Académique Documents
Professionnel Documents
Culture Documents
October, 2012
Section 1. INSTALLATION
Section 2. DESCRIPTION
Section 3. SPECIFICATIONS
-1-
1.1 INSTALLATION
1. Cable Connection
1) Set up the Antenna Matching Unit at a place where avoid rain as possible.
2) Using the RG-8 Cable, Connect the J1 terminal placed at bottom with the Output
Transmitter terminal.
3) Using a thicker than 0.75mm Shield Cable (20AWG 3p), Connect the J2 A,B,C
terminal placed at bottom and the J5 6,7,19 terminal placed at Transfer unit of
Transmitter.
4) Using a thicker than 14 sq mm cable, Connect to the Ground.
5) Connect the antenna to the Output Terminal.
1) First, place the meter select switch “TUNE” on the front panel of Antenna
Matching Unit(KMW-250RB-MU), than make TX on for transmitter with 50W
output.
7) Place Meter Selecter Switch “HI” or “LO” and see Antenna Current’s value.
-2-
Section. 2 DESCRIPTION
-3-
2.1 DESCRIPTION
-4-
Section 3. SPECIFICATIONS
-5-
3.1 SPECIFICATIONS
5) Metering : Antenna current and tuning. Single meter with a four. Single meter
with a four position switch for OFF, TUNE, HIGH and LOW tuning
6) Tuning : Large coil with coarse taps, fine tapes and a rotating shorted ring
controlled by the autotune system
-6-
Section 4. TEST DATA
-7-
MATCHING UNIT TEST DATA
NO.
300KHz 11 6 5 7 35T 4T 1 3
320KHz 11 6 6 10 4T 11T 1 4
360KHz 11 5 7 11 1T 23T 1 4
430KHz 11 4 8 8 8T 9T 1 1
490KHz 11 4 9 9 9T 28T 2 2
535KHz 11 4 10 10 4T 4T 2 2
FINAL SET
300KHz 8 3 15T 3
(5Ω+700pF)
-8-
Section 4. SCHEMATICS & PART LIST
-9-
KMW-250RB-MU SCHEMATICS LIST
- 10 -
MF RADIO BEACON ANTENNA MATCHING UNIT
E1 SPARK CAP 1
F1 FUSE 1A 1
J1 CONNECTOR M-R 1
J2 CONNECTOR 18-21P 1
L1 1NDUCTOR 10MH 1
L2 1NDUCTOR 35T 1
R1 RESISTOR 8W 50 ohm 1
T1 TRANSFORMER 18T:13T 1
T2 TRANSFORMER 1T:14T 1
T3 TRANSFORMER 1T:14T 1
- 13 -
MACHING UNIT CURRENT METER PCB
PIN HEADER
JP1,JP2 KA2-2P 2
CONNECTOR
- 15 -