Vous êtes sur la page 1sur 4

technology

solutions

GigaBeam Links Product

WiFiber Training
Design
Support
Maintenance
Integration
GigaBeam WiFiber 1000Mbps Links
WiFiber RF transmission uses spectrum at 71-76 GHz
and 81-86 GHz, with 99.999% weather availability up
to 1.6km in 80% of Australia and beyond 3.5km with
loop deployments for most areas of the coun-
try. GigaBeams’ technology is the only communication
solution available today that can communicate reliably
at multi-Gigabit speeds at these distances. The tech-
nology can be operated in virtually all weather condi-
tions and is almost impervious to conditions such as
fog, snow, and dust storms.

• Full duplex GigE/1.25 Gbps data capacity.


• Typical 1.6km transmission at 99.999%.
• Rapid slip-fit antenna mounting.
• Low power draw at 28 watt from –48vdc.
• Local and remote management via SNMP.
• Redundant power supply configuration.
technology at work for you
CONNECTING YOUR BUSINESS TO THE TECHNOLOGY RESOURCES YOU NEED CUST O M S OL UT IO NS

WiFiber comes with features


GigaBeam links utilise a highly directional milli-
include Adaptive Transmitter
metre-wave (MMW) antenna and a low-noise
Power Control (ATPC), forward
amplitude-modulated transceiver. The antennas
error correction, and encryption.
generate a pencil-like beam less than one de- WiFiber is an OSI Layer 1
gree wide. This narrow beam translates to a (physical layer) device that is
small illuminated “footprint” at the receiv- relatively indistinguishable from
ing antenna location. A second WiFiber link, the native fibre optic cable and
even when placed within this small beam foot- will easily integrate into standard
print, can reuse the same spectrum without inter- networks
ference, simply by pointing in a slightly different
direction (less than 2 degrees away).

flexible solutions for


your business needs RE MOT E MAN AG EM ENT
GMG Solutions can remotely
access all link parameters of
WiFiber devices via SNMP. This
SUPP OR T IN G T E CH NO L OG Y provides fast and convenient

• 70-80GHZ BAND. diagnostic and resolutions to


faults or to upload any new
• 1 GBPS FULL DUPLEX. software releases.

• FIBRE IN FIBRE OUT.

• SINGLE MODE FIBRE CONNECTION.

• REMOTE MANAGEMENT.

• PROTOCOL INDEPENDENT.

• LOW COST ACMA LICENSING.

• EXPANDABLE (FUTURE RELEASES).


L INK CO NF I GU RAT I ON
The WiFiber link is extremely easy to
configure. Using an intuitive web in-
terface, users have access to all of
the advanced facilities of the unit.
This includes power levels, link gain
parameters and antenna alignment.
Feature Characteristics

Native Network Compatibility GigE


Switched Network Compatibility 100Mb, DS-3, OC-3, and OC-12
OSI layer Physical Layer 1
Data format 802.3z Gigabit Ethernet
Beam width <1º (Antenna size dependent)
Network Management SNMPv2 via Ethernet 100Base-Tx, RJ-45
Signal interface LC Single Optical Connector
Power input (40-100 Watts), -48 VDC
Antenna size Normally 600mm
Weight Antenna – 16.78kg, Radio – 5.0kg
Temperature range - 33º to + 55º C
Altitude Up to 4,500m
Humidity Up to 95% non-condensing
Frequency 71-76GHz and 81-86GHz
Transmit power +20dBm (100mW) for 71-76GHz and 81-86GHz
Receiver threshold -57dBm
System Noise Figure 11dB (system level)
Transmit power control range ~20dB
System Gain - above threshold 177dB
Spectral Efficiency 1 bit per hertz (nyquist – calculated)
Antenna Gain 50dB @ 71GHz and 52.5dB @ 86GHz
Data Rate 1000Mbps full duplex
Centre Frequency 73.5GHz and 83.5GHz

technology
solutions

Suite 4, 7-9 Activity Crescent


Molendinar QLD 4214
+61 7 5539 4638 ph
+61 7 5564 0099 fax
www.gmgsolutions.com.au

Vous aimerez peut-être aussi