator lamp, power take-off, clutch independent 6036 Solenoid valve, reverse (LO58)
(LP11) 6036 Solenoid valve, reverse (LO81)
5023 Indicator lamp, gearbox (ND4, ND14) 6037 Solenoid valve, crawler (LO59)
5029 Warning lamp, locking, 3rd axle (LJ20) 6039 Solenoid valve, low split (LO65)
5033 Indicator lamp, seat heater (HD15) 6040 Solenoid valve, high split (LO67)
5035 Warning lamp, steering servo circuit 2 (pss dual) 6041 Solenoid valve, gear lever carrier (LO75)
(ND32) 6043 Solenoid valve, air suspension, front axle (MN35)
5036 Indicator lamp, air pressure, Geartronic (ND14) 6044 Solenoid valve, rear axle (MN15)
5037 Indicator lamp, check engine (ND13) 6045 Solenoid valve, trailing axle (MP22)
5038 Indicator lamp, VEB (ND10) 6045 Solenoid valve, trailing axle (MS13)
600 A Solenoid valve, exhaust brake (BL58) 6046 Solenoid valve, pusher axle, down (MY11)
600 B Solenoid valve, exhaust brake (BL60) 6047 Solenoid valve, pusher axle, up (MY15)
601 Solenoid valve, diff. lock, rear wheels (LG8) 6048 Solenoid valve body, gearbox (LO55)
602 Solenoid valve, diff. lock inter axles (LG4) 6049 Solenoid valve body, clutch cylinder (LO76)
604 Solenoid valve, power take-off, side (LD3) 6052 Fan motor, parking heater (HC31)
605 Solenoid valve, power take-off, rear (LD6) 6054 Fuel pump, parking heater (HC38)
606 Solenoid valve, bogie lift, up (LJ10) 6055 Coolant pump, parking heater (HC25)
20
Group 37 Wiring Diagram FL12 LHD List of components
6056 L Motor level control, headlights (PA2) 858 Buzzer, reverse warner (FB8)
6056 R Motor level control, headlights (PA7) 859 External alarm, communication radio (JA22)
6072 Unit injectors (BL37) 8006 Air dryer with time relay (HK4)
700 Speedometer (NG3) 8010 Control, gearbox (LP16)
701 Tachograph (NG15) 900 Radio (JA9)
702 A DIS (NA3) 901 Voltage converter (JA9)
702 B DIS (NA42) 902 L Loudspeaker (JA5)
703 Tachometer (NA32) 902 M Loudspeaker (JA9)
704 A Pressure gauge, air (NA24) 902 R Loudspeaker (JA12)
704 B Pressure gauge, air (NA27) 903 Diode (BL60)
705 Pressure gauge, oil (NA51) 903 Diode (BL64)
706 Thermometer, coolant temp. gauge (NA6) 903 Diode (CE49)
707 Fuel gauge (NA20) 903 Diode (JA15)
710 Timer engine/cab heater (HC3) 903 Diode (MA9)
713 Voltmeter (NA43) 903 Diode (MD10)
753 Engine, speed sensor (LO28) 903 Diode (ND13)
753 A Engine speed sensor, flywheel (BL4) 903 Diode (ND42)
753 B Sensor, cylinder identification, camshaft (BL10) 903 Diode (NG37)
754 Pressure sensor, air (MN39) 903 Diode (NG39)
754 Pressure sensor, air (MR53) 903 D1 Diode (CE34)
754 F Pressure sensor, air (NA23) 903 D2 Diode (CE8)
754 R Pressure sensor, air (NA28) 903 IB Diode (LG6)
756 Temperature sensor, coolant (BB11) 903 LB Diode (MS14)
756 B Temperature sensor, coolant (BL22) 903 A Diode (MY16)
757 Fuel gauge sensor (NA19) 903 AA Diode (LO82)
758 Gearbox, speed sensor (LP35) 903 B Diode (MY7)
759 Level indicator, coolant (ND16) 903 C Diode (MY26)
767 Oil temperature sensor, torque converter (LP58) 903 D Diode (MY7)
7006 Tripmeter (NA14) 903 E Diode (MY4)
7007 Display automatic transmission (LO10) 903 GA Diode (LO94)
7052 Sensor, speedometer (LO49) 903 GA Diode (LP41)
7052 Sensor, speedometer (NG24) 903 GB Diode (LO90)
7053 Inductive sensor, bogie lift (MD31) 903 LD Diode (MR44)
7053 Inductive sensor, bogie lift (MK20) 905 Communication radio (JA20)
7053 Inductive sensor, bogie lift (MR41) 911 Loudspeaker, communication radio (JA18)
7057 LF Sensor, pole wheel, ABS (OA34) 952 Magnetic clutch, air conditioning (HA29)
7057 RF Sensor, pole wheel, ABS (OA42) 952 Magnetic clutch, air conditioning (HA3)
7057 RR Sensor, pole wheel, ABS (OA58) 952 Magnetic clutch, air conditioning (HA58)
7059 Sensor, outer temperature (NA44) 971 L Lock, seat belt (KD8)
7061 Sensor, oil pressure (NA51) 971 R Lock, seat belt (KD4)
7065 Sensor, accelerator pedal (BL4) 9001 Pressure monitor, bogie lift (LJ3)
7065-2 Sensor, accelerator pedal (LO18) 9001 Pressure monitor, bogie lift (MP5)
7065-2 Sensor, accelerator pedal (LP24) 9001 Pressure monitor, bogie lift (MR9)
7066 Sensor, turbo pressure (BL28) 9001 Pressure monitor, bogie lift (MS21)
7067 Sensor, intake air temperature, engine (BL16) 9006 Glow plug, parking heater (HC35)
7068 Sensor, clutch position (LO3) 9008 Control unit, ABS (OA19)
7071 Sensor, temperature (HC32) 9009 Control box, air suspension, rigids (MN2)
802 L Heated rearview mirror (HG11) 9010 Control box, air suspension, tractors (MN2)
802 R Heated rearview mirror (HG7) 9010 Control box, air suspension, tractors (MR28)
803 A Heated seat (HD5) 9019 Voltage converter (CS8)
803 B Heated seat (HD5) 9057 Control unit, automatic transmission (LO20)
804 Cigarette lighter (EV4) 9057 Control unit, automatic transmission (LP16)
805 Rheostat (NG48) 9057 Control unit, automatic transmission (LP5)
810 Heated air dryer (HK9) 9065 Control unit, engine and cab heater (HC27)
850 Horn (FA7) 9070 Control unit, unit injector (BL3)
851 Buzzer, airdump (MY4)
853 Buzzer (NG40)
21
Group 37 Wiring Diagram FL12 LHD Cable colour code
Abbreviations
ATC ..................... Automatic air conditioning LU ........................ Left upper
BGT-19 ................ Bogie load 19 tonnes LVA ...................... Load-volume adapted
BLF-F ................... Leaf springs, front Not HBS3200 ...... Not wheelbase 3200 mm
C .......................... Centre P .......................... Passenger
CU-HEAT ............. Cab heater R .......................... Right
D .......................... Driver Reostat ................ Rheostat
"EG" ..................... EC-market RF ........................ Right front
F .......................... Front RHD ..................... Right hand drive
HB3200 ................ Wheelbase 3200 mm RL ........................ Right lower
ID-ljus .................. ID-light RR ....................... Right rear
KH ........................ Day cab RU ....................... Right upper
KHH ..................... High cay cab "S" ........................ Sweden + other markets
L ........................... Left U .......................... Upper
LF ........................ Left front UFSKR ................ Without tachograph
LH ........................ Sleeper cab VAB2600 ............. Vehicle width 260 cm
LHD ..................... Left hand drive VAB2500 ............. Vehicle Width 250 cm
LL ......................... Left lower
LR ........................ Left rear
22
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007548
23
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007616
24
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007617
25
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007618
26
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007752
27
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007553
28
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007554
29
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007753
30
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007754
31
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007755
32
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007756
33
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007757
34
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007567
35
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
36 T3007758
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007759
37
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007760
38
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007761
39
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007762
40
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007763
41
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007575
42
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007764
43
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007822
44
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007579
45
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007766
46
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007767
47
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007584
48
