Académique Documents
Professionnel Documents
Culture Documents
Hot Tip
s
Lure M for
a
“Spinn k i n g
Visit O erbaits
u
www.l r Web Site ”
urema ..
king.c .
Making Your Own Spinnerbaits om
Follow these basic steps shown Putting the Spinnerbait Together
below and you will quickly become Before you begin assembling your spinnerbaits decide if you
a spinnerbait making expert. want a single or tandem spinnerbait. If you want a tandem (2
blades) spinnerbait you must first put the secondary blade on
Blade Styles the upper arm. Have your pair of needle nose pliers handy.
Here are the 4 most popular blades used on spinnerbaits.
1a Tandem spinnerbaits only.
Slide one or two beads on the
upper arm. Then slide the
blade down the upper arm on
the correct sized stirrup clevise.
Now slide a few (2 to 5) beads
down on top of the clevise.
Always use at least one bead
above and below the clevise.
Hatch Blade Colorado Blade Indiana Blade Willowleaf Blade
1b All spinnerbaits. Using your
Form loop here
Spinnerbait components needle nose pliers form a
Look over the following spinnerbait component chart. small loop at the end of the
upper arm. Leave enough
room to insert the crane
swivel or snap swivel.