Académique Documents
Professionnel Documents
Culture Documents
M PC M LAN cable
M Ground cable M HUB*2
Step 3 Set the VE-PG3's IP address, according to your
M Icom transceiver* and their instruction manual.
3
Configure the network system environment.
M SIP phone (KX-UT123/KX-UT136 series (Manufacture: Panasonic))*4
Installation guide 1
*2 The VE-PG3 can be directly connected to the PC using the MDI-X (crossover) type Ethernet cable.
(Separate leaflet) *3 See the topic below regarding the connection cables.
Step 4 Select the operating mode and configure the VE- *4 Necessary when you use the VE-PG3 in the Converter mode.
Configure the VE-PG3 PG3, according to your operating needs.
Connect the VE-PG3 and the transceiver, using the Options (As of November 2015)
appropriate optional cable.
Step 5 Installation guide 2 OPC-2273 CONNECTION CABLE for the IC-M604 (Length: approximately 5m/16.4 ft)
• Verify that both the VE-PG3 and the transceiver
Connect the transceiver are turned OFF when connecting or disconnecting (Separate leaflet) OPC-2274 CONNECTION CABLE for the IC-FR5000/FR6000 (Length: approximately 5m/16.4 ft)
the cable. OPC-2275 CONNECTION CABLE for the IC-F5060/F6060, IC-A110 and IC-A120/E (Length: approximately 5m/16.4 ft)
OPC-2276 CONNECTION CABLE for the Icom microphone and speaker (Length: approximately 5m/16.4 ft)
5
CT-24* DIGITAL VOICE CONVERTER to communicate using AMBE+2™ codec.
[About the operating mode] 6
RC-FS10* REMOTE COMMUNICATOR to create a virtual radio or simple dispatcher on a PC. CT-24
• Converter mode : When communicating between a SIP phone and the transceiver through the IP network, select this
mode.
• Bridge mode (default) : When communicating between 2 transceivers (A1 and B1 in the illustration below) through the IP
network, select this mode.
(You can download the Instruction Manual from the Icom web site; http://www.icom.co.jp/world/)
NOTE: Set the transceiver channel, volume level, TX output power, and other necessary settings, before NOTE: When two or more transceivers are connected to the VE-PG3, separate their antennas as far as possible to
connecting to the VE-PG3. reduce interference between them.