The equipment is visual instruments used to measure various
02 Introduction signal parameters. 1. AC Votage Measurements 2. DC Voltage Measurements 03 Purpose 3. Time Measurements 4. Phase Shift Measurements 5. Genration Of Lissajous Patterns: 1. Collect the equipments and components for the experiment from Lab In-charge with proper entry in Issue/Return register. 2. Make a circuit connection on a breadboard as per the circuit diagrams. 3. To measure the ac / dc voltage. The input signal is applied from the signal generator / outlet of circuit/ dc power supply to a channel of CRO. 4. The voltage/div switch (Y-plates) and time base switch (X- plates) are adjusted such that a steady picture of the Operating 04 Procedure of waveform is obtained on the screen. Equipment 5. For amplitude measurement, the height of the signal is measured in vertical axis and multiply with magnitude division factor. 6. For time measurement, the distance between successive peak of the signals is measured in horizontal axis and multiply with time division factor, then calculate the frequency. 7. Note down the observation in laboratory record note book as per the aim of experiments.
1. Experiment table should be clean and should not be
surrounded with any other unwanted materials. 2. As the experiment deals with heaver components handle all items carefully. 3. Utmost care should be taken in handling the CRO 05 Safety Precautions instruments. 4. Apply the proper operating voltage and input signal voltage as per the specification of components used in a circuit. 5. Hold the plug with fingers on the outside of the plug and away from the pins. 6. Must wear shoe and tuck in shirts to avoid electrical shock 1. The instruments for experiment collected from Lab In- charge are to be returned with proper entry in Issue/Return After Completion register. 06 of Experiment 2. The experiment table and the equipment used should be cleaned for any unwanted materials.
SAFETY RULES ARE YOUR BEST TOOLS.
USE THE RIGHT TOOL FOR THE RIGHT JOB IN RIGHT WAY.