2004 Ford Escape
2004 ENGINE Engine Ignition - 3.0L (4V) - Escape
2004 ENGINE
Engine Ignition - 3.0L (4V) - Escape
SPECIFICATION
GENERAL SPECIFICATIONS
GENERAL SPECIFICATIONS
Item Specification]
Firing order 1-4-2-5-3-6]
Spark plue va 13-14 mm (0.052-
Park plus Sap 0.056 in)
Spark plug AWSF-32F|
Silicone Brake Caliper Grease and Dielectrie Compound oC
DIAZ - 19A331-A ESE - MICI71 -A|
TORQUE SPE |CATIONS
TORQUE SPECIFICATIONS,
Description Nm Ib-ft Ib-in}
Coil hold-down bolts 6 - 53
Spark plugs 15 ul +
DESCRIPTION AND OPERATION
ENGINE IGNITION
Six separate ignition coils:
# are mounted directly above each spark plug,
# are controlled by the powertrain control module (PCM) for correct firing sequence.
The spark plug:
« changes the high voltage pulse into a spark which ignites the fuel and air mixture.
« originally equipped on the vehicle has a platinum-enhanced active electrode for long
life.
Crankshaft position (CKP) sensor:
NOTE: Initial engine ignition timing is set at 10 degrees +/- 2 degrees
before top dead center (BTDC) and is not adjustable. For
additional information, refer to the INTRODUCTION - CNG, FLEX-2004 Ford Escape
2004 ENGINE Engine Ignition - 3.0L (4V) - Escape
FUEL & GASOLINE article.
«+ is a variable reluctance sensor triggered by a 36-minus -1 tooth trigger pulse wheel
located on the crankshaft located inside the engine front cover.
The sine wave type signal generated from the CKP sensor provides two types of information:
* position of the crankshaft in 10 degree increments.
« the crankshaft speed.
The PCM uses this information to determine ignition coil turn ON and turn OFF times and
misfire detection. For additional information, refer to ELECTRONIC ENGINE
CONTROLS article.
DIAGNOSIS AND TESTING
ENGINE TION
REFER to the INTRODUCTION - CNG, FLEX-FUEL & GASOLIN|
diagnosis and testing of the electronic ignition (EI) system.
article for
REMOVAL AND INSTALLATION
IGNITION COIL-ON-PLUG -LH
Removal and Installation
1. Remove the ignition coil-on-plug.
1, Disconnect the electrical connector.
2. Remove the bolt.
3. Remove the coil-on-plug.2004 Ford Escape
2004 ENGINE Engine Ignition - 3.0L (4V) - Escape
02740304
Fig. 1: Removing LH Ignition Coil-On-Plug
Courtesy of FORD MOTOR CO.
2. To install, reverse the removal procedure
+ Apply a light film of silicone brake caliper grease and dielectric compound to the
interior of the spark plug boot prior to installation.
IGNITION COIL-ON-PLUG -RH.
Removal and Installation
1, Remove the upper intake manifold. For additional information, refer to ENGINE-3.0L,
(av)
2. Remove the ignition coil-on-plug.
1. Disconnect the electrical connector.
2. Remove the bolt.
3. Remove the coil-on-plug.