Académique Documents
Professionnel Documents
Culture Documents
Abstract:
Photo-voltaic power control is one of the burning research fields these days.
When compared to fossil fuels,solar energy is relatively untapped source of energy.
Solar energy represents a promising alternative that will likely supplement fossil
fuel based energy supply, and eventually replace the fossil fuel source as the
availability of latter declines. A solar powered pump is a normal pump with an
electric DC motor. Solar powered pumps will naturally work best during sunny
days. Electricity for the motor is generated on-site through a solar panel which
converts solar energy to DC. A solar photovoltaic water pumping system (SPWPS)
consists of PV array, motor-pump set, associated electronics and an On/OFF
switch
Existing System:
The SPWPS may use any of the motor pump sets like surface mounted
motor pump set, submersible motor pump set or floating motor pump set. The
‘Motor Pump Set’ should have a capacity in the range of 0.2HP.
Maximum Power Point Tracker (MPPT) should be use the Solar panel and
maximize the water discharge
Disadvantages:
Proposed System
Shunt hybrid power filter has been proved to be a useful approach to eliminate
current harmonics caused by nonlinear loads. The passive power filter suppresses
harmonic currents produced by the load, whereas the active power filter improves
filtering characteristics of the passive filter. Nowadays, the passive filter has many
kinds of topologies. Among them, the single tuned passive filter has gained
extensive interests because of its simplicity and practicability. Different from
conventional design methods, a novel design method for the single tuned passive
filter is proposed in this paper to minimize the rating of active power filter.
Advantage: