Académique Documents
Professionnel Documents
Culture Documents
L-T-P:4-0-0 Credits: 04
Pre-requisites:
• Basic electronics
• Analog electronic circuits
Course Outcomes: At the end of the course, Students will be able to
2. Discuss the effects of Input and output voltage ranges upon Op-Amp circuits
3. Sketch and analyze op- amp circuits to determine input impedances, output impedances
and other performance parameters
4. Describe and sketch the various switching circuits of Op-Amp and 555 timer and
analyze its operations
5. Differentiate between various types of DACs and ADCs and evaluate the performance
of each with neat circuit diagrams and assuming suitable inputs.
PO 1 2 3 4 5 6 7 8 9 10 11 12
CO1 * * *
CO2 * * *
CO3 * * * *
CO4 * * * *
CO5 * * * *
Teaching Methodology:
• Blackboard teaching
• Power Point presentations (if needed)
• Regular review of students by asking questions based on topics covered in the class
• Regular updating of the op –amp related activities in the world.
Assessment Methods
• Two Surprise Tests, 10 Marks each. Average of two tests will be taken.
• Three internals, 30 Marks each will be conducted and the Average of best of two will
be taken.
• Course Project( Mini project)
• Final examination, of 100 Marks will be conducted and will be evaluated for 50 Marks.
UNIT-I
Operational Amplifier parameters: Input and Output voltage, Common mode and supply
rejection ratio, Offset voltages and currents, Input and output impedances, Slew rate and
frequency limitations.
UNIT-II
OPAMP’s frequency response and compensation: OPAMP circuit stability, Frequency and
phase response, Frequency compensating methods
Text 1:4.1,4.3,4.5,4.6,4.7,4.8
UNIT- III
Miscellaneous OPAMP linear applications: Voltage sources, Current sources and current
sinks, Current amplifiers, Instrumentation amplifier.
Signal Processing Circuits: Precision have wave rectifiers, Precision full wave rectifiers,
Limiting circuits, Clamping circuits, Peak detectors, Sample and hold circuits
UNIT-IV
Text1: 8.1, 8.2, 8.4, 8.5, 9.1, 9.2, 9.3, 9.4, 9.5, 9.6 10 Hrs
UNIT-V
Active Filters: All Pass shifting Circuits, First order Low Pass active filter, First order high
pass filter, Band pass filters, Band Stop filter
Phase Locked Loop: Basic Principles, Phase detector / comparator, Voltage Controlled
Oscillator (VCO)
D-A and A-D Converters: Basic DAC techniques, weighted Resistor DAC, R-2R Ladder
DAC, A-D Converters, Direct Type ADCs: Parallel Comparator (flash) A/D Converter,
Successive Approximation Converter
1. David A. Bell,” Operational Amplifiers and Linear IC's", PHI, 2nd edition, 2004.
2. D. Roy Choudhury and Shail B. Jain "Linear Integrated Circuits", New Age
International, 2nd edition, 2006.
References: