Académique Documents
Professionnel Documents
Culture Documents
User input
# E1
Available resource/setting 128 128 200 240 256 6
Utilization 0% 0% 0% 0% 0% 0%
The Downlink Transmission Power Admission
Where:
P estimate rl is the estimation of the downlink transmitted carrier power needed for the new radio link
F is a power scaling factor for the radio link that is connected to the Activity Factor of the radio link
P max rl is the maximum downlink transmitted code power (absolute in W) allowed for the radio link.
The value of P max rl is set according to a per-cell-definable mapping, based on the maximum rate
The maximum power per radio link is relative to the power of the primary CPICH.
Where:
primaryCpichPower is the downlink output power used for the PCPICH in the cell where the connection is set up
Ec/No_PCPICH is the measured Ec/No on PCPICH in the cell where the connection is set up, received from the UE.
dlInitSirTarget is the required initial SIR target for the downlink DPDCH.
SF_DL_DPDCH is the Spreading Factor for the downlink DPDCH.
cBackOff is a parameter to back off the Open Loop Power Control estimate to a conservative starting point or to increase
Radio Connection Type Spreading Factor Initial DL Power (dBm) Initial DL Power (W)
Guaranteed
SRB 256 22.0279 0.1595
AMR 12.2 128 25.0382 0.3190
CS64 32 31.0588 1.2761
Guaranteed-HS
PS64/HS 16 34.0691 2.5522
PS384/HS 16 34.0691 2.5522
Non-Guaranteed
PS64/64 32 31.0588 1.2761
PS64/128 16 34.0691 2.5522
PS64/384 8 37.0794 5.1043
Total User Traffic Power
Assumption: The parameter "P max rl" is an estimate value from the mapping curve of the maximum radio link rate (bps) onto the maximu
per radio link (dB).
ed for the new radio link
e Activity Factor of the radio link
W) allowed for the radio link.
pping, based on the maximum rate of the radio link.
e primary CPICH.
1.9953 0.5986
1.9953 0.2993
4.1687 1.2506
1.9953 0.5986
1.9953 0.5986
4.3652 0.9167
5.0119 1.0525
6.0256 1.0846
connection is set up
et up, received from the UE.
onservative starting point or to increase the initial downlink power to improve the call setup reliability.
Power (W)
0.8795
0.1318
0.0891
0.0501
0.3020
0.2818
0.3639
0.3981
1.9937 <-- max should be about 2W only, approx the value of CPICH.
19.94%
80.0553%
Current %
23.46% <-- This is a percentage of each of the threshold
26.59%
23.46%
23.46%
26.59%
30.68%