Académique Documents
Professionnel Documents
Culture Documents
3. down speed control – controls rate of carriage descent, multi-turn color coded, each turn
calibrated at 0-9. pull red locking ring to set; push locking ring to lock. Return rate is fixed.
7. Trigger pressure control – selects dynamic triggering pressure; calibrated 1-24 in half steps/48
detents corresponding to a force range of 15-200 lbs/67-890 N.
5. RESET SWITCH resets any resettable or latchable alarm condition (indicated by the switch led
blinking). Holding reset prevents a weld cycle form starting. Releasing reset returns the welber to
the ready state, if there are no non-resettable errors.
6. TEST SWITCH- activates ultrasonic power and places the ultrasonic power supply module into
test ( autotune) mode for approximately 6 seconds. While this switch in pressed, power displays
on both the numeric display and the power bargraph. When you release test, the welder returns
to the ready state, you can select the scale factor for test mode by setting the scale multiplier dip
switch to 1x or 2x. refer to section 4.1.1 setting dip switchs on page 4-32 for further information
about dip settings.
Selects the horn down mode. when pressed, the swich led will light. pressing the start witches
while in the horn down mode will bring the carriage down without triggering ultrasonics. pressing
the switch again will de-selec HORN DOWN mode.
8. AB TIME SWITCH – selects the afterburs time parameter for modification when display lock is
inactive; displays the ab TIME PARAMETER in the numeric display, and linghts the ab time switch
led.
9. AB DELAY SWITCH- select the hold time parameter for modification when display lock is
inactive; displays the ab delay parameter in the numeric display, and light the ab delay switch led.
10.- HOLD TIME SWITCH. select the hold time parameter for modification when display lock is
inactive; displays the hold parameter in the numeric display, and lights the hold time switch led.
11 WELD TIME SWITCH. selects the weld time parameter for modification when display lock is
inactive; display the weld parameter in the numeric display; and lights the hold time switch led.
7. RESET SWITCH- resets any resettable or latchable alarm condition (indicated by the switch led
Blinking). Holding reset prevents a weld cycle form starting. Releasing reset returns the welder to
the ready state, if there are no non-resettable errors.
8.
5. RESET SWITCH restablece cualquier condición de alarma reiniciable o enganchable (indicada por
el parpadeo del led del interruptor). El reinicio del mantenimiento evita que se inicie un ciclo de
soldadura. Al soltar el restablecimiento, se devuelve el soldador al estado listo, si no hay errores
no reiniciables.
Selecciona el modo de bocina. cuando se presiona, se enciende el led swich. presionar el botón de
iniciar brujas mientras está en modo de bocina bajará el carro sin activar el ultrasonido. presionar
el interruptor nuevamente desactivará el modo HORN DOWN.
BEEPER DEL GATILLO: UNA SEÑAL AUDIBLE SONORIZADA CUANDO SE HACE EL GATILLO