Académique Documents
Professionnel Documents
Culture Documents
00
Owner Italfluid
Location Egypt
Unit U-150.2.5
Customer Reference # GE PO#1100015460 (9964423)
Most Recent Revision 00
Original Report Date June 13, 2016
The information in this report was prepared by BETA Machinery Analysis for GE Oil & Gas. Distribution of this
material is limited to the staff of GE Oil & Gas unless specific permission is obtained from BETA Machinery
Analysis.
Summary
Reciprocating compressors produce mechanical forces and moments due to the action of reciprocating and
rotating components, as well as pulsation forces due to the intermittent movement of gas. These forces can be
minimized, but cannot be eliminated. Direct and stiff connections to adequate foundation are required to
ensure vibrations of components are maintained at amplitudes low enough for long-term reliability. That
requires design, construction and installation in accordance with good practices.
Many of the high vibration areas found are due to inadequate supports and poor connection to a solid
foundation. This results in a system that is unable to resist the normal forces and moments produced by the
compressor and engine. Vibration of skid beams should ideally be less than 0.05 in/s pk, especially where
stiffness is critically needed. Skid vibrations of 0.10 in/s pk would be marginally acceptable at those critical
locations. In this case there are many areas on the main and secondary scrubber skids with vertical vibrations
near or above 0.20 in/s pk. Those locations are at the base of the scrubbers, engine pedestal, cylinder wedge
supports, and skid outriggers used to support process piping. Additionally, there are also areas beyond skid
limits, near the coolers, where the installed pipe support posts have inadequate stiffness, poor fit up, and are
not well connected to the concrete foundation.
It is paramount that the main compressor and the secondary scrubber skids be a solid part of the foundation
system, and are well connected to the concrete foundation through a good epoxy grout layer. If proper
foundation and adequate connection between skid beams and the foundation cannot be achieved, the addition
of bracing and gussets as recommended will not be sufficient to ensure long-term reliability.
This report contains recommendations to replace existing supports or increase support stiffness after the
foundation issues are corrected. While the recommendations such as braces and gussets made in this report are
one way of improving the existing support stiffness, there are other acceptable solutions that may be
implemented. If required, an alternative approach to increase support stiffness, or implement the
recommendations may be discussed with BETA Machinery Analysis to ensure best practices are followed.
Table of Contents
Summary ............................................................................................................................................................. 2
Table of Contents ................................................................................................................................................ 4
List of Figures ...................................................................................................................................................... 5
List of Tables ........................................................................................................................................................ 7
1 Introduction and History .............................................................................................................................. 9
2 Physical Layout .......................................................................................................................................... 11
3 Summary of Problem Areas........................................................................................................................ 13
4 Recommendations and Analyses ................................................................................................................ 15
4.1 Speeds to Avoid.................................................................................................................................. 17
4.2 Correct Cooler Area Pipe Supports ..................................................................................................... 22
4.3 Replace Existing Grout and Repair the Foundation Connection ........................................................... 31
4.4 Stage 2, 3, and 4 Suction Scrubber Recommendations (TP# 210, 300, and 400) .................................. 35
4.5 Stage 2 Scrubber Liquid Level Gauge Support Design (TP# 210 Sight Glass) ......................................... 42
4.6 Modify Existing Support Clamp and Post Design ................................................................................. 44
4.7 Correct Stage 1 and Stage 2 Scrubber Outlet Spool Flange Misalignment............................................ 48
4.8 Stage 4 Scrubber Outlet Spool (TP# 399)............................................................................................. 49
4.9 Stage 2, 3, and 4 Discharge PSV (TP# 250, 350, and 450)..................................................................... 52
4.10 Stage 3 and 4 Bottle Wedge and Inboard Support Recommendations................................................. 58
4.11 Cylinder 2, Stage 4 Suction and Discharge Bottles ............................................................................... 63
4.12 Cylinder 1, Stage 3 Suction Bottle and Suction Inlet Spool................................................................... 68
4.13 Stage 1 Bypass – Scrubber Inlet Spool (TP# 105) ................................................................................. 72
4.14 Secondary Suction Bottle and Stage 1 and 2 Discharge Bottle Recommendations ............................... 73
4.15 Coupling ............................................................................................................................................. 76
4.16 Additional Site Visit Details and Observations ..................................................................................... 77
4.17 General .............................................................................................................................................. 78
APPENDIX A Machine Details | Operating Conditions | Test Equipment.......................................................... 79
A.1 Machine and Operating Details .......................................................................................................... 79
A.2 Test Equipment .................................................................................................................................. 80
A.2.1 Instrumentation.......................................................................................................................... 80
A.2.2 Sensors ....................................................................................................................................... 80
A.2.3 Data Acquisition Setups .............................................................................................................. 80
APPENDIX B Data Summary | Vibration | Pulsation |Impact Response Data ................................................... 82
B.1 Data Plot Example .............................................................................................................................. 82
B.2 Vibration Data Summary .................................................................................................................... 83
B.3 Pulsation Plot Index ............................................................................................................................ 93
B.4 Torsional Data Summary .................................................................................................................... 94
B.5 Impact Response Plot Index................................................................................................................ 95
List of Figures
Figure 2.1 – Physical Layout – Stage 1 and Stage 2 ............................................................................................. 11
Figure 2.2 – Physical Layout – Stage 3 and Stage 4 ............................................................................................. 12
Figure 4.1.1 – Summary of Speeds to Avoid (Day Test without Side Stream) ...................................................... 18
Figure 4.1.2 – Summary of Speeds to Avoid (Day Test with Side Stream)............................................................ 19
Figure 4.1.3 – Summary of Speeds to Avoid (Night Test without Side Stream) .................................................... 20
Figure 4.1.4 – Summary of Speeds to Avoid (Night Test with Side Stream) ......................................................... 21
Figure 4.2.1 – Cooler Inlet and Outlet Pipe Spool Support Structure ................................................................... 23
Figure 4.2.2 – Stage 2 and Stage 3 Cooler Inlet Pipe Spool Support Posts ........................................................... 23
Figure 4.2.3 – Stage 1 Discharge Cooler Outlet Pipe Spool Missing Support........................................................ 24
Figure 4.2.4 – Stage 1 Discharge Cooler Outlet Spool (Near TP# 200) ................................................................. 24
Figure 4.2.5 – Cooler Inlet and Outlet Pipe Spool Support Recommendations .................................................... 25
Figure 4.2.6 – Alternative Cooler Pipe Spool Concrete Pile Support Recommendations ...................................... 25
Figure 4.2.7 – BETA Standard PS-1 – Pipe Support Post Design........................................................................... 26
Figure 4.2.8 – BETA Standard CL-1 – Flat Bar Clamp ........................................................................................... 27
List of Tables
Table 1.1 – Summary of Definitions, Directions and Abbreviations ..................................................................... 10
Table 3.1 – Summary of Problem Areas.............................................................................................................. 13
Table 3.2 – Summary of Problem Areas (Skid Vibration) ..................................................................................... 14
Table 4.2.1 – Vibration Observation Summary (Cooler Inlet and Outlet Spool Vibrations) .................................. 28
Table 4.3.1 – Vibration Observation Summary (Compressor and Secondary Skid Vibration) ............................... 32
Table 4.4.1 – Vibration Observation Summary (Stage 2 Suction Scrubber) ......................................................... 39
Table 4.4.2 – Vibration Observation Summary (Stage 3 Suction Scrubber) ......................................................... 39
Table 4.4.3 – Vibration Observation Summary (Stage 4 Suction Scrubber) ......................................................... 40
Table 4.5.1 – Vibration Observation Summary (TP# 210 Sight Glass – Stage 2 Scrubber Liquid Level Gauge) ...... 43
Table 4.6.1 – Vibration Observation Summary (Stage 4 Discharge Spool Downstream of Discharge Bottle) ........ 46
Table 4.7.1 – Vibration Observation Summary (Stage 2 Scrubber Outlet Pipe Spool) .......................................... 48
Table 4.8.1 – Vibration Observation Summary (Stage 4 Scrubber Outlet Spool).................................................. 51
Table 4.9.1 – Vibration Observation Summary (Stage 2, 3, and 4 PSVs – Velocity Guideline) .............................. 55
Table 4.9.2 – Vibration Observation Summary (Stage 2, 3, and 4 PSVs – Acceleration Guideline) ....................... 55
Table 4.10.1 – Vibration Observation Summary (Cylinder 2 and Discharge Bottle).............................................. 60
Table 4.10.2 – Vibration Observation Summary (Cylinder 4 Vertical Vibration)................................................... 61
Table 4.10.3 – Vibration Observation Summary (Skid Vibration at Stage 4 Wedge Supports) .............................. 62
Table 4.11.1 – Vibration Observation Summary (Elevated Stage 4 Suction Elbow TP# 414) ................................ 66
Table 4.11.2 – Vibration Observation Summary (Suction Bottle) ........................................................................ 67
Table 4.11.3 – Pulsation Observation Summary (Stage 4 Discharge TP# 460) ..................................................... 67
Table 4.12.1 – Vibration Observation Summary (Cylinder 1 and Stage 3 Suction Bottle) ..................................... 70
Table 4.12.2 – Vibration Observation Summary (Stage 3 Suction Inlet Spool TP# 314) ........................................ 70
Table 4.13.1 – Vibration Observation Summary (Stage 1 Suction Bypass Spool) ................................................. 72
Table B.2.1 – Vibration Data Summary (Anomaly Report: As-Found Vibration) ................................................... 83
Table B.2.2 – Vibration Data Summary (Anomaly Report: After Alignment Done)............................................... 87
Table B.2.3 – Vibration Data Summary (Anomaly Report: After Pipe at TP# 436 Braced) .................................... 88
Table B.2.4 – Vibration Data Summary (Anomaly Report: Stage 4 Discharge Bottle Wedges Braced) .................. 89
Table B.2.5 – Vibration Data Summary (Anomaly Report: Night Operation, no Side Stream) .............................. 90
Table B.2.6 – Vibration Data Summary (Anomaly Report: Night Operation, with Side Stream) ........................... 92
Table B.4.1 – Torsional Data Summary (Anomaly Report)................................................................................... 94
Table B.5.1 – Impact Response Plot Index .......................................................................................................... 95
Table D.1.1 – Typical Orifice Plate Thickness .................................................................................................... 279
BETA Machinery performed a field vibration analysis on compressor U-150.2.5 at the Agiba gas plant in Egypt on
May 28 – June 5, 2016. High vibrations and failures of the stage 4 suction and discharge bottles were previously
reported. Additionally, three couplings have failed during operation on this, and second nominally identical
compressor package installed at site.
The unit was tested through an operating speed range of 800 – 1000 rpm and vibration and pulsation data was
collected. Additionally, torsional vibration data was collected for the compressor package at compressor
auxiliary pump end for various operating scenarios including compressor cold and warm startup, compressor
unloaded speed sweep, compressor loaded speed sweep, and normal and ESD compressor shutdown.
Vibrations in many areas, including at components away from the compressor such as scrubbers and piping
were found to exceed guideline as discussed in the report. Detailed measurements and troubleshooting has
shown high skid vibrations in the vertical direction are present on the main and on the secondary scrubber skids.
Various concerns including inadequate foundation installation, flexible support design, and pulsations exceeding
guideline on stage 4 discharge were identified and details are provided in this report. Recommendations such as
improvement of existing supports, installation of gussets and braces are made in this report; however it is
paramount that the main compressor and the secondary scrubber skids be a solid part of the foundation system
and are well connected to the concrete foundation through a good epoxy grout layer. If proper foundation and
adequate connection between skid beams and the foundation cannot be achieved, the addition of the bracing
and gussets as recommended will not be sufficient to ensure long-term reliability.
Torsional measurements were found to similar to values predicted during the torsional vibrational analysis
completed under BETA Ref. # 208643. The primary concern from the torsional perspective is the long startup
time when the engine and compressor are cold due to ambient temperatures. The slow ramp up rate results in
high torsional vibration as the compressor passes through the first torsional natural frequency. The slow ram up
is believed to be a result of the following operating concerns:
1. Engine has not been equipped with heater. Ambient temperatures below 10°C have significant impact
on engine startup and ramp up.
2. Fuel gas quality: Fuel gas has been noted to be saturated resulting in condensation collection during
startup and operation.
3. Loaded startup: Compressor is currently starting up with an initial load of 40-50%. Startup at loads
exceeding 30% is not recommended by engine manufacturer. And typically torsionally soft couplings
require an unloaded start to ensure reliability.
Measurement Method
Unless specified otherwise, BETA uses the following measurement methods as required:
Vibrations are measured using magnet-mounted Integral Electronic Piezo-Electric (IEPE) velometers.
Pulsations are measured using IEPE pressure sensors.
Shaft speed / position is measured using a photo-optical sensor aimed at the rotating shaft.
Impact force used in response tests is measured using an instrumented hammer.
Torsional vibration is measured using a through bore encoder connected to auxiliary pump connection.
All signals are fed to a PC-based data acquisition and analysis system for display and storage.
2 Physical Layout
Legend:
Guideline Type Likely Causes
C – cylinder CF – component failure
E – frame (engine) CM – cylinder motion
F – frame (compressor) FM – unbalanced forces & moments
M – motor MA – misalignment
P – piping MR – mechanical resonance
S – skid, foundation PA – pulsation & acoustic resonance
PS – pipe strain
TR – torque reaction
WS – weak or loose support
The following Recommendation Punch List provides an overview of the recommendations made in the report.
Review all sections to ensure the recommendations are implemented as intended and to ensure all detailed
notes are followed.
Check vibrations of the stage 4 suction and discharge bottles after recommendations in section 4.3 and
4.10 have been implemented. Implement the following if required:
o Ensure all recommended orifice plates are installed as recommended by BETA Report Ref. #
208642, in particular stage 4 discharge bottle outlet orifice not visible during site visit
o Install missing stage 4 suction bottle inlet riser brace as recommended in BETA Report Ref. #
4.11
208642, ensure skid beam below brace foot is appropriately gusseted
o Move existing support brace to the location recommended in BETA Report Ref. # 208642, ensure
skid outrigger below brace foot is appropriately gusseted
o Install suction bottle knee brace for the stage 4 suction bottle
o Install a support post and appropriate brace at the stage 4 discharge bottle outlet elbow
Check vibrations of the stage 3 suction bottle, suction inlet riser, and discharge bottle outlet spool after
recommendations in section 4.3 and 4.10 have been implemented. Implement the following if
required:
4.12
o Install outrigger beam gussets and support post knee braces as recommended
o Install a support post and appropriate brace at the stage 3 discharge bottle outlet elbow
o Install an additional brace in the horizontal-axial direction on stage 3 suction inlet riser
4.13 Install a brace in the axial direction for the stage 1 bypass spool
Install second wedge support as recommended in BETA Report Ref. # 208642 to ensure adequate
support is provided for stage 3 and stage 4 secondary suction bottles
Replace existing bottle band clamp with a double bolt band clamp design connected directly to beam
4.14 sleeper below secondary suction bottles
Install additional gussets in the beam sleepers installed below the secondary suction bottle
Adjust the band clamp installed on stage 3 secondary suction bottle to ensure it is installed in vertical
direction
Install the missing stage 1 and stage 2 discharge bottle overhung end band clamps
4.15 Monitor vibrations at locations where supports were not installed as recommended in BETA Report Ref.
# 208642
Recommendation
Vibrations exceeding guideline by over 100% were observed throughout the unit operating speed range of 800 –
1000 rpm at various test points as shown in the speed to avoid charts in Figure 4.1.1 to Figure 4.1.4. Due to high
vibrations observed, it is recommended the unit is not operated until recommendations are implemented and
vibrations have been checked throughout the operating speed range. In order to allow for unit operation, the
recommendations made in report sections 4.2 and 4.3 will allow for operation at the lower speed range of 800 –
820 rpm. Additional speed range may be introduced as additional recommendations are implemented. Check
vibrations throughout the speed range to confirm acceptable levels after modifications have been completed.
Analysis
The Vibration vs Speed chart below displays the test points where the “as-found” vibration levels were
significantly over guideline and the speeds at which they exceeded 100%, 150%, and 200% of guideline. For any
desired operating speed, vibrations that are over 150% (orange or red) should be reduced to an acceptable level
for all appropriate test points before operating continuously at that speed. Vibrations are displayed in
descending order of severity from left to right. Green zones are considered safe for continuous operation.
Vibration vs Speed
Grey vib > 100% guideline, Orange vib > 150% guideline, Red vib > 200% guideline
Figure 4.1.1 – Summary of Speeds to Avoid (Day Test without Side Stream)
Grey vib > 100% guideline, Orange vib > 150% guideline, Red vib > 200% guideline
Figure 4.1.2 – Summary of Speeds to Avoid (Day Test with Side Stream)
Grey vib > 100% guideline, Orange vib > 150% guideline, Red vib > 200% guideline
Figure 4.1.3 – Summary of Speeds to Avoid (Night Test without Side Stream)
Grey vib > 100% guideline, Orange vib > 150% guideline, Red vib > 200% guideline
Figure 4.1.4 – Summary of Speeds to Avoid (Night Test with Side Stream)
Recommendation
Implement the following recommendations for the cooler inlet and outlet pipe spools.
1. Install new horizontal support structure extending from existing cooler legs. Use a minimum 6” wide
flange beam and install braces in the horizontal direction as shown in Figure 4.2.1. Optional vertical
braces may be installed to support the newly installed horizontal beam. Ensure gussets are installed at
all pipe spool center lines (see Figure 4.2.8 for typical gusset placement for pipe sleepers). Do not use
short support legs/posts to attach pipes to support beam, attach pipes directly support beam. Ensure
pipe spools are adequately shimmed and CL-1 type flat bar clamps are used for all pipe spools. If
required, tack-weld thick, solid steel plate (packer) to shim gaps larger than 1/4".
2. Install a support post in the axial direction for stage 2 and stage 3 cooler inlet spool from support
structure recommended in #1 above. Install a brace in the horizontal direction to maximize support
stiffness. Ensure pipe spools are adequately shimmed and CL-1 type flat bar clamps are used for all pipe
spools. If required, tack-weld thick, solid steel plate (packer) to shim gaps larger than 1/4".
3. Install a concrete pile directly below existing stage 1 discharge cooler outlet pipe spool. Install a wide
flange beam support sleeper with appropriate gussets. Support pipe as close to elbow as possible and
ensure pipe is properly shimmed and attached using a CL-1 type flat bar clamp as shown in Figure 4.2.8.
See Figure 4.2.3 for support location and additional details.
4. Install minimum four (minimum 1/2" diameter) anchor bolts into existing concrete pile to ensure proper
connection at the existing support location. Use a bed of epoxy grout to ensure proper bond between
steel plate and support sleeper. Additionally, install a minimum of two gussets in each wide flange beam
sleeper directly below pipe spool. Ensure gusset thickness is minimum 1/4" or equal to thickness of the
beam web, whichever is greater. See Figure 4.2.4 for gusset placement additional information.
5. Replace all existing supports (some of which are shown in Figure 4.2.5) at the cooler inlet and outlet
risers with support posts of adequate support stiffness. Use a bed of epoxy grout with adequate number
of 1/2” adhesive anchor bolts to ensure adequate bond between wide flange beam sleeper the
foundation. If support posts are welded to an existing wide flange beam as shown in Figure 4.2.5, ensure
gussets are installed at each support post. Ensure gusset thickness is greater of the beam web thickness
or 1/4” thick. Refer to BETA Standard PS-1 (shown in Figure 4.2.7) for typical support post design.
Alternative to individual support posts: Install a new concrete support pile directly in place of existing
flexible beam. Ensure new pile is properly attached to existing foundation. Install a wide flange beam on
a full bed of epoxy grout and adhesive anchor bolts are used to ensure all gaps are filled and beam is
properly bonded to concrete pile. Install gussets (minimum thickness equal or greater of the beam web
thickness or 1/4") below all pipes being supported (as recommended in BETA Standard CL-1 shown in
Figure 4.2.8). Use CL-1 type clamps as shown in Figure 4.2.8 to attach pipe spool to gusseted beam
sleeper. See Figure 4.2.6 for additional details.
6. Replace existing process pipe clamps and U-bolts with a CL-1 type flat bar clamp as shown in Figure
4.2.8. The use of U-bolts is not recommended in vibratory service due to their limited stiffness and their
tendency to come loose and/or wear into the pipe.
Check vibrations throughout the speed range after these recommendations have been implemented to ensure
vibrations have been reduced to acceptable levels.
Figure 4.2.1 – Cooler Inlet and Outlet Pipe Spool Support Structure
Plan View
Figure 4.2.2 – Stage 2 and Stage 3 Cooler Inlet Pipe Spool Support Posts
Figure 4.2.3 – Stage 1 Discharge Cooler Outlet Pipe Spool Missing Support
Figure 4.2.4 – Stage 1 Discharge Cooler Outlet Spool (Near TP# 200)
Figure 4.2.5 – Cooler Inlet and Outlet Pipe Spool Support Recommendations
Use CL-1 type flat bar clamp (as shown in Figure 4.2.8) for all
process piping support locations. U-bolts are not recommended
for use in vibratory service due to their limited dynamic stiffness,
and their tendency to come loose and wear into the pipe.
Existing pipe
Figure 4.2.6 – Alternative Cooler Pipe Spool Concrete Pile Support Recommendations
Analysis
High cooler inlet and outlet spool vibrations were measured as summarized in Table 4.2.1 below. High vibrations
were observed primarily at low frequencies, coincident with the 1x and 2x compressor run speed. Vibrations at
low frequencies are typical of inadequate support stiffness at existing support locations, or insufficient number
of supports installed. Some details of visual inspection of supports near the cooler and samples of deficiencies
are shown in Figure 4.2.9 to Figure 4.2.12.
Table 4.2.1 – Vibration Observation Summary (Cooler Inlet and Outlet Spool Vibrations)
Test Point Dir’n Amplitude Frequency Speed Order % of MNF
(in/s pk) (Hz) (rpm) Guideline (Hz)
Day: 200 a 1.73 13.4 800 1 409 -
Day: 200 h 1.22 13.4 820 1 288 -
Day: 270 h 1.86 30.6 920 2 193 32.8
Day: 360 h 1.95 26.6 800 2 233 26.3
Day: 390 a 4.10 41.9 840 3 410 42.8
Day: 470 a 1.49 16.9 1000 1 281 17.5
Day: 470 a 1.71 33.4 1000 2 171 -
Day: 490 h 3.70 31.9 960 2 370 32.2
Figure 4.2.12 – Existing Cooler Inlet and Outlet Pipe Spool Brace Beam
Recommendation
Implement the following recommendations for the skid foundation and the skid outriggers:
1. Check and repair existing grout and concrete foundation to ensure proper bond between the concrete,
grout pad, and the skid and beam outriggers is achieved. This is in particular important for the
foundation below the scrubbers, engine, and skid outriggers where high vertical skid vibrations were
measured. See report section 4.4 for additional details related to recommendations made for scrubbers.
2. Ensure all outriggers on stage 3 and stage 4 side of the compressor (shown in Figure 4.3.3) have been
properly shimmed against the skid and all bolts have been properly tightened to eliminate all gaps.
3. Ensure epoxy grout is used to provide adequate bond between the skid and the existing concrete
foundation. Ensure thermal expansion joints are used during grout installation to ensure the difference
in thermal expansion between skid and concrete is appropriately handled and to ensure skid and grout
do not become detached due to the ambient temperature changes at the site.
Analysis
High vibrations were measured on the compressor skid near the engine pedestal, at the skid outriggers, and on
the secondary skid at the suction scrubbers as summarized in Table 4.3.1. Particular areas of concern are the
stage 3 and stage 4 skid outriggers with pipe spools installed where the concrete and grout condition is visibly a
concern. Visual inspection and hand checks of stage 4 outriggers indicate relative vibration between existing
wide flange beam outrigger and the grout, as well as relative vibration between the concrete foundation and
grout pad. Detailed measurements of the grout and foundation vibrations could not be collected due to lack of
ability to attach transducers to concrete/grout as no epoxy was available at site to affix transducers to concrete.
Similar trend appears to be present on other outriggers on stage 3 and stage 4 side of this and the other
compressor installed at this site. Some examples of the detached grout are shown in Figure 4.3.1 and Figure
4.3.2. Visual inspection of the grout also indicates that no thermal expansion joints were used during the original
grout installation. Thermal expansion joints are typically installed in attempt to control and minimize the
potential of skid detachment from concrete foundation due to differential in thermal growth of the concrete,
grout, and the skid beams.
Additional skid vibration measurements were collected on the secondary skid at the suction scrubbers as a part
of troubleshooting. These measurements indicate vibrations at the scrubbers exceed the BETA skid guideline by
up to 120%. These measurements are graphically represented in the scrubber vibration analysis section of this
report and shown in Figure 4.4.6. While no measurements could be collected inside the compressor or
secondary scrubber skid to confirm proper bond between skid beams and foundation, vibrations exceeding
guideline around the engine pedestal, wedge supports, and vertical vibrations of the skid around the scrubbers
indicate lack of contact or proper bond between the skid and the foundation.
Finally, a few of the outriggers installed were observed to have a gap (missing shims) between the skid beam
bracket and the outrigger bolt bracket as shown in Figure 4.3.3. The observed gap in addition to flexible skid
bracket attachment and poor foundation support provide inadequate stiffness at the skid outriggers and any
supports attached.
Table 4.3.1 – Vibration Observation Summary (Compressor and Secondary Skid Vibration)
Test Point Dir’n Amplitude Frequency Speed Order % of
(in/s pk) (Hz) (rpm) Guideline
414 Outrigger v 0.98 182.8 1000 11 975
414 Outrigger -a 0.77 70.3 840 5 766
414 Outrigger -a 0.51 133.4 1000 8 510
Skid Edge Back Right Frame -a 0.19 175.9 800 13 192
Skid at Engine Ped. Front Left v 0.16 31.9 940 2 160
Skid at Engine Ped. Front Right v 0.16 30.9 920 2 158
4D Right Wedge Skid L v 0.23 81.6 980 5 234
4D Left Wedge Skid R v 0.20 61.3 920 4 199
4D Right Wedge Skid R v 0.16 61.3 920 4 162
4D Right Wedge Skid R v 0.16 33.4 1000 2 157
Stage 3 Scr. Skid Back v 0.22 31.6 940 2 220
Stage 3 Scr. Skid Front v 0.22 31.6 940 2 220
Stage 3 Scr. Skid Back Right v 0.16 31.6 940 2 160
Stage 3 Scr. Skid Back Right 2 v 0.12 31.6 940 2 117
Stage 3 Scr. Skid Back Left v 0.12 31.6 940 2 117
Stage 3 Scr. Skid Front Left v 0.20 31.6 940 2 197
Stage 3 Scr. Skid Front Right v 0.19 31.6 940 2 193
Stage 3 Scr. Skid Front Right 2 v 0.17 31.6 940 2 170
Stage 4 Scr. Skid Back v 0.18 28.1 840 2 184
Stage 4 Scr. Skid Back Right v 0.12 28.1 840 2 121
Vibration measurements close to or exceeding the BETA skid vibration guideline for test points located on the
main skid are displayed in Figure 4.3.4.
0.10
0.16
0.09
0.16 – 0.23
0.16
0.20
0.11
Figure 4.3.4 – Skid Vibrations Measured Near Engine and Compressor Pedestal
A fine crack was observed on the concrete on the back side of the secondary (scrubber) skid at the skid beam
flange connection as shown in Figure 4.3.5. Additionally, concrete condition appears to be atypical of proper,
homogeneous mix typically visible.
4.4 Stage 2, 3, and 4 Suction Scrubber Recommendations (TP# 210, 300, and 400)
Recommendation
Check and repair existing foundation and grout installation below secondary scrubber skid to ensure all skid
beams are properly bonded to foundation using epoxy grout. Additional areas of concern were identified and
recommendations were made in report section 4.3 due to visible grout/concrete foundation separation near the
skid outriggers.
Check scrubber vibrations throughout the operating speed range and implement the following
recommendations for the suction scrubbers if the foundation and grout repair was not effective in reducing
vibrations to acceptable levels.
1. Stage 2 suction scrubber:
a. Install a 6” x 6” x 1/2” (or equivalent metric size) HSS (hollow square section) brace between
stage 2 and stage 1 suction scrubbers as shown in Figure 4.4.1 to increase the scrubber
mechanical natural frequency above 2.4x compressor run speed. Install brace to scrubbers using
a band clamp type of connection on each scrubber. Install the scrubber-to-scrubber brace
directly below the top head seam and ensure it is positioned horizontally for maximum
effectiveness. A typical scrubber-to-scrubber brace design is presented in BETA Standard SC-6 as
shown in Figure 4.4.4.
2. Stage 3 suction scrubber:
a. Install scrubber skirt gussets in the axial direction as originally recommended in BETA Pulsation
Report Ref. # 208642. Ensure skirt gussets are of full height, minimum 1/2” thick, and extend to
the edge of the scrubber skid beam below. Ensure gussets extend to the bottom of skid beams
to ensure adequate stiffness is added in the axial direction.
3. Stage 4 suction scrubber:
a. Install scrubber skirt gussets in the axial and horizontal direction as originally recommended in
BETA Pulsation Report Ref. # 208642. Ensure skirt gussets are of full height, minimum 3/4” thick,
and extend to the edge of the scrubber skid beams below. Ensure gussets extend to the bottom
of skid beams to ensure adequate stiffness is added in the axial direction.
Check vibrations on all suction scrubbers in both (horizontal and axial) directions after recommendations are
implemented to confirm the resulting scrubber vibrations are reduced to acceptable levels. Additional
recommendations to increase the scrubber mechanical natural frequencies can be provided if found to be
required after the above recommendations have been properly implemented.
Figure 4.4.4 – BETA Standard SC-6 – Scrubber Brace with Band Connection
Analysis
Visual inspection of the suction scrubbers shows that the following gussets were missed during compressor
package construction and are a contributing factor to high stage 3 and stage 4 scrubber vibrations due to
scrubber mechanical natural frequency (MNF) coincidence with 2x compressor run speed:
Stage 1 Scrubber: Two gussets were not installed in the horizontal direction. Scrubber vibrations were
found to be approximately 60% of guideline.
Stage 3 Scrubber: Two gussets were not installed in the axial direction, matching the high scrubber
vibration direction.
Stage 4 Scrubber: Four gussets were not installed during construction, two in the horizontal and two in
the axial direction. Missing gussets in the axial direction match the high scrubber vibration direction.
Stage 2 suction scrubber vibrations were found to exceed guideline in the horizontal direction as summarized in
Table 4.4.1. Additional measurements were collected on the scrubber and several test points on the skid beams
around the suction scrubber. The measurements collected were found to exceed the BETA skid vibration
guideline of 0.1 in/s pk in a few areas as shown in green color in Figure 4.4.6.
Stage 3 suction scrubber vibrations were found to exceed guideline in the axial direction as summarized in Table
4.4.2. Additional measurements were collected on the scrubber and several test points on the skid beams
around the suction scrubber. Scrubber ODS vibration data for the stage 3 suction scrubber is shown in Figure
4.4.5 for test points along the scrubber height and directly next to the scrubber skirt on the skid. The
measurements collected were found to exceed the BETA skid vibration guideline of 0.1 in/s pk in a few areas as
shown in red color in Figure 4.4.6.
Figure 4.4.5 – Stage 3 Suction Scrubber ODS Plot of Scrubber and Skid Vibration at Skirt
Stage 4 suction scrubber vibrations were found to exceed guideline in the axial direction as summarized in Table
4.4.3. Additional measurements were collected on the scrubber and several test points on the skid beams
around the suction scrubber. The measurements collected were found to exceed the BETA skid vibration
guideline of 0.1 in/s pk in a few areas as shown in blue color in Figure 4.4.6.