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007587
49
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007596
50
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007589
51
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007590
52
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007591
53
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007592
54
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007593 55
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007594
56
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007595
57
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007588
58
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007597
59
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007598
60
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007768
61
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007601
62
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007769
63
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007603
64
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007604
65
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007605
66
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007770
67
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007771
68
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007772
69
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007773
70
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007774
71
Group 37 Wiring Diagram FL12 LHD Cable harness illustrations
T3007615
72
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007619
73
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007620
74
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007623
75
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007624
76
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007625
77
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007626
78
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007627
79
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007628
80
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007629
81
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007630
82
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007631
83
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007632
84
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007633
85
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007634
86
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007635
87
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007636
88
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007640
89
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007641
90
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007642
91
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007643
92
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007644
93
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007645
94
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007646
95
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007647
96
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007648
97
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007649
98
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007652
99
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007654
100
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007655
101
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007657
102
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007659
103
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007660
104
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007661
105
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007666
106
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
T3007667
107
Group 37 Wiring Diagram FL12 LHD Component wiring diagrams
108
Feedback
One of our objectives is that workshop personnel should have access to correct and
appropriate service manuals where it concerns fault tracing, repairs and maintenance
of Volvo trucks.
In order to maintain the high standards of our literature, your opinions and experience
when using this manual would be greatly appreciated.
If you have any comments or suggestions, make a copy of this page, write down your
comments and send them to us, either via telefax or mailing directly to the address
listed below.
To From
Sweden ..........................................................................
..........................................................................
..........................................................................
Comments/proposals
................................................................................................................................................................................
................................................................................................................................................................................
................................................................................................................................................................................
................................................................................................................................................................................
................................................................................................................................................................................
................................................................................................................................................................................
................................................................................................................................................................................
................................................................................................................................................................................
................................................................................................................................................................................
................................................................................................................................................................................
................................................................................................................................................................................
................................................................................................................................................................................
................................................................................................................................................................................
................................................................................................................................................................................
................................................................................................................................................................................
Concerns Service Manual: ...............................................................................................................................
T3007621
Foldout A
Wiring diagram BL
T3007622
Foldout B
Wiring diagram CE
T3007637
Foldout C
Wiring diagram GA
T3007638
Foldout D
Wiring diagram HA
T3007639
Foldout E
Wiring diagram HC
T3007650
Foldout F
Wiring diagram LO
T3007651
Foldout G
Wiring diagram LP
T3007653
Foldout H
Wiring diagram MD
T3007656
Foldout I
Wiring diagram MN
T3007658
Foldout J
Wiring diagram MR
T3007662
Foldout K
Wiring diagram NA
T3007663
Foldout L
Wiring diagram ND
T3007664
Foldout M
Wiring diagram NG
T3007665
Foldout N
Wiring diagram OA
T3007668
Foldout O
Wiring diagram XD
T3007669
Foldout P
Wiring diagram ZA
T3007670
Foldout Q
Wiring diagram ZD
Volvo Truck Corporation
Göteborg, Sweden