Académique Documents
Professionnel Documents
Culture Documents
Product Description Spray 77 Low Mist Adhesive Spray 77 Low Mist Adhesive The Low Mist spray pattern
is a multi-purpose aerosol is a light coloured, non improves adhesive
adhesive. It is fast tacking staining adhesive. coverage compared to
and has a long tack range conventional aerosols.
when applied to both
surfaces.
Propellant Hydrocarbon
Directions for Use Ensure all surfaces to be For Temporary Bonds Clean Up:
bonded are clean, dry and with Easy Removal: To Spray nozzle or excess
free from dust, oil and bond substrates for short material may be cleaned
grease before application of periods and to permit easy with Scotch-Grip Solvent
adhesive. removal, apply a light coat No. 1.
to one surface and allow to
Ensure that the nozzle dry for about 1 minute. Most NOTE: Solvent No. 1 is
points away from all surfaces can then be highly flammable. When
persons and towards the removed when desired using solvents for clean up
surface to be sprayed. Turn without adhesive transfer. it is essential that proper
the spray tip to select the safety precautions are
desired spray width. NOTE: When bonding observed.
expanded polystyrene foam,
Shake the can well before leave surface open for about
using, 5-10 seconds should 10 minutes to allow most of
be sufficient. the solvent to escape before
making a bond.
For Strong Permanent
Bonds: Spray both surfaces To prevent spray nozzle
to be bonded and allow a from blocking, at the end of
minimum of 30 seconds each day, turn the can
drying time before upside down and press tip
assembly. until spray is clear from
adhesive.
Applications Spray 77 Low Mist Adhesive For bonding fabric The adhesive is also widely
is extensively used for backcloths in studios and used in the heating and
bonding lightweight boards, window dressing, and ventilating industry.
foams, plastics, fabric, bonding polystyrene foam in
paper and insulating fabricating packaging units.
materials.
Precautionary Refer to product label and Material Safety Data Sheet for health and safety information
Information before using the product.
For information please contact your local 3M Office.
3M Svenska AB, Industri, 191 89 Sollentuna
wwwp.3M.se
3M and Scotch-Grip are trademarks of the 3M Company.
Values presented have been determined by standard test methods and are average values not to be used for specification purposes.
Our recommendations on the use of our products are based on tests believed to be reliable but we would ask that you conduct your own tests to
determine their suitability for your applications.
This is because 3M cannot accept any responsibility or liability direct or consequential for loss or damage caused as a result of our
recommendations.
3
3M Svenska AB
Industri
Bollstanäsvägen 3
191 89 Sollentuna
Tel: 08-92 22 50
Fax: 08-92 22 88
E-post: kundservice@mmm.com
www.3M.se/tejp