The vertical vibrations of the skid as measured at the top of the skid beams were found to exceed the BETA skid
guideline by up to 120% in some areas. This is a strong indication of a poor bond and/or gaps between the
scrubber skid beams and the concrete foundation below. A deck plate installed on the skid prevented additional
measurements to be collected and could not be removed at the time of the site visit to collect additional
measurements at the bottom flange of the skid beams.
0.05 0.03
0.12 0.09
0.08
0.16 0.22 0.18
0.12
0.12
0.20
0.19
0.22 0.07
0.17 0.07
0.07
0.07
0.03
Figure 4.4.6 – Scrubber Skid Vibrations (Values shown in/s pk during ODS Measurement at Fixed Speed)
4.5 Stage 2 Scrubber Liquid Level Gauge Support Design (TP# 210 Sight Glass)
Recommendation
Implement the following recommendations in the order they are presented below. Check scrubber liquid level
gauge vibrations throughout the operating speed range after completing each step to determine if the
remaining recommendations are required.
1. Check the scrubber liquid gauge for misaligned fitment during installation to ensure no pipe strain is
introduced due to improper installation. See report section D.2 for additional information related to
pipe strain due to misalignment.
2. Install existing level gauge on support post placed next to the scrubber as shown in Figure 4.5.1 Option 3
and use flexible braided hose to connect the level gauge to scrubber. Ensure support post is a minimum
4” x 4” wide flange beam, or equivalent HSS (hollow structural section) tubing welded directly to a skid
beam. Do not weld support post to skid deck plate.
Figure 4.5.1 – BETA Standard SA-8 – Small Bore Level Gauge Support Design
Analysis
Stage 2 suction scrubber liquid level gauge vibrations were found to exceed guideline as summarized in Table
4.5.1. An impact test was completed and level gauge mechanical natural frequency (MNF) was found to be
coincident with 6x compressor run speed. Additional vibration amplification due to pipe strain introduced by
misalignment of connections at the time of installation may be present.
Table 4.5.1 – Vibration Observation Summary (TP# 210 Sight Glass – Stage 2 Scrubber Liquid Level Gauge)
Test Point Dir’n Amplitude Frequency Speed Order % of MNF
(in/s pk) (Hz) (rpm) Guideline (Hz)
Day: 210 Sight Glass tan 3.30 96.9 960 6 330 97.8
Night: 210 Sight Glass tan 1.79 96.9 820 7 179 97.8
Night SS: 210 Sight Glass tan 1.78 97.5 840 7 178 97.8
Recommendation
Implement the following recommendations for existing support posts and pipe clamp locations after the
concrete and grout foundation has been repaired as recommended in report section 4.3 above:
1. Install gussets at the six existing support post locations shown in Figure 4.6.1 (shown in green) to
increase the support sleeper stiffness in the axial direction. Ensure gusset thickness is greater of the
outrigger beam web thickness or 1/4”. See Figure 4.2.7 for additional best practice recommendations
related to support post design.
2. Install four support post braces in the horizontal direction for the support posts shown in Figure 4.6.1
and Figure 4.6.2 to provide adequate support stiffness in the horizontal direction.
3. Install a minimum 3” HSS (hollow square section) (or equivalent) support post as close to elbow as
possible and install a brace in the horizontal direction. Use a bed of epoxy grout and adhesive anchor
bolts to ensure proper bond between support post, brace and the concrete foundation. Use four,
minimum 1/2” anchor bolts for the support foot and brace. Use CL-1 type flat bar clamp at the support
post. See Figure 4.2.7 and Figure 4.2.8 for typical support post and additional details on the CL-1 type
flat bar clamp.
4. Ensure all existing pipe support clamps are checked for proper alignment while the compressor is at
operating temperature. Ensure pipe clamps are loosened, properly shimmed, and retightened at normal
operating temperature to ensure no pipe strain is introduced into the system during operation.
Note: The compressor package is installed in a location where ambient and operating temperatures vary
significantly. The resulting temperature difference may result in significant thermal expansion, in
particular for long spans between the discharge bottles and the coolers and result in high nozzle loads at
the bottles and coolers. A thermal (pipe stress) analysis may be beneficial to ensure vessel and cooler
nozzle stresses are acceptable.
Install a support post 3” HSS or equivalent directly to concrete foundation. Use a bed
of epoxy grout and attach to concrete using four, minimum 1/2” anchor bolts to
ensure proper bond. Install a brace to concrete in the horizontal direction.
Table 4.6.1 – Vibration Observation Summary (Stage 4 Discharge Spool Downstream of Discharge Bottle)
Test Point Dir’n Amplitude Frequency Speed Order % of MNF
(in/s pk) (Hz) (rpm) Guideline (Hz)
Day: 408 h 1.52 85.3 860 6 152 86.56
Day: 436 (Braced) h 2.31 133.4 1000 8 231 125.9
Day: 436 (Braced) v 2.15 115.0 860 8 215 -
Day: 436 (Braced) h 1.72 152.2 840 11 172 156.6
Day: 436 (Braced) h 1.55 165.3 900 11 155 156.6
Night: 436 h 3.30 132.5 1000 8 330 125.9
Night: 436 h 2.06 170.0 940 11 206 -
Night: 436 h 1.76 133.4 800 10 176 125.9
Night SS: 436 h 3.43 174.1 940 11 343 -
Night SS: 436 h 2.90 132.5 980 8 290 125.9
Night SS: 436 a 2.33 66.9 1000 4 233 -
Night SS: 436 v 1.96 118.4 880 8 196 -
Night SS: 436 a 1.54 118.4 880 8 154 -
Day: 437 h 4.51 46.9 920 3 451 51.6
Day: 438 h 2.28 75.9 920 5 228 73.8
Day: 237 v 2.62 76.9 920 5 262 78.1
Figure 4.6.3 – Support Post and Inadequate Shimming (First Support Downstream of TP# 436)
Figure 4.6.4 – Stage2 Support Post and Skid Outrigger (First Support Downstream of TP# 237)
Stage 4 discharge bottle outlet flanges were separated during one of the shutdowns and a flange misalignment
was confirmed at the bottle outlet flange sets in parallel, horizontal and vertical directions. Photos of the
horizontal and parallel misalignments are shown in Figure 4.6.5.
4.7 Correct Stage 1 and Stage 2 Scrubber Outlet Spool Flange Misalignment
Recommendation
Check and correct existing flange misalignment at all flanged connections between the stage 1 and stage 2
suction scrubbers and suction bottles. While the flange misalignment was most noticeable on pipe spools
between the scrubbers and suction bottles, it is recommended all flanged connections are checked for
misalignment. Check vibrations of the stage 2 scrubber outlet spool after all flange alignment has been
corrected to ensure vibrations are reduced to acceptable levels. Additional recommendations may be provided if
the above was not effective in reducing vibrations to acceptable levels.
Analysis
Vibrations of the stage 2 scrubber outlet spool were found to exceed guideline as summarized in Table 4.7.1. An
impact test was completed and found the measured vibration is coincident with the pipe spool’s mechanical
natural frequency (MNF). Flange misalignment was also observed on at least three flanged connections between
the stage 1 and stage 2 suction scrubbers and suction bottles. Flange misalignment typically results in
introduction of pipe strain and therefore in amplifications of vibrations. See appendix D.2 and D.3 for additional
details on pipe strain and allowable misalignments at the flanged connections.
Table 4.7.1 – Vibration Observation Summary (Stage 2 Scrubber Outlet Pipe Spool)
Test Point Dir’n Amplitude Frequency Speed Order % of MNF
(in/s pk) (Hz) (rpm) Guideline (Hz)
Day: 212 h 2.42 89.7 900 6 242 91. 6
Night: 212 h 2.84 90.3 900 6 284 91. 6
Recommendation
Implement recommendations in report section 4.4 and check resulting vibrations at the stage 4 scrubber outlet
spool throughout the operating speed range.
The following recommendations may be implemented in the order in which they are presented if the above
recommendation was not effective at reducing vibrations to acceptable levels:
1. Check for proper support installation at the brace installed back to the scrubber (shown in Figure 4.8.1).
Ensure pipe clamp is installed while pipe is in its neutral position and no pipe strain is introduced. Ensure
the pipe is properly shimmed and clamped while compressor is at its operating temperature.
2. Install a double band clamp support of the elevated scrubber outlet spool mid-way between the existing
post and the top of the scrubber outlet spool (near TP# 399 as shown in Figure 4.8.3). See Figure 4.8.2
for a sketch of a typical double band clamp pipe support.
Analysis
Vibrations exceeding guideline were measured in the axial direction on the stage 4 suction scrubber outlet pipe
spool. Vibrations exceeding guideline were measured at three separate frequencies. The vibrations at 29 Hz (2x
compressor run speed) are due to scrubber axial vibration, while vibrations measured at 80 – 86 Hz are
coincident with the pipe spool mechanical natural frequency as determined using the impact test. A summary of
vibrations measured is provided in Table 4.8.1.
TP# 400
TP# 399
4.9 Stage 2, 3, and 4 Discharge PSV (TP# 250, 350, and 450)
Recommendation
Check all PSV connections (upstream and downstream) for proper alignment at the flanged and threaded
connections to ensure no pipe strain is introduced during installation. See report section D.2 for additional
information related to pipe strain.
Implement the following recommendations for the stage 2 and stage 4 PSVs to reduce the source of high
vibrations due to base excitation and therefore the high relative vibration between the main pipe spool and the
top of the PSV:
1. Install a support post at the stage 2 and stage 4 PSV to minimize the PSV base excitation and increase
the pipe spool and PSV mechanical natural frequency. Ensure the newly installed support post provides
adequate dynamic stiffness in the horizontal direction by installing gussets or short knee-brace in the
horizontal direction as shown in Figure 4.9.1. Use CL-1 and FS-1 type clamps or flanged support
connections. Ensure pipe spool is properly shimmed when clamp is installed. The support posts
recommended will also be effective to control motion in the axial direction, reducing the potential for
internal component failure due to high acceleration measured.
Implement the following recommendation for stage 3 PSV to minimize the chance of failure of the PSV internal
components due to high acceleration. This recommendation is provided as best practice in attempt to reduce
the potential of internal failure and therefore does not have to be implemented if the PSV manufacturer deems
the acceleration to be acceptable.
1. Install a post support as close to PSV as possible and ensure the support post provides adequate support
stiffness in the horizontal and axial direction. Support posts similar to those shown for stage 2 and stage
4 PSV may also be used to control vibrations in the axial direction.
Figure 4.9.1 – Stage 2 and Stage 4 Discharge PSV Recommended Support Post
Figure 4.9.2 – BETA Standard PS-2 – Multiple Stacked Pipe Support Post Design
Analysis
High PSV vibrations were measured for stage 2, stage 3, and stage 4 PSVs as summarized in Table 4.9.1.
Table 4.9.1 – Vibration Observation Summary (Stage 2, 3, and 4 PSVs – Velocity Guideline)
Test Point Dir’n Amplitude Frequency Speed Order % of MNF
(in/s pk) (Hz) (rpm) Guideline (Hz)
Day: 250 PSV h 3.25 59.7 900 4 325 60.0
Day: 250 PSV a 2.33 59.7 880 4 233 -
Day: 350 PSV h 1.59 176.6 820 13 159 179.4
Day: 350 PSV h 2.94 180.0 980 11 294 179.4
Day: 350 PSV -a 1.70 176.3 960 11 170 175.3
Day: 450 PSV h 2.11 75.0 900 5 211 75.0
Day: 450 PSV a 1.71 71.6 860 5 171 74.1
The ODS data collected indicates only stage 2 and stage 4 PSVs have relative vibrations exceeding 1 in/s pk in the
horizontal direction that may potentially lead to failure due to bending. Internal components of the PSV are
more likely to fail when vibrations exceed an absolute value of 2 g’s pk. The vibration data was converted and is
reported in g’s pk in Table 4.9.2 for all PSVs exceeding the allowable acceleration guideline.
Table 4.9.2 – Vibration Observation Summary (Stage 2, 3, and 4 PSVs – Acceleration Guideline)
Test Point Dir’n Amplitude Frequency Speed Order % of
(g pk) (Hz) (rpm) Guideline
Day: 250 PSV h 3.15 59.7 900 4 158
Day: 250 PSV a 2.26 59.7 880 4 113
Day: 350 PSV h 5.66 176.6 820 13 283
Day: 350 PSV h 8.60 180.0 980 11 430
Day: 350 PSV -a 4.87 176.3 960 11 244
Day: 450 PSV h 2.58 75.0 900 5 129
Operating deflection shape (ODS) vibration data was collected for the stage 2 PSV in the axial and horizontal
direction (TP# 250) at the problem speeds/frequencies and the respective ODS plots are shown in Figure 4.9.4. A
relative vibration between the PSV base and the top of the PSV is estimated to be less than 1 in/s pk in the axial
direction. Relative vibrations in the horizontal direction as well as the acceleration in the horizontal and axial
direction measured for stage 2 PSV were found to exceed the recommended guideline.
Operating deflection shape (ODS) vibration data was collected for the stage 3 PSV in the axial and horizontal
direction (TP# 350) at the problem speeds/frequencies and the respective ODS plots are shown in Figure 4.9.5. A
relative vibration between the PSV base and the top of the PSV is estimated to be less than 1 in/s pk in the
horizontal and the axial direction. The acceleration in the horizontal and axial direction measured for stage 3
PSV were found to exceed the recommended guideline.
Operating deflection shape (ODS) vibration data was collected for the stage 4 PSV in the axial and horizontal
direction (TP# 450) at the problem speeds/frequencies and the respective ODS plots are shown in Figure 4.9.6. A
relative vibration between the PSV base and the top of the PSV is estimated to be less than 1 in/s pk in the axial
direction. Relative vibrations in the horizontal direction as well as the acceleration in the horizontal and axial
direction measured for stage 4 PSV were found to exceed the recommended guideline.
Recommendation
Implement the following recommendations for stage 3 and stage 4 discharge bottle wedge supports and the
cylinder inboard support after the grout and foundation has been repaired as recommended in report section
4.3 above. The following recommendations may be implemented in the order in which they are presented.
Check vibrations throughout the operating speed range after each step is completed to determine if the
remaining recommendations are required.
1. Improve the skid and wedge support design:
a. Install full depth skid beam gussets directly below each wedge support post. Ensure gusset is
minimum 1/2” thick and extends to at least edge of existing skid beam. Triangular extension of
gusset to the edge of wedge support gussets is strongly recommended to increase stiffness at
the wedge support gusset edge. See gussets shown in red in Figure 4.10.1.
b. Install wedge support gussets as shown green in Figure 4.10.1. Gussets can be built using a T-
section beam, cutaway I beam, or two solid plates welded together perpendicularly as shown.
Ensure minimum gusset thickness of 1/2”. Wedge support gussets should be fully welded to
existing wedge support post, top plate of wedge support, and the existing skid beam and deck
plate. It is strongly recommended the skid gussets recommended in part a) extend to edge of
wedge support gussets.
2. Ensure all wedge supports are properly adjusted when the compressor package is at its operating
temperature. Proper adjustment technique as well as best practices are discussed in Figure 4.14.2.
Check vibrations on all cylinders after proper cylinder wedge support adjustment to determine if
additional action is required.
3. Increase vertical inboard support stiffness, in particular at the front where high relative vibrations of the
inboard support were measured. Increase in stiffness can be achieved by installation of additional
gussets at the front of the inboard support, area indicated by green arrow in Figure 4.10.2. An alternate
inboard support design may have to be considered to allow for access to cylinder bolts and jack screws
installed in on the inside of the support. While cylinder 1, 2, and 4 were the only cylinders with
vibrations exceeding guideline by more than 50%, it is recommended the updated, stiffer cylinder
inboard support be installed for all cylinders.
Plan View
Deck Plate
Strongly recommended
triangular gusset extension to
wedge support gusset edges Skid Beam
Install full height rectangular skid beam gussets Rectangular, full depth skid
directly below both wedge support posts. If beam gussets.
possible, include a triangular wedge to edge of
wedge support to provide adequate stiffness. Side View
Analysis
High cylinder and discharge bottle vertical and axial vibrations were measured on stage 4 cylinder and discharge
bottle as summarized in Table 4.10.1. While the cylinder axial and vertical vibrations are not coincident with the
cylinder measured mechanical natural frequencies, the vibrations do occur close and may result in some
vibration amplification near the natural frequencies as shown in Figure 4.10.3. Additional measurements
indicated the wedge support ‘ears’ on existing wedge posts were flexible in the vertical direction, and the wedge
support posts were flexible in the axial direction.
Figure 4.10.3 – Cylinder 2 Vertical and Axial Vibrations and Impact Test Overlay Plots
Cylinder 4 vertical vibrations were found to exceed guideline as shown in Table 4.10.2. Vibrations were also
found to exceed guideline marginally on the stage 2 discharge bottle in the horizontal direction due to flexible
wedge support design or improperly adjusted wedge supports at the time of testing. Detailed vibration
measurements at the compressor skid, directly below the wedge supports were not collected during the site
visit due to lack of time, however based on other areas of concern identified, a poor bond between skid beams
and the foundation is possible.
Detailed testing and troubleshooting of the stage 4 cylinder (cylinder 2) showed the existing cylinder inboard
support has high flexibility and results in high relative vibration across the inboard support as shown in Figure
4.10.4. A relative vibration of 0.239 in/s pk was measured across the top and bottom of the inboard support at
the problem frequency of 62.8 Hz, coincident with 4x compressor run speed at 940 rpm. The flexibility observed
is a contributing factor for high cylinder 1 and cylinder 4 vibrations as discussed in the individual report sections.
0.352 in/s pk
0.391 in/s pk
0.152 in/s pk
Vibrations exceeding BETA skid vibration guideline were measured directly below/at the wedge support skid
beams. This is indicative of poor skid beam stiffness or lack of connection between skid beam and the concrete
foundation below. A summary of vibration measurements is included in Table 4.10.3.
Table 4.10.3 – Vibration Observation Summary (Skid Vibration at Stage 4 Wedge Supports)
Test Point Dir’n Amplitude Frequency Speed Order % of
(in/s pk) (Hz) (rpm) Guideline
4D Right Wedge Skid L v 0.23 81.6 980 5 234
4D Left Wedge Skid R v 0.20 61.3 920 4 199
4D Right Wedge Skid R v 0.16 61.3 920 4 162
4D Right Wedge Skid R v 0.16 33.4 1000 2 157
Recommendation
Implement the following recommendations for cylinder 2 and the stage 4 system after the grout and foundation
has been repaired as recommended in report section 4.3 above:
1. Check the following stage 4 discharge locations to ensure appropriate orifice plates are installed and in
good condition:
a. Check the stage 4 discharge cylinder outlet orifice to ensure it is in good shape and the hole
matches the recommended ID of 1.875” as shown in Figure 4.11.1. Refer to pulsation analysis
recommendations and see report appendix D.1 for additional details on recommended orifice
plate thickness.
b. Install the stage 4 discharge bottle outlet orifice as recommended (but not visible at the time of
site visit) in the pulsation analysis under BETA Ref. 208462. Recommended orifice plate location
and size is shown in Figure 4.11.1. Refer to pulsation analysis recommendations and see report
appendix D.1 for additional details on recommended orifice plate thickness.
2. Install the missing suction riser brace back to skid in the horizontal direction as originally recommended
by BETA Report Ref. 208462. Ensure brace is properly gusseted at the skid beam if installed overhanging
the beam centerline. Ensure gusset thickness is greater of the beam web thickness or 1/4”. New
(previously recommended) brace to be installed is shown in Figure 4.11.2.
3. Move the originally recommended stage 4 bottle inlet riser brace to the originally recommended
location according to BETA Report Ref. 208462. Ensure support outrigger beam gussets are installed
directly below brace foot to minimize beam flexibility at the connection. Ensure gusset thickness is
greater of the beam web thickness or 1/4”. See Figure 4.11.2 for recommended brace location.
4. Install suction bottle knee brace for the stage 4 suction bottle as shown in Figure 4.11.3. Use BETA
Standard SB-4 type connection (shown in Figure 4.11.4) on the suction bottle and attach opposite end to
existing distance piece lifting lug connection.
Check vibrations throughout the operating speed range on the associated components after the
recommendations have been implemented to ensure vibrations have been reduced to acceptable levels.
Analysis
A visual inspection showed the recommended support braces for the stage 4 suction bottle inlet riser was not
braced as recommended in BETA Report Ref. 208462. The foot of the upper brace was not installed at the
proper location of the outrigger beam and the recommended gussets at the foot of the brace were not installed
resulting in a flexible connection. Finally, the existing skid outrigger beam is not properly bonded to the grout or
concrete foundation as discussed in report section 4.3 resulting in additional flexibility, and significantly reducing
the effectiveness of the brace installed. In addition to the improperly installed brace, a second brace between
the suction spool and the skid beam recommended by BETA Report Ref. # 208462 was not installed at the time
of site visit.
High vibrations were measured in the horizontal and axial directions at the elevated elbow at TP# 414. Impact
tests completed indicate the vibration is coincident with a number of mechanical natural frequencies of the pipe
spool. A summary of the vibration measurements collected and the results of the impact test are summarized in
Table 4.11.1.
Table 4.11.1 – Vibration Observation Summary (Elevated Stage 4 Suction Elbow TP# 414)
Test Point Dir’n Amplitude Frequency Speed Order % of MNF
(in/s pk) (Hz) (rpm) Guideline (Hz)
Day: 414 h 2.41 43.8 880 3 241 45.0
Day: 414 (Braced Wedge) -a 3.82 60.3 900 4 382 59.7
Night: 414 -a 3.67 58.1 860 4 367 59.7
Night: 414 h 2.07 66.6 1000 4 207 -
Night: 414 h 1.66 44.1 880 3 166 45.0
*1
Night SS: 414 -a 5.00 57.8 880 4 500 59.7
*1
Night SS: 414 h 2.53 66.3 1000 4 253 -
*1
Night SS: 414 h 1.79 47.8 960 3 179 45.0
*1
Night SS: 414 h 1.65 120.6 920 8 165 120.6
*1
– Wedge supports were found to be loose after compressor maintenance was completed
earlier in the day, and wedge supported were not properly retightened.
TP# 414
High vibrations of the stage 4 suction were found to be coincident with the bottle rocking mode at 5x
compressor run speed. Suction bottles installed in the axial direction have an increased chance of the rocking
motion due to cylinder piston motion. Additionally, high cylinder vertical vibrations as discussed in report
section 4.10 above were found to be the source or vertical bottle vibrations at 4x compressor run speed. A
summary of vibration measurements and the stage 4 suction bottle mechanical natural frequencies is included
in Table 4.11.2.
Pulsation measurements were collected on the stage 4 discharge system at TP# 460 near the cooler inlet risers.
Pulsations were found to exceed guideline by up to 180% and are twice the pulsations that were predicted in
the pulsation analysis completed under BETA Ref. # 208642. Orifice plates were recommended to be installed at
the cylinder 2 outlet and the stage 4 discharge bottle outlet flanges. A visual inspection indicated a 1.88” ID
orifice was installed at the cylinder 2 outlet flange, however an orifice plate tag/handle was not visible at the
bottle outlet flange at the time of site visit for the recommended 1.625” ID stage 4 discharge bottle outlet orifice
plate. Sensitivity checks performed by BETA on stage 4 discharge acoustical model indicate that an increase in
pulsation levels associated with missing orifice plates are similar to those measured at the cooler inlet risers.
Recommendation
Implement the recommendations to repair grout and improve the existing wedge support and inboard support
design as discussed in report sections 4.3 and 4.10 respectively. Check vibrations of the cylinder, suction bottle,
suction inlet riser and the discharge spool. Implement the following recommendations if the above were not
effective to reduce vibrations to acceptable levels. Recommendations below may be implemented one step at a
time with a check of resulting vibrations and only installing following recommendations if vibrations have not
been reduced to acceptable levels.
1. Modify existing support locations:
a. Install gussets below existing support posts as shown in Figure 4.12.1 to increase the support
post and outrigger stiffness in the axial direction. Ensure gusset thickness is greater of 1/4” or
outrigger web thickness.
b. Install two support post knee-braces in the horizontal direction to increase the support post
stiffness in the horizontal direction. Alternative to a brace in the horizontal direction, a single
minimum 3/4” thick gusset may be installed to the top of the support post. Ensure gusset is
installed at the support post and outrigger beam centerline.
2. Install a support post and adequate brace as close to the elbow as possible. See BETA Standard support
post design as shown in Figure 4.2.7 and Figure 4.12.2 for recommended support post layout. Attach
foot of the support post and the brace using a bed of epoxy grout and four minimum 1/2” adhesive
anchor bolts to ensure proper bond.
3. Install a brace (4” x 4” x 1/4” HSS beam) on the stage 3 suction inlet riser in the horizontal-axial direction
to raise the pipe spool mechanical natural frequency in both directions. Use a CL-1 type connection at
the pipe and connect the brace foot directly to the top of the skid beam.
Note: This recommendation is made if the modifications to grout and outrigger beams are not effective
in increasing the existing brace dynamic support stiffness.
Analysis
High cylinder 1 and stage 3 suction bottle axial vibrations were measured as summarized in Table 4.12.1. An
impact test was completed and found cylinder 1 and the suction bottle mechanical natural frequencies are
coincident with the vibration and compressor run speed. Additionally, vibrations on the stage 3 discharge spool
at TP# 336 were found to exceed guideline in horizontal and vertical direction. Vibrations were measured at a
number of frequencies including a high frequency of 181 Hz typical of vibration due to pipe strain due to
improper fit-up during installation.
Table 4.12.1 – Vibration Observation Summary (Cylinder 1 and Stage 3 Suction Bottle)
Test Point Dir’n Amplitude Frequency Speed Order % of MNF
(in/s pk) (Hz) (rpm) Guideline (Hz)
Day: Cylinder 1 (After Align) a 1.05 30.9 920 2 155 32.8
Night: Cylinder 1 a 1.08 31.9 960 2 154 32.8
Day: 315 (After Align) a 1.58 30.6 920 2 164 30.9
Day: 336 v 1.84 83.4 1000 5 184 -
Day: 336 (After Align) -h 1.57 180.9 985 11 157 -
Night: 336 v 1.83 81.6 980 5 183 -
Night SS: 336 v 3.41 83.4 1000 5 341 -
Night SS: 336 h 1.88 161.3 880 11 188 -
Night SS: 336 h 1.54 83.4 1000 5 154 -
Vibrations of the stage 3 suction inlet riser were found to exceed guideline as shown in Table 4.12.2. An impact
test completed indicates vibration is due to a coincidence with mechanical natural frequency. Support brace
installed to existing skid outrigger was not properly gusseted at the brace foot and existing support posts.
Table 4.12.2 – Vibration Observation Summary (Stage 3 Suction Inlet Spool TP# 314)
Test Point Dir’n Amplitude Frequency Speed Order % of MNF
(in/s pk) (Hz) (rpm) Guideline (Hz)
Day SS: 314 -h 1.92 60.0 900 4 192 61.6
Day: 314 (After Align) -h 2.04 62.5 920 4 204 61.6
Day: 314 (After Align) a 1.87 30.9 920 2 192 31.9
Night: 314 -h 2.73 61.9 920 4 273 61.6
Night: 314 -a 1.88 31.6 940 2 189 31.9
Night: 314 -a 1.63 61.9 920 4 163 55.9
Night SS: 314 -h 2.03 62.8 940 4 203 61.6
Night SS: 314 -a 1.90 62.8 940 4 190 55.9
Night SS: 314 -a 1.79 31.3 940 2 182 31.9
Visual inspection of the stage 3 discharge bottle indicated the threaded rod was bowed upwards, typical of
wedge support that has been overtightened. Additionally, wedge support ‘ear’ appears to be bent downwards,
potentially due to overtightening or repeated discharge bottle impact while wedge supports were loose.
Recommendation
Check vibrations after the grout and foundation recommendations presented in report section 4.3 above have
been implemented. Install a brace in the axial direction as shown if vibrations exceed guideline after the grout
has been repaired. Ensure brace is a minimum 4” x 4” x 1/4” HSS (hollow square section) beam or equivalent.
Use a CL-1 type flat bar clamp (shown in Figure 4.2.8) at the pipe connection and attach the brace foot directly
to the web of an existing skid beam to ensure maximum stiffness is achieved.
Analysis
Vibrations were found to exceed guideline on the stage 1 suction bypass spool (TP# 105) as summarized in Table
4.13.1. Vibration measured was found to be coincident with the pipe spool mechanical natural frequency.
4.14 Secondary Suction Bottle and Stage 1 and 2 Discharge Bottle Recommendations
Recommendation
Implement the following recommendations (previously made in the pulsation analysis report BETA Ref. #
208642) for both secondary suction bottles to improve the existing bottle supports.
1. Stage 3 and 4 Secondary Suction Bottle: Install minimum two gussets for each of the bottle support
sleepers (total of 4 gussets per secondary suction bottle). Ensure gusset thickness is greater of 1/4” or
the beam web thickness. Place gussets directly below wedge support. See Figure 4.14.2 (circled in red)
for recommended gusset locations for each of the two sleepers.
2. Stage 3 and 4 Secondary Suction Bottle: Install second wedge support at the existing band clamp
location to ensure bottle can be installed in its neutral position. A low profile wedge support similar to
one shown in Figure 4.14.3 may be used if limited room is available due to band clamp installation.
3. Stage 3 and 4 Secondary Suction Bottle: Install second band clamp at the existing wedge support
location to ensure bottle can be installed in its neutral position. Use a dual bolt design band clamp as
shown in Figure 4.14.2 (circled in green) to provide adequate stiffness and eliminate the need for the
flexible bracket currently welded to the beam.
4. Stage 3 Secondary Suction Bottle: Ensure stage 3 secondary suction bottle band clamp is checked and
adjusted such that the band clamp is installed in the vertical direction.
Install second wedge support to ensure Install second band clamp to ensure
bottle can the properly supported in its bottle can the properly supported in
neutral position. its neutral position.
Figure 4.14.1 – Secondary Suction Bottle Recommendations (Typical for Stage 3 and Stage 4)
Analysis
While the vibrations on the stage 3 and stage 4 secondary suction bottles were found within guideline, the
existing wedge support and band clamp is not recommended. A single band clamp with significant offset from
wedge support may introduce bottle twisting and pipe strain if overtightened. Additionally, ensure band clamp
bracket installed on the support sleeper provides adequate clamping stiffness, or the band clamp is attached
directly to the beam sleeper below.
Stage 3 secondary suction bottle band clamp was observed to be installed at an angle, or has moved over time
due to potential thermal expansions.
Figure 4.14.4 – Stage 3 Secondary Suction Bottle (TP# 309 & 310)
4.15 Coupling
Recommendation
Ensure that the engine is supplied clean, dry gas. For startups unload the compressor as much as possible to
limit the load as the speed passes through the resonances.
Install the revised coupling (stiffer, higher rated springs plus extra inertia) as soon as possible. BETA Machinery
Analysis is currently working with the coupling manufacturer to size springs with greater stiffness and a higher
torque rating.
Analysis
The torsional measurements show that the model is a reasonable approximation of the actual system. The
torsional natural frequencies are close to the ranges predicted, and the measured response is also close to
predicted. Based on the measurements, the coupling torques are near the coupling limit, but should not be
exceeded during normal running. However, the response measured during cold starts was much higher (5 – 6X)
than under normal operation during the resonance below the run speed range. That is, when the 1X torque
excitation is resonant with the first torsional natural frequency between 600 and 650 rpm. The response was
high for 40-60 seconds. Simulation of that event shows high coupling torques due to the load on the
compressor.
During normal warm starts, the run speed passed through the resonance in less than 5 seconds, and the
response was reasonable.
However, to reduce the possibility of damage occurring during cold starts and, or emergency shutdowns, Beta is
working with the coupling vendor on an uprated version of the coupling design. The result of that design study
will be presented in a separate report.
4.17 General
Modifications
Typically, recommendations in this report are provided with the goal of reducing vibrations. It is the
responsibility of our clients to ensure implementing these recommendations, especially pipe layout changes, will
not interfere with the safe operation of the unit.
Changing Operation
All the measurements are taken at the specific load step and operating conditions listed in Appendix A. Changes
in load steps or operating conditions can lead to an increase in forces on components resulting in higher
vibrations.
Assumptions
Some Finite Element Analysis (FEA) may be performed to assess the stress levels due to high vibrations on
specific components. Carefully review the assumptions made for FEA if applicable. Inform BETA if the
assumptions (dimensions, material, etc.) are not accurate. This could significantly change the results of FEA.
Follow-up Analysis
After modifications have been completed, confirm that vibration levels are acceptable before operating at
speeds or conditions where vibrations have been identified as problems.
Solution Options
In some cases, adding supports lowers vibration levels simply by masking the effects of high forces. BETA strives
to apply practical, cost-effective solutions that deal with the source of the problem, not just the symptoms.
Measuring vibration is a useful method of identifying problems. However, it can be impractical to test the
system under all possible operating conditions. Computer modelling can be applied to simulate many different
operating conditions, identify weak points in the system and optimize solutions. The use of advanced methods
including acoustical and mechanical modelling, stress measurements, and finite element analysis can improve
machine reliability while minimizing time spent on trial-and-error approaches. BETA can provide assistance in
this regard.
BETA also offers a monitoring, analysis, and optimization (MAO) service which can increase equipment reliability
and efficiency and reduce maintenance costs. Monitoring can be provided by on-site personnel and equipment,
or by BETA. Measurement data is then sent to BETA for analysis. A comprehensive report is provided which
presents machine status and includes recommendations for corrections to any faults or inefficiencies. The MAO
service includes performance and condition monitoring of many types of rotating and reciprocating machines.
More details can be provided upon request.
More Information
BETA has published many technical papers and offers technical presentations and seminars. For additional
information, please refer to our website at www.BETAMachinery.com, or contact the author of this report.
Job US00365-01-1 GE Oil & Gas (Egypt) Date May 28 – June 5, 2016
Design speed range (rpm) 800 – 1000 Test speed range (rpm) 800 – 1000
Stage # 1 1 2 2 3 4
Cylinder/throw # 3 5 4 6 1 2
# of distance pieces 1 1 1 1 1 1
# of side streams - - - - 1 -
Operating Conditions
Suction press. ( psig ) 25.1 – 25.7 91.8 – 95.0 261.0 – 270.6 682.0 – 695.6
Discharge press. ( psig ) 93.6 – 97.1 265.8 – 270.5 684.0 – 700.5 2000 – 2024
Discharge temp. ( °F ) 232.6 – 293.8 233.5 – 301.0 279.3 – 296.5 281.3 – 306.4 267.0 – 238.9 239.7 -289.0
Recycle ( % ) 0 0 0 0 0 0
A.2.2 Sensors
Sensitivity Engineering
Ch # Make Model Ser. No.
(mV/EU) Units (EU)
1 CTC VE102-1D 1114 95.49 ips
2 V0622A01 3672 105.86 ips
3 CTC VE101-1D 1710 96.70 ips
4 CTC VE101-1D 1850 91.22 ips
1 PCB 086D20 25810 1.041 lbf
S111A24 16063 5.110 psi
S111A24 16065 5.050 psi
1 Encoder Products Co. 25T42SJ-0360NV1RP5-SMW 1969557 0.247m deg/s
test point
guideline
Table B.2.2 – Vibration Data Summary (Anomaly Report: After Alignment Done)
Beta Reference#: US00365-01-01 Test Date: Jun 03, 2016 Analyst: MG2
Company: GE Oil & Gas Location: Agiba Gas Plant, Egypt Unit: U-150.2.5 (After Alignment)
Driver Make/Model: Cameron WG76 Driven Make/Model: Waukesha 16V275GL RPM min/max: 800-1000
Table B.2.3 – Vibration Data Summary (Anomaly Report: After Pipe at TP# 436 Braced)
Beta Reference#: US00365-01-01 Test Date: Jun 02, 2016 Analyst: MG2
Company: GE Oil & Gas Location: Agiba Gas Plant, Egypt Unit: U-150.2.5 (436 Braced)
Driver Make/Model: Cameron WG76 Driven Make/Model: Waukesha 16V275GL RPM min/max: 800-1000
Table B.2.4 – Vibration Data Summary (Anomaly Report: Stage 4 Discharge Bottle Wedges Braced)
Beta Reference#: US00365-01-01 Test Date: Jun 03, 2016 Analyst: MG2
Company: GE Oil & Gas Location: Agiba Gas Plant, Egypt Unit: U-150.2.5 (Brace Wedge)
Driver Make/Model: Cameron WG76 Driven Make/Model: Waukesha 16V275GL RPM min/max: 800-1000
Table B.2.5 – Vibration Data Summary (Anomaly Report: Night Operation, no Side Stream)
Beta Reference#: US00365-01-01 Test Date: Jun 04, 2016 Analyst: MG2
Company: GE Oil & Gas Location: Agiba Gas Plant, Egypt Unit: U-150.2.5 (Night Oper'n)
Driver Make/Model: Cameron WG76 Driven Make/Model: Waukesha 16V275GL RPM min/max: 800-1000
Table B.2.6 – Vibration Data Summary (Anomaly Report: Night Operation, with Side Stream)
Beta Reference#: US00365-01-01 Test Date: Jun 05, 2016 Analyst: MG2
Company: GE Oil & Gas Location: Agiba Gas Plant, Egypt Unit: U-150.2.5 (Night w/ SS)
Driver Make/Model: Cameron WG76 Driven Make/Model: Waukesha 16V275GL RPM min/max: 800-1000
420 v 301 P 3.01 ips Pk 74.4 B.6.83 Vibration higher due to wedge support left loose after web deflection checks by GE
415 v 204 P 2.04 ips Pk 65.6 B.6.83 Vibration higher due to wedge support left loose after web deflection checks by GE
420 -h 231 P 2.31 ips Pk 73.4 B.6.84 Vibration higher due to wedge support left loose after web deflection checks by GE
430 v 123 P 1.23 ips Pk 83.8 B.6.85 Vibration higher due to wedge support left loose after web deflection checks by GE
435 v 142 P 1.42 ips Pk 65.3 B.6.85 Vibration higher due to wedge support left loose after web deflection checks by GE
430 -a 161 P 1.61 ips Pk 47.5 B.6.85 Vibration higher due to wedge support left loose after web deflection checks by GE
435 -a 158 P 1.58 ips Pk 47.5 B.6.85 Vibration higher due to wedge support left loose after web deflection checks by GE
435 -h 98 P 0.984 ips Pk 65 B.6.86 Vibration higher due to wedge support left loose after web deflection checks by GE
436 h 343 P 3.43 ips Pk 174.1 B.6.86 Vibration higher due to wedge support left loose after web deflection checks by GE
436 v 196 P 1.96 ips Pk 118.4 B.6.86 Vibration higher due to wedge support left loose after web deflection checks by GE
436 a 233 P 2.33 ips Pk 66.9 B.6.86 Vibration higher due to wedge support left loose after web deflection checks by GE
414 h 253 P 2.53 ips Pk 66.3 B.6.87 Vibration higher due to wedge support left loose after web deflection checks by GE
414 -a 500 P 5 ips Pk 57.8 B.6.87 Vibration higher due to wedge support left loose after web deflection checks by GE
Cylinder 2 v 284 C 1.99 ips Pk 65.3 B.6.84 Vibration higher due to wedge support left loose after web deflection checks by GE
Cylinder 2 -a 144 C 1.01 ips Pk 33.4 B.6.84 Vibration higher due to wedge support left loose after web deflection checks by GE
Beta Reference#: US00365-01-01 Test Date: Jun 05, 2016 Analyst: MG2
Company: GE Oil & Gas Location: Agiba Gas Plant, Egypt Unit: U-150.2.5 (Pulsations)
Driver Make/Model: Cameron WG76 Driven Make/Model: Waukesha 16V275GL RPM min/max: 800-1000
4
5 6 162.2 7.79E-01
0.8 6 7 162.8 7.17E-01
7 8 163.4 6.62E-01
0.7 8 9 57.5 6.14E-01
9 10 45.3 5.63E-01
0.6 10 11 158.8 5.35E-01
11
12 16.9 3.81E-01
0.5 13 166.9 3.76E-01
14 155.9 3.72E-01
0.4 12
16
14 13
1517 15 165.9 3.51E-01
19 18 16 76.6 3.47E-01
0.3 20 17 173.4 3.33E-01
0.2 18 179.4 2.91E-01
19 85.3 2.90E-01
0.1 20 181.3 2.50E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00022\G1, 1_P1sv00000 - 220 215.csv
Freq. Magnitude
# Hz ips Pk
1.2 1 48.8 1.41E+00
2 45.3 6.25E-01
3 161.6 5.97E-01
1.0 4 162.2 5.75E-01
5 162.8 5.17E-01
Magnitude (ips Pk)
6 163.4 4.78E-01
7 31.9 4.13E-01
0.8 8 158.8 4.13E-01
9 64.7 3.71E-01
2
10 57.5 3.49E-01
0.6 3
4 11 16.6 3.21E-01
5
12 56.3 3.07E-01
6 13 166.9 2.94E-01
7 8 14 173.4 2.87E-01
0.4 10
9 15 76.9 2.64E-01
11 12 16 171.9 2.16E-01
1314
15 17 171.3 2.14E-01
1920 17
16
18 18 174.7 2.06E-01
0.2 19 66.6 2.04E-01
20 73.4 1.91E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00022\G2, 2_P1sv00000 - 220 215.csv
Freq. Magnitude
# Hz ips Pk
1 64.7 1.24E+00
1.0 2 196.3 5.43E-01
3 68.4 4.18E-01
4 197.5 3.98E-01
5 89.7 3.06E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00022\G3, 3_P1sv00000 - 220 215.csv
6 170.9 2.92E-01
3
7 162.2 2.91E-01
0.50 8 162.8 2.76E-01
4 9 76.9 2.62E-01
10 163.4 2.62E-01
0.40 11 69.1 2.51E-01
12 159.1 2.17E-01
5 13 45.3 2.06E-01
0.30 7 6
8 14 67.5 2.03E-01
11 9 10
12
15 80.6 1.88E-01
13 14 16 164.7 1.87E-01
0.20 15 16
17 19 18 20 17 48.1 1.62E-01
18 166.6 1.61E-01
0.10 19 112.8 1.54E-01
20 175.3 1.53E-01
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00022\G4, 4_P1sv00000 - 220 215.csv
Fig: B.6.2
Spectrum TP: 220 (a)
1.1 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 02:35
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 33.4 6.80E-01
2 64.7 6.51E-01
3 90.0 5.87E-01
0.7 1 4 159.4 5.32E-01
2
5 157.8 4.72E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00023\G1, 1_P1sv00000 - 220 C4.csv
Freq. Magnitude
# Hz ips Pk
1 177.5 3.83E-01
0.55 2 178.1 3.69E-01
3 179.4 3.41E-01
4 181.6 3.23E-01
5 182.2 3.22E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00023\G2, 2_P1sv00000 - 220 C4.csv
6 178.8 2.74E-01
0.8 7 178.1 2.71E-01
8 180.3 2.52E-01
0.7 9 181.6 2.51E-01
10 182.5 2.45E-01
0.6 11 45.0 2.40E-01
2 12 110.0 2.39E-01
3
0.5 13 183.8 2.37E-01
14 184.4 2.36E-01
0.4 15 185.0 2.29E-01
4
16 110.9 2.28E-01
0.3 5 76
11 12
16
813
914
1015 17 82.5 2.08E-01
17
18
19
20 18 85.3 2.07E-01
0.2
19 81.3 2.01E-01
0.1 20 84.1 1.93E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00023\G3, 3_P1sv00000 - 220 C4.csv
Freq. Magnitude
# Hz ips Pk
0.60
1 33.4 7.11E-01
2 76.3 3.47E-01
3 16.9 2.84E-01
0.50 4 140.9 2.20E-01
5 40.0 1.93E-01
Magnitude (ips Pk)
6 45.6 1.92E-01
7 245.9 1.86E-01
0.40 8 46.3 1.81E-01
2 9 61.3 1.78E-01
10 63.1 1.77E-01
0.30 11 244.1 1.66E-01
3
12 247.5 1.62E-01
13 243.4 1.60E-01
4 14 41.6 1.48E-01
0.20 56 7 15 64.4 1.47E-01
8 910
1112
13 16 242.8 1.45E-01
14 15 16
18 17
20 19 17 70.9 1.34E-01
18 49.1 1.26E-01
0.10 19 145.3 1.25E-01
20 89.7 1.20E-01
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00023\G4, 4_P1sv00000 - 220 C4.csv
Fig: B.6.3
Spectrum TP: 217 (h)
1.5 Channel: 1 P:BMA-Pipe
6 64.4 4.03E-01
0.8 7 60.9 3.82E-01
8 62.8 3.64E-01
0.7 9 200.3 2.29E-01
2 10 183.4 2.05E-01
0.6 3 11 182.5 2.02E-01
45
12 196.9 2.02E-01
0.5 13 30.9 1.91E-01
6 14 163.4 1.70E-01
0.4 78
15 198.4 1.69E-01
16 73.1 1.62E-01
0.3 17 109.4 1.62E-01
9
13 10 12
11 18 173.4 1.46E-01
0.2 16 17 14 15
2019 18 19 25.0 1.42E-01
0.1 20 16.9 1.42E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00024\G1, 1_P1sv00000 - 217 C6.csv
Freq. Magnitude
# Hz ips Pk
1 16.9 2.68E-01
0.55 2 76.3 2.49E-01
3 64.4 2.48E-01
4 61.3 2.43E-01
5 176.6 2.11E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00024\G2, 2_P1sv00000 - 217 C6.csv
Freq. Magnitude
# Hz ips Pk
1 61.3 6.25E-01
0.50 2 57.2 4.75E-01
2
3 73.4 4.07E-01
4 89.4 3.79E-01
3 5 76.6 3.30E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00024\G3, 3_P1sv00000 - 217 C6.csv
Freq. Magnitude
# Hz ips Pk
1 33.4 6.10E-01
0.50 2 76.3 3.34E-01
3 16.9 3.25E-01
4 45.0 2.15E-01
5 46.3 2.08E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00024\G4, 4_P1sv00000 - 217 C6.csv
Fig: B.6.4
Spectrum TP: 217 (-v)
1.1 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 02:52
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 196.3 3.76E-01
2 55.9 3.02E-01
3 56.9 2.86E-01
0.7 4 76.3 2.83E-01
5 60.6 2.59E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00025\G1, 1_P1sv00000 - 217 230.csv
6 179.4 1.00E+00
0.7 7 64.1 8.26E-01
8 186.3 7.79E-01
0.6 10
9 68.4 7.54E-01
11
12
10 55.9 5.89E-01
0.5 11 71.6 5.46E-01
13
14 12 78.8 5.06E-01
16 18 15 1719
0.4 20 13 233.1 4.44E-01
14 233.8 4.43E-01
15 204.4 4.18E-01
0.3 16 48.1 4.18E-01
17 227.8 4.12E-01
0.2 18 173.1 4.12E-01
19 231.9 4.00E-01
0.1 20 226.9 3.98E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00025\G2, 2_P1sv00000 - 217 230.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00025\G3, 3_P1sv00000 - 217 230.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00025\G4, 4_P1sv00000 - 217 230.csv
Fig: B.6.5
Spectrum TP: 420 (-a)
1.2 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 03:02
Setup:
1
Note:
1.0
Freq. Magnitude
# Hz ips Pk
1 63.8 1.04E+00
2 2 75.9 8.30E-01
0.8 3 59.7 6.95E-01
4 83.8 6.81E-01
3 5 102.2 6.60E-01
Magnitude (ips Pk)
4
5 6 32.2 5.35E-01
7 33.4 5.17E-01
0.6 8 93.4 4.75E-01
6 9 87.8 4.54E-01
7
8 10 109.4 3.59E-01
9 11 72.5 3.57E-01
12 91.6 3.57E-01
0.4 13 11 12 10 13 57.2 3.57E-01
15 14
16
14 217.2 3.56E-01
1817 15 56.3 3.49E-01
19
20 16 178.4 3.37E-01
17 95.9 2.95E-01
0.2
18 90.0 2.88E-01
19 80.3 2.62E-01
20 70.0 2.47E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00026\G1, 1_P1sv00000 - 420 415.csv
3
4 6 60.3 8.36E-01
7 83.8 8.15E-01
0.9 6
5 8 45.0 6.30E-01
7
9 80.0 5.53E-01
10 81.9 4.58E-01
11 28.4 4.40E-01
8
12 68.1 3.86E-01
0.6 9 13 90.6 3.24E-01
10 14 214.7 3.20E-01
11 15 213.8 3.12E-01
12
16 212.8 2.97E-01
13 14
15
17 19 18 16 17 39.1 2.96E-01
0.3 20
18 65.0 2.88E-01
19 56.6 2.80E-01
20 182.2 2.78E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00026\G2, 2_P1sv00000 - 420 415.csv
6 213.8 5.73E-01
7 214.4 5.71E-01
1.2 8 212.8 5.70E-01
9 217.2 5.56E-01
10 210.0 5.39E-01
11 211.3 5.30E-01
3 12 208.8 4.87E-01
0.8 13 82.2 4.84E-01
5 4 14 206.6 4.28E-01
867 15 204.7 4.01E-01
119
10
13 12 16 205.3 3.97E-01
14
0.4 15
16
17 17 203.8 3.70E-01
19
20 18
18 315.6 3.47E-01
19 200.6 3.45E-01
20 201.3 3.45E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00026\G3, 3_P1sv00000 - 420 415.csv
5
6 68.1 7.93E-01
6 7 75.6 3.65E-01
0.8 8 53.8 3.64E-01
9 315.6 3.57E-01
10 79.4 3.56E-01
0.6 11 316.6 3.14E-01
12 182.2 3.09E-01
13 317.5 2.58E-01
14 84.1 2.52E-01
0.4 8 710 9 15 32.5 2.36E-01
12 11 16 318.4 2.30E-01
14 13 17 33.4 2.28E-01
15
19
17 18
20 16
18 176.6 2.27E-01
0.2 19 31.9 2.26E-01
20 175.9 2.23E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00026\G4, 4_P1sv00000 - 420 415.csv
Fig: B.6.6
Spectrum TP: 420 (-h)
1.2 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 03:12
1 Setup:
Note:
1.0
Freq. Magnitude
2 # Hz ips Pk
3 1 72.2 1.06E+00
4 2 70.6 8.87E-01
0.8 5 3 55.9 8.59E-01
7 6 4 59.1 8.20E-01
5 64.4 7.63E-01
Magnitude (ips Pk)
8
6 75.3 7.30E-01
7 66.6 7.30E-01
0.6 8 68.4 6.80E-01
9 182.5 5.01E-01
9
10 10 61.6 4.77E-01
11 82.8 3.95E-01
11 12 16.9 3.55E-01
0.4 13 14.7 3.23E-01
12
13 14 15 14 33.4 3.17E-01
15 180.6 3.07E-01
18 17
16 16 176.9 2.24E-01
20 19 17 176.3 2.24E-01
0.2
18 44.4 2.23E-01
19 216.6 2.10E-01
20 152.8 2.10E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00027\G1, 1_P1sv00000 - 420 c2.csv
Freq. Magnitude
# Hz ips Pk
1 210.9 3.47E-01
0.55 2 210.3 3.20E-01
3 16.9 3.11E-01
4 214.4 3.01E-01
5 208.4 2.98E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00027\G2, 2_P1sv00000 - 420 c2.csv
3 6 59.1 6.59E-01
7 82.5 3.28E-01
0.9 8 33.4 2.63E-01
9 44.7 2.04E-01
10 49.1 2.04E-01
645 11 31.3 2.01E-01
12 48.1 1.96E-01
0.6 13 91.3 1.92E-01
14 93.4 1.92E-01
15 16.6 1.61E-01
16 217.2 1.52E-01
7
0.3 17 15.0 1.33E-01
8
18 86.3 1.31E-01
11 912
10 13
14
15 16 19 96.3 1.25E-01
20 17 18 19 20 5.3 1.17E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00027\G3, 3_P1sv00000 - 420 c2.csv
6 47.8 3.73E-01
7 28.4 3.69E-01
0.6 8 16.6 3.40E-01
4 9 60.0 3.19E-01
10 38.8 3.14E-01
5 11 27.5 3.10E-01
12 59.4 3.09E-01
0.4 7 6 13 63.4 2.98E-01
8
11 10 9
12 14 82.8 2.62E-01
13
15 87.2 1.83E-01
14
16 229.4 1.69E-01
0.2 15 17 228.8 1.68E-01
18 17
16
19
20 18 56.3 1.66E-01
19 227.5 1.59E-01
20 230.6 1.58E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00027\G4, 4_P1sv00000 - 420 c2.csv
Fig: B.6.7
Spectrum TP: 414 (h)
2.0 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 03:23
1.8 Setup:
1 Note:
6 182.5 5.63E-01
7 60.0 5.39E-01
1.0 8 82.5 5.28E-01
3
9 120.0 4.49E-01
10 244.4 4.34E-01
0.8 4 11 246.6 4.29E-01
12 33.1 4.26E-01
5
13 243.8 4.26E-01
0.6 7 8
6
14 245.3 4.13E-01
9 15 31.9 4.02E-01
12 10
11
13
14
15 16 17 16 119.1 3.92E-01
0.4 19 18 20
17 247.8 3.90E-01
18 89.1 3.82E-01
0.2 19 66.3 3.81E-01
20 153.4 3.73E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00028\G1, 1_P1sv00000 - 414 410.csv
2 6 33.4 1.39E+00
7 82.5 1.36E+00
2.5 8 75.0 1.31E+00
9 31.9 1.31E+00
10 177.5 9.84E-01
2.0 11 86.9 9.22E-01
3 4 12 176.3 9.05E-01
5 13 53.8 8.77E-01
1.5 6
9 87 14 185.0 8.33E-01
15 180.0 8.23E-01
10 16 192.5 7.34E-01
1.0 13 11 12
1514 17 191.9 7.26E-01
16
17
1819
20 18 193.8 7.15E-01
0.5 19 201.6 7.15E-01
20 38.1 6.49E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00028\G2, 2_P1sv00000 - 414 410.csv
1
0.6 6 73.1 1.92E-01
2
7 89.7 1.81E-01
8 87.2 1.76E-01
0.5 9 48.4 1.72E-01
10 82.8 1.72E-01
11 74.1 1.71E-01
0.4 12 64.1 1.52E-01
13 71.3 1.48E-01
3 14 55.9 1.45E-01
0.3
15 56.9 1.36E-01
4
5 16 182.8 9.61E-02
0.2 6 17 260.3 9.59E-02
9 11 1087
14 1213 18 217.2 9.31E-02
15
19 16 20 18 17 19 92.8 9.29E-02
0.1 20 192.5 8.68E-02
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00028\G3, 3_P1sv00000 - 414 410.csv
3
6 70.6 2.41E-01
0.7 7 87.8 2.14E-01
8 88.4 2.09E-01
0.6 9 59.1 1.96E-01
4 10 208.4 1.48E-01
0.5 5 11 209.4 1.46E-01
12 210.0 1.45E-01
0.4 13 63.4 1.19E-01
14 211.9 1.05E-01
15 212.5 1.04E-01
0.3 16 107.8 9.50E-02
6
9
78 17 153.8 8.81E-02
0.2 18 105.0 8.36E-02
10
11
12
13 14
15
19 90.6 8.20E-02
16
0.1 20 19 18 17 20 56.6 7.67E-02
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00028\G4, 4_P1sv00000 - 414 410.csv
Fig: B.6.8
Spectrum TP: 430 (-a)
2.0 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 03:32
1.8 Setup:
1 Note:
6 47.5 4.05E-01
3 7 59.4 3.68E-01
1.0 8 30.9 3.11E-01
9 86.9 2.99E-01
4 10 90.9 2.32E-01
0.8 11 64.1 1.79E-01
12 92.2 1.75E-01
13 53.8 1.69E-01
0.6 14 16.6 1.68E-01
15 150.6 1.58E-01
6 5 16 49.4 1.47E-01
0.4 7
17 101.6 1.37E-01
8 9
10
18 148.1 1.33E-01
0.2 14 11 12 19 27.5 1.11E-01
1613 17 15
18 20 153.1 1.04E-01
19 20
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00029\G1, 1_P1sv00000 - 430 435.csv
6 33.1 6.60E-01
7 81.6 5.07E-01
1.0 8 39.1 3.90E-01
4 9 40.0 3.71E-01
10 28.4 2.61E-01
0.8 5
11 161.6 2.47E-01
6 12 83.8 2.36E-01
13 90.9 2.35E-01
0.6 14 16.9 2.22E-01
7
15 27.5 2.18E-01
89 16 150.6 2.07E-01
0.4 17 85.3 1.95E-01
10
1213 11 18 66.9 1.64E-01
14 15 16
0.2 18
17 19 49.1 1.42E-01
20 19 20 35.3 1.38E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00029\G2, 2_P1sv00000 - 430 435.csv
6 63.4 4.03E-01
7 122.8 3.66E-01
1.0 8 61.3 2.94E-01
9 86.9 2.79E-01
10 117.5 2.25E-01
0.8 11 150.3 2.16E-01
2
12 93.4 2.09E-01
13 96.3 2.03E-01
0.6 14 160.3 1.98E-01
3 4
15 95.0 1.94E-01
5
6 16 254.4 1.88E-01
0.4 7
17 160.9 1.88E-01
8 9 18 215.0 1.84E-01
12
13 10 11 14
0.2 15 17 18
20
19 16 19 217.2 1.84E-01
20 215.6 1.84E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00029\G3, 3_P1sv00000 - 430 435.csv
2 Freq. Magnitude
# Hz ips Pk
1 63.8 1.23E+00
1.0 2 55.9 1.08E+00
3 70.9 7.12E-01
4 123.1 6.85E-01
5 153.8 6.39E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00029\G4, 4_P1sv00000 - 430 435.csv
Fig: B.6.9
Spectrum TP: 409 (h)
1.1 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 03:49
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 44.7 6.80E-01
2 66.3 3.51E-01
3 58.4 3.32E-01
0.7 1 4 55.9 3.29E-01
5 82.2 3.11E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00030\G1, 1_P1sv00000 - 435 436 409.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00030\G2, 2_P1sv00000 - 435 436 409.csv
Freq. Magnitude
# Hz ips Pk
1 122.8 5.94E+00
5.0 2 153.4 4.25E+00
3 154.4 3.37E+00
2 4 149.4 3.17E+00
5 148.1 3.15E+00
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00030\G3, 3_P1sv00000 - 435 436 409.csv
6 6 61.3 6.91E-01
0.7 7 66.6 6.05E-01
7 8 72.8 4.74E-01
0.6 9 55.6 4.62E-01
10 58.1 4.14E-01
0.5 8 11 59.1 4.02E-01
9
12 117.2 4.00E-01
10
11 12
0.4 13 70.0 3.66E-01
13
14 74.1 3.20E-01
14
15 16 15 71.3 3.15E-01
0.3 17 16 210.9 3.07E-01
18 19
20
17 327.5 2.60E-01
0.2 18 88.4 2.51E-01
19 328.1 2.45E-01
0.1 20 326.9 2.40E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00030\G4, 4_P1sv00000 - 435 436 409.csv
Fig: B.6.10
Spectrum TP: 210 (h)
2.0 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 04:03
1.8 Setup:
1 Note:
6 48.4 2.09E-01
7 49.1 2.08E-01
1.0 8 456.6 1.82E-01
9 16.3 1.61E-01
10 222.2 1.49E-01
0.8 2 11 161.3 1.38E-01
12 160.6 1.37E-01
13 338.1 1.36E-01
0.6 3
14 338.8 1.34E-01
15 457.8 1.34E-01
4
16 336.3 1.31E-01
0.4 17 78.1 1.30E-01
5 18 337.5 1.26E-01
67 19 315.9 1.24E-01
0.2 9 12
11 10 13
14
8
15
17 19 2016
18 20 329.1 1.24E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00031\G1, 1_P1sv00000 - 210 212.csv
3 6 73.1 4.66E-01
0.7 7 75.0 3.34E-01
8 50.0 3.16E-01
0.6 4 9 77.8 3.15E-01
10 40.0 2.90E-01
0.5 56 11 16.6 2.71E-01
12 46.3 2.47E-01
0.4 13 27.5 2.40E-01
7 14 44.7 2.39E-01
8 9 15 68.4 2.11E-01
0.3 10
11 16 191.9 1.54E-01
13 12
14
15 17 191.3 1.53E-01
0.2 16 18 195.0 1.48E-01
17
18
20
19
19 193.1 1.44E-01
0.1 20 192.5 1.42E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00031\G2, 2_P1sv00000 - 210 212.csv
6 43.8 6.07E-01
7 78.1 5.92E-01
1.5 8 108.8 5.84E-01
9 62.2 5.21E-01
10 16.9 5.15E-01
1.2 11 161.6 3.46E-01
12 112.8 3.42E-01
13 425.9 3.17E-01
0.9 14 97.5 2.75E-01
