Académique Documents
Professionnel Documents
Culture Documents
Dale of Norway
Shoulder Wrap
Stork
9006 Shoulder Wrap
- Designer: Ane Sæthre
MATERIALS: Stork Rnd 3: Ch 3, work in rnd 1 behind previous rnd, * 1 sc between second
and third dc, ch 4, 1 sc in sc between ch loops, ch 1; rep from * to end
ONE SIZE: 100 gr bark 30 of rnd, then join with a slip st in top of ch at beg of rnd.
Rnd 4: Ch 1, * work 6 dc in ch-4 loop, 1 sc in ch-1 space; rep from * to
SUGGESTED NEEDLE SIZES: Cir or straight needles in size 3.5mm and
end of rnd, then join with a slip st in ch at beg of rnd.
crochet hook in size 3mm. Note: US and metric needle sizes often do
Rnd 5: Ch 4, work in rnd 3 behind previous rnd, 1 sc between third and
not match exactly and size equivalencies have changed. The original
fourth dc, ch 4, 1 sc in sc between ch loops, ch 4; rep from * to end of
version of this pattern was written to use metric size needles; if in
rnd, then join with a slip st in top of ch at beg of rnd.
doubt as to whether a given US needle size is the same as a metric size,
Rnd 6: Ch 1, work (1 sc, 4 dc, 1 sc) in each ch-4 loop across rnd, then join
use the metric size needle. As always, please take the time to check
with a slip st in ch at beg of rnd. Fasten off.
your gauge carefully and change needle sizes as needed to obtain the
correct gauge. MEDIUM FLOWER: Work rnds 1 - 4 of Large Flower, working 5 dc in
each ch-4 loop on rnd 4. Fasten off.
GAUGE: 34 sts over Drop St pattern = 4"(10cm).
SMALL FLOWER: With crochet hook and 1 strand each of Stork and
ACCESSORIES: Approx 438yds(400m) gold metallic thread and pin
metallic thread held tog, ch 7, then join with a slip st in first ch to form
back or large safety pin.
ring.
FINISHED MEASUREMENTS: Rnd 1: Ch 1, * ch 3, work 1 sc in ring; rep from * 5 times more, then join
with a slip st in ch at beg of rnd.
Rnd 2: Ch 1, work (1 sc, 3 dc, 1 sc) in each ch-3 loop across rnd, then join
with a slip st in ch at beg of rnd. Fasten off.
LARGE FLOWER: With crochet hook and 1 strand each of Stork and
metallic thread held tog, ch 7, then join with a slip st in first ch to form
ring.
Rnd 1: Ch 1, * ch 3, work 1 sc in ring; rep from * 5 times more, then
join with a slip st in ch at beg of rnd.
Rnd 2: Ch 1, work (1 sc, 4 dc, 1 sc) in each ch-3 loop across rnd, then
join with a slip st in ch at beg of rnd.