Académique Documents
Professionnel Documents
Culture Documents
1. XLPE cable
(6.1)capacitance between conductor and screen is 1.53*10-7 whereas it is 1.31*10-7 in TDS
Answer:
55.7
C= *10-12
Di
ln( )
dc
=1.53×10-10 F/m
=1.53×10-7 F/km
Refer to item 10.10 IEC 60840:2011, the max. value not exceed the declared nominal value by
more than 8 %
C max. =1.53×10-7 F/km×1.08
1. inductance of conductor
hereinto:
Li:inner inductance of conductor =5 × 10-8 H/m
S: space between cable conductor centre = 300 mm
dc: diameter of conductor =26.6mm
(7) maximum charging current per 100 m of completed…… is 0.393 whereas it is 3.65 in TDS.
Answer:
1.Capacitive reactance
Xc= 1/ωC
=1/2πfC
=2.09×107 Ω/m
hereinto:
ω= 2πf
f= rated frequency 50 Hz
2. Charging current
A = U0/Xc
=76/1.53×10-7
=3.64 A/km
AMax. = 1.08 A
Hereinto:
Answer:we confirm with you that nominal drum length 700 m is available for us to produce and
shipment.but we do not know if it is easy to lay out on the jobsite.
(27) maximum dielectric loss of completed cable….. Is 0.84 kw/km whereas it is 0.72 kw/km.
Answer as below:
1. Cable losses
The cable total losses(Wt) include conductor losses (Wc), dielectric losses (Wd), sheath
losses(Ws).
132kV XLPE 1×500SQMM, directly buried under ground in trefoil formation(2 circle).
where:
0.222﹝W/m,per phase
where:
ω—2πf(π=3.14,f=50Hz) 314﹝1/s﹞
C —Capacitance per meter 1.53×10-10﹝F/m﹞
where:
where:
15.95﹝kW/km (I=560A,
Wt = ﹝Wc+Wd+Ws﹞
per phase﹞)
maximum dielectric loss is 0.666kW/km ,three phase , so 0.72 kW/km is error value
(36) total loss of completed cable per 1000m of 3 phase circuit
(36.1) should be as it is TDS.
(36.2) should be as it is TDS.
(36.3) should be as it is TDS.
(36.4) should be as it is TDS.
(36.5) should be as it is TDS.
(36.6) should be as it is TDS.
2. Outdoor Termination
Creepage distance of terminal outer insulation is 4200mm whereas required is 4475mm.
Answer: the creepage distance of terminal outer insulation is 4475mm now, please take
your time to check the attached amended TDS.
maximum wind speed is 34.4 km/s.
Answer: the unit of the wind speed should be m/s. km/s is not right as the requirement of
the standard.
thank you!
18th,June 2018