Académique Documents
Professionnel Documents
Culture Documents
27
25 ±0.5
A A
20
25
A A
B B
50 ±0.5 24 64
Round
half shear
C C
5X 6.4
8 56.2 ±0.5
22.4
6.5 ±0.5
P0001
39
A
Round half 5 1.8
21.1 shear
D 45° Notes: D
11.7 [Notas:]
6.6 1.- Material thickness: 2.5mm.
[Espesor de material: 2.5mm.]
2.- Bending radius: 2.5mm.
25.4 [Radio de doblez: 2.5mm.]
71 DETAIL A 3.- No sharp edges allowed.
[No se permiten bordes afilados.]
4.- Maximum burr allowed 0.13mm.
SECTION A-A [Rebaba máxima permitida 0.13mm.]
5.- No strokes and stripes allowed.
[No se permiten golpes ni rayaduras.]
6.- Component must be free of spots, riflings and bleanchings.
[El componente no debe presentar manchas, grietas o tallados.]
7.- Flat pattern dimensions for reference only.
DOWN 301.1° R 3.3
E
E [Dimensiones en el desplegado solo para referencia.]
DOWN 12.6° R 2.5
UP 45.0° R 2.5
Unless otherwise specified make reference to 2TDA900000 for We reserve all rights in this document and in the information contained therein. Reproduction use
or disclosure to third parties without expressed authority is strictly forbidden. C BU Low Voltage Systems
tolerances.
--------------- E
Revision:
2016/12/30 FA 120 DEG HINGE 4 HOLES No. of sheets
F
F
C 1
115.3
103.5
71.4
48.6
39.4