Académique Documents
Professionnel Documents
Culture Documents
Spec.
0.1dB ripple fractional bandwidth ¼ lambda
coupled line BPF
S11 should smaller than -15dB in the
passband
FBW=30%
Open MWO from the shortcut
To create a project:
1 Choose File > New Project.
2 Choose File > Save Project As.
Choose Options > Project Options.
Click the Global Units tab
Set project frequencies
To specify the simulation frequency:
Click the Project tab in the lower left of the window.
Double-click Project Options.
Click the Frequencies tab.
Change the Data Entry Units to MHz.
Type “500” in Start, “4000” in Stop, and “50” in Step, and
then click Apply.
The frequency range and steps you specified display in
Current Range.
Click OK.
1.Open New Schematic
1.click Substrates
3.Double click to
change the value
2.Choose MSUB
Here Al2O3 substrate is used
Dielectric constant=9.8
Substrate Thickness=15mil
4.Choose coupled line
1.Coupled lines
2.Drag MCLIN
Hand calculation data for coupled lines
Click here
7. See the response- Add Graph
Add Graph cont’d
Enter graph
name
Add measurement
use dB scale
Result
8. Fine tune the ckt parameters
1.click tune
2.Goal type
3.frequency to
satisfy goal
Optimize (3)
Variables to opt
optimize (4)
optimize (5)
optimize(6)
10. TXL
TXL cont’d