Académique Documents
Professionnel Documents
Culture Documents
com
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never fit accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Install no accessories in the areas between the A and B-posts, the B and C-posts, and the C
and D-posts.
Test terminal
Fuse in cargo compartment auxiliary fuse box
Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.
The first part is a type number that describes the This manual contains a section with a list of branch-
type of component in question, for example 3/xx. ing points. This list shows all the components that
are connected to each branching point.
The second part of the designation is a serial num-
ber, e.g. x/2. The location of the branching points is shown in the
"Cable harness routing in vehicle" section.
Together, this constitutes a component designation,
e.g. 3/2. C. Connectors
Connectors provide a bridge between two cable har-
At the end of the manual is a list of components, nesses and are described in the "Connectors" sec-
where, with the help of the component designation, tion.
you can read off the name of the component, for
example, 3/2 = light switch.
D. Electrical distribution
List of type numbers Operation of the fuses and relays is shown in the
"Electrical distribution" section.
The list shows which type of component that respec-
tive type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
E. Data communication
Today’s cars contain CAN, LIN and MOST networks
1 Battery that transfer information. Connections to these net-
2 Relay works are not shown in their entirety in the respec-
3 Switch tive wiring diagram. Complete information on CAN,
4 Control module LIN and MOST communication is found in the sec-
5 Driver information module tion "Control modules".
6 Electric motor
7 Sensor F. Abbreviations
8 Actuator A number of different abbreviations are used in the
9 Heating element manual. These are explained in the section "Abbre-
10 Light viations".
11 Fuse
15 Electrical distribution rail/box G. Component location
16 Audio
17 Service/diagnostics The end of the manual contains a section that
18 Contact reel describes component appearance and location in
19 Meter numerical order.
20 Ignition component/shunt
27 Optics
31 Ground connection
73 Branching point
74 Connector
A D C E F B List of symbols
= System voltage
30+
15/31 5/1
1 1 1
DIM
= Ground connection via wiring
2
11A/1 11A/2 11B/23
6
2 2 2
= Ground connection in compo-
CAN
nent/chassis
= Screened wire
RD-BU
RD-BK
= Junction point
RD-BK
= Twisted cable
12 74/411
CEM
3/111
RD-BK 1 LSM
73/4017
C3:52 GN-VT 6
LIN
5 BK RHD BK
= Electrical connection
BK LHD
C1:49 CAN C1:10 73/4016
BK-OG
= Variant
C1:50 C1:40
LIN
BK-VT
10/1 10 10/2 10
BK
C2:52 C2:50 C2:24
TURN POS HIGH LOW
M
TURN POS HIGH LOW
M = CAN communication
YE-VT
1 1
74/601 1
GN-OG
GY-RD
= CAN high data signal (CAN H)
YE-BK
73/3035
73/3033
VT-GN
TURN STOP FOG POS REV REV POS FOG STOP TURN = LIN communication
1 GND GND
3 3
= LIN communication
10/51
10/52
10/44
10/45
LIN
BK-BU
= Data communication
BK-OG
BK-BU
4 74/601
= MOST communication
BK-OG
BK-BU
G 1
= Connector between cable har-
10/17
nesses
1 = Connector connected in compo-
nent
G029147
5 2/35 5 2/17
3 3 R2
R12
2 1 2 1
RD-VT
73/3041
RD-VT
GY-VT 5 2/32 R10
3 RD
2 1 2/32 R11 1 2
RD (4 Cyl. Diesel) 11B/29
1 2
GY-VT
11B/28
1 2
2 1 11B/27
11B/35
GY-VT RD
73/3085 2 1 1 2 GY-BK
11B/39 11B/17 4/56C1:65
8CYL 2 1 1 2
11B/40 11B/16
2 1 1 2
11B/41 11B/18
GY-VT 1 2
11B/19
2 1 RD
11B/38
2 1
RD
11B/37 1 2
2 1
11B/36 11B/21
1 2
11B/20
1 2 BU-OG 5CYL T
11B/22
RD
4CYL D
BU-OG 2/14 R10 1 2
7 (4 Cyl. Diesel) 11B/23
5CYL T
RD-BU
5 3 2/133 R11
(5 Cyl. T)
5CYL T 2 1 2/239 R11 16 74/301
RD (8 Cyl.)
2 1
BU-OG
11A/44
4CYL D 2 1
11A/42
RD 2 1
11A/43
RD RD
RD 2/31 5
73/3068 2 1 R8 3
11B/30 GN-VT
4/56C1:45
RD 1 2
2 1 RD
11B/31
RD
2 1
11B/32
RD
8CYL & 4CYL D 2 1
11B/33
11A/7
1 2 RD
RD 9/42
EXC 5CYL D
1 2 RD-BK
2/22 11A/1 4/56C5:1
& 4CYL P
5 1 2
3 R13 11A/2 RD_BU 4/56C5:2
1 2 RD-GN
2 1 11A/3 15/32
RD 1 2 RD-GY
11A/4 15/32
1 2 RD-BN
11A/5
RD-VT
15/32
1 2
{
4/46B:16 5&6CYL 11A/6
4/46B:G4 4CYL D RD
4/46B:54 8CYL RD-GY 5 2/193
3 R9
4/56C1:48 VT-GN
1 1 2
2 11B/14
RD 1 2
11B/13
1 2
11B/11
1 2
2 1
11B/15 11B/9
1 2
11B/12
1 2
2 1 11B/10
11B/24 1 2
11B/8
2 1 RD
11B/25 RD
2 1
11B/26 RD
RD
1/1 12V BK RD
6/25
31/3
1 1
PF1 PF2 M 30
C1:1
2 2 6/26 31
RD RD C1:1
B+
73/3076 ACM
G
G029145
31
LIN
15/32
BK NL YE-VT
RD-GN
RD-GN 1 2
11D/B1
1 2
2 1 11D/B2
RD-GN
RD-BN
11D/A1 1 2
2 1 11D/B3
11D/A2 11D/B4
1 2
2 1
11D/A3
2 1
11D/A4 11D/B5
1 2
1 2
2 1
11D/B6
1 2
11D/A5 11D/B7
2 1 1 2
11D/A6 11D/B8
RD-VT 2 1
11D/A7 RD-GY
2 1
11D/A8 1 2
73/5040
RD-GN 11D/B9
73/5075 2 1
11D/A9 1 2
2 1 11D/B10
11D/A10 RD-GY
RD-GN
1 2
2 1 11D/B11
V70 11D/A11 RD-GY
RD-GN
1 2
2 1 11D/B12
11D/A12
2/16 2/75
RA2 RB2
5 5
3 3
2 1 1 2
RD-GY
2/82 2/88
RA1 RB1
5 5 YE-VT
3 3
2 1 1 2
RD-VT RD-GY
A B
D 1 2
BU-RD
11D/D1
1 2
11D/D2
1 2
11D/D3
1 2
1 74/505 11D/D4
1 2
11D/D5
1 2
11D/D6
1 2
11D/D7
1 2
11D/D8
1 2
11D/D9
1 2
11D/D10
1 2
11D/D11
1 2
11D/D12
RD2
5
3
1 2
RD1 4 BU-RD
5 RD-BN
3
1 2
BU
G029143
G029438
20 16
15
21 17
27 24
39 36 22 18
28 25
40 37
34 23 19
32 30 29 26
41 38 35
33 31
44 43 42
14 13 12
11 10 9 8
G029458