2 3 4 15 163.1 2.72E-01
65 7 8 16 96.9 2.70E-01
0.6 10 9 17 99.7 2.69E-01
11
18 102.2 2.57E-01
12 13
0.3 19 14
16
120
7
18 15 19 41.6 2.55E-01
20 100.6 2.53E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00031\G3, 3_P1sv00000 - 210 212.csv
6 85.0 5.45E-01
0.8 7 55.6 5.22E-01
8 88.8 5.18E-01
0.7 9 80.0 5.00E-01
10 68.4 4.85E-01
0.6 34 5 11 78.4 4.69E-01
6
7 8
10 119 12 115.0 4.61E-01
0.5 12 13 116.9 4.15E-01
13 14 86.6 3.68E-01
0.4 14 15
16 15 98.8 3.50E-01
17 18 19 20 16 309.4 3.46E-01
0.3
17 54.1 3.41E-01
0.2 18 81.3 3.26E-01
19 310.0 3.24E-01
0.1 20 425.9 3.16E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00031\G4, 4_P1sv00000 - 210 212.csv
Fig: B.6.11
Spectrum TP: 235 (h)
1.5 Channel: 1 P:BMA-Pipe
4
5 6 60.6 7.77E-01
0.8 6 7 47.8 7.15E-01
7 8 59.4 6.60E-01
0.7 98 10 9 58.8 6.57E-01
11 12 10 70.9 6.44E-01
0.6 11 16.6 6.15E-01
13 12 72.5 5.96E-01
0.5 14 13 90.0 5.06E-01
15
16 14 66.9 4.51E-01
0.4 15 57.2 4.28E-01
17 18
19 20 16 75.0 3.87E-01
0.3 17 81.9 3.34E-01
0.2 18 112.2 3.29E-01
19 113.4 3.11E-01
0.1 20 182.8 3.03E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00032\G1, 1_P1sv00000 - 235 232.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00032\G2, 2_P1sv00000 - 235 232.csv
6 78.4 7.72E-01
0.8 54
7 6 7 69.7 7.55E-01
8
8 76.6 6.88E-01
0.7 10 9 9 84.4 6.56E-01
11 10 56.3 6.48E-01
0.6 11 71.3 6.19E-01
12 54.1 4.14E-01
0.5 13 122.2 4.02E-01
12 1715 1416
13 14 117.2 4.02E-01
0.4 18 15 89.4 4.00E-01
20 19 16 121.3 3.99E-01
0.3
17 81.9 3.96E-01
0.2 18 82.8 3.48E-01
19 108.4 3.06E-01
0.1 20 48.8 3.05E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00032\G3, 3_P1sv00000 - 235 232.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00032\G4, 4_P1sv00000 - 235 232.csv
Fig: B.6.12
Spectrum TP: 209 (h)
1.1 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 04:22
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 30.6 6.87E-01
2 117.2 5.26E-01
3 89.7 5.17E-01
0.7 1
4 32.8 3.78E-01
5 33.4 3.77E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00033\G1, 1_P1sv00000 - 209 210sg.csv
Freq. Magnitude
# Hz ips Pk
1.2
1 50.3 1.44E+00
2 42.5 9.19E-01
3 63.1 8.16E-01
1.0 4 62.5 8.07E-01
5 71.6 7.89E-01
Magnitude (ips Pk)
2
6 59.1 6.05E-01
43 5 7 46.3 6.01E-01
0.8 8 43.4 5.91E-01
9 66.9 4.99E-01
10 51.6 3.61E-01
87 6 11 33.4 3.54E-01
0.6
12 55.3 3.51E-01
9 13 40.0 3.45E-01
14 53.8 3.15E-01
0.4 1113 1012 15 73.4 2.84E-01
14 16 204.7 2.43E-01
15 17 78.8 2.17E-01
16
17 18 18 195.0 2.10E-01
0.2 19
20
19 194.4 1.92E-01
20 193.8 1.84E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00033\G2, 2_P1sv00000 - 209 210sg.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00033\G3, 3_P1sv00000 - 209 210sg.csv
6 78.1 3.17E-01
7 33.4 3.15E-01
2.0 8 73.4 2.91E-01
9 66.9 2.85E-01
10 181.3 2.73E-01
1.6 11 60.9 2.47E-01
12 190.9 2.40E-01
13 195.0 2.37E-01
1.2 14 195.6 2.25E-01
15 193.1 2.19E-01
16 193.8 2.12E-01
0.8 2 3 17 112.5 2.05E-01
18 75.0 2.04E-01
0.4 54 6 19 117.2 1.89E-01
7 8
119 18 1719
10 1213
15
14
16 20 50.0 1.85E-01
20
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00033\G4, 4_P1sv00000 - 209 210sg.csv
Fig: B.6.13
Spectrum TP: 436 (v)
6.0 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 04:39
Setup:
Note:
5.0 21
3 4 Freq. Magnitude
5 # Hz ips Pk
6
1 77.2 4.91E+00
9 87 2 76.6 4.89E+00
4.0 3 57.8 4.70E+00
4 75.9 4.68E+00
5 83.4 4.45E+00
Magnitude (ips Pk)
10
11 6 82.5 4.19E+00
12
7 81.3 4.06E+00
3.0 14 13 8 80.6 4.06E+00
15 9 60.3 4.03E+00
10 55.6 3.32E+00
11 55.0 3.31E+00
12 56.6 3.18E+00
2.0 13 153.8 2.84E+00
16 17 14 62.5 2.84E+00
19 18 15 123.1 2.68E+00
20
16 85.6 1.71E+00
17 152.2 1.63E+00
1.0
18 150.6 1.35E+00
19 43.1 1.33E+00
20 150.0 1.29E+00
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00034\G1, 1_P1sv00000 - 436 fr front.csv
6 71.9 1.24E+00
9 10 7 57.8 1.05E+00
0.9 11 8 83.4 1.05E+00
9 43.1 9.25E-01
10 150.0 9.22E-01
12 11 151.3 8.37E-01
14 13
12 66.9 6.83E-01
0.6 13 159.4 6.59E-01
15
16
14 65.9 6.38E-01
19 1718
20 15 64.4 5.34E-01
16 85.6 5.06E-01
17 146.9 4.28E-01
0.3
18 153.1 4.21E-01
19 45.6 4.19E-01
20 147.5 4.17E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00034\G2, 2_P1sv00000 - 436 fr front.csv
1
0.30 6 45.6 1.59E-01
2
7 90.0 1.45E-01
8 122.5 1.28E-01
0.25 9 123.1 1.28E-01
3 10 62.2 1.22E-01
4
11 121.6 1.14E-01
0.20 12 67.8 1.14E-01
5 6 13 180.9 1.04E-01
0.15 7 14 181.6 1.03E-01
10 89 15 85.9 9.63E-02
12 11 16 43.1 9.60E-02
13
14
0.10 1617 15 17 48.8 9.56E-02
18 19
20
18 116.9 8.90E-02
19 203.4 8.81E-02
0.05 20 205.0 8.66E-02
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00034\G3, 3_P1sv00000 - 436 fr front.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00034\G4, 4_P1sv00000 - 436 fr front.csv
Fig: B.6.14
Spectrum TP: Engine Front (h)
0.55 Channel: 1 EW:BMA-Waukesha Engine
Date: May 30, 2016 04:51
0.50 Setup:
Note:
0.45
Freq. Magnitude
# Hz ips Pk
1
0.40 1 16.9 4.00E-01
2 48.8 3.15E-01
3 47.2 3.08E-01
0.35 4 23.8 2.60E-01
5 31.6 1.33E-01
Magnitude (ips Pk)
32
0.30 6 57.2 1.21E-01
7 56.3 1.19E-01
4 8 26.6 1.18E-01
0.25 9 29.1 1.09E-01
10 66.3 1.05E-01
11 65.3 1.01E-01
0.20 12 91.9 9.70E-02
13 53.8 9.61E-02
0.15 14 90.3 9.14E-02
5 15 89.4 8.90E-02
8 76
9 10 16 40.9 8.87E-02
0.10 13 11 12
14
15 17 107.8 7.92E-02
16
17
19
120
8
18 110.9 7.88E-02
19 109.4 7.86E-02
0.05 20 111.9 7.46E-02
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00035\G1, 1_P1sv00000 - engine hv.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00035\G2, 2_P1sv00000 - engine hv.csv
Freq. Magnitude
0.70 # Hz ips Pk
1 16.9 7.57E-01
2 23.8 4.40E-01
0.60 3 33.4 2.14E-01
4 80.3 1.87E-01
5 79.7 1.84E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00035\G3, 3_P1sv00000 - engine hv.csv
2
0.30 6 43.4 1.29E-01
7 65.9 1.10E-01
8 24.1 1.06E-01
0.25 9 38.4 1.05E-01
10 66.9 1.05E-01
11 25.0 1.02E-01
0.20 12 71.9 1.02E-01
3 13 72.8 9.29E-02
0.15 4 14 47.8 8.68E-02
56
15 83.4 8.65E-02
8 9
11
7
10
12
16 94.1 8.28E-02
0.10 14 13 15
16
18 1920
17
17 74.7 8.25E-02
18 74.1 8.23E-02
19 93.1 8.13E-02
0.05 20 100.3 7.86E-02
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00035\G4, 4_P1sv00000 - engine hv.csv
Fig: B.6.15
Spectrum TP: Engine Front (a)
0.55 Channel: 1 EW:BMA-Waukesha Engine
Date: May 30, 2016 06:02
0.50 Setup:
Note:
0.45
Freq. Magnitude
# Hz ips Pk
0.40 1 32.2 7.84E-02
2 24.1 5.04E-02
3 230.6 4.93E-02
0.35 4 228.4 4.92E-02
5 229.1 4.89E-02
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00036\G1, 1_P1sv00000 - engine frame.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00036\G2, 2_P1sv00000 - engine frame.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00036\G3, 3_P1sv00000 - engine frame.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00036\G4, 4_P1sv00000 - engine frame.csv
Fig: B.6.16
Spectrum TP: 237 (h)
1.2 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 06:13
Setup:
1 Note:
1.0
Freq. Magnitude
2 # Hz ips Pk
3
4
1 76.9 1.02E+00
5
67 2 180.3 8.85E-01
0.8 89
10 3 43.1 8.79E-01
4 43.8 8.38E-01
5 180.9 8.31E-01
Magnitude (ips Pk)
11 6 179.7 8.21E-01
7 183.1 8.21E-01
0.6 12
8 177.5 7.89E-01
13 9 181.6 7.89E-01
14
1615 10 178.4 7.72E-01
11 70.0 6.53E-01
17 18
19
20 12 48.1 5.86E-01
0.4 13 33.4 5.29E-01
14 212.5 4.99E-01
15 210.6 4.88E-01
16 205.9 4.88E-01
17 16.9 4.22E-01
0.2
18 218.4 4.16E-01
19 217.5 4.11E-01
20 199.7 4.03E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00037\G1, 1_P1sv00000 - 237 437.csv
6 43.1 5.71E-01
7 53.1 4.12E-01
1.5 8 215.3 3.81E-01
9 214.7 3.69E-01
10 213.1 3.61E-01
1.2 2
11 213.8 3.54E-01
3
12 218.4 3.41E-01
13 210.9 3.29E-01
0.9 14 116.9 3.22E-01
4 15 222.8 3.10E-01
5 16 225.0 3.04E-01
0.6 6
17 57.5 3.04E-01
7 18 225.9 2.90E-01
9812
10
11
17 14 13 15
16
0.3 19 18
20 19 83.4 2.80E-01
20 228.1 2.79E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00037\G2, 2_P1sv00000 - 237 437.csv
6 219.4 9.71E-01
7 225.9 9.60E-01
0.6 8 220.6 9.38E-01
9 227.2 9.11E-01
11
12 10 227.8 9.10E-01
13 11 70.0 5.09E-01
12 231.9 4.78E-01
0.4 14 13 232.8 4.45E-01
15
16 14 213.8 3.60E-01
1718 15 213.1 3.38E-01
20 19 16 210.9 3.31E-01
0.2 17 205.6 2.80E-01
18 209.7 2.72E-01
19 249.1 2.48E-01
20 209.1 2.48E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00037\G3, 3_P1sv00000 - 237 437.csv
6 73.1 7.81E-01
7 53.1 7.77E-01
2.5 8 70.0 6.92E-01
9 80.9 6.77E-01
10 43.4 6.37E-01
2.0 11 83.8 6.14E-01
12 45.0 4.84E-01
13 66.9 4.26E-01
1.5 14 169.7 3.92E-01
2 15 65.9 3.89E-01
16 59.7 3.56E-01
1.0 5
3 4
7 6 17 122.5 3.16E-01
10 8 9 18 85.6 2.15E-01
11
0.5 12 13 19 173.4 1.73E-01
1615 14
17 20 208.4 1.73E-01
18 19 20
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00037\G4, 4_P1sv00000 - 237 437.csv
Fig: B.6.17
Spectrum TP: 400 (h)
1.1 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 06:29
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 30.9 3.07E-01
2 24.4 2.35E-01
3 32.8 2.13E-01
0.7 4 27.2 1.26E-01
5 55.6 8.94E-02
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00038\G1, 1_P1sv00000 - 400 250.csv
Freq. Magnitude
# Hz ips Pk
1 28.1 3.12E+00
2.5 2 31.3 5.04E-01
3 32.8 3.62E-01
4 82.5 1.17E-01
5 40.3 7.79E-02
Magnitude (ips Pk)
1.0
2
0.5
3
58 674 12 10
9
11
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00038\G2, 2_P1sv00000 - 400 250.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00038\G3, 3_P1sv00000 - 400 250.csv
6 72.2 4.30E-01
7 65.6 4.01E-01
2.0 8 201.6 3.88E-01
9 212.2 3.84E-01
10 90.0 3.74E-01
1.6 11 210.6 3.70E-01
12 195.6 3.37E-01
13 204.4 3.35E-01
1.2 14 196.9 3.31E-01
15 88.1 3.28E-01
2 16 214.1 3.06E-01
0.8
17 118.4 2.94E-01
3 45 18 168.4 2.82E-01
76 10 8 9 19 167.2 2.75E-01
0.4 15 17 18 14 11
1213 16
19 20 20 215.0 2.71E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00038\G4, 4_P1sv00000 - 400 250.csv
Fig: B.6.18
Spectrum TP: 399 (h)
1.1 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 06:40
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 223.8 6.16E-01
2 217.2 4.93E-01
3 255.0 3.80E-01
0.7 4 254.4 3.76E-01
5 255.9 3.49E-01
Magnitude (ips Pk)
1
0.6 6 220.0 3.38E-01
7 221.6 3.30E-01
8 28.1 3.10E-01
0.5 2 9 30.6 3.09E-01
10 258.4 2.59E-01
11 210.9 2.53E-01
0.4 43 12 215.3 2.48E-01
67 5
13 159.7 2.39E-01
89
0.3 14 204.7 2.31E-01
1112 10 15 78.4 2.30E-01
15 13 14
16
17
16 205.3 2.16E-01
0.2 20 18
19
17 209.4 2.02E-01
18 176.3 1.67E-01
19 179.7 1.66E-01
0.1 20 155.0 1.63E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00039\G1, 1_P1sv00000 - 399 450 250.csv
6 87.5 7.06E-01
7 65.9 5.57E-01
1.5 8 75.9 4.08E-01
9 30.6 3.69E-01
10 33.4 2.34E-01
1.2 11 134.1 2.24E-01
12 90.0 1.59E-01
13 255.0 1.36E-01
0.9 14 254.4 1.36E-01
54
6 15 137.5 1.35E-01
16 190.6 1.35E-01
0.6 7
17 255.9 1.35E-01
9 8 18 63.4 1.20E-01
0.3 19 70.3 1.17E-01
10 11
12 20 284.4 1.17E-01
1819 15 16 14
13
17 20
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00039\G2, 2_P1sv00000 - 399 450 250.csv
2
6 244.1 1.04E+00
7 90.0 9.01E-01
1.5 3 8 86.9 8.82E-01
9 208.1 7.53E-01
10 208.8 7.38E-01
1.2 4 11 82.5 6.88E-01
56 12 62.5 6.34E-01
87 13 273.1 5.98E-01
0.9 14 272.5 5.93E-01
9
10
11 15 271.9 5.85E-01
12
14
13
15 16 65.9 5.05E-01
0.6 16 17 19
20 18 17 210.0 4.76E-01
18 298.8 4.74E-01
0.3 19 275.0 4.69E-01
20 275.6 4.55E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00039\G3, 3_P1sv00000 - 399 450 250.csv
6 78.4 5.24E-01
7 79.4 5.21E-01
1.2 8 65.9 5.20E-01
2
9 62.2 4.67E-01
3
10 83.4 4.52E-01
4
11 68.1 4.06E-01
12 109.1 3.47E-01
0.8 13 89.7 3.29E-01
14 110.3 3.13E-01
15 112.2 3.01E-01
8 675
9 10 16 88.1 3.00E-01
11 17 113.1 2.81E-01
0.4 13 12
16 14
15
17
18 86.3 2.63E-01
18
19 19 116.9 1.97E-01
20
20 115.9 1.87E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00039\G4, 4_P1sv00000 - 399 450 250.csv
Fig: B.6.19
Spectrum TP: 300 (h)
1.1 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 06:51
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 32.5 6.96E-01
2 30.3 5.62E-01
1 3 26.6 2.06E-01
0.7 4 41.9 1.72E-01
5 43.4 1.26E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00040\G1, 1_P1sv00000 - 300 450.csv
6 73.4 1.77E-01
7 27.2 1.62E-01
1.5 8 195.3 1.19E-01
9 55.9 1.10E-01
10 76.6 1.07E-01
1.2 11 71.9 1.07E-01
12 56.9 1.06E-01
13 65.0 1.04E-01
0.9 14 115.9 9.89E-02
2
15 193.8 9.01E-02
16 193.1 8.98E-02
0.6 17 60.0 8.77E-02
3 18 59.4 8.60E-02
0.3 19 58.8 8.35E-02
4
7 6 5 20 63.1 8.14E-02
919
1213
201110
18
17 14 8
16
15
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00040\G2, 2_P1sv00000 - 300 450.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00040\G3, 3_P1sv00000 - 300 450.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00040\G4, 4_P1sv00000 - 300 450.csv
Fig: B.6.20
Spectrum TP: 110 (h)
1.1 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 08:28
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 2
1 1 46.6 7.88E-01
2 32.2 7.68E-01
3 33.1 5.94E-01
0.7 4 29.4 5.39E-01
5 26.9 4.80E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00041\G1, 1_P1sv00000 - 110 350.csv
6 80.9 3.05E-01
7 27.2 2.73E-01
0.50 4 8 56.9 2.72E-01
5
9 69.4 2.32E-01
10 70.9 2.19E-01
0.40 11 53.4 2.16E-01
12 180.0 2.06E-01
6 13 48.1 1.94E-01
0.30 7 8 14 50.0 1.91E-01
9 15 72.8 1.78E-01
11 10 12
13
14 16 54.7 1.75E-01
0.20 16 15 17 40.0 1.33E-01
17
19 20 18 18 181.9 1.29E-01
0.10 19 41.6 1.26E-01
20 117.2 1.22E-01
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00041\G2, 2_P1sv00000 - 110 350.csv
2
0.6 6 71.6 2.53E-01
7 70.3 2.49E-01
8 97.8 2.42E-01
0.5 9 76.6 2.23E-01
3 10 137.2 2.05E-01
11 163.1 1.86E-01
0.4 12 77.8 1.78E-01
13 30.6 1.65E-01
0.3 14 138.4 1.63E-01
4
765 8 15 115.3 1.61E-01
9
10 16 116.9 1.58E-01
0.2 13 12
15 14
11 17 95.3 1.52E-01
17 16
18 19
20 18 28.4 1.48E-01
19 289.1 1.46E-01
0.1 20 289.7 1.45E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00041\G3, 3_P1sv00000 - 110 350.csv
Freq. Magnitude
# Hz ips Pk
1 180.0 2.94E+00
2.5 2 177.8 2.14E+00
3 177.2 2.14E+00
32 4 176.3 1.97E+00
5 182.2 1.51E+00
Magnitude (ips Pk)
2.0 4
6 197.8 1.44E+00
7 198.8 1.44E+00
8 196.6 1.34E+00
5 9 149.4 1.29E+00
1.5 67 10 150.6 1.22E+00
8 11 136.9 1.14E+00
9
10 12 189.1 1.13E+00
11 14 12
13
15 1617 13 189.7 1.12E+00
18
1.0 14 151.6 1.12E+00
2019 15 152.5 1.08E+00
16 190.3 1.04E+00
17 194.1 1.02E+00
0.5 18 71.9 9.91E-01
19 138.4 8.45E-01
20 133.4 8.27E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00041\G4, 4_P1sv00000 - 110 350.csv
Fig: B.6.21
Spectrum TP: 150 psv (h)
1.1 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 08:51
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 60.0 3.32E-01
2 175.6 2.63E-01
3 62.5 2.58E-01
0.7 4 41.9 2.40E-01
5 69.1 2.27E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00042\G1, 1_P1sv00000 - 150 109 350.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00042\G2, 2_P1sv00000 - 150 109 350.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00042\G3, 3_P1sv00000 - 150 109 350.csv
6 62.8 4.88E-01
3
7 199.7 4.48E-01
1.0 8 129.7 4.45E-01
9 190.9 4.40E-01
10 148.8 4.27E-01
0.8 11 64.1 4.26E-01
12 139.7 4.21E-01
13 186.9 4.15E-01
0.6 14 148.1 4.14E-01
6 4 5 15 142.2 3.94E-01
11 8 12 10 9 7
1514 1716 13 16 171.6 3.74E-01
0.4 19 20 18
17 164.4 3.68E-01
18 163.8 3.63E-01
0.2 19 60.6 3.62E-01
20 142.8 3.59E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00042\G4, 4_P1sv00000 - 150 109 350.csv
Fig: B.6.22
Spectrum TP: 100 psv (h)
1.1 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 09:00
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 41.9 4.02E-01
2 61.9 3.64E-01
3 60.0 2.92E-01
0.7 4 69.4 2.79E-01
5 62.8 2.69E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00043\G1, 1_P1sv00000 - 100 109.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00043\G2, 2_P1sv00000 - 100 109.csv
5
6 70.0 5.71E-01
0.7 7 69.4 5.59E-01
8 74.1 4.68E-01
0.6 76 9 97.8 3.42E-01
10 117.2 2.86E-01
0.5 8 11 87.8 2.53E-01
12 115.3 2.52E-01
0.4 13 86.3 2.18E-01
9 14 58.8 2.01E-01
15 100.0 1.85E-01
0.3 10
16 33.4 1.67E-01
11 12
14 13 17 30.0 1.66E-01
0.2 17
16
19 18
20
15 18 90.6 1.64E-01
19 30.6 1.63E-01
0.1 20 93.4 1.62E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00043\G3, 3_P1sv00000 - 100 109.csv
21 6 83.8 2.86E-01
0.6
7 93.4 2.79E-01
8 94.1 2.71E-01
0.5 3
9 97.5 2.70E-01
10 62.5 2.69E-01
4 11 61.9 2.61E-01
0.4 12 60.3 2.56E-01
13 96.6 2.42E-01
5 14 80.6 2.41E-01
0.3 10
6 789
11
12 14 13
15 31.6 2.40E-01
15
18 17 16 16 90.3 2.37E-01
19
20
0.2 17 79.7 2.28E-01
18 64.4 2.24E-01
19 137.5 2.05E-01
0.1 20 138.1 1.98E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00043\G4, 4_P1sv00000 - 100 109.csv
Fig: B.6.23
Spectrum TP: 136 (v)
1.1 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 09:10
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 100.0 5.44E-01
2 129.7 4.82E-01
3 98.1 4.76E-01
0.7 4 126.3 3.74E-01
5 126.9 3.56E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00044\G1, 1_P1sv00000 - 136 135.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00044\G2, 2_P1sv00000 - 136 135.csv
4
0.6 6 83.1 4.53E-01
7 81.9 3.83E-01
8 97.2 3.50E-01
0.5 9 66.6 3.46E-01
65 10 98.1 3.26E-01
11 96.3 3.25E-01
0.4 7
12 176.9 3.20E-01
9 8
11
10 12 13 362.2 3.04E-01
16 15 13
14 14 362.8 3.02E-01
0.3 19 18 17
20 15 175.9 3.01E-01
16 33.4 2.95E-01
0.2 17 361.3 2.81E-01
18 208.4 2.69E-01
19 57.5 2.68E-01
0.1 20 86.3 2.54E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00044\G3, 3_P1sv00000 - 136 135.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00044\G4, 4_P1sv00000 - 136 135.csv
Fig: B.6.24
Spectrum TP: 112 (h)
1.1 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 09:19
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 46.6 5.96E-01
2 73.1 5.29E-01
3 26.6 4.99E-01
0.7 4 31.6 4.48E-01
5 83.1 4.21E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00045\G1, 1_P1sv00000 - 112 115.csv
6 76.3 2.98E-01
0.7 7 68.4 2.42E-01
8 45.9 2.35E-01
0.6 9 66.9 2.26E-01
4
10 70.3 2.15E-01
0.5 11 50.0 1.49E-01
12 97.2 1.49E-01
0.4 13 80.3 1.43E-01
14 26.9 1.33E-01
5 15 33.4 1.31E-01
6
0.3 16 97.8 1.30E-01
8 9710 17 89.1 1.30E-01
0.2 18 288.4 1.29E-01
11 1319 12
1415 2017 16 18 19 88.1 1.28E-01
0.1 20 84.7 1.26E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00045\G2, 2_P1sv00000 - 112 115.csv
6 54.4 3.20E-01
7 162.2 3.06E-01
0.6 8 155.9 2.97E-01
9 137.2 2.89E-01
10 57.8 2.80E-01
2
3 11 29.4 2.79E-01
12 160.6 2.50E-01
0.4 54 13 15.9 2.28E-01
6 14 31.9 2.18E-01
9 87
11 10 15 60.6 2.07E-01
12 16 72.8 2.00E-01
13 14
15 17
16 17 71.9 1.93E-01
0.2 20 18 19
18 150.3 1.85E-01
19 332.5 1.83E-01
20 70.3 1.82E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00045\G3, 3_P1sv00000 - 112 115.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00045\G4, 4_P1sv00000 - 112 115.csv
Fig: B.6.25
Spectrum TP: 117 (-h)
1.1 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 09:28
1.0 Setup:
Note:
0.9
Freq. Magnitude
1 # Hz ips Pk
0.8 2 1 46.9 8.10E-01
2 45.9 7.84E-01
3 54.1 4.78E-01
0.7 4 26.9 4.45E-01
5 50.3 3.78E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00046\G1, 1_P1sv00000 - 117 132.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00046\G2, 2_P1sv00000 - 117 132.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00046\G3, 3_P1sv00000 - 117 132.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00046\G4, 4_P1sv00000 - 117 132.csv
Fig: B.6.26
Spectrum TP: 120 (-h)
1.2 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 09:38
Setup:
1 Note:
1.0
Freq. Magnitude
# Hz ips Pk
1 46.6 1.01E+00
2 73.1 7.05E-01
0.8 3 54.4 6.38E-01
4 58.1 6.37E-01
2 5 82.8 6.02E-01
Magnitude (ips Pk)
34 6 153.8 5.47E-01
5 7 81.9 5.46E-01
0.6 8 180.0 5.39E-01
7 6 8
10 9 9 181.3 5.16E-01
11 12 10 33.4 5.12E-01
13
14
11 56.6 4.95E-01
16 15
17 12 176.6 4.84E-01
0.4 19 20 18 13 177.2 4.64E-01
14 175.9 4.62E-01
15 177.8 4.26E-01
16 26.9 4.24E-01
17 80.0 4.03E-01
0.2
18 76.3 3.76E-01
19 16.9 3.68E-01
20 66.9 3.65E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00047\G1, 1_P1sv00000 - 120 130.csv
3
0.6 6 155.9 5.27E-01
5 4 7 58.1 5.18E-01
7 6 8 147.8 4.97E-01
8
0.5 9
9 147.2 4.63E-01
10 10 162.2 4.31E-01
11 11 163.4 4.05E-01
0.4 13 12
14
15 12 176.6 3.91E-01
17 16
18 13 61.3 3.90E-01
19
0.3 20 14 177.2 3.79E-01
15 175.9 3.74E-01
16 177.8 3.49E-01
0.2 17 160.9 3.40E-01
18 160.3 3.25E-01
19 159.1 3.16E-01
0.1 20 149.1 2.93E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00047\G2, 2_P1sv00000 - 120 130.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00047\G3, 3_P1sv00000 - 120 130.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00047\G4, 4_P1sv00000 - 120 130.csv
Fig: B.6.27
Spectrum TP: 310 (-h)
1.1 Channel: 1 P:BMA-Pipe
Date: May 30, 2016 09:48
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 94.7 3.18E-01
2 53.4 2.59E-01
3 30.6 2.41E-01
0.7 4 45.0 1.90E-01
5 97.8 1.88E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00048\G1, 1_P1sv00000 - 310 309.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00048\G2, 2_P1sv00000 - 310 309.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00048\G3, 3_P1sv00000 - 310 309.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00048\G4, 4_P1sv00000 - 310 309.csv
Fig: B.6.28
Spectrum TP: Cylinder 5 (-h)
0.77 Channel: 1 C:BMA-Cylinder
Date: May 30, 2016 09:59
Setup:
0.66 Note:
Freq. Magnitude
# Hz ips Pk
1 176.9 4.11E-01
0.55 2 177.5 3.87E-01
3 180.6 2.76E-01
4 16.3 2.49E-01
5 182.2 2.45E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00049\G1, 1_P1sv00000 - C5 460.csv
Freq. Magnitude
# Hz ips Pk
1 97.2 4.41E-01
0.55 2 57.5 3.84E-01
3 58.4 3.70E-01
4 45.9 3.47E-01
5 55.0 2.99E-01
Magnitude (ips Pk)
1
0.44 6 59.7 2.65E-01
2 7 32.8 2.17E-01
3 8 26.6 2.10E-01
4 9 80.9 2.00E-01
0.33 10 100.0 1.96E-01
5
11 94.4 1.86E-01
