Académique Documents
Professionnel Documents
Culture Documents
TECH SEMINAR
The sequence in which the thesis material should be arranged and bound should be as
follows:
1. Cover page
2. Inside cover page
3. Acknowledgements
4. Abstract
5. Table of Contents
6. List of Tables
7. List of Figures
8. List of Symbols, Abbreviations or Nomenclature (Optional)
9. Chapters
10.Conclussion
11. Scope for Future Work
12.Appendices or APPENDIX
13. References
A NEW CRUISE CONTROL SYSTEM (name of topic ) (18pt bold)
of
in
I would like to place on record my deep sense of gratitude to Prof. S. A. Malhotra, Dept. of
Mechanical Engineering, DAVIET, Jalandhar, India for his generous guidance, help and useful
suggestions.
I express my sincere gratitude to Prof. Manoj Kumar, Dept.Mechanical Engineering, DAVIET,
Jalandhar, India, for his stimulating guidance,continuous encouragement and supervision throughout
the course of present work.
I also wish to extend my thanks to Dr. I. M. Talwar,Dr. A. K. Gupta, Dr. Shakti Kumar,
Dr. D. Singhal and other colleagues for attending my seminars and for their insightful
comments and constructive suggestions to improve the quality of this research work. (12 pt)
RAJINDER
(Roll No.)
ABSTRACT(14 pt Bold)
Many commercial and industrial power systems are being burdened by the proliferation of sensitivity
computing equipments like personal computer, uninterruptible
-----------------------
(Body of abstract 12 pt italic)
----------------------------current waveforms, caused by the non linear, on the power distribution equipment
in the system.
In this project, --------------------------------------------------an attempt has been made
List of Contents(16 pt. and bold)
Acknowledgement i
Abstract ii
List of Table iv
List of Figure
Chapter 1 1.1 Introduction 1
1.2 Composite 1
1.8 Fatigue failure 9
Chapter -2 Literature survey 11
Chapter -3 Experimental 14
3.1 Material 14
4.3 Characterize the cyclic fatigue 28
Conclusion 33
Scope for Future 34
Work
Appendices 35
References 36
List of Table
Table No. Title Page No.
In the last decade both electrical utilities and customers have experienced increasing costs for electric
power and energy due to escalating costs of burning fuels and capital costs for building new generation
capacity. Load management which changes the shape of the load curve so that the generation by costly
peaking units or capacity additions are avoided, is an effective solution to the above problem. ----------------
------------------------------an important option for utilities to manage their peak deficit.
[1] J. F. Fuller and K. J. Roesler, "Influence of harmonics on power distribution system protection," IEEE
Trans. on Power Delivery, Vol. 3, No 2, Apr. 1988, pp. 549-557.
[8] www. doe.hov.org/fundamental Series Item Power Quality and Harmonics.htm (as on 23-3-07)
Reference to Book
The Seminar report shall be computer typed (English- British, Font -Times Roman, Size-12
Point, 1.5 line spacing) and printed on A4 size paper.
DIMENSIONS AND MARGIN
The thesis should be prepared on good quality white paper preferably not lower than 80 gsm.
Standard A4 size (210 mm X 297 mm) paper should be used for preparing the copies. The
final thesis should have the following page margins:
Top edge : 1 inch (25 mm)
Left side : 1 ½ inch (38 mm)
Bottom edge : 1 inch (25 mm)
Right side : 1 inch (25 mm)