Académique Documents
Professionnel Documents
Culture Documents
EASYCAN module must be installed in the vehicles program for a specific vehicle, in which
12 Vehicle speed
100 mA KM
frequency depends on the
the module is mounted. Module set by entering the code, which can be found in the attached pulse speed of the vehicle
list of vehicles.
13 Power module +12 V power +12V
To enter the code
The output is active when the
- The list of supported vehicles to select code for the vehicle Engine rpm RPM engine speed exceeds 500 rpm
- Hold down the button on the module or service EASYCAN button car alarm (unless it is di-
rectly connected with car alarm module) for 20 sec. Until the LED lights up on the module EA-
R
Output is active for reverse
Reverse gear
SYCAN or LED on key service gear
- Release the service pin. LED goes out. Programming is started (-)
- Press the button as many times as large is the value of the first digit of the code (0 = 10but- 14 Handbrake
100 mA
permanent Output is active for handbrake
ton). After each compression LED flashes. After the required number of compression, the LED
flashes to confirm the rapid establishment of the first issue of the code. The output is active after
- In the same way, enter the second and third digit of the code Clutch
depressing the clutch pedal
- The accuracy of the code and given access to the CAN BUS to confirm by briefly pressing
the service button on the ignition. LED quickly flashes intermittently. After about 5 seconds. Low beam
The output is activated after switching
LED goes out. on dipped lights (parking) lights
- If you entered the vehicle is not in the list of supported vehicles, the LED is lit. Disconnect the
power supply module. Once again enter the access code of the vehicle. input CANBUS H (2-wire CANBUS system)
1 CAN H
input CANBUS H (1-wire CANBUS system)
yellow Lock
output (+) - 100mA
Some types of car alarms KEETEC a connector for direct connection to the module EASYCAN. CAN grey Doors
For car alarms, which do not have this connector, you can join by reconnecting the module output(-) - 100mA
specific inputs that you need for correct car alarm. Description of outputs and colors of wires
found in the circuit diagram. brown
Ground
green/blue Trunk
output (-) - 100mA
pink Ignition
input (+) - 500mA
white/black Speed
KM
output (-) - 100mA
Rpm
red/white
RPM output (-) - 100mA
(output is activated over 500 rpm)