6 12 70.0 1.74E-01
13 71.3 1.71E-01
0.22 87 9 14 103.8 1.59E-01
10
11 15 105.0 1.55E-01
12
13
14
15 16 111.3 1.47E-01
20 17
16
1918
17 107.8 1.47E-01
0.11 18 111.9 1.45E-01
19 107.2 1.45E-01
20 75.0 1.39E-01
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00049\G2, 2_P1sv00000 - C5 460.csv
6 130.3 4.83E-01
5 34 7 132.2 4.50E-01
0.50 6 8 131.3 4.32E-01
7 9 30.9 3.66E-01
8
10 33.4 3.48E-01
0.40 9 11 69.7 3.21E-01
10 12 71.6 3.05E-01
11
13 12 13 58.1 3.01E-01
0.30 17 16
18
14
15 14 121.3 2.90E-01
19
20
15 120.6 2.78E-01
16 64.4 2.74E-01
0.20
17 28.4 2.73E-01
18 62.5 2.70E-01
0.10 19 114.4 2.60E-01
20 116.9 2.54E-01
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00049\G3, 3_P1sv00000 - C5 460.csv
Freq. Magnitude
# Hz ips Pk
1 175.9 3.05E-01
0.55 2 175.0 2.93E-01
3 16.6 2.86E-01
4 174.4 2.83E-01
5 173.8 2.68E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00050\G1, 1_P1sv00000 - C3 460 open.csv
Fig: B.6.29
Spectrum TP: Cylinder 3 (v)
0.77 Channel: 2 C:BMA-Cylinder
Date: May 30, 2016 10:10
Setup:
0.66 Note:
Freq. Magnitude
# Hz ips Pk
1 71.9 3.66E-01
0.55 2 72.5 3.54E-01
3 58.1 3.52E-01
4 70.3 3.42E-01
5 58.8 3.42E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00050\G2, 2_P1sv00000 - C3 460 open.csv
Freq. Magnitude
# Hz ips Pk
1 125.6 5.95E-01
0.50 2
2 127.5 4.93E-01
3 3 130.3 4.46E-01
4 4 130.9 4.29E-01
5 133.4 3.80E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00050\G3, 3_P1sv00000 - C3 460 open.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00051\G1, 1_P1sv00000 - 120 130 314.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00051\G2, 2_P1sv00000 - 120 130 314.csv
Fig: B.6.30
Spectrum TP: 314 (h)
2.4 Channel: 3 P:BMA-Pipe
Date: May 30, 2016 10:22
Setup:
1 Note:
2.0
Freq. Magnitude
# Hz ips Pk
1 60.6 2.02E+00
2 110.9 5.68E-01
1.6 3 110.0 5.16E-01
4 158.1 5.14E-01
5 114.1 5.10E-01
Magnitude (ips Pk)
6 116.6 4.69E-01
7 182.2 4.62E-01
1.2 8 175.9 4.50E-01
9 164.1 4.47E-01
10 45.9 4.39E-01
11 45.0 4.16E-01
12 165.0 4.16E-01
0.8 13 161.9 4.07E-01
14 166.6 3.86E-01
2 15 161.3 3.81E-01
35 4
6 9 87 16 54.7 3.77E-01
10
11 12
13
14
15 17 55.9 3.71E-01
0.4 18 19 16
20
17
18 30.6 3.49E-01
19 42.8 3.33E-01
20 30.0 3.28E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00051\G3, 3_P1sv00000 - 120 130 314.csv
6 58.8 5.97E-01
7 71.6 5.63E-01
1.2 8 106.6 4.48E-01
9 115.0 4.04E-01
10 116.6 3.55E-01
3 11 43.1 3.54E-01
12 105.3 3.25E-01
0.8 13 26.6 3.07E-01
4 14 83.1 2.89E-01
5
6
7 15 321.3 2.75E-01
8 16 322.2 2.66E-01
9 17 322.8 2.65E-01
0.4 11 12 10
13 14 18 195.0 2.61E-01
18 15
16
17
19 20 19 66.9 2.09E-01
20 319.4 2.05E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00051\G4, 4_P1sv00000 - 120 130 314.csv
6 158.1 5.25E-01
7 75.3 5.16E-01
0.6 3
4 8 16.6 4.87E-01
56 9 62.8 4.24E-01
7
8 10 162.8 3.31E-01
11 163.4 3.20E-01
9
12 164.4 3.15E-01
0.4 13 69.4 2.99E-01
10
11 14 160.6 2.99E-01
12
13
15 14
18
16
17 15 71.9 2.96E-01
19
20 16 151.9 2.82E-01
0.2 17 150.6 2.81E-01
18 81.9 2.64E-01
19 80.0 2.52E-01
20 80.6 2.49E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00052\G1, 1_P1sv00000 - 330 335 c1.csv
6 62.8 3.84E-01
7 26.9 2.89E-01
1.0 8 69.4 2.68E-01
9 43.1 2.24E-01
10 83.4 2.04E-01
0.8 11 81.9 2.01E-01
2
4
3 12 82.8 1.97E-01
13 78.1 1.95E-01
0.6 14 80.0 1.86E-01
15 45.3 1.82E-01
0.4 6 5 16 80.6 1.80E-01
17 158.4 1.77E-01
7 8 18 37.2 1.72E-01
9 10
11
0.2 1815 1312
14
16 17
19 20
19 156.9 1.71E-01
20 254.7 1.61E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00052\G2, 2_P1sv00000 - 330 335 c1.csv
Fig: B.6.31
Spectrum TP: Cylinder 1 (a)
1.4 Channel: 3 C:BMA-Cylinder
Date: May 30, 2016 10:36
Setup:
1.2 1 Note:
Freq. Magnitude
# Hz ips Pk
1 30.3 1.19E+00
1.0 2 16.9 5.09E-01
3 60.3 3.47E-01
4 76.9 2.43E-01
5 203.4 2.34E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00052\G3, 3_P1sv00000 - 330 335 c1.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00052\G4, 4_P1sv00000 - 330 335 c1.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00053\G1, 1_P1sv00000 - 320 315 c1 335.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00053\G2, 2_P1sv00000 - 320 315 c1 335.csv
Fig: B.6.32
Spectrum TP: Cylinder 1 (v)
0.77 Channel: 3 C:BMA-Cylinder
Date: May 30, 2016 10:47
Setup:
0.66 Note:
Freq. Magnitude
# Hz ips Pk
1 62.2 3.53E-01
0.55 2 46.6 3.45E-01
3 53.1 2.87E-01
4 83.4 2.87E-01
5 76.6 2.83E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00053\G3, 3_P1sv00000 - 320 315 c1 335.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00053\G4, 4_P1sv00000 - 320 315 c1 335.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00054\G1, 1_P1sv00000 - 330 335 c1 336.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00054\G2, 2_P1sv00000 - 330 335 c1 336.csv
Fig: B.6.33
Spectrum TP: Cylinder 1 (-h)
0.77 Channel: 3 C:BMA-Cylinder
Date: May 30, 2016 10:55
Setup:
0.66 Note:
Freq. Magnitude
# Hz ips Pk
1 16.9 3.13E-01
0.55 2 70.6 2.89E-01
3 73.1 2.67E-01
4 181.6 1.88E-01
5 180.9 1.85E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00054\G3, 3_P1sv00000 - 330 335 c1 336.csv
78
9 6 182.5 1.04E+00
1210
11 7 212.5 9.02E-01
0.8 15 13
14
16 17 8 213.4 9.00E-01
1819
20 9 83.8 8.54E-01
10 214.1 8.46E-01
0.6 11 209.7 8.31E-01
12 210.3 8.27E-01
13 209.1 7.91E-01
14 206.9 7.86E-01
0.4 15 81.6 7.77E-01
16 190.3 7.66E-01
17 207.8 7.49E-01
18 76.6 7.33E-01
0.2 19 80.6 7.15E-01
20 188.4 7.09E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00054\G4, 4_P1sv00000 - 330 335 c1 336.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00055\G1, 1_P1sv00000 - 330 335 336.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00055\G2, 2_P1sv00000 - 330 335 336.csv
Fig: B.6.34
Spectrum TP: 336 (-a)
1.1 Channel: 3 P:BMA-Pipe
Date: May 30, 2016 11:04
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 69.7 7.36E-01
1 2 70.9 6.47E-01
3 60.0 6.16E-01
0.7 4 81.9 4.49E-01
2 5 76.9 4.37E-01
Magnitude (ips Pk)
3
0.6 6 73.8 3.48E-01
7 199.7 3.27E-01
8 198.1 3.00E-01
0.5 9 175.6 2.65E-01
54 10 65.6 2.61E-01
11 192.2 2.29E-01
0.4 12 201.6 2.28E-01
6
7 13 182.2 2.08E-01
8 14 177.2 2.07E-01
0.3 9
10 15 57.2 2.07E-01
11 12 16 185.9 2.05E-01
15 14131619
17
20 18
0.2 17 174.4 2.01E-01
18 193.4 2.00E-01
19 190.9 1.99E-01
0.1 20 173.1 1.98E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00055\G3, 3_P1sv00000 - 330 335 336.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00055\G4, 4_P1sv00000 - 330 335 336.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00095\G1, 1_P1sv00000 - Skid Left.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00095\G2, 2_P1sv00000 - Skid Left.csv
Fig: B.6.35
Spectrum TP: Skid Edge Back Left Engine (h)
0.11 Channel: 3 S:BMA-Skid/Foundation
Date: Jun 02, 2016 07:19
0.10 Setup:
Note:
0.09
Freq. Magnitude
# Hz ips Pk
0.08 1 175.6 2.38E-02
2 173.4 2.35E-02
3 177.5 2.10E-02
0.07 4 178.4 2.10E-02
5 215.6 1.80E-02
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00095\G3, 3_P1sv00000 - Skid Left.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00095\G4, 4_P1sv00000 - Skid Left.csv
6 182.2 5.84E-02
7 41.6 5.07E-02
0.09 8 223.1 4.95E-02
9 216.6 4.93E-02
3 4 10 43.1 4.71E-02
11 221.9 4.65E-02
5 12 214.7 4.51E-02
0.06 6
13 224.1 4.38E-02
7 98
10 14 38.1 4.25E-02
1211
13
14 16
18
19
20
15 17 15 160.3 4.23E-02
16 48.8 4.10E-02
0.03 17 220.0 4.08E-02
18 47.8 3.94E-02
19 45.6 3.91E-02
20 47.2 3.91E-02
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00096\G1, 1_P1sv00000 - eng ped Skid Left.csv
6
7 6 43.1 7.40E-02
0.07 7 27.5 7.03E-02
8 9 8 41.6 6.30E-02
0.06 10 11 9 133.4 6.19E-02
12 10 45.6 5.70E-02
13
0.05 14 15 11 71.3 5.67E-02
17 16
18
20
19 12 222.5 5.34E-02
0.04 13 47.2 4.99E-02
14 50.0 4.87E-02
15 224.1 4.71E-02
0.03 16 131.3 4.54E-02
17 120.3 4.46E-02
0.02 18 121.9 4.37E-02
19 123.1 4.23E-02
0.01 20 122.5 4.23E-02
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00096\G2, 2_P1sv00000 - eng ped Skid Left.csv
Fig: B.6.36
Spectrum TP: Skid Edge Back Left Frame (h)
0.11 Channel: 3 S:BMA-Skid/Foundation
Date: Jun 02, 2016 07:38
0.10 Setup:
Note:
0.09
Freq. Magnitude
# Hz ips Pk
0.08 1 542.8 3.98E-02
2 542.2 3.76E-02
3 547.5 3.50E-02
0.07 4 544.1 3.44E-02
5 544.7 3.36E-02
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00096\G3, 3_P1sv00000 - eng ped Skid Left.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00096\G4, 4_P1sv00000 - eng ped Skid Left.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00097\G1, 1_P1sv00000 - skid back.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00097\G2, 2_P1sv00000 - skid back.csv
Fig: B.6.37
Spectrum TP: Skid at Frame Ped. Back Left (v)
0.11 Channel: 3 S:BMA-Skid/Foundation
Date: Jun 02, 2016 07:51
0.10 Setup:
Note:
0.09
Freq. Magnitude
# Hz ips Pk
0.08 1 163.4 7.59E-02
1 2 383.1 6.51E-02
3 83.1 6.18E-02
0.07 4 383.8 6.03E-02
2
5 80.0 6.03E-02
Magnitude (ips Pk)
3
6 5 7 4 6 41.3 6.03E-02
0.06 12 9 810 11
13
15 14 18 17 16 7 200.0 5.98E-02
20 19
8 367.8 5.79E-02
0.05 9 161.3 5.73E-02
10 370.9 5.71E-02
11 382.5 5.71E-02
0.04 12 84.7 5.69E-02
13 369.1 5.66E-02
0.03 14 53.1 5.60E-02
15 30.9 5.53E-02
16 369.7 5.52E-02
0.02 17 166.3 5.50E-02
18 81.6 5.50E-02
19 361.3 5.36E-02
0.01 20 44.1 5.34E-02
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00097\G3, 3_P1sv00000 - skid back.csv
12
1413
1615 6 73.4 6.43E-02
20 17
18
19 7 200.3 6.13E-02
0.05 8 30.9 6.02E-02
9 28.4 5.95E-02
10 216.9 5.95E-02
0.04 11 181.3 5.80E-02
12 224.4 5.74E-02
13 222.8 5.71E-02
0.03 14 219.4 5.66E-02
15 221.9 5.49E-02
16 218.4 5.38E-02
0.02 17 179.1 5.16E-02
18 179.7 5.15E-02
0.01 19 183.1 5.13E-02
20 83.8 5.07E-02
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00097\G4, 4_P1sv00000 - skid back.csv
6 16.6 5.89E-02
7 179.7 5.68E-02
0.09 8 25.0 5.35E-02
9 41.3 4.65E-02
43 10 176.9 4.57E-02
5 11 160.3 4.39E-02
6 12 161.9 4.15E-02
0.06 7
13 45.3 3.86E-02
8
9 14 47.5 3.84E-02
11 10 15 37.5 3.82E-02
12
1613
15 14
20 19 18 17 16 38.1 3.78E-02
0.03 17 213.4 3.67E-02
18 204.1 3.51E-02
19 156.3 3.49E-02
20 138.1 3.46E-02
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00098\G1, 1_P1sv00000 - skid right.csv
0.02 2
43
5
0.01 8 6 9 711 10
1412 15
13
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00098\G2, 2_P1sv00000 - skid right.csv
Fig: B.6.38
Spectrum TP: Skid at Enigne Ped. Back Right (v)
0.11 Channel: 3 S:BMA-Skid/Foundation
Date: Jun 02, 2016 08:11
0.10 1 Setup:
Note:
0.09
Freq. Magnitude
# Hz ips Pk
0.08 2 1 31.6 9.84E-02
2 33.4 7.86E-02
3 43.1 6.12E-02
0.07 4 28.8 6.09E-02
5 27.5 5.74E-02
Magnitude (ips Pk)
4 3
0.06 6 133.8 5.60E-02
5 6 7 44.7 5.35E-02
78 8 45.3 5.31E-02
0.05 9 10 11 9 16.9 4.85E-02
12 13 10 50.0 4.83E-02
14
15
16 11 181.3 4.80E-02
0.04 19 20
18 17
12 25.0 4.45E-02
13 71.3 4.41E-02
0.03 14 217.2 4.22E-02
15 216.6 4.20E-02
16 69.7 4.10E-02
0.02 17 215.3 3.91E-02
18 131.3 3.87E-02
19 47.5 3.85E-02
0.01 20 66.9 3.73E-02
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00098\G3, 3_P1sv00000 - skid right.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00098\G4, 4_P1sv00000 - skid right.csv
8 9
10 6 214.7 6.53E-01
11
12 7 197.2 6.38E-01
0.50 13 14
15 8 64.7 5.64E-01
16 17 9 181.6 5.57E-01
19 18
20 10 116.9 5.48E-01
0.40 11 189.7 5.22E-01
12 190.9 5.02E-01
13 136.3 4.89E-01
0.30 14 211.6 4.86E-01
15 212.2 4.71E-01
16 137.8 4.50E-01
0.20
17 183.8 4.42E-01
18 193.1 4.22E-01
0.10 19 132.5 4.09E-01
20 209.4 4.07E-01
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00099\G1, 1_P1sv00000 - 337 308.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00099\G2, 2_P1sv00000 - 337 308.csv
Fig: B.6.39
Spectrum TP: 308 (-h)
1.00 Channel: 3 P:BMA-Pipe
Date: Jun 02, 2016 08:27
0.90 Setup:
Note:
1
0.80 Freq. Magnitude
# Hz ips Pk
1 108.1 8.30E-01
0.70 2 53.1 3.79E-01
3 72.5 2.11E-01
4 48.1 1.71E-01
0.60 5 114.7 1.71E-01
Magnitude (ips Pk)
6 68.4 1.66E-01
7 410.3 1.64E-01
0.50 8 49.1 1.53E-01
9 158.1 1.48E-01
10 217.2 1.43E-01
0.40 2 11 66.9 1.42E-01
12 71.3 1.40E-01
13 50.0 1.36E-01
0.30 14 113.1 1.30E-01
15 411.9 1.29E-01
3
16 162.8 1.25E-01
0.20 4 6 5 7 17 116.9 1.22E-01
8 9
13 1112 14 16
10
15 18 220.0 1.22E-01
17 18
19
20
0.10 19 219.4 1.20E-01
20 223.1 1.19E-01
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00099\G3, 3_P1sv00000 - 337 308.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00099\G4, 4_P1sv00000 - 337 308.csv
2 6 63.4 4.22E-01
7 165.0 4.10E-01
1.5 8 66.3 3.64E-01
9 165.9 2.93E-01
10 239.7 2.04E-01
1.2 11 242.8 1.89E-01
12 85.9 1.85E-01
13 182.5 1.82E-01
0.9 14 183.1 1.81E-01
3
4 15 326.6 1.80E-01
16 240.3 1.80E-01
0.6
5 17 325.9 1.77E-01
6 7 18 181.6 1.75E-01
8
0.3 9 19 241.6 1.69E-01
20 12 13
14
18 10
11
16
19 15
17 20 59.4 1.69E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00101\G1, 1_P1sv00000 - 438 408.csv
Freq. Magnitude
# Hz ips Pk
1 72.5 1.24E+00
1.0 2 63.4 1.23E+00
3 70.6 7.86E-01
4 66.3 7.33E-01
5 89.7 6.76E-01
Magnitude (ips Pk)
0.8 3
6 81.3 5.34E-01
4
7 77.8 5.15E-01
5 8 137.2 5.00E-01
9 86.6 4.62E-01
0.6 10 76.3 4.02E-01
6 11 88.1 3.94E-01
7 8
9 12 177.2 3.47E-01
10 11
13 181.3 3.46E-01
0.4 14 59.1 3.38E-01
14 16 1213
19 17 15
18 15 175.6 3.33E-01
20
16 68.8 3.23E-01
17 112.5 3.22E-01
0.2 18 179.7 3.11E-01
19 94.7 3.09E-01
20 178.8 3.01E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00101\G2, 2_P1sv00000 - 438 408.csv
Fig: B.6.40
Spectrum TP: 408 (h)
1.8 Channel: 3 P:BMA-Pipe
Date: Jun 02, 2016 08:57
Setup:
1 Note:
1.5
Freq. Magnitude
# Hz ips Pk
1 85.3 1.52E+00
2 175.6 8.83E-01
1.2 3 178.8 5.08E-01
4 177.5 5.00E-01
5 183.4 4.50E-01
Magnitude (ips Pk)
6 180.0 3.68E-01
7 88.1 3.51E-01
0.9 2
8 181.6 2.94E-01
9 89.7 2.93E-01
10 87.2 2.68E-01
11 190.9 2.54E-01
12 77.8 2.50E-01
0.6 13 81.3 2.43E-01
43 14 65.0 2.31E-01
5
15 224.1 2.17E-01
7 6 16 66.3 1.74E-01
9 8 17 332.8 1.44E-01
0.3 10 11
14 1213 15 18 185.9 1.42E-01
16
17
19 186.6 1.31E-01
18
19
20 20 188.8 1.14E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00101\G3, 3_P1sv00000 - 438 408.csv
3
6 207.8 5.51E-01
0.8 7 137.8 3.53E-01
8 136.9 3.31E-01
0.7 9 86.9 3.22E-01
4 10 112.5 2.91E-01
0.6 65 11 176.3 2.89E-01
12 175.6 2.84E-01
0.5 13 180.6 2.11E-01
14 113.8 2.03E-01
0.4 7 15 85.3 2.03E-01
9 8
10 11 16 114.7 1.98E-01
0.3 12
17 155.9 1.79E-01
15 14
16 13 18 129.4 1.77E-01
0.2 20 18 17 19
19 205.3 1.75E-01
0.1 20 116.9 1.69E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00101\G4, 4_P1sv00000 - 438 408.csv
6 80.9 5.66E-01
7 55.3 4.39E-01
1.0 8 72.5 4.34E-01
3 9 76.6 3.82E-01
10 53.1 3.19E-01
0.8 4
11 70.3 2.65E-01
12 44.4 2.37E-01
5
13 71.3 2.27E-01
0.6 6
14 41.6 2.18E-01
7 15 120.3 2.12E-01
8
16 40.0 2.09E-01
0.4 9
10 17 40.9 2.01E-01
12
11 18 133.4 1.96E-01
14
16 13 15 19
17 18 19 132.5 1.95E-01
0.2 20
20 14.1 1.74E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00102\G1, 1_P1sv00000 - 470 360 160 299.csv
Freq. Magnitude
# Hz ips Pk
1.2
1 31.6 1.41E+00
2 26.6 7.69E-01
3 44.4 5.14E-01
1.0 4 45.6 4.76E-01
5 46.3 4.73E-01
Magnitude (ips Pk)
6 13.4 4.46E-01
7 41.6 3.96E-01
0.8 2 8 28.8 3.43E-01
9 63.1 3.25E-01
10 54.7 3.00E-01
0.6 11 69.1 2.74E-01
3
12 40.0 2.40E-01
45 13 72.8 2.28E-01
6 14 65.9 2.22E-01
7
0.4 8
15 76.9 2.19E-01
10
9 16 66.6 2.06E-01
11 17 50.0 1.87E-01
12 14 13
16 15 18 16.3 1.83E-01
0.2 18 17 19
19 60.9 1.68E-01
20
20 116.9 1.37E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00102\G2, 2_P1sv00000 - 470 360 160 299.csv
Fig: B.6.41
Spectrum TP: 160 (a)
1.1 Channel: 3 P:BMA-Pipe
Date: Jun 02, 2016 09:18
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 40.6 1.70E-01
2 41.6 1.64E-01
3 16.3 1.38E-01
0.7 4 269.1 1.29E-01
5 270.0 1.29E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00102\G3, 3_P1sv00000 - 470 360 160 299.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00103\G1, 1_P1sv00000 - 470 360 160 299 op.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00103\G2, 2_P1sv00000 - 470 360 160 299 op.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00103\G3, 3_P1sv00000 - 470 360 160 299 op.csv
Fig: B.6.42
Spectrum TP: 490 (a)
1.1 Channel: 1 P:BMA-Pipe
Date: Jun 02, 2016 10:20
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 40.3 6.95E-01
2 32.2 6.90E-01
3 32.8 6.46E-01
0.7 2 1
4 41.6 4.95E-01
3 5 28.4 3.43E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00104\G1, 1_P1sv00000 - 490 270 290 390.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00104\G2, 2_P1sv00000 - 490 270 290 390.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00104\G3, 3_P1sv00000 - 490 270 290 390.csv
6 62.5 3.03E-01
7 64.1 2.44E-01
2.5 8 135.6 2.04E-01
9 200.6 1.66E-01
10 201.6 1.62E-01
2.0 11 198.8 1.51E-01
12 197.8 1.48E-01
13 73.8 1.18E-01
1.5 14 66.9 1.12E-01
15 132.2 9.69E-02
16 59.1 9.47E-02
1.0
2 17 76.6 8.69E-02
3 18 129.1 8.69E-02
0.5 4 5 19 176.6 8.62E-02
67 20 181.6 8.39E-02
8 9
10
161413
17 15
18 1920 12
11
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00104\G4, 4_P1sv00000 - 490 270 290 390.csv
Fig: B.6.43
Spectrum TP: 490 (h)
4.5 Channel: 1 P:BMA-Pipe
Date: Jun 02, 2016 10:32
4.0 Setup:
Note:
1
Freq. Magnitude
3.5 # Hz ips Pk
1 31.9 3.70E+00
2 77.2 7.16E-01
3.0 3 42.2 6.75E-01
4 40.0 6.17E-01
5 63.8 5.81E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00105\G1, 1_P1sv00000 - 490 270 290 390 h.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00105\G2, 2_P1sv00000 - 490 270 290 390 h.csv
4 6 72.8 5.49E-01
0.6 5
7 6 7 56.9 5.45E-01
8 42.2 4.43E-01
0.5 9 71.3 3.86E-01
8 10 53.4 3.63E-01
11 50.0 3.27E-01
0.4 10
9
12 66.9 2.51E-01
11 13 68.1 2.47E-01
0.3 14 69.1 2.05E-01
12
13 15 40.0 1.94E-01
14 16 79.4 1.65E-01
0.2 15
16
17 116.9 1.55E-01
18 17 18 78.4 1.45E-01
19 20
19 45.3 1.33E-01
0.1 20 158.4 1.29E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00105\G3, 3_P1sv00000 - 490 270 290 390 h.csv
5
6 59.7 5.06E-01
0.8 7 66.3 4.37E-01
8 31.6 3.52E-01
0.7 9 33.1 3.17E-01
10 135.6 3.12E-01
0.6 11 135.0 3.11E-01
6 12 75.6 3.11E-01
0.5 13 50.0 3.09E-01
7
14 45.0 2.15E-01
0.4 8 15 131.9 1.50E-01
9 13 12 11
10 16 130.0 1.43E-01
0.3
17 113.8 1.32E-01
14
0.2 18 77.2 1.29E-01
15
17 16 19 183.1 1.28E-01
20 18 19
0.1 20 47.8 1.16E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00105\G4, 4_P1sv00000 - 490 270 290 390 h.csv
Fig: B.6.44
Spectrum TP: 492 (-v)
1.2 Channel: 1 P:BMA-Pipe
Date: Jun 02, 2016 11:00
1 Setup:
Note:
1.0
Freq. Magnitude
# Hz ips Pk
1 86.6 1.06E+00
2 2 76.6 8.27E-01
0.8 3 44.1 5.81E-01
4 82.8 5.49E-01
5 71.6 4.52E-01
Magnitude (ips Pk)
6 99.7 3.66E-01
7 205.6 3.50E-01
0.6 3 8 181.6 2.17E-01
4
9 162.5 1.63E-01
10 149.1 1.45E-01
5 11 183.8 1.40E-01
12 60.0 1.40E-01
0.4 6 13 79.7 1.33E-01
7
14 155.6 1.31E-01
15 61.3 1.21E-01
16 63.1 1.17E-01
8
17 40.3 1.04E-01
0.2 9
12 13 1014 11
18 90.0 1.03E-01
15
16 19 158.8 9.54E-02
17 18 2019
20 153.4 9.41E-02
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00106\G1, 1_P1sv00000 - 492 398 291 295.csv
6 64.7 2.43E-01
7 66.9 1.77E-01
0.9 8 76.3 1.32E-01
9 69.1 1.17E-01
10 73.4 9.95E-02
11 40.0 7.29E-02
2 12 83.4 7.13E-02
0.6 13 145.9 6.48E-02
14 182.2 6.11E-02
3 15 28.4 5.51E-02
4
16 183.8 5.49E-02
5 17 135.9 5.23E-02
0.3 6 18 33.1 5.10E-02
7
9108
151811 12 17 13 14
16
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00106\G2, 2_P1sv00000 - 492 398 291 295.csv
0.5
0.4
0.3
0.2
2 1
3
0.1 5 4
7 6
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00106\G3, 3_P1sv00000 - 492 398 291 295.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00106\G4, 4_P1sv00000 - 492 398 291 295.csv
Fig: B.6.45
Spectrum TP: 492 (a)
1.5 Channel: 1 P:BMA-Pipe
6 42.8 4.44E-01
0.8 7 40.3 3.58E-01
8 77.5 3.43E-01
0.7 9 41.3 2.88E-01
2 10 75.9 2.65E-01
0.6 11 44.1 2.47E-01
3
12 37.8 2.12E-01
0.5 45
13 55.6 1.99E-01
6
14 115.6 1.96E-01
0.4 7 15 50.0 1.90E-01
8
9 16 53.4 1.85E-01
0.3 11 10 17 116.9 1.69E-01
12 13 14 18 28.4 1.69E-01
0.2 15
18 2016 17 19
19 135.3 1.64E-01
0.1 20 46.9 1.62E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00107\G1, 1_P1sv00000 - 492 398 291 295 a.csv
1 6 73.8 2.63E-01
0.6
7 71.9 2.62E-01
8 182.5 2.55E-01
0.5 9 181.3 2.06E-01
10 100.0 2.00E-01
2 11 69.7 1.78E-01
0.4 3 12 56.3 1.77E-01
4 5 13 83.4 1.64E-01
0.3 14 82.5 1.60E-01
76 8 15 135.6 1.59E-01
9 16 30.6 1.56E-01
10
0.2 12 11 13 17 115.3 1.32E-01
16 14 15
17
1920 18 18 133.4 1.31E-01
19 107.5 1.28E-01
0.1 20 112.2 1.15E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00107\G2, 2_P1sv00000 - 492 398 291 295 a.csv
2 6 68.4 1.73E-01
7 163.4 1.67E-01
0.6 8 71.3 1.23E-01
9 155.6 1.18E-01
10 64.7 1.09E-01
11 59.7 9.78E-02
3 12 149.4 9.64E-02
0.4 13 150.3 9.58E-02
14 148.8 9.52E-02
15 66.9 9.45E-02
16 140.0 8.73E-02
4
0.2 5 17 200.6 8.56E-02
6 7 18 152.8 8.45E-02
8 9 19 138.8 7.94E-02
1110
15 12
1614
13
18 17
19 20 20 175.9 7.78E-02
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00107\G3, 3_P1sv00000 - 492 398 291 295 a.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00107\G4, 4_P1sv00000 - 492 398 291 295 a.csv
Fig: B.6.46
Spectrum TP: 499 (v)
1.3 Channel: 1 P:BMA-Pipe
Date: Jun 02, 2016 11:46
1.2 1 Setup:
Note:
1.1 2
Freq. Magnitude
1.0 # Hz ips Pk
1 77.2 1.15E+00
0.9 2 33.4 1.06E+00
3 44.1 6.45E-01
0.8 4 50.0 5.50E-01
5 82.5 4.89E-01
Magnitude (ips Pk)
6 28.1 4.26E-01
0.7 7 26.6 4.19E-01
3
8 30.6 3.62E-01
0.6 9 35.9 3.46E-01
4
10 31.9 3.11E-01
0.5 5 11 14.7 1.50E-01
76
12 72.5 1.46E-01
0.4 13 65.6 1.44E-01
89 14 142.8 1.38E-01
10 15 37.8 1.36E-01
0.3 16 100.3 1.35E-01
17 99.4 1.29E-01
0.2 18 46.6 1.27E-01
11 15 18 1312 16 14
17 19 98.1 1.25E-01
20 19
0.1 20 84.7 1.12E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00108\G1, 1_P1sv00000 - 499 398 105 Frame Front.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00108\G2, 2_P1sv00000 - 499 398 105 Frame Front.csv
