Académique Documents
Professionnel Documents
Culture Documents
MII 16426
INSTALLATION CB ANTENNA
GL1800/D/DA Issue Date
P/N 08E85-MKC-A00
INSTRUCTIONS January 2018
Honda Dealer: Please give a copy of these instructions to your customer.
PARTS LIST INSTALLATION
NOTE:
(7) • Heat the bonding surfaces with a hair dryer if the
ambient air temperature is below 70°F (21°C).
• The adhesive reaches full strength in 72 hours. Wait
at least 24 hours before riding your motorcycle.
• Disconnect the negative (-) cable from the battery
(4) before installing this accessory.
(3)
• The memory of the clock will be erased when
you disconnect the battery. Reset the clock after
(6)
reconnecting the battery.
(5)
• Reinstall the removed parts on the motorcycle and
make sure that the wires and harnesses are not
(1)
pinched.
(2)
WASHER (Save)
TOOLS AND SUPPLIES REQUIRED
Hex wrench (5 mm)
Electric drill
Drill bit (14 mm)
Hole saw (18 mm)
Scale
Marker
Isopropyl alcohol
Shop towel
Torque wrench
TORQUE CHART
Tighten all screws, bolts, and nuts to their specified
torque values. Refer to the Service Manual for the torque
values of the removed parts.
© 2018 American Honda Motor Co., Inc. - All Rights Reserved. 1 of 4 87962-MKC-A000
3. Drill a 14 mm hole at each marked line of the trunk 5. Drill an 18 mm hole at the marked line of the right
inner box as shown. trunk side cover as shown.
• Drill holes at the center of the marked lines. • Drill hole at the center of the marked line.
• Remove the any burrs from the edge of the • Remove the any burrs from the edge of the
hole. hole.
<Right side>
ELECTRIC DRILL
(18 mm HOLE SAW)
ELECTRIC DRILL
(14 mm BIT) MARKED LINE
RIGHT TRUNK
SIDE COVER MARKED LINE
ISOPROPYL ALCOHOL
RIGHT TRUNK
SIDE COVER
ELECTRIC DRILL
(14 mm BIT)
2 of 4
7. Route the CB antenna cord as shown. 10. Route the CB antenna cord as shown.
RIGHT TRUNK SIDE COVER GROMMET
Insert in to the hole.
HARNESS BOOT
Move.
CB ANTENNA CORD
RIGHT TRUNK
SIDE COVER
CB ANTENNA CORD
WIRE TIE
Secure the mark of the
CB ANTENNA CORD
CB antenna cord to the
motorcycle’s harness.
3 of 4
13. Connect the CB antenna cord as shown.
CB ANTENNA CORD
CB MAIN UNIT
HARNESS
4 of 4