Académique Documents
Professionnel Documents
Culture Documents
Silglaze N-10
SCS2700
NEUTRAL SILICONE
DESCRIPTION APPLICATIONS
PROPERTY VALUE
Polyethylene closed cell foam rod is the When necessary to produce a neat
recommended back up material to provide appearance masking tape is
the correct depth of joint. If the joint is to recommended.
shallow use a polyethylene tape bond This should be removed immediately after
breaker. tooling before skin forms.
Do not allow the silicone sealant to contact
the back of the joint or any staining material. Uncured sealant should be cleaned off
non-porous surfaces while in the uncured
SURFACE PREPARATION state with a commercial solvent.
HEALTH AND SAFETY
All surfaces must be clean, dry, sound, and
free from dust, oil, rust, or any other Contact with uncured product will irritate
contamination. eyes. In case of eye contact immediately
Metals should be cleaned with a non-oily flush with water for 15 minutes and seek
solvent soaked clean cloth. Solvent should medical advice.
be wiped from the surface with a clean dry Use in well ventilated areas. Keep our of
cloth. Use an alcohol such as methylated reach of children. Avoid contact with skin
spirits on glass. For plastics contact the or clothing.
manufacturer for a recommended cleaning This product emits Methyl ethyl Ketoxime
solvent. (meko) whilst curing.
When used on remedial work all existing LIMITATIONS
sealant must be removed.
Silglaze N -10 is not recommended for use:
STORAGE/SHELF LIFE •On submerged joints where porous
The shelf life of Silglaze N-10 is 12 months substrates permit water to the bond interface.
if stored in a cool dry place . The storage • In aquarium construction and structural
temperature should not exceed 25oC as glazing. GE recommends SCS1200 sealant
this will or Ultraglaze.
decrease shelf life. • For certain rubber products where bleeding
of plasticiser may occur.
Packsize •In horizontal walkways where sealant will be
300grm cartridge available in carton of 20. subject to abrasion.
Product Packed Australia.
Sealant Volume Calculator
Number of
300gm Cartridges =Joint Width (mm) X Joint Depth (mm) X Joint Length (meter) X 1.15
Divided by 292.