6 70.3 5.45E-01
1.4 7 61.9 5.15E-01
8 62.8 4.89E-01
1.2 9 60.0 4.63E-01
3 10 137.8 3.98E-01
1.0 4 11 136.3 3.26E-01
12 90.0 2.77E-01
0.8 13 166.9 2.32E-01
14 354.4 2.18E-01
5
15 141.3 1.91E-01
0.6 7 6 16 30.9 1.84E-01
98
10 17 54.1 1.83E-01
0.4 11 18 127.5 1.64E-01
12 19 355.0 1.61E-01
13 14
0.2 16 17
20 18 15 19 20 56.3 1.60E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00108\G3, 3_P1sv00000 - 499 398 105 Frame Front.csv
Freq. Magnitude
# Hz ips Pk
1.2
1 63.4 1.43E+00
2 65.0 1.43E+00
3 61.6 1.38E+00
1.0 4 4 77.2 9.80E-01
5 5 68.1 9.36E-01
Magnitude (ips Pk)
6 26.6 5.04E-01
7 116.6 3.98E-01
0.8 8 33.1 3.71E-01
9 27.8 3.38E-01
10 100.3 3.12E-01
0.6 11 82.5 2.90E-01
12 49.4 2.66E-01
6
13 89.1 2.47E-01
14 115.3 2.17E-01
7
0.4 8 15 112.8 2.06E-01
9
10 16 86.3 1.75E-01
11
12 13 17 47.2 1.75E-01
14
15 18 110.6 1.67E-01
0.2 17 16 18 19 19 127.8 1.55E-01
20
20 95.9 1.29E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00109\G1, 1_P1sv00000 - 499 205 105 207.csv
Fig: B.6.47
Spectrum TP: 205 (v)
1.00 Channel: 2 P:BMA-Pipe
Date: Jun 03, 2016 03:44
0.90 Setup:
1 Note:
6 70.3 1.28E-01
7 181.6 1.09E-01
0.50 8 173.8 9.07E-02
9 172.8 8.67E-02
10 27.2 7.43E-02
0.40 2
11 55.6 7.05E-02
12 64.1 7.04E-02
13 41.9 6.12E-02
0.30 14 66.9 6.03E-02
3
4 15 189.1 5.49E-02
0.20 5
6
7
0.10 10 98
13 1112
14 15
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00109\G2, 2_P1sv00000 - 499 205 105 207.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00109\G3, 3_P1sv00000 - 499 205 105 207.csv
0.4
2
0.3
0.2
5 4 3
0.1 6 789
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00109\G4, 4_P1sv00000 - 499 205 105 207.csv
3 6 28.1 3.96E-01
0.6
4 7 71.3 2.95E-01
8 69.4 2.34E-01
0.5 5 9 116.3 2.13E-01
10 26.6 2.11E-01
6 11 14.4 2.04E-01
0.4 12 72.8 1.99E-01
13 40.0 1.93E-01
0.3 7 14 42.2 1.88E-01
15 43.4 1.83E-01
8
11 10 13 9 16 47.5 1.79E-01
12
0.2 14
156
17 119 18 17 38.1 1.69E-01
20 18 83.1 1.67E-01
19 49.1 1.63E-01
0.1 20 89.4 1.44E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00110\G1, 1_P1sv00000 - 499 205 207.csv
Fig: B.6.48
Spectrum TP: 205 (h)
1.1 Channel: 2 P:BMA-Pipe
Date: Jun 03, 2016 03:59
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 13.4 4.00E-01
2 130.3 2.95E-01
3 129.4 2.65E-01
0.7 4 72.2 2.16E-01
5 54.1 1.85E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00110\G2, 2_P1sv00000 - 499 205 207.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00110\G3, 3_P1sv00000 - 499 205 207.csv
0.2 2
3
4
0.1 56
8 12
9 14 7
13 10
11
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00110\G4, 4_P1sv00000 - 499 205 207.csv
6 45.9 3.49E-01
7 59.1 3.38E-01
0.6 8 16.6 3.34E-01
9 38.8 3.33E-01
10 63.8 3.27E-01
11 76.3 3.20E-01
4 5
12 47.8 3.10E-01
0.4 13 40.0 2.78E-01
8 6 7
9 10 11 14 82.8 2.26E-01
12
13 15 56.3 1.77E-01
14 16 80.9 1.72E-01
0.2 17 34.7 1.70E-01
17 15 16
20 18
19 18 227.2 1.60E-01
19 225.9 1.53E-01
20 69.1 1.53E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00011\G4, 4_P1sv00000 - 415 420 C2 -a.csv
Fig: B.6.49
Spectrum TP: 200 (a)
1.8 Channel: 4 P:BMA-Pipe
Date: May 29, 2016 05:02
1 Setup:
Note:
1.5 2
Freq. Magnitude
# Hz ips Pk
1 64.1 1.58E+00
2 75.9 1.46E+00
1.2 3 55.9 9.85E-01
4 61.6 9.63E-01
5 58.8 5.83E-01
Magnitude (ips Pk)
34 6 82.5 3.22E-01
7 33.4 2.80E-01
0.9 8 90.3 2.14E-01
9 44.4 2.12E-01
10 49.7 1.72E-01
11 86.3 1.61E-01
12 217.2 1.54E-01
0.6 5
13 45.9 1.51E-01
14 16.6 1.45E-01
15 30.0 1.44E-01
16 15.3 1.36E-01
6
17 14.4 1.30E-01
0.3 7
9 8 18 28.8 1.23E-01
10
15 13
14 18 11 12 19 182.2 1.17E-01
16
17 19 20 20 212.8 1.15E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00012\G4, 4_P1sv00000 - 415 420 C2 v.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00013\G4, 4_P1sv00000 - 415 414 C2 h.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00064\G2, 2_P1sv00000 - tors loaded engine frame.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00064\G3, 3_P1sv00000 - tors loaded engine frame.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00064\G4, 4_P1sv00000 - tors loaded engine frame.csv
6
7 6 100.0 6.32E-01
0.6
8 9 7 31.6 6.05E-01
8 32.5 5.57E-01
0.5 9 102.8 5.57E-01
10 10 182.2 4.37E-01
11
13 12 11 76.9 4.24E-01
0.4 15 14
12 109.1 4.13E-01
16 13 90.9 4.06E-01
17 14 99.1 3.95E-01
0.3 18
20 19 15 80.3 3.90E-01
16 87.5 3.26E-01
0.2 17 29.4 3.05E-01
18 217.2 2.89E-01
19 179.4 2.58E-01
0.1 20 73.1 2.43E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00066\G1, 1_P1sv00000 - 420 415 c2.csv
Fig: B.6.51
Spectrum TP: 415 (-a)
1.3 Channel: 2 P:BMA-Pipe
Date: Jun 01, 2016 12:50
1.2 1 Setup:
Note:
1.1 2
3
Freq. Magnitude
1.0 # Hz ips Pk
4
5 1 31.6 1.16E+00
0.9 2 76.3 1.09E+00
3 32.5 1.05E+00
0.8 4 73.4 9.30E-01
5 74.1 9.10E-01
Magnitude (ips Pk)
6 82.5 6.58E-01
0.7 6 7 44.1 6.00E-01
7 8 60.9 5.67E-01
0.6 8 9 70.6 3.97E-01
10 80.0 3.04E-01
0.5 11 183.4 3.00E-01
12 101.6 2.95E-01
0.4 9 13 201.9 2.86E-01
14 65.6 2.69E-01
10 12 11 15 39.4 2.56E-01
0.3 1519 14 13
16 16 209.4 2.54E-01
17 2018
17 38.1 2.49E-01
0.2 18 215.3 2.46E-01
19 47.5 2.43E-01
0.1 20 211.6 2.42E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00066\G2, 2_P1sv00000 - 420 415 c2.csv
Freq. Magnitude
# Hz ips Pk
2
1 31.6 1.24E+00
1.0 2 32.8 1.02E+00
3 44.4 5.81E-01
4 45.9 4.44E-01
5 58.1 4.03E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00066\G3, 3_P1sv00000 - 420 415 c2.csv
3
4 6 61.6 6.05E-01
0.8 5 7 68.4 5.68E-01
8 183.1 5.32E-01
0.7 9 81.9 4.52E-01
6 10 54.1 3.83E-01
0.6 7 11 33.4 3.36E-01
8
12 80.3 3.17E-01
0.5 9 13 16.6 3.12E-01
14 175.6 2.65E-01
0.4 10
15 176.6 2.60E-01
11 12
13 16 190.9 2.54E-01
0.3 14
15 16
1920
18 17 17 216.9 2.47E-01
0.2 18 185.9 2.40E-01
19 185.3 2.40E-01
0.1 20 192.5 2.33E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00066\G4, 4_P1sv00000 - 420 415 c2.csv
4.0 2
6 75.0 2.62E+00
3 7 80.0 2.54E+00
8 83.4 2.22E+00
9 115.3 2.02E+00
3.0 4
5 10 70.6 1.90E+00
67 11 54.4 1.76E+00
12 43.4 1.66E+00
8
9
13 183.8 1.50E+00
2.0 11
10 14 56.3 1.49E+00
12 15 57.5 1.48E+00
16 14
15 13
16 46.9 1.43E+00
17
18 17 33.1 1.26E+00
1.0 19 18 143.8 1.15E+00
20
19 5.6 9.48E-01
20 66.9 8.23E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00067\G1, 1_P1sv00000 - c2 436.csv
Fig: B.6.52
Spectrum TP: 436 (v)
9.0 Channel: 2 P:BMA-Pipe
Date: Jun 01, 2016 13:24
8.0 Setup:
1 Note:
Freq. Magnitude
7.0 # Hz ips Pk
2 1 73.4 7.60E+00
2 76.6 6.35E+00
6.0 3 3 75.0 5.83E+00
4 80.0 5.18E+00
5 79.4 5.16E+00
Magnitude (ips Pk)
54
5.0 6 54.4 4.58E+00
6 7 70.6 4.24E+00
7 8 57.5 4.07E+00
98 9 56.3 3.97E+00
4.0 10
10 83.4 3.82E+00
11 43.4 2.98E+00
11 12 149.4 2.44E+00
3.0 13 150.9 1.89E+00
12 14 66.9 1.66E+00
15 152.8 1.49E+00
2.0 13 16 60.6 1.15E+00
14
15 17 46.6 1.14E+00
17 16
18 18 45.9 1.12E+00
19
1.0 20 19 87.2 9.73E-01
20 5.3 8.83E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00067\G2, 2_P1sv00000 - c2 436.csv
5
7 6 6 79.7 1.66E+00
8 7 43.4 1.65E+00
1.5 8 147.2 1.54E+00
9 9 69.7 1.30E+00
10 66.3 1.15E+00
1.2 10
11 83.4 1.04E+00
11 12 64.7 9.41E-01
12 13 57.8 8.66E-01
0.9 13
14 14 150.9 8.22E-01
16
15 15 56.3 6.76E-01
17 16 54.4 6.74E-01
0.6 18 19 17 152.5 5.86E-01
20
18 117.8 5.23E-01
0.3 19 160.3 4.93E-01
20 45.9 4.46E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00067\G3, 3_P1sv00000 - c2 436.csv
2 Freq. Magnitude
# Hz ips Pk
1 57.8 1.22E+00
1.0 3
2 73.4 1.09E+00
3 60.6 9.75E-01
4 75.0 7.94E-01
5 76.3 7.81E-01
Magnitude (ips Pk)
0.8 45
6 63.4 6.79E-01
7 53.8 4.61E-01
6
8 5.6 4.10E-01
9 5.0 3.70E-01
0.6 10 83.4 3.42E-01
11 33.4 3.37E-01
7 12 81.6 2.99E-01
8 13 31.3 2.58E-01
0.4 9 14 7.8 2.51E-01
11 10 15 29.4 1.95E-01
12
13
16 16.6 1.83E-01
14
17 50.0 1.81E-01
0.2 16 15
19 17 18 18 217.2 1.80E-01
20
19 15.3 1.71E-01
20 27.2 1.52E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00067\G4, 4_P1sv00000 - c2 436.csv
2 6 32.5 1.49E+00
7 44.1 1.16E+00
3.0 8 82.5 1.07E+00
9 178.4 1.04E+00
10 45.6 9.82E-01
11 201.9 9.38E-01
12 175.9 8.88E-01
2.0 13 63.1 8.77E-01
3 45 14 71.6 8.24E-01
6
15 28.1 6.82E-01
7 16 38.1 6.24E-01
8 9
1.0 10 11 17 75.3 6.01E-01
1314 12
18 74.1 5.67E-01
15 16
17
18 19
20 19 193.1 5.40E-01
20 192.2 5.27E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00068\G1, 1_P1sv00000 - 414 437 400 420.csv
Fig: B.6.53
Spectrum TP: 437 (h)
5.0 Channel: 2 P:BMA-Pipe
Date: Jun 01, 2016 13:35
1
4.5 Setup:
Note:
6 55.9 1.01E+00
7 72.2 9.95E-01
2.5 8 57.2 9.86E-01
9 70.3 8.46E-01
10 79.1 8.25E-01
2.0 11 81.3 7.21E-01
3 2
12 66.9 5.29E-01
13 86.6 3.99E-01
1.5 14 121.3 3.54E-01
54
15 50.0 3.38E-01
68 7 16 40.0 1.98E-01
1.0 9 10 17 235.9 1.88E-01
11
18 84.7 1.67E-01
12 19 39.1 1.51E-01
0.5 15
13 14 20 90.6 1.36E-01
16
19 1820 17
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00068\G2, 2_P1sv00000 - 414 437 400 420.csv
1.2 12
Date: Jun 01, 2016 13:35
Setup:
Note:
1.1
Freq. Magnitude
1.0 # Hz ips Pk
1 43.1 1.18E+00
0.9 2 43.8 1.17E+00
3
3 68.8 8.55E-01
4
0.8 4 76.6 8.12E-01
5 72.8 7.18E-01
Magnitude (ips Pk)
5 6 71.9 7.01E-01
6
0.7 7 70.6 6.50E-01
7
8 8 75.0 6.30E-01
9
0.6 9 79.1 6.00E-01
10 58.4 4.94E-01
10 11 46.9 4.54E-01
0.5 11
12 12 60.6 4.20E-01
0.4 13 13 31.6 3.84E-01
14 14 45.6 3.60E-01
16 15 15 63.1 3.20E-01
0.3 16 49.1 3.06E-01
17 18 17 83.4 2.19E-01
0.2 19 18 149.4 2.18E-01
20
19 53.1 1.81E-01
0.1 20 65.6 1.48E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00068\G3, 3_P1sv00000 - 414 437 400 420.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00068\G4, 4_P1sv00000 - 414 437 400 420.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00117\G1, 1_P1sv00000 - 320 315.csv
Fig: B.6.54
Spectrum TP: 315 (a)
1.8 Channel: 2 P:BMA-Pipe
Date: Jun 03, 2016 09:04
1 Setup:
2 Note:
1.5
Freq. Magnitude
# Hz ips Pk
1 30.9 1.58E+00
2 31.9 1.51E+00
1.2 3 16.9 5.23E-01
4 83.4 5.17E-01
5 58.4 4.87E-01
Magnitude (ips Pk)
6 72.5 4.11E-01
7 73.1 4.11E-01
0.9 8 57.2 4.08E-01
9 26.9 3.86E-01
10 62.2 3.42E-01
11 77.2 2.89E-01
12 28.4 2.65E-01
0.6 13 43.8 2.31E-01
3 4
5 14 75.9 2.22E-01
8 67 15 45.3 2.12E-01
9
10 16 53.8 2.00E-01
11 17 37.8 1.92E-01
0.3 12
13 14 18 253.4 1.75E-01
1715 16 20 18
19 19 256.3 1.70E-01
20 157.5 1.70E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00117\G2, 2_P1sv00000 - 320 315.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00117\G3, 3_P1sv00000 - 320 315.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00117\G4, 4_P1sv00000 - 320 315.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00118\G1, 1_P1sv00000 - 320 c1.csv
Fig: B.6.55
Spectrum TP: Cylinder 1 (-h)
0.77 Channel: 2 C:BMA-Cylinder
Date: Jun 03, 2016 09:17
Setup:
0.66 Note:
Freq. Magnitude
# Hz ips Pk
1 16.6 3.36E-01
0.55 2 82.5 2.48E-01
3 72.8 2.31E-01
4 32.2 2.13E-01
5 180.9 2.09E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00118\G2, 2_P1sv00000 - 320 c1.csv
Freq. Magnitude
# Hz ips Pk
1 62.5 4.19E-01
0.55 2 55.6 4.13E-01
3 46.3 3.35E-01
4 60.6 2.52E-01
5 80.0 2.50E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00118\G3, 3_P1sv00000 - 320 c1.csv
6 28.4 2.25E-01
7 63.1 2.24E-01
0.6 8 27.2 2.17E-01
9 77.8 1.50E-01
10 202.8 1.43E-01
3 11 211.6 1.33E-01
4 12 181.3 1.24E-01
0.4 13 73.8 1.22E-01
5 14 214.7 1.22E-01
15 214.1 1.21E-01
16 182.8 1.19E-01
86 7
0.2 17 177.8 1.19E-01
9 1011 18 90.0 1.16E-01
13 18 12
17
16
20 14
19 15 19 205.3 1.11E-01
20 179.7 1.10E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00118\G4, 4_P1sv00000 - 320 c1.csv
1 6 214.4 3.35E-01
0.6
7 180.9 3.34E-01
8 200.6 3.30E-01
0.5 2
9 213.8 3.29E-01
3 10 116.9 3.19E-01
4 11 179.4 3.14E-01
0.4 12 205.0 2.88E-01
5 7 8 96 13 216.6 2.81E-01
10 11
0.3 12 13 14 133.1 2.71E-01
14
15
16 15 135.9 2.64E-01
17
18 19 16 136.6 2.63E-01
20
0.2 17 203.8 2.37E-01
18 138.1 2.18E-01
19 211.3 2.08E-01
0.1 20 209.4 2.01E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00119\G1, 1_P1sv00000 - 330 335.csv
Fig: B.6.56
Spectrum TP: 335 (v)
1.1 Channel: 2 P:BMA-Pipe
Date: Jun 03, 2016 09:26
1.0 Setup:
Note:
0.9
Freq. Magnitude
# Hz ips Pk
0.8 1 177.5 4.86E-01
2 73.1 4.80E-01
3 180.9 4.46E-01
0.7 4 46.9 3.65E-01
5 55.6 3.50E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00119\G2, 2_P1sv00000 - 330 335.csv
4
0.6 6 91.9 3.64E-01
7 73.8 3.47E-01
8 76.3 3.34E-01
0.5 9 120.6 3.18E-01
10 77.8 3.10E-01
5 11 62.5 2.98E-01
0.4 6 12 63.4 2.81E-01
78
9 13 134.4 2.76E-01
11 10 14 55.6 2.76E-01
0.3 1412 13
15
16
17 15 131.6 2.56E-01
20 18 19
16 130.9 2.51E-01
0.2 17 130.3 2.45E-01
18 69.7 2.41E-01
19 94.4 2.37E-01
0.1 20 54.1 2.37E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00119\G3, 3_P1sv00000 - 330 335.csv
6 83.4 3.54E-01
7 55.3 3.45E-01
0.50 8 63.4 2.76E-01
3 9 62.5 2.68E-01
4 10 91.9 2.37E-01
0.40 5
11 73.8 2.31E-01
7 6
12 135.3 2.30E-01
13 135.9 2.27E-01
0.30 98 14 118.1 2.25E-01
11 10 14 12
13
15 15 136.6 2.25E-01
18 16 17
20 19 16 75.0 2.21E-01
0.20
17 90.0 2.16E-01
18 16.6 2.15E-01
0.10 19 138.4 2.03E-01
20 66.6 1.98E-01
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00119\G4, 4_P1sv00000 - 330 335.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00120\G1, 1_P1sv00000 - 335 314 336.csv
Fig: B.6.57
Spectrum TP: 314 (-h)
2.4 Channel: 2 P:BMA-Pipe
Date: Jun 03, 2016 09:41
Setup:
1 Note:
2.0
Freq. Magnitude
# Hz ips Pk
1 62.5 2.04E+00
2
2 60.0 1.67E+00
1.6 3 55.9 1.42E+00
4 175.6 6.37E-01
3
5 112.8 6.21E-01
Magnitude (ips Pk)
6 30.9 6.08E-01
7 112.2 5.84E-01
1.2 8 162.5 5.16E-01
9 114.4 5.06E-01
10 181.3 4.96E-01
11 161.3 4.77E-01
12 46.9 4.73E-01
0.8 13 160.0 4.59E-01
6 5 4 14 159.1 4.40E-01
7 15 110.6 4.35E-01
9 8
12 11 10
13 16 166.6 4.18E-01
15 14 16
19 18 17 17 183.4 4.00E-01
0.4 20
18 164.4 3.87E-01
19 116.9 3.83E-01
20 32.8 3.72E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00120\G2, 2_P1sv00000 - 335 314 336.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00120\G3, 3_P1sv00000 - 335 314 336.csv
5
9 67 6 191.3 9.67E-01
12 1011 8 7 190.6 9.56E-01
0.9 16 15 13 1714 8 213.4 9.54E-01
18 19
20 9 83.8 9.54E-01
10 189.7 9.30E-01
11 195.0 9.16E-01
12 150.6 9.15E-01
0.6 13 188.1 8.75E-01
14 210.9 8.58E-01
15 177.5 8.56E-01
16 81.3 8.51E-01
0.3 17 205.0 8.40E-01
18 132.5 8.33E-01
19 178.1 8.24E-01
20 155.6 7.92E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00120\G4, 4_P1sv00000 - 335 314 336.csv
5
6 8 7
6 150.9 1.59E+00
9 7 179.7 1.59E+00
10
1.5 11
8 159.7 1.58E+00
12
13
9 165.3 1.55E+00
1415 10 150.3 1.50E+00
1.2 11 120.9 1.47E+00
16
12 175.9 1.39E+00
17 13 163.8 1.27E+00
0.9 18
14 161.9 1.20E+00
19 20
15 166.9 1.20E+00
16 154.7 1.07E+00
0.6 17 156.9 9.03E-01
18 115.0 8.40E-01
0.3 19 116.6 7.86E-01
20 170.6 7.85E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00070\G1, 1_P1sv00000 - 436 c2.csv
2
6 64.1 8.26E-01
7 177.8 8.22E-01
1.2 3 8 201.6 8.00E-01
4
9 81.6 7.88E-01
5 10 202.2 7.39E-01
11 175.9 7.34E-01
6 7 8 12 183.4 7.04E-01
0.8 9
1112 10 13 120.3 6.85E-01
13
14 14 133.4 6.33E-01
15 16
19 17 18 15 66.6 5.97E-01
20
16 205.3 5.72E-01
0.4 17 74.1 5.50E-01
18 205.9 5.37E-01
19 45.0 5.31E-01
20 76.9 5.16E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00070\G2, 2_P1sv00000 - 436 c2.csv
6 6 69.4 7.98E-01
0.8 78 7 66.9 7.46E-01
8 70.6 7.36E-01
0.7 9
9 130.9 6.77E-01
10 11
12 10 111.9 6.41E-01
0.6 13
11 180.6 6.24E-01
14 15 12 81.6 6.05E-01
0.5 16
13 128.4 5.74E-01
17 18
19 14 83.4 5.06E-01
0.4 20 15 125.9 5.06E-01
16 125.3 4.83E-01
0.3
17 60.0 4.08E-01
0.2 18 123.8 4.01E-01
19 123.1 3.90E-01
0.1 20 167.2 3.53E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00070\G3, 3_P1sv00000 - 436 c2.csv
6 83.4 4.59E-01
7 70.9 4.45E-01
0.9 8 69.1 4.42E-01
9 75.6 4.13E-01
10 53.4 2.66E-01
11 32.8 2.43E-01
43
12 80.3 2.18E-01
0.6 13 48.1 2.12E-01
5 14 48.8 1.95E-01
87 6
9 15 217.2 1.65E-01
16 16.3 1.56E-01
0.3 17 45.3 1.55E-01
11 10 18 45.9 1.51E-01
13 12
14
16 20 17
19 18 15 19 14.4 1.49E-01
20 30.0 1.42E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00070\G4, 4_P1sv00000 - 436 c2.csv
Fig: B.6.59
Spectrum TP: 420 (v)
1.8 Channel: 1 P:BMA-Pipe
Date: Jun 02, 2016 02:17
1 Setup:
Note:
1.5
Freq. Magnitude
# Hz ips Pk
1 72.8 1.58E+00
2 64.1 8.95E-01
1.2 3 75.9 7.72E-01
4 66.3 5.62E-01
5 82.5 5.61E-01
Magnitude (ips Pk)
6 60.0 5.10E-01
2 7 212.2 4.77E-01
0.9 8 209.1 4.62E-01
3 9 210.3 4.54E-01
10 214.1 4.40E-01
11 80.0 4.21E-01
12 217.2 4.19E-01
0.6 4 5 13 58.4 3.84E-01
6
89710 14 205.3 3.73E-01
11 12 15 89.4 3.26E-01
13 14 16 203.4 3.07E-01
15 16
18
19 17 17 315.3 3.03E-01
0.3 20
18 201.9 3.02E-01
19 201.3 2.99E-01
20 314.4 2.69E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00071\G1, 1_P1sv00000 - 420 415.csv
1
Date: Jun 02, 2016 02:17
1.8 Setup:
Note:
4
6 83.8 4.60E-01
7 315.3 3.33E-01
1.0 8 317.2 2.49E-01
9 316.6 2.48E-01
10 177.8 2.42E-01
0.8 11 212.2 2.42E-01
12 182.8 2.35E-01
13 209.4 2.35E-01
0.6 5 14 210.0 2.31E-01
6 15 45.0 2.17E-01
16 214.1 2.15E-01
0.4 7 17 32.5 2.08E-01
1012 11
13
14 98 18 33.4 2.06E-01
18 15
17 19 16
20 19 175.9 2.01E-01
0.2
20 217.2 1.94E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00071\G2, 2_P1sv00000 - 420 415.csv
3
4 6 61.3 3.74E-01
0.8 7 81.6 3.57E-01
8 16.3 3.06E-01
0.7 9 179.7 2.99E-01
10 32.5 2.72E-01
0.6 11 217.2 2.69E-01
5 12 33.4 2.66E-01
0.5 13 175.0 2.65E-01
14 185.0 2.35E-01
0.4 6 7 15 177.2 2.29E-01
8 9 16 200.6 2.29E-01
0.3 10
12 13 11
17 151418 16 17 83.8 2.28E-01
19 20 18 191.6 2.27E-01
0.2
19 44.7 2.10E-01
0.1 20 171.9 2.06E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00071\G3, 3_P1sv00000 - 420 415.csv
3
5 4 6 72.8 5.87E-01
7 33.4 5.24E-01
0.6 6
8 88.8 5.07E-01
7 9 31.9 5.02E-01
9 8
10 10 109.4 4.77E-01
13 1114 12 11 90.9 4.52E-01
15
16 12 178.1 4.44E-01
0.4 13 80.6 4.41E-01
14 95.3 4.39E-01
18 17 15 103.4 4.20E-01
19 20 16 55.9 3.90E-01
0.2 17 217.2 2.94E-01
18 97.2 2.82E-01
19 29.1 2.54E-01
20 99.7 2.50E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00071\G4, 4_P1sv00000 - 420 415.csv
Fig: B.6.60
Spectrum TP: 415 (-a)
1.2 Channel: 1 P:BMA-Pipe
Date: Jun 02, 2016 02:37
1 Setup:
23
Note:
1.0
Freq. Magnitude
4 # Hz ips Pk
5 1 33.4 1.07E+00
2 31.3 1.05E+00
0.8 3 31.9 1.05E+00
6 4 78.1 8.86E-01
5 81.6 8.69E-01
Magnitude (ips Pk)
7
6 73.4 7.30E-01
8
9 7 79.4 6.69E-01
0.6 10
11 8 72.2 6.13E-01
12 9 83.4 5.97E-01
10 44.4 5.86E-01
13 11 43.8 5.81E-01
14
12 60.0 5.16E-01
0.4 13 61.6 4.46E-01
15
1617
14 28.4 4.18E-01
18 20
19
15 65.3 3.51E-01
16 63.1 3.04E-01
17 68.1 3.00E-01
0.2
18 75.6 2.79E-01
19 210.3 2.64E-01
20 209.7 2.63E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00072\G1, 1_P1sv00000 - 415 c2 430.csv
Freq. Magnitude
# Hz ips Pk
1 210.3 3.13E-01
0.55 2 16.6 3.11E-01
3 209.7 3.05E-01
4 182.2 2.74E-01
5 211.9 2.42E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00072\G2, 2_P1sv00000 - 415 c2 430.csv
6 16.6 3.47E-01
0.7 7 38.1 2.95E-01
8 39.1 2.81E-01
0.6 9 57.8 2.68E-01
3
10 83.4 2.59E-01
0.5 11 79.4 2.42E-01
4 12 55.9 2.34E-01
0.4 5 13 58.8 2.30E-01
6 14 63.1 2.26E-01
78 15 48.4 2.20E-01
0.3 9 10 16 59.4 2.20E-01
1512 314 11
116
17 18
17 81.3 1.94E-01
0.2 19
20
18 210.6 1.93E-01
19 228.8 1.90E-01
0.1 20 230.0 1.88E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00072\G3, 3_P1sv00000 - 415 c2 430.csv
Freq. Magnitude
2
# Hz ips Pk
1.2
1 43.8 1.37E+00
2 78.4 1.22E+00
3 81.6 1.02E+00
43
1.0 5
4 79.4 9.99E-01
5 83.1 9.56E-01
Magnitude (ips Pk)
6 6 82.5 8.85E-01
7 45.9 5.96E-01
0.8 8 73.4 3.87E-01
9 57.2 3.67E-01
10 57.8 3.57E-01
0.6 7 11 55.9 3.25E-01
12 31.3 2.93E-01
13 75.6 2.89E-01
14 94.1 2.68E-01
0.4 9 8 15 58.8 2.50E-01
10
11 16 48.4 2.47E-01
12 13
16 15
17
14 17 59.4 2.41E-01
18 18 90.3 2.20E-01
20 19
0.2 19 118.8 1.96E-01
20 87.2 1.91E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00072\G4, 4_P1sv00000 - 415 c2 430.csv
Fig: B.6.61
Spectrum TP: 435 (-a)
1.8 Channel: 1 P:BMA-Pipe
Date: Jun 02, 2016 02:47
Setup:
Note:
1.5 1
Freq. Magnitude
# Hz ips Pk
1 43.8 1.47E+00
2 31.3 8.03E-01
1.2 3 79.4 6.98E-01
4 33.4 6.92E-01
5 81.3 6.26E-01
Magnitude (ips Pk)
6 80.3 6.24E-01
7 83.4 4.60E-01
0.9 8 39.1 4.34E-01
2 9 40.0 4.08E-01
10 38.1 3.89E-01
4 3
11 118.1 3.04E-01
65 12 75.6 2.60E-01
0.6 13 27.8 2.38E-01
7 14 16.6 2.38E-01
8 15 28.4 2.38E-01
109
16 73.8 2.32E-01
11 17 179.1 1.74E-01
0.3 12
14 13
15 16 18 69.4 1.60E-01
20 18
19 17 19 70.3 1.59E-01
20 48.1 1.56E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00073\G1, 1_P1sv00000 - 435 430.csv
6 133.8 3.57E-01
2 7 56.9 3.25E-01
0.9 8 180.6 3.23E-01
9 55.9 3.09E-01
10 90.3 2.65E-01
11 63.1 2.53E-01
12 216.9 2.02E-01
0.6 13 216.3 1.99E-01
14 256.3 1.97E-01
15 214.7 1.97E-01
3 45
6 16 215.3 1.96E-01
97 8
17 259.7 1.95E-01
0.3 11 10
18 87.2 1.95E-01
18 12
15
13
16 1417
1920 19 255.3 1.93E-01
20 260.3 1.92E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00073\G2, 2_P1sv00000 - 435 430.csv
6 61.3 7.65E-01
0.8 6 7 7 76.6 7.47E-01
8 8 60.6 7.27E-01
0.7 119
10 9 74.4 6.60E-01
10 69.4 6.52E-01
0.6 12 11 70.3 6.46E-01
13 12 135.3 5.59E-01
0.5 13 133.8 4.90E-01
14
14 83.4 4.26E-01
0.4 15 15 181.3 3.46E-01
16 16 179.7 2.96E-01
0.3 17
20
18 19 17 179.1 2.79E-01
0.2 18 33.4 2.43E-01
19 117.8 2.42E-01
0.1 20 32.8 2.40E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00073\G3, 3_P1sv00000 - 435 430.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00073\G4, 4_P1sv00000 - 435 430.csv
Fig: B.6.62
Spectrum TP: 414 (h)
3.0 Channel: 1 P:BMA-Pipe
Date: Jun 02, 2016 08:45
2.7 Setup:
Note:
12
2.4 Freq. Magnitude
# Hz ips Pk
1 43.8 2.41E+00
2.1 2 45.3 2.39E+00
3 120.3 7.62E-01
4 86.9 6.94E-01
1.8 5 32.8 5.07E-01
Magnitude (ips Pk)
6 180.3 4.66E-01
7 66.3 4.63E-01
1.5 8 77.8 4.60E-01
9 31.3 4.60E-01
10 181.9 4.51E-01
1.2 11 243.4 4.19E-01
12 183.8 3.88E-01
13 58.4 3.85E-01
0.9 14 63.4 3.67E-01
3
4 15 118.1 3.66E-01
16 176.9 3.43E-01
0.6 5 17 244.7 3.41E-01
9 7 8 6
10
1314 12 11 18 50.0 3.40E-01
18 15 16 17
20 19
0.3 19 133.8 3.27E-01
20 53.1 3.13E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00100\G1, 1_P1sv00000 - 414.csv
6 183.8 1.33E+00
2 7 81.6 1.33E+00
1.5 3 8 181.9 1.32E+00
7 5 846 9 180.3 1.30E+00
9
10 43.4 1.14E+00
1.2 10 11 44.4 1.01E+00
11
13 12 12 173.8 9.82E-01
1415 13 70.6 9.72E-01
0.9 17 16
18 14 192.2 9.07E-01
19
20 15 195.6 8.74E-01
16 196.3 8.67E-01
0.6 17 86.6 8.54E-01
18 197.2 8.26E-01
0.3 19 185.6 7.76E-01
20 198.1 7.20E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00100\G2, 2_P1sv00000 - 414.csv
Freq. Magnitude
0.70 # Hz ips Pk
1 70.3 7.66E-01
2 135.0 5.26E-01
0.60 3 133.4 5.10E-01
4 115.9 4.44E-01
2 5 182.8 4.09E-01
Magnitude (ips Pk)
3
0.50 6 210.6 3.81E-01
4
7 183.8 3.76E-01
8 180.0 3.69E-01
5
0.40 9 127.2 3.60E-01
6
9 87 10 208.1 3.28E-01
10 11 213.8 3.10E-01
1211 12 207.2 3.08E-01
0.30 14 13
15
19 16 17
18 13 153.8 2.89E-01
20
14 65.9 2.85E-01
15 154.4 2.84E-01
0.20 16 205.3 2.79E-01
17 215.0 2.79E-01
18 204.7 2.77E-01
0.10 19 178.1 2.69E-01
20 212.2 2.58E-01
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00100\G3, 3_P1sv00000 - 414.csv
7 8
0.6 9 6 205.3 7.56E-01
7 180.3 6.12E-01
10 8 200.6 6.10E-01
11
0.5 9 200.0 5.82E-01
12
14 13 10 213.8 5.18E-01
15
11 212.2 4.98E-01
0.4 17 16
18
19 12 198.4 4.60E-01
20
13 216.9 4.41E-01
0.3 14 197.5 4.30E-01
15 63.4 4.24E-01
16 185.9 3.88E-01
0.2 17 154.4 3.84E-01
18 185.3 3.76E-01
19 186.6 3.75E-01
0.1 20 177.2 3.59E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00100\G4, 4_P1sv00000 - 414.csv
Fig: B.6.63
Spectrum TP: Frame Front (h)
0.55 Channel: 4 F:BMA-Frame
Date: Jun 02, 2016 11:46
0.50 Setup:
Note:
0.45
Freq. Magnitude
# Hz ips Pk
0.40 1 82.5 2.67E-01
2 83.4 2.44E-01
3 73.1 2.12E-01
0.35 4 32.2 2.12E-01
5 71.9 2.04E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00108\G4, 4_P1sv00000 - 499 398 105 Frame Front.csv
4
5 6 60.6 6.37E-01
0.7 7 214.4 5.65E-01
6
8 212.5 5.10E-01
0.6 7 9 315.0 4.94E-01
8
10 66.3 4.86E-01
0.5 1011 9 11 71.9 4.71E-01
12 210.9 3.69E-01
0.4 13 317.8 3.51E-01
12
13 14 85.3 3.14E-01
14 15 90.0 2.82E-01
0.3 15 16 16 208.1 2.73E-01
18 17
19
20 17 312.2 2.33E-01
0.2 18 88.1 2.32E-01
19 205.9 2.11E-01
0.1 20 206.6 2.07E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00111\G1, 1_P1sv00000 - 420 415 c2 braced wedge.csv
6 6 66.9 6.42E-01
7 83.8 5.28E-01
0.6 8 54.7 5.13E-01
8 7 9 315.3 4.95E-01
9 10 74.7 4.75E-01
10
11
11 75.3 4.71E-01
12 13
12 70.9 4.19E-01
0.4 14
15 16 13 79.7 4.12E-01
17
19 18 14 80.9 3.80E-01
20
15 81.6 3.77E-01
16 177.5 3.75E-01
0.2 17 53.1 3.55E-01
18 317.8 3.28E-01
19 72.8 3.22E-01
20 217.5 3.08E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00111\G2, 2_P1sv00000 - 420 415 c2 braced wedge.csv
Freq. Magnitude
# Hz ips Pk
1 62.5 1.19E+00
1.0 2 60.6 1.18E+00
3 83.8 8.74E-01
3
4 57.5 7.30E-01
5 55.9 6.55E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00111\G3, 3_P1sv00000 - 420 415 c2 braced wedge.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00112\G1, 1_P1sv00000 - 420 415 c2 braced wedge a.csv
Fig: B.6.65
Spectrum TP: 415 (-a)
1.3 Channel: 2 P:BMA-Pipe
6 62.5 5.98E-01
0.7 5 7 60.3 4.64E-01
6
8 65.6 4.42E-01
0.6 9 57.5 3.70E-01
10 64.4 3.61E-01
0.5 7
11 71.9 3.58E-01
8 12 45.0 3.26E-01
0.4 13 215.3 2.99E-01
9 1011
14 213.8 2.90E-01
12
13
14 15 27.5 2.80E-01
0.3 15 18 1716 16 217.2 2.80E-01
20 19
17 212.8 2.66E-01
0.2 18 38.1 2.64E-01
19 75.6 2.50E-01
0.1 20 38.8 2.49E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00112\G2, 2_P1sv00000 - 420 415 c2 braced wedge a.csv
Freq. Magnitude
0.70 2 # Hz ips Pk
3
1 31.3 7.89E-01
2 33.1 6.78E-01
0.60 3 32.2 6.31E-01
4 45.9 4.35E-01
5 57.8 3.94E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00112\G3, 3_P1sv00000 - 420 415 c2 braced wedge a.csv
6 57.5 6.01E-01
7 74.7 5.39E-01
0.9 8 183.4 5.34E-01
9 65.6 5.30E-01
2 10 72.8 4.97E-01
4 3 11 76.6 4.39E-01
6 5 12 16.6 4.02E-01
0.6 13 215.6 3.87E-01
9 7 8
10 14 56.3 3.85E-01
11 15 55.6 3.84E-01
12 14
15 13
16
19 17
18 16 212.2 3.82E-01
20
0.3 17 214.7 3.68E-01
18 214.1 3.57E-01
19 54.4 3.55E-01
20 33.4 3.34E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00113\G1, 1_P1sv00000 - 420 415 c2 braced wedge v.csv
5 6 81.6 5.67E-01
0.6 6 7 57.5 5.08E-01
7 8 56.3 3.92E-01
0.5 9 72.5 3.70E-01
10 118.1 3.36E-01
8
11 47.8 3.22E-01
0.4 9 12 87.5 3.16E-01
11 12
10 13 117.2 3.16E-01
14 13
0.3 15 14 31.3 3.06E-01
16 15 66.6 2.96E-01
17 18 16 64.1 2.61E-01
0.2 19 17 32.8 2.18E-01
20 18 74.1 2.14E-01
19 69.4 1.67E-01
0.1 20 90.0 1.56E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00113\G2, 2_P1sv00000 - 420 415 c2 braced wedge v.csv
Fig: B.6.66
Spectrum TP: 435 (-a)
1.1 Channel: 3 P:BMA-Pipe
Date: Jun 03, 2016 05:59
1.0 Setup:
1 Note:
0.9 Freq. Magnitude
2 # Hz ips Pk
0.8 1 42.8 9.48E-01
2 44.1 8.23E-01
3 3 33.4 7.08E-01
0.7 4 4 31.3 6.83E-01
5 40.0 5.51E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00113\G3, 3_P1sv00000 - 420 415 c2 braced wedge v.csv
4 3 6 55.9 5.56E-01
7 117.8 5.55E-01
0.6 5 8 72.5 5.50E-01
6 8 7
9 10 9 70.3 5.20E-01
11 10 83.4 5.07E-01
11 81.6 4.75E-01
12 12 180.0 3.98E-01
0.4 13 181.6 3.36E-01
13 14 211.6 2.29E-01
15 212.2 2.11E-01
14 16 139.1 2.07E-01
16
17 15 17 139.7 2.00E-01
0.2 192018
18 176.6 1.88E-01
19 161.3 1.79E-01
20 168.4 1.78E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00114\G1, 1_P1sv00000 - 430 435 414 Wedge braced.csv
6 132.2 4.77E-01
1.4 7 180.9 3.21E-01
3 8 181.6 2.93E-01
1.2 9 90.0 2.61E-01
10 254.1 2.18E-01
1.0 11 254.7 2.09E-01
12 217.5 1.99E-01
0.8 13 253.4 1.97E-01
4 14 216.6 1.95E-01
15 215.6 1.92E-01
0.6 16 259.4 1.76E-01
5 6
17 214.4 1.76E-01
0.4 78 18 55.9 1.70E-01
9 19 85.9 1.68E-01
14
12
15 10
1116
13
0.2 18 19 20 17 20 123.8 1.63E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00114\G2, 2_P1sv00000 - 430 435 414 Wedge braced.csv
6 132.2 7.03E-01
7 55.9 6.89E-01
0.9 2 8 78.4 6.85E-01
3 9 70.3 6.65E-01
4 10 55.0 6.03E-01
75 6
9 8 11 75.0 4.13E-01
10 12 181.9 2.81E-01
0.6 13 180.9 2.76E-01
14 213.1 2.35E-01
11 15 214.4 2.31E-01
16 212.5 2.25E-01
0.3 12
13 17 33.4 2.20E-01
17 14
15
16
2018
19 18 215.3 2.19E-01
19 216.6 2.19E-01
20 210.9 2.10E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00114\G3, 3_P1sv00000 - 430 435 414 Wedge braced.csv
Fig: B.6.67
Spectrum TP: 414 (-a)
4.5 Channel: 4 P:BMA-Pipe
Date: Jun 03, 2016 06:13
4.0 Setup:
1 Note:
Freq. Magnitude
3.5 # Hz ips Pk
2 1 60.3 3.82E+00
2 57.8 3.15E+00
3.0 3 62.5 2.18E+00
4 177.5 1.62E+00
5 176.6 1.40E+00
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00114\G4, 4_P1sv00000 - 430 435 414 Wedge braced.csv
Freq. Magnitude
2 # Hz ips Pk
1 71.9 1.25E+00
1.0 3
2 82.5 1.03E+00
3 81.9 9.83E-01
4 60.9 7.33E-01
5 217.2 7.14E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00160\G1, 1_P1sv00000 - 420 415.csv
6 69.4 7.12E-01
5
7 315.3 5.75E-01
0.8 8 80.9 4.57E-01
6 9 53.4 3.83E-01
10 75.3 3.11E-01
0.6 7 11 178.8 2.76E-01
12 217.2 2.68E-01
13 76.6 2.67E-01
8
14 181.3 2.66E-01
0.4 9 15 182.8 2.58E-01
10 16 245.6 2.45E-01
13 11
14
15 12 17 33.4 2.44E-01
17 19 16 18
20 18 317.5 2.41E-01
0.2 19 175.6 2.35E-01
20 85.0 2.19E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00160\G2, 2_P1sv00000 - 420 415.csv
6 31.6 5.32E-01
0.7 7 80.9 5.19E-01
8 33.1 5.05E-01
0.6 3
4 9 83.4 5.00E-01
6 5 10 217.2 4.97E-01
8 7
9 10
0.5 12 11 11 181.3 4.81E-01
13 12 71.6 4.65E-01
0.4 13 178.4 4.21E-01
1514 14 107.2 3.62E-01
1617
15 100.0 3.59E-01
0.3 18
2019 16 93.1 3.21E-01
17 101.6 3.19E-01
0.2 18 97.8 2.83E-01
19 95.9 2.75E-01
0.1 20 90.6 2.69E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00160\G3, 3_P1sv00000 - 420 415.csv
6 65.0 5.36E-01
7 65.6 5.21E-01
0.6 8 84.7 4.62E-01
6 9 83.4 4.10E-01
7
10 69.4 4.08E-01
8
11 215.6 3.22E-01
10 9 12 217.2 3.21E-01
0.4 13 202.2 2.93E-01
11
12 14 39.4 2.77E-01
13
14 15 15 245.6 2.65E-01
18 16 17 19
20 16 86.3 2.60E-01
0.2 17 109.4 2.48E-01
18 46.9 2.46E-01
19 212.8 2.45E-01
20 178.8 2.36E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00160\G4, 4_P1sv00000 - 420 415.csv
Fig: B.6.69
Spectrum TP: 420 (-h)
1.6 Channel: 1 P:BMA-Pipe
Date: Jun 04, 2016 13:11
Setup:
1.4 1 Note:
Freq. Magnitude
# Hz ips Pk
1.2
1 71.6 1.38E+00
2 61.3 1.00E+00
3 57.8 9.57E-01
2
1.0 3
4 65.9 9.13E-01
5 56.3 7.74E-01
Magnitude (ips Pk)
4
6 178.4 6.74E-01
7 175.6 6.07E-01
0.8 5 8 182.2 5.89E-01
9 183.1 5.87E-01
6
10 216.3 4.54E-01
78 11 82.8 4.12E-01
0.6 9
12 82.2 4.08E-01
13 16.6 3.90E-01
10
11 14 78.4 3.88E-01
0.4 13 1412 15 33.4 3.57E-01
15
16 185.0 2.60E-01
16 17 315.6 2.38E-01
20 1819 17
18 166.9 2.36E-01
0.2 19 170.9 2.27E-01
20 31.3 2.23E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00161\G1, 1_P1sv00000 - 420 c2.csv
Freq. Magnitude
# Hz ips Pk
1 215.0 3.43E-01
0.55 2 215.6 3.37E-01
3 217.2 3.22E-01
4 213.4 3.07E-01
5 16.6 2.96E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00161\G2, 2_P1sv00000 - 420 c2.csv
6 81.9 6.05E-01
3
7 83.4 5.64E-01
0.9 4 8 82.8 5.60E-01
9 68.8 3.97E-01
5
10 84.7 3.79E-01
11 70.3 3.60E-01
6 12 71.3 3.43E-01
0.6 87 13 33.4 2.85E-01
14 75.9 2.05E-01
9 10 15 315.6 1.96E-01
11
12 16 31.3 1.94E-01
0.3 13 17 50.0 1.94E-01
18 217.2 1.82E-01
16 17 14 15
18 19 29.4 1.56E-01
20 19
20 15.9 1.48E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00161\G3, 3_P1sv00000 - 420 c2.csv
6 16.6 2.90E-01
0.7 7 48.4 2.88E-01
8 46.9 2.85E-01
0.6 9 28.1 2.70E-01
2 10 38.1 2.59E-01
0.5 11 63.8 2.13E-01
12 221.6 1.94E-01
3
0.4 13 88.1 1.89E-01
14 71.9 1.78E-01
6 574 15 84.1 1.76E-01
0.3 9 10 8 16 220.0 1.72E-01
11
12
17 223.1 1.72E-01
0.2 19 14 1513 16
18120
7 18 217.2 1.66E-01
19 42.5 1.66E-01
0.1 20 226.9 1.66E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00161\G4, 4_P1sv00000 - 420 c2.csv
Fig: B.6.70
Spectrum TP: 430 (v)
1.8 Channel: 1 P:BMA-Pipe
Date: Jun 04, 2016 13:20
Setup:
Note:
1.5 1
2
Freq. Magnitude
# Hz ips Pk
1 79.4 1.46E+00
2 80.9 1.44E+00
1.2 3 83.4 1.06E+00
4 74.7 6.91E-01
3 5 73.4 6.70E-01
Magnitude (ips Pk)
6 132.8 5.29E-01
7 70.3 3.17E-01
0.9 8 60.9 3.01E-01
9 56.3 2.33E-01
10 217.2 2.02E-01
54 11 255.0 1.99E-01
12 182.2 1.99E-01
0.6 13 64.1 1.94E-01
6
14 255.9 1.91E-01
15 261.6 1.89E-01
16 215.9 1.87E-01
8 7 17 249.1 1.75E-01
0.3
9 18 250.6 1.75E-01
13 12 10 1115
19 16 181420
17 19 180.3 1.64E-01
20 260.0 1.61E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00162\G1, 1_P1sv00000 - 430 435.csv
4 6 57.5 7.96E-01
7 80.9 7.88E-01
0.9 8 70.0 7.33E-01
5
6 7 9 79.4 7.20E-01
8 9 10 68.8 6.84E-01
10 11 76.3 5.95E-01
11 12 83.4 4.09E-01
0.6 13 213.8 3.25E-01
14 215.3 3.19E-01
12 15 214.7 3.15E-01
16 33.4 3.09E-01
16 13
14
15
0.3 18 17 17 217.2 2.93E-01
18 31.6 2.84E-01
1920
19 117.5 2.07E-01
20 126.9 2.07E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00162\G2, 2_P1sv00000 - 430 435.csv
3
6 46.6 4.64E-01
7 73.4 3.89E-01
0.6 4 8 75.0 3.85E-01
9 31.6 3.67E-01
10 48.4 3.54E-01
6 5
11 88.1 3.38E-01
12 32.8 2.62E-01
0.4 9
78
13 118.8 1.86E-01
10
11
14 117.5 1.76E-01
12
15 66.9 1.72E-01
16 159.1 1.69E-01
0.2 13 17 64.7 1.31E-01
15 14 16 18 62.2 1.27E-01
19 17
18 20 19 16.9 1.23E-01
20 95.9 1.21E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00162\G3, 3_P1sv00000 - 430 435.csv
4
0.6 6 83.4 5.40E-01
5 7 118.4 2.19E-01
6
8 117.5 2.16E-01
0.5 9 132.8 2.10E-01
10 64.1 1.92E-01
11 88.1 1.90E-01
0.4 12 65.9 1.72E-01
13 27.5 1.70E-01
0.3 14 60.6 1.61E-01
15 16.9 1.59E-01
87 9 16 122.2 1.58E-01
0.2 10 11 17 182.2 1.29E-01
15 13 1412 16
17 18 159.1 1.24E-01
18
19
20
19 160.0 1.22E-01
0.1 20 160.9 1.20E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00162\G4, 4_P1sv00000 - 430 435.csv
Fig: B.6.71
Spectrum TP: 4D Right Wedge Skid R (v)
0.18 Channel: 1 S:BMA-Skid/Foundation
Date: Jun 04, 2016 13:30
1
3 2 Setup:
4
Note:
0.15
5 Freq. Magnitude
6 # Hz ips Pk
7 8 1 61.3 1.62E-01
9 10 2 64.1 1.59E-01
0.12 3 33.4 1.57E-01
4 64.7 1.56E-01
5 79.7 1.40E-01
Magnitude (ips Pk)
6 66.6 1.33E-01
11
7 57.8 1.27E-01
0.09 12 8 81.9 1.27E-01
9 31.3 1.25E-01
15 16 13
14
18 17 19 10 56.3 1.23E-01
20 11 217.2 9.46E-02
12 68.4 8.43E-02
0.06 13 364.4 7.54E-02
14 363.4 7.52E-02
15 219.4 7.41E-02
16 232.5 7.41E-02
17 220.6 7.37E-02
0.03
18 75.0 7.27E-02
19 231.6 7.20E-02
20 221.9 6.87E-02
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00163\G1, 1_P1sv00000 - Skid at Wedges.csv
45 6 83.8 1.55E-01
6 7 57.8 1.33E-01
0.15 8 33.4 1.30E-01
8 7 9 56.3 1.24E-01
9 10 31.3 1.10E-01
0.12 10 11 217.2 1.01E-01
11 12 215.6 9.15E-02
12
13 13 215.0 8.77E-02
0.09 1514
16 14 549.1 8.03E-02
17
18 19
20 15 545.0 8.01E-02
16 544.4 7.95E-02
0.06
17 542.8 7.93E-02
18 543.4 7.83E-02
0.03 19 549.7 7.60E-02
20 75.0 7.33E-02
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00163\G2, 2_P1sv00000 - Skid at Wedges.csv
6 5
0.12 7
6 57.8 1.23E-01
8
7 56.3 1.16E-01
8 33.4 1.09E-01
0.10 9 549.1 9.00E-02
11 10 129
14
13
15 10 217.2 8.93E-02
16
17
19 18
20 11 31.3 8.87E-02
0.08 12 545.0 8.81E-02
13 544.4 8.74E-02
0.06 14 542.8 8.73E-02
15 543.4 8.64E-02
16 549.7 8.53E-02
0.04 17 215.6 8.18E-02
18 550.3 7.97E-02
19 215.0 7.94E-02
0.02 20 547.8 7.86E-02
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00163\G3, 3_P1sv00000 - Skid at Wedges.csv
0.14 1
Date: Jun 04, 2016 13:30
Setup:
0.13 Note:
2
0.12 Freq. Magnitude
# Hz ips Pk
0.11 1 81.6 1.36E-01
2 79.4 1.23E-01
0.10 3 61.3 8.18E-02
4 33.4 7.98E-02
0.09 5 64.7 6.55E-02
Magnitude (ips Pk)
4
3 6 31.3 6.34E-02
0.08 7 215.0 5.93E-02
8 545.0 5.66E-02
0.07 5 9 544.4 5.62E-02
6
7 10 217.2 5.50E-02
0.06 10
11 98 11 213.4 5.47E-02
12 13
14
19 17 161815 12 212.8 5.39E-02
0.05 20 13 549.7 5.38E-02
14 549.1 5.35E-02
0.04 15 550.3 4.99E-02
16 543.8 4.92E-02
0.03
17 74.4 4.90E-02
0.02 18 546.9 4.89E-02
19 56.3 4.88E-02
0.01 20 57.8 4.61E-02
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00163\G4, 4_P1sv00000 - Skid at Wedges.csv
Fig: B.6.72
Spectrum TP: 435 (-h)
1.1 Channel: 1 P:BMA-Pipe
Date: Jun 04, 2016 13:41
1.0 1
Setup:
Note:
0.9 2 3 Freq. Magnitude
# Hz ips Pk
4
0.8 5 1 61.3 9.90E-01
2 64.1 8.75E-01
6
7 3 132.5 8.72E-01
0.7 4 79.4 8.06E-01
5 80.9 7.83E-01
Magnitude (ips Pk)
8
0.6 6 66.9 7.25E-01
7 72.8 6.95E-01
9
8 57.8 6.19E-01
0.5 9 70.3 5.37E-01
10 117.2 3.54E-01
11 115.6 3.21E-01
0.4 12 211.9 3.16E-01
10
11 12
13 181.6 2.70E-01
0.3 14 175.0 2.40E-01
13 15 175.6 2.30E-01
14
15 16 169.4 1.82E-01
0.2 20 16
19
18 17 17 325.6 1.76E-01
18 151.6 1.75E-01
19 150.9 1.75E-01
0.1 20 153.8 1.70E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00164\G1, 1_P1sv00000 - 435 436.csv
6 212.8 1.16E+00
2 7 167.2 1.05E+00
2.0 3
8 191.6 9.72E-01
4 9 217.2 9.50E-01
10 215.0 9.49E-01
1.6 11 192.8 9.33E-01
5 12 215.9 9.27E-01
13 154.1 9.15E-01
1.2 6
14 161.9 8.97E-01
7
8
11 9
10
12 15 155.3 8.78E-01
1314
1715 16
19
18
20 16 189.1 8.71E-01
0.8
17 151.9 8.52E-01
18 200.0 7.87E-01
0.4 19 198.1 7.85E-01
20 199.4 7.80E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00164\G2, 2_P1sv00000 - 435 436.csv
6 202.8 1.12E+00
7 80.9 8.18E-01
0.9 8 122.5 8.05E-01
7 8 9 9 201.9 7.83E-01
11 10 10 211.6 7.13E-01
12
13 11 79.4 7.13E-01
12 175.0 6.72E-01
0.6 17 15 16 14
13 175.6 6.70E-01
1918
20 14 215.9 5.66E-01
15 83.4 5.58E-01
16 187.8 5.58E-01
0.3 17 73.1 5.43E-01
18 215.0 5.33E-01
19 208.4 5.28E-01
20 63.8 4.92E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00164\G3, 3_P1sv00000 - 435 436.csv
6 66.6 8.36E-01
4 7 64.7 8.28E-01
0.9 5
8 122.5 7.62E-01
76
9 181.6 6.85E-01
8
10 124.1 6.65E-01
10 9 11 44.1 5.36E-01
12 71.3 5.30E-01
0.6 11 13 126.6 5.27E-01
12 13
14
15 14 75.0 4.81E-01
19 16 1718 15 72.5 4.77E-01
20
16 68.1 4.33E-01
0.3 17 78.8 4.29E-01
18 83.4 4.25E-01
19 45.0 4.18E-01
20 69.1 4.04E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00164\G4, 4_P1sv00000 - 435 436.csv
Fig: B.6.73
Spectrum TP: Engine Front (h)
0.55 Channel: 1 EW:BMA-Waukesha Engine
Date: Jun 04, 2016 13:52
0.50 Setup:
Note:
0.45 Freq. Magnitude
# Hz ips Pk
0.40 1 1 48.1 3.86E-01
2 2 25.0 3.78E-01
3 16.9 2.77E-01
0.35 4 26.6 1.76E-01
5 33.1 1.34E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00165\G1, 1_P1sv00000 - Engine hv.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00165\G2, 2_P1sv00000 - Engine hv.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00165\G3, 3_P1sv00000 - Engine hv.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00165\G4, 4_P1sv00000 - Engine hv.csv
Fig: B.6.74
Spectrum TP: Engine Back (-a)
0.55 Channel: 1 EW:BMA-Waukesha Engine
Date: Jun 04, 2016 14:01
0.50 Setup:
Note:
0.45 Freq. Magnitude
# Hz ips Pk
0.40 1 33.4 5.94E-02
2 29.1 5.73E-02
3 26.6 5.32E-02
0.35 4 38.8 4.88E-02
5 16.6 4.81E-02
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00166\G1, 1_P1sv00000 - eng a frame front.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00166\G2, 2_P1sv00000 - eng a frame front.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00166\G3, 3_P1sv00000 - eng a frame front.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00166\G4, 4_P1sv00000 - eng a frame front.csv
Fig: B.6.75
Spectrum TP: 414 (h)
2.4 Channel: 1 P:BMA-Pipe
Date: Jun 04, 2016 14:18
Setup:
1 Note:
2.0
Freq. Magnitude
# Hz ips Pk
1 66.6 2.07E+00
2 2 44.1 1.66E+00
1.6 3 65.0 1.40E+00
4 46.9 1.12E+00
3 5 120.9 1.08E+00
Magnitude (ips Pk)
6 88.1 9.61E-01
7 58.8 6.91E-01
1.2 4 8 133.1 6.10E-01
5
9 245.9 5.90E-01
6 10 31.6 5.83E-01
11 245.3 5.58E-01
12 33.4 5.35E-01
0.8 13 32.8 5.30E-01
7
8 14 217.2 5.21E-01
10 9
12
13 11 15 40.0 5.03E-01
15 14
16
16 180.9 4.42E-01
17 18 19 20 17 50.0 4.35E-01
0.4
18 61.3 4.34E-01
19 128.1 4.25E-01
20 247.8 4.02E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00167\G1, 1_P1sv00000 - 414 c4 212.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00167\G2, 2_P1sv00000 - 414 c4 212.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00167\G3, 3_P1sv00000 - 414 c4 212.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00167\G4, 4_P1sv00000 - 414 c4 212.csv
Fig: B.6.76
Spectrum TP: Frame Back (h)
0.55 Channel: 1 F:BMA-Frame
Date: Jun 04, 2016 14:36
0.50 Setup:
Note:
0.45 Freq. Magnitude
# Hz ips Pk
0.40 1 16.9 2.81E-01
2 33.4 2.61E-01
3 179.4 2.14E-01
0.35 4 176.9 2.13E-01
5 178.8 2.06E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00168\G1, 1_P1sv00000 - frame back 438 408.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00168\G2, 2_P1sv00000 - frame back 438 408.csv
6 183.1 3.95E-01
0.7 7 87.8 3.85E-01
8 66.9 3.75E-01
0.6 9 334.7 2.65E-01
2 10 334.1 2.47E-01
0.5 5
3
4
11 225.0 2.29E-01
12 335.9 2.14E-01
0.4 8 7 6 13 215.6 2.05E-01
14 224.1 2.03E-01
15 190.0 1.95E-01
0.3 9 16 151.6 1.83E-01
10
11 12 17 192.8 1.66E-01
15 1314
0.2 16 17
18 19 18 195.0 1.65E-01
20 19 332.2 1.57E-01
0.1 20 337.5 1.34E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00168\G3, 3_P1sv00000 - frame back 438 408.csv
4
6 238.1 3.56E-01
0.8 7 162.8 3.29E-01
8 159.7 2.93E-01
0.7 9 327.8 2.80E-01
10 158.8 2.69E-01
0.6 11 180.9 2.52E-01
12 151.6 2.43E-01
0.5 13 152.2 2.38E-01
5 14 235.9 2.29E-01
0.4 6 15 178.4 2.17E-01
7
8 16 63.4 2.13E-01
0.3 10 11
9
12
13 14 17 183.1 2.00E-01
16 1517
0.2 18 19 20 18 150.3 1.97E-01
19 194.4 1.93E-01
0.1 20 325.9 1.93E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00168\G4, 4_P1sv00000 - frame back 438 408.csv
Fig: B.6.77
Spectrum TP: 320 (a)
1.00 Channel: 1 P:BMA-Pipe
Date: Jun 04, 2016 14:48
0.90 1
Setup:
2 Note:
5 6 158.1 5.08E-01
6 7 83.4 4.54E-01
0.50 8 162.2 4.52E-01
10 11 7 98 9 155.9 4.51E-01
12
10 16.9 4.47E-01
0.40 13 11 71.9 4.46E-01
14
15
16 12 61.6 4.26E-01
17 13 175.9 3.71E-01
0.30 14 114.1 3.59E-01
18
19
20 15 111.9 3.48E-01
16 112.8 3.33E-01
0.20 17 135.0 3.11E-01
18 55.9 2.62E-01
0.10 19 257.5 2.49E-01
20 165.9 2.32E-01
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00169\G1, 1_P1sv00000 - 320 315.csv
6 68.1 5.05E-01
7 66.9 4.41E-01
0.9 8 40.0 3.07E-01
9 55.9 3.03E-01
2 10 72.2 2.98E-01
11 83.4 2.73E-01
3
4 12 45.9 2.47E-01
0.6 13 114.1 2.29E-01
5 6 14 112.8 1.91E-01
7 15 151.9 1.85E-01
16 151.3 1.84E-01
8 9 10 17 111.9 1.80E-01
0.3 12
11
13 18 162.8 1.62E-01
14
17 15
16 19 253.8 1.58E-01
18 19
20
20 254.7 1.51E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00169\G2, 2_P1sv00000 - 320 315.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00169\G3, 3_P1sv00000 - 320 315.csv
0.6 2
6 106.6 3.11E-01
7 105.6 2.59E-01
8 68.4 2.40E-01
0.5 9 49.4 2.14E-01
43 10 70.0 2.14E-01
11 47.2 2.14E-01
0.4 5 12 134.7 2.10E-01
13 175.6 2.05E-01
6
0.3 14 138.8 1.94E-01
8
7 15 140.0 1.85E-01
119 10 12 13 16 153.8 1.77E-01
0.2 14
15 17
16 17 154.4 1.73E-01
181920
18 152.2 1.60E-01
19 156.3 1.60E-01
0.1 20 164.7 1.52E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00169\G4, 4_P1sv00000 - 320 315.csv
Fig: B.6.78
Spectrum TP: 320 (h)
1.1 Channel: 1 P:BMA-Pipe
Date: Jun 04, 2016 14:58
1.0 Setup:
Note:
0.9 Freq. Magnitude
# Hz ips Pk
0.8 1 177.2 5.32E-01
2 63.8 5.23E-01
3 83.4 4.58E-01
0.7 4 106.6 4.07E-01
5 16.6 3.58E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00170\G1, 1_P1sv00000 - 320 c1.csv
Freq. Magnitude
# Hz ips Pk
1 16.6 3.03E-01
0.55 2 177.2 2.83E-01
3 176.6 2.79E-01
4 61.6 2.23E-01
5 180.6 1.83E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00170\G2, 2_P1sv00000 - 320 c1.csv
6 70.9 2.25E-01
7 49.4 2.08E-01
0.50 2 8 33.4 1.48E-01
9 30.3 1.41E-01
10 177.8 1.39E-01
0.40 11 44.4 1.39E-01
3 4 12 16.6 1.35E-01
13 31.9 1.32E-01
0.30 14 15.6 1.29E-01
5 6 15 85.0 1.28E-01
7 16 215.9 1.27E-01
0.20
17 86.3 1.26E-01
98 11
12 13 10 18 90.6 1.14E-01
14 15
1718 16
20 19
0.10 19 213.8 1.14E-01
20 87.5 1.07E-01
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00170\G3, 3_P1sv00000 - 320 c1.csv
6 64.4 3.33E-01
7 40.0 1.50E-01
0.6 8 68.4 1.49E-01
9 177.2 1.44E-01
10 204.7 1.43E-01
11 82.2 1.30E-01
3 2 12 202.2 1.22E-01
0.4 5 4 13 71.3 1.20E-01
6 14 215.6 1.12E-01
15 215.0 1.11E-01
16 183.1 1.09E-01
0.2 17 72.5 1.04E-01
7 8 9 10 18 181.9 1.02E-01
13 11 16 12 15
14 19 80.0 9.52E-02
1719 18 20
20 210.9 9.48E-02
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00170\G4, 4_P1sv00000 - 320 c1.csv
Fig: B.6.79
Spectrum TP: 330 (v)
1.1 Channel: 1 P:BMA-Pipe
Date: Jun 04, 2016 15:07
1.0 Setup:
Note:
0.9 Freq. Magnitude
# Hz ips Pk
0.8 1 83.4 5.82E-01
2 177.2 5.07E-01
3 215.3 3.50E-01
0.7 4 214.4 3.43E-01
5 213.4 3.32E-01
Magnitude (ips Pk)
0.6 1
6 211.3 3.28E-01
7 179.7 3.17E-01
2
8 180.6 3.16E-01
0.5 9 63.8 3.06E-01
10 179.1 2.87E-01
11 62.2 2.79E-01
0.4 12 56.6 2.67E-01
43 13 200.0 2.66E-01
78 65
9 14 200.6 2.64E-01
0.3 1211 10
13
16 1815
19
14
17
20
15 139.1 2.62E-01
16 57.2 2.61E-01
0.2 17 202.2 2.56E-01
18 134.4 2.49E-01
19 133.4 2.42E-01
0.1 20 205.9 2.36E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00171\G1, 1_P1sv00000 - 330 335.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00171\G2, 2_P1sv00000 - 330 335.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00171\G3, 3_P1sv00000 - 330 335.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00171\G4, 4_P1sv00000 - 330 335.csv
Fig: B.6.80
Spectrum TP: 335 (-h)
1.1 Channel: 1 P:BMA-Pipe
Date: Jun 04, 2016 15:18
1.0 Setup:
Note:
0.9 Freq. Magnitude
# Hz ips Pk
0.8 1 135.9 5.60E-01
2 136.6 5.60E-01
3 135.3 5.59E-01
0.7 4 63.8 5.38E-01
5 115.6 5.34E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00172\G1, 1_P1sv00000 - 335 336.csv
12
13
15 14 6 178.1 1.19E+00
19 16 17
18
20 7 194.7 1.10E+00
0.9 8 195.6 1.10E+00
9 193.1 1.10E+00
10 153.8 1.09E+00
11 194.1 1.09E+00
12 202.2 1.01E+00
0.6 13 201.6 1.00E+00
14 213.8 9.83E-01
15 203.8 9.62E-01
16 205.3 9.17E-01
0.3 17 215.0 9.14E-01
18 189.7 9.11E-01
19 191.3 9.11E-01
20 190.6 9.07E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00172\G2, 2_P1sv00000 - 335 336.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00172\G3, 3_P1sv00000 - 335 336.csv
2 6 80.0 4.55E-01
0.6
3 7 164.7 4.22E-01
4 8 163.4 3.81E-01
0.5 9 165.6 3.67E-01
65 10 71.9 3.63E-01
7
11 66.9 3.25E-01
0.4 10
8
9 12 70.3 3.10E-01
11 13 65.9 2.79E-01
12
0.3 13
14 116.9 2.72E-01
15 14
15 65.3 2.69E-01
16 16 31.9 2.30E-01
17 20 18 19
0.2 17 63.4 2.06E-01
18 177.5 2.01E-01
19 272.2 2.00E-01
0.1 20 76.3 1.96E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00172\G4, 4_P1sv00000 - 335 336.csv
Fig: B.6.81
Spectrum TP: 314 (-h)
3.5 Channel: 1 P:BMA-Pipe
Date: Jun 04, 2016 15:41
Setup:
3.0 Note:
1 Freq. Magnitude
# Hz ips Pk
1 61.9 2.73E+00
2.5 2 57.2 1.26E+00
3 56.3 1.04E+00
4 111.9 7.61E-01
5 175.6 6.87E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00173\G1, 1_P1sv00000 - 314 400 399.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00173\G2, 2_P1sv00000 - 314 400 399.csv
6 79.1 6.82E-02
7 44.4 6.71E-02
1.5 8 167.5 6.17E-02
9 40.3 5.26E-02
10 174.7 5.17E-02
1.2 11 81.3 5.07E-02
0.9
0.6
0.3 2
97 4 6113 8 10 5
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00173\G3, 3_P1sv00000 - 314 400 399.csv
3 6 77.8 7.80E-01
7 181.3 4.11E-01
1.2 4 8 189.1 3.64E-01
9 177.8 3.20E-01
5 10 176.6 2.56E-01
11 33.4 2.21E-01
6 12 256.9 2.02E-01
0.8 13 75.0 1.79E-01
14 73.4 1.69E-01
15 284.1 1.60E-01
16 258.1 1.60E-01
7 17 58.1 1.55E-01
0.4 8
9 18 185.3 1.50E-01
10 19 186.3 1.38E-01
11 12
13
17 14 16 15
18
19 20 20 285.0 1.33E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00173\G4, 4_P1sv00000 - 314 400 399.csv
Fig: B.6.82
Spectrum TP: 210 (h)
2.0 Channel: 1 P:BMA-Pipe
Date: Jun 04, 2016 16:02
1.8 1 Setup:
Note:
6 40.6 2.53E-01
7 50.0 1.95E-01
1.0 8 328.1 1.94E-01
9 217.2 1.83E-01
10 223.4 1.83E-01
0.8 11 327.5 1.82E-01
12 224.1 1.76E-01
13 48.1 1.76E-01
0.6 2 14 63.8 1.70E-01
3 15 221.9 1.60E-01
16 57.5 1.54E-01
0.4 4
17 56.6 1.51E-01
65 18 244.4 1.45E-01
0.2 137 17 910
12 8
11 19 16.6 1.45E-01
19 1614 20 15 18 20 159.7 1.37E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00174\G1, 1_P1sv00000 - 210 300 299 460.csv
Freq. Magnitude
3.5 # Hz ips Pk
1 31.9 3.90E+00
2 68.1 6.58E-01
3.0 3 66.9 3.74E-01
4 64.4 2.81E-01
5 53.4 2.32E-01
Magnitude (ips Pk)
6 313.4 3.35E-01
7 312.8 3.15E-01
1.0 8 321.3 3.04E-01
9 318.1 2.99E-01
10 319.1 2.99E-01
0.8 11 320.6 2.98E-01
2 12 319.7 2.95E-01
13 314.7 2.89E-01
0.6 3 14 316.9 2.85E-01
4
15 315.6 2.71E-01
16 111.3 2.40E-01
0.4 5
7611208
911
17 321.9 2.40E-01
13
14
15
16 17 18 18 360.3 2.37E-01
19
20
0.2 19 359.7 2.31E-01
20 361.9 2.31E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00175\G1, 1_P1sv00000 - 210 sg 237 puls.csv
Freq. Magnitude
# Hz ips Pk
1.2
1 111.9 1.38E+00
2 113.1 1.35E+00
3 114.1 8.53E-01
1.0 4 221.3 8.37E-01
5 225.6 8.31E-01
Magnitude (ips Pk)
3 6 220.3 8.27E-01
645 7 224.7 7.89E-01
0.8 7
8 226.9 7.13E-01
8 9 80.9 6.17E-01
10 181.9 6.02E-01
9 10
0.6 11
12
14 13 11 180.9 5.98E-01
15
12 182.8 5.92E-01
16 17 13 228.4 5.84E-01
18 14 183.8 5.81E-01
0.4 15 116.9 5.68E-01
19 20 16 75.9 5.01E-01
17 109.1 4.85E-01
18 77.5 4.24E-01
0.2 19 83.4 3.36E-01
20 232.5 3.36E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00175\G2, 2_P1sv00000 - 210 sg 237 puls.csv
Freq. Magnitude
# Hz ips Pk
1 65.0 1.26E+00
1.0 2 58.1 8.84E-01
2 3
3 73.8 8.83E-01
4 63.1 7.65E-01
5 110.9 5.88E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00180\G1, 1_P1sv00000 - 420 415.csv
Freq. Magnitude
1.2 # Hz ips Pk
1 73.8 1.40E+00
2 85.9 9.33E-01
3 33.4 9.11E-01
1.0 4 31.9 8.61E-01
2 5 69.4 7.29E-01
Magnitude (ips Pk)
3
4 6 60.6 6.99E-01
7 65.3 6.66E-01
0.8 8 58.8 5.69E-01
5
6 9 62.8 5.63E-01
7 10 82.2 5.62E-01
0.6 11 47.8 3.44E-01
89 10
12 202.8 2.90E-01
13 110.9 2.54E-01
14 198.8 2.50E-01
0.4 11
15 28.1 2.49E-01
16 29.1 2.40E-01
12
15
16 13 14 17 200.6 2.35E-01
20 18 17 19 18 191.9 2.27E-01
0.2 19 215.6 2.18E-01
20 89.1 2.18E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00180\G2, 2_P1sv00000 - 420 415.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00180\G3, 3_P1sv00000 - 420 415.csv
6 315.6 3.96E-01
7 316.3 3.69E-01
1.2 8 315.0 3.42E-01
9 85.9 2.66E-01
10 176.9 2.56E-01
11 31.9 2.45E-01
5 12 32.8 2.30E-01
0.8 13 217.2 2.27E-01
14 215.6 2.24E-01
15 179.4 2.12E-01
16 89.1 1.95E-01
0.4 6 17 182.2 1.82E-01
87 18 48.8 1.76E-01
11 9 10
12
16 15 13
14 19 319.7 1.70E-01
18 17 20 19 20 265.9 1.70E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00180\G4, 4_P1sv00000 - 420 415.csv
Fig: B.6.84
Spectrum TP: 420 (-h)
3.0 Channel: 1 P:BMA-Pipe
Date: Jun 05, 2016 16:11
2.7 Setup:
Note:
2.4 1
Freq. Magnitude
# Hz ips Pk
1 73.4 2.31E+00
2.1 2 65.6 1.81E+00
3 70.6 1.30E+00
2 4 69.7 1.26E+00
1.8 5 57.8 1.22E+00
Magnitude (ips Pk)
6 67.8 1.16E+00
7 63.4 8.14E-01
1.5 8 62.5 7.63E-01
3 9 16.6 3.70E-01
5 4 10 176.6 3.12E-01
1.2 6
11 199.1 3.09E-01
12 175.9 3.00E-01
13 32.8 2.83E-01
0.9 7 14 214.7 2.75E-01
8
15 183.8 2.72E-01
16 85.6 2.71E-01
0.6 17 182.5 2.56E-01
9 18 48.8 2.49E-01
13 18 10
12 11 14 19 31.6 2.47E-01
0.3 19 16 1520
17
20 191.6 2.34E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00181\G1, 1_P1sv00000 - 420 c2.csv
Freq. Magnitude
# Hz ips Pk
1 176.6 3.03E-01
0.55 2 175.9 3.01E-01
3 16.6 2.85E-01
4 65.6 2.28E-01
5 66.6 2.19E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00181\G2, 2_P1sv00000 - 420 c2.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00181\G3, 3_P1sv00000 - 420 c2.csv
6 65.3 2.96E-01
7 28.1 2.60E-01
0.6 8 222.2 2.42E-01
9 223.1 2.41E-01
10 223.8 2.41E-01
11 40.0 2.35E-01
3 12 60.3 2.23E-01
0.4 13 220.9 2.20E-01
5 4
14 73.4 2.07E-01
6
15 71.3 2.05E-01
7
11 12
89
10 16 229.4 1.92E-01
14
15 13
0.2 20 1918 17 16 17 66.9 1.89E-01
18 50.0 1.81E-01
19 44.7 1.79E-01
20 35.9 1.79E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00181\G4, 4_P1sv00000 - 420 c2.csv
Fig: B.6.85
Spectrum TP: 430 (v)
1.4 Channel: 1 P:BMA-Pipe
Date: Jun 05, 2016 16:19
1 Setup:
1.2 Note:
Freq. Magnitude
# Hz ips Pk
1 83.8 1.23E+00
1.0 2 65.0 4.67E-01
3 85.3 4.34E-01
4 176.9 4.26E-01
5 62.8 3.84E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00182\G1, 1_P1sv00000 - 430 435.csv
2 Freq. Magnitude
# Hz ips Pk
1.2 1 65.3 1.42E+00
2 66.6 1.25E+00
3 75.0 8.77E-01
1.0 4 74.4 8.70E-01
5 62.2 8.41E-01
Magnitude (ips Pk)
43 6 83.8 7.94E-01
5
6 7 81.9 7.08E-01
0.8 8 68.8 6.49E-01
7 9 57.8 6.42E-01
9 8 10 70.9 5.56E-01
0.6 11 133.8 5.40E-01
10 11 12 176.9 3.72E-01
13 136.3 3.54E-01
14 85.3 2.86E-01
0.4 13 12 15 181.3 2.46E-01
16 179.7 2.43E-01
14
15
16 17 119.1 2.28E-01
17 18 48.8 2.02E-01
18 19
0.2 20
19 89.1 1.98E-01
20 197.5 1.82E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00182\G2, 2_P1sv00000 - 430 435.csv
6 81.9 3.80E-01
7 31.9 3.16E-01
0.9 8 70.6 2.78E-01
9 50.0 2.78E-01
2 10 33.4 2.78E-01
11 76.9 2.33E-01
12 62.8 2.07E-01
0.6 13 110.9 1.96E-01
3 4 14 93.8 1.79E-01
5 15 89.7 1.71E-01
6 16 16.9 1.31E-01
7 17 120.6 1.29E-01
0.3 10 9 8
11 18 119.4 1.28E-01
12 13
1514 19 97.5 1.21E-01
16 1920 1817 20 104.7 1.10E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00182\G3, 3_P1sv00000 - 430 435.csv
6 74.4 2.97E-01
7 40.3 2.36E-01
0.9 8 119.4 2.16E-01
9 81.9 2.15E-01
10 64.7 2.10E-01
11 67.5 2.00E-01
12 49.7 1.97E-01
0.6 2
3 13 76.9 1.75E-01
14 133.8 1.71E-01
4 15 16.9 1.66E-01
16 28.1 1.50E-01
5 6 17 122.2 1.48E-01
0.3 7 18 70.6 1.39E-01
11 9
12 10 8
15 16 13
17 14 19 126.6 1.11E-01
18
19
20 20 127.2 1.08E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00182\G4, 4_P1sv00000 - 430 435.csv
Fig: B.6.86
Spectrum TP: 435 (-h)
1.1 Channel: 1 P:BMA-Pipe
Date: Jun 05, 2016 16:28
1.0 1 Setup:
2 Note:
0.9 43
Freq. Magnitude
# Hz ips Pk
0.8 5
1 65.0 9.84E-01
6 2 66.6 9.32E-01
3 83.4 8.89E-01
0.7 4 82.8 8.85E-01
7
5 74.4 7.68E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00183\G1, 1_P1sv00000 - 435 436.csv
6 165.9 1.04E+00
7 138.8 9.85E-01
2.0 8 166.9 9.64E-01
9 161.9 8.72E-01
4 10 118.8 8.32E-01
1.6 11 125.6 8.32E-01
5
12 159.4 7.86E-01
13 149.7 6.62E-01
1.2 14 145.0 6.58E-01
6
7 8
9
15 144.1 6.48E-01
1011 12 16 151.9 6.23E-01
0.8
1413
15 16 17 155.3 5.59E-01
18
17 20
19 18 154.4 5.59E-01
0.4 19 196.6 5.46E-01
20 195.9 5.42E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00183\G2, 2_P1sv00000 - 435 436.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00183\G3, 3_P1sv00000 - 435 436.csv
6 47.8 9.31E-01
3 2 7 132.5 7.74E-01
1.5 8 61.6 4.93E-01
9 127.8 4.78E-01
10 128.4 4.71E-01
1.2 11 125.6 4.63E-01
4
5 12 83.4 4.06E-01
6 13 82.2 3.97E-01
0.9 14 135.9 3.93E-01
7
15 58.4 3.81E-01
16 114.4 3.40E-01
0.6 8 9
10
11 17 115.6 3.24E-01
15 12
13 14 18 111.9 2.37E-01
16
17
0.3 19 85.6 2.37E-01
19 18 20
20 174.7 2.31E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00183\G4, 4_P1sv00000 - 435 436.csv
Fig: B.6.87
Spectrum TP: 414 (h)
3.0 Channel: 1 P:BMA-Pipe
Date: Jun 05, 2016 16:38
2.7 Setup:
1 Note:
3 6 45.9 1.03E+00
7 57.8 1.01E+00
1.5 4 8 177.5 6.65E-01
9 85.6 5.23E-01
10 132.5 5.17E-01
1.2 11 128.4 4.77E-01
6 75 12 33.1 4.67E-01
13 245.3 4.29E-01
0.9 14 191.9 4.24E-01
8 15 133.8 4.15E-01
16 191.3 4.15E-01
0.6 9 10 17 31.9 4.10E-01
12 11
17 15 14
2016 13
18 19 18 182.2 3.93E-01
0.3 19 246.6 3.91E-01
20 182.8 3.91E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00184\G1, 1_P1sv00000 - 414 C4 212.csv
6 70.6 1.03E+00
7 191.9 9.85E-01
3.0 8 191.3 9.50E-01
9 199.7 8.93E-01
10 174.1 8.84E-01
11 67.5 8.76E-01
2 12 183.4 8.58E-01
2.0 13 195.0 8.54E-01
3 14 182.8 8.51E-01
4 15 194.4 8.44E-01
5 16 195.9 8.33E-01
6 17 196.6 8.31E-01
1.0 11 10 14 87 9
19 12 18
13
15
1720
16 18 193.4 8.23E-01
19 85.6 7.83E-01
20 201.3 7.58E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00184\G2, 2_P1sv00000 - 414 C4 212.csv
Freq. Magnitude
# Hz ips Pk
1.2 1 64.7 1.41E+00
2 62.8 8.97E-01
3 61.3 8.18E-01
1.0 4 69.1 6.10E-01
5 47.2 3.10E-01
Magnitude (ips Pk)
2
6 180.0 2.92E-01
3 7 178.4 2.90E-01
0.8 8 180.9 2.75E-01
9 48.1 2.45E-01
10 111.9 2.43E-01
4 11 110.3 2.42E-01
0.6
12 175.3 2.37E-01
13 182.2 2.28E-01
14 115.3 2.28E-01
0.4 15 83.4 2.22E-01
5 16 56.3 2.19E-01
768
9 11
10 17 57.5 2.05E-01
16 15 14 1213
17 18 27.5 1.80E-01
0.2 18 20 19
19 172.8 1.73E-01
20 74.4 1.72E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00184\G3, 3_P1sv00000 - 414 C4 212.csv
7 6 91.6 7.70E-01
0.7 8 7 62.8 7.05E-01
8 61.6 6.68E-01
0.6 9 9 109.7 5.61E-01
10 87.5 5.05E-01
10
0.5 11 16.6 4.54E-01
11
12 73.8 3.85E-01
0.4 12 13 111.6 3.56E-01
13 14 429.4 3.27E-01
15 16 14
18 17 15 28.1 3.26E-01
0.3 19
20 16 94.1 3.19E-01
17 69.1 3.09E-01
0.2 18 56.3 2.97E-01
19 95.0 2.88E-01
0.1 20 115.0 2.64E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00184\G4, 4_P1sv00000 - 414 C4 212.csv
Fig: B.6.88
Spectrum TP: 320 (a)
1.00 Channel: 1 P:BMA-Pipe
Date: Jun 05, 2016 17:47
0.90 Setup:
1 Note:
6 83.1 4.89E-01
7 114.4 4.66E-01
0.50 6
7 8 115.3 4.50E-01
8 9 76.9 4.13E-01
11 190 10 77.5 4.08E-01
0.40 12
13
15 14 11 16.9 4.01E-01
16
12 71.9 3.91E-01
17 13 149.7 3.61E-01
0.30 1918 14 259.1 3.60E-01
20
15 146.6 3.56E-01
16 138.1 3.24E-01
0.20 17 141.6 3.08E-01
18 156.6 2.73E-01
0.10 19 152.8 2.68E-01
20 28.8 2.55E-01
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00186\G1, 1_P1sv00000 - 320 315.csv
Freq. Magnitude
# Hz ips Pk
1.2 1 31.6 1.38E+00
2 68.8 5.41E-01
3 64.7 4.64E-01
1.0 4 16.9 4.63E-01
5 66.9 4.29E-01
Magnitude (ips Pk)
6 62.5 4.26E-01
7 83.1 4.05E-01
0.8 8 27.8 3.56E-01
9 28.8 3.27E-01
10 29.7 2.87E-01
0.6 11 60.0 2.72E-01
2 12 72.5 2.59E-01
4 3 13 115.3 2.57E-01
65 7
14 114.4 2.52E-01
0.4 8 15 57.2 2.47E-01
9 16 252.5 2.41E-01
10 11 12 13
14 17 77.2 2.32E-01
18 15 17 16
2019 18 46.3 2.27E-01
0.2 19 48.4 2.20E-01
20 40.0 2.04E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00186\G2, 2_P1sv00000 - 320 315.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00186\G3, 3_P1sv00000 - 320 315.csv
6 48.8 2.65E-01
7 53.4 2.39E-01
0.50 8 46.3 2.04E-01
9 177.2 1.83E-01
10 165.3 1.81E-01
0.40 11 138.1 1.78E-01
2 12 115.3 1.64E-01
3
4 13 59.7 1.62E-01
0.30 6 5 14 258.8 1.59E-01
7 15 72.5 1.47E-01
8 16 141.3 1.45E-01
0.20 11 10 9
13 12 14 17 259.7 1.45E-01
15 16 17
20 18 19 18 116.6 1.39E-01
0.10 19 261.3 1.35E-01
20 105.3 1.32E-01
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00186\G4, 4_P1sv00000 - 320 315.csv
Fig: B.6.89
Spectrum TP: 320 (-h)
1.1 Channel: 1 P:BMA-Pipe
Date: Jun 05, 2016 17:55
1.0 Setup:
Note:
0.9 Freq. Magnitude
# Hz ips Pk
0.8 1 64.7 5.90E-01
2 83.1 5.74E-01
3 141.3 5.37E-01
0.7 4 136.9 4.91E-01
5 189.7 4.34E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00187\G1, 1_P1sv00000 - 320 c1.csv
Freq. Magnitude
# Hz ips Pk
1 16.9 3.28E-01
0.55 2 62.8 2.52E-01
3 177.2 2.20E-01
4 177.8 2.15E-01
5 68.4 1.98E-01
Magnitude (ips Pk)
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00187\G2, 2_P1sv00000 - 320 c1.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00187\G3, 3_P1sv00000 - 320 c1.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00187\G4, 4_P1sv00000 - 320 c1.csv
Fig: B.6.90
Spectrum TP: 330 (v)
1.1 Channel: 1 P:BMA-Pipe
Date: Jun 05, 2016 18:02
1.0 Setup:
Note:
0.9 Freq. Magnitude
# Hz ips Pk
0.8 1 83.4 4.46E-01
2 64.4 3.60E-01
3 197.5 3.07E-01
0.7 4 199.1 2.99E-01
5 190.0 2.88E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00188\G1, 1_P1sv00000 - 330 335.csv
6 163.4 3.18E-01
7 156.3 2.73E-01
0.50 8 199.1 2.72E-01
2 9 202.8 2.47E-01
10 157.8 2.46E-01
0.40 11 197.5 2.44E-01
3
4
56 12 57.5 2.33E-01
13 202.2 2.32E-01
0.30 7 8 14 154.7 2.31E-01
10 9
1113
12 17 14
15 16 15 154.1 2.27E-01
19 20 18 16 200.9 2.24E-01
0.20
17 72.8 2.23E-01
18 212.5 2.03E-01
0.10 19 46.3 2.03E-01
20 190.0 2.02E-01
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00188\G2, 2_P1sv00000 - 330 335.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00188\G3, 3_P1sv00000 - 330 335.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00188\G4, 4_P1sv00000 - 330 335.csv
Fig: B.6.91
Spectrum TP: 335 (-h)
1.1 Channel: 1 P:BMA-Pipe
Date: Jun 05, 2016 18:11
1.0 Setup:
Note:
0.9 Freq. Magnitude
# Hz ips Pk
0.8 1 140.6 5.58E-01
2 64.7 5.47E-01
3 139.4 5.10E-01
0.7 4 136.9 4.99E-01
5 138.8 4.98E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00189\G1, 1_P1sv00000 - 335 336.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00189\G2, 2_P1sv00000 - 335 336.csv
6 68.8 7.77E-01
7 140.6 7.62E-01
2.0 8 75.9 7.46E-01
9 139.4 6.88E-01
10 199.4 6.73E-01
1.6 11 155.3 6.51E-01
12 154.4 6.32E-01
2 13 200.6 5.96E-01
1.2 3 14 197.2 5.90E-01
4 15 136.9 5.70E-01
5
68 16 72.8 5.66E-01
0.8 7
9 11
12 10 17 189.4 5.63E-01
16 15
19
20 1714
13
18 18 201.6 5.44E-01
0.4 19 134.1 5.43E-01
20 135.3 5.43E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00189\G3, 3_P1sv00000 - 335 336.csv
Freq. Magnitude
# Hz ips Pk
1.2
1 83.4 1.42E+00
2 71.3 4.81E-01
3 68.8 4.61E-01
1.0 4 72.8 4.58E-01
5 63.1 3.90E-01
Magnitude (ips Pk)
6 64.4 3.84E-01
7 187.5 3.84E-01
0.8 8 189.1 3.49E-01
9 183.8 2.67E-01
10 191.3 2.57E-01
0.6 11 76.6 2.56E-01
12 87.5 2.29E-01
2
34
13 31.6 2.03E-01
14 181.9 1.88E-01
0.4 56 7 15 66.6 1.87E-01
8
16 204.1 1.86E-01
11 9 10 17 203.1 1.76E-01
12
13 14 18 85.3 1.58E-01
0.2 15
18 19 20
16
17
19 128.4 1.51E-01
20 184.7 1.45E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00189\G4, 4_P1sv00000 - 335 336.csv
Fig: B.6.92
Spectrum TP: 314 (-h)
2.4 Channel: 1 P:BMA-Pipe
Date: Jun 05, 2016 18:25
Setup:
1 Note:
2.0 2
Freq. Magnitude
3 # Hz ips Pk
1 62.8 2.03E+00
2 61.9 1.94E+00
1.6 3 64.1 1.81E+00
4 56.9 1.12E+00
5 113.8 9.43E-01
Magnitude (ips Pk)
6 115.3 7.58E-01
7 175.9 5.65E-01
1.2 4 8 46.3 5.35E-01
9 175.0 5.34E-01
5 10 31.6 5.08E-01
11 66.6 5.06E-01
12 165.6 4.76E-01
0.8 6
13 165.0 4.72E-01
14 180.6 4.50E-01
97 15 178.4 4.41E-01
10 8 11
13
12 14
15
16 48.8 3.85E-01
16 17 183.8 3.61E-01
0.4 17
18
19 20 18 182.8 3.53E-01
19 137.8 3.08E-01
20 258.4 3.04E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00190\G1, 1_P1sv00000 - 314 400 399.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00190\G2, 2_P1sv00000 - 314 400 399.csv
6 44.1 8.17E-02
7 167.2 5.53E-02
2.0 8 205.3 5.21E-02
9 174.4 5.08E-02
10 175.0 5.03E-02
1.6
1.2
0.8
0.4
2
34
6 5 7 10
9 8
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00190\G3, 3_P1sv00000 - 314 400 399.csv
6 189.1 3.13E-01
7 191.9 2.46E-01
2.0 8 180.9 2.46E-01
9 73.8 2.27E-01
10 74.7 2.23E-01
1.6 4
11 178.8 2.12E-01
12 284.7 2.02E-01
5
13 57.8 2.00E-01
1.2 14 285.3 1.88E-01
15 158.8 1.86E-01
16 33.1 1.85E-01
0.8
17 256.6 1.78E-01
18 183.8 1.73E-01
0.4 19 182.5 1.66E-01
6
13 190 11819 7 12
14
20 194.1 1.61E-01
16 15 18 20 17
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00190\G4, 4_P1sv00000 - 314 400 399.csv
Fig: B.6.93
Spectrum TP: 210 (h)
2.2 Channel: 1 P:BMA-Pipe
Date: Jun 05, 2016 18:38
2.0 Setup:
1 Note:
1.8 Freq. Magnitude
# Hz ips Pk
1.6 1 33.4 1.86E+00
2 34.7 3.57E-01
3 45.6 3.34E-01
1.4 4 47.2 3.30E-01
5 90.6 2.83E-01
Magnitude (ips Pk)
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00191\G1, 1_P1sv00000 - 210 300 299 460 closed.csv
6 64.1 3.23E-01
2 7 53.1 2.18E-01
1.5 8 71.6 1.68E-01
9 72.2 1.67E-01
10 193.4 1.46E-01
1.2 3 11 360.3 1.42E-01
12 198.4 1.09E-01
13 199.1 1.05E-01
0.9 14 363.4 1.04E-01
15 201.3 1.00E-01
16 364.4 8.96E-02
0.6
17 196.9 8.87E-02
4
18 55.3 8.38E-02
65 19 36.6 8.25E-02
0.3 7
89 1012 11 20 161.9 7.52E-02
19 18 20 13
1715 14
16
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00191\G2, 2_P1sv00000 - 210 300 299 460 closed.csv
6 62.8 3.98E-01
7 79.4 3.94E-01
1.0 8 179.7 3.48E-01
9 66.9 3.13E-01
10 310.9 3.04E-01
0.8 11 312.2 3.00E-01
12 311.6 2.98E-01
13 68.4 2.94E-01
0.6 2
14 94.7 2.81E-01
3
15 313.8 2.79E-01
46 16 313.1 2.76E-01
75
0.4 8
913 10
11
17 102.2 2.54E-01
14 12
15
16
1718
20 19 18 110.6 2.48E-01
0.2 19 314.7 2.48E-01
20 100.9 2.43E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00192\G1, 1_P1sv00000 - 210sg 237 299 460 open.csv
9
6 220.6 8.81E-01
0.7 10 7 80.0 8.23E-01
8 227.8 7.59E-01
0.6 9 180.6 7.43E-01
10 182.5 6.63E-01
0.5 11 230.6 4.62E-01
12 11
13 12 215.6 4.60E-01
14 15
17 16
0.4 19 18 20
13 75.6 4.25E-01
14 76.9 4.11E-01
15 116.9 4.10E-01
0.3 16 216.9 4.01E-01
17 120.0 4.01E-01
0.2 18 214.7 3.91E-01
19 87.8 3.78E-01
0.1 20 231.9 3.76E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00192\G2, 2_P1sv00000 - 210sg 237 299 460 open.csv
4 5 155.9 8.91E-02
6 183.1 8.91E-02
5 6 7 201.6 8.59E-02
0.09 8
7 8 145.6 8.36E-02
9 9 181.9 7.75E-02
10 10 202.5 7.22E-02
13 11 12
14 15 11 136.6 7.00E-02
1916 17 18
20
12 192.5 6.88E-02
0.06 13 72.2 6.82E-02
14 70.3 6.76E-02
15 158.8 6.68E-02
16 78.1 6.57E-02
17 194.1 6.56E-02
0.03
18 204.1 6.55E-02
19 71.3 6.47E-02
20 193.4 6.43E-02
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00049\G4, 4_P1sv00000 - C5 460.csv
43 Freq. Magnitude
# Hz psi Pk-Pk
1 64.4 2.48E+01
38 2 53.4 1.53E+01
3 33.1 1.19E+01
4 70.9 1.11E+01
Magnitude (psi Pk-Pk)
32 5 76.3 8.75E+00
6 28.8 8.50E+00
7 55.9 8.16E+00
27 8 30.3 7.72E+00
1
9 83.1 7.32E+00
10 69.1 6.87E+00
22 11 26.6 6.75E+00
12 79.7 6.46E+00
13 78.8 6.09E+00
16 2
14 13.4 5.74E+00
3 15 86.3 5.39E+00
4 16 41.9 5.06E+00
11
6 7 5 17 42.8 3.83E+00
8
11 10 129 18 43.4 3.79E+00
14 13
5 16 15 19 211.6 3.46E+00
20 17
18 19 20 16.6 3.45E+00
0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00050\G4, 4_P1sv00000 - C3 460 open.csv
5 34.1 8.26E-01
7 6 18.4 7.23E-01
7 40.3 6.64E-01
0.6 8 22.5 5.54E-01
10 89
11
12 9 27.5 5.49E-01
1413 16
15
10 14.1 5.43E-01
19 17 18 11 16.3 5.32E-01
20
12 19.4 5.26E-01
0.4 13 30.0 5.06E-01
14 26.3 5.05E-01
15 25.3 5.04E-01
16 39.4 4.91E-01
0.2 17 21.3 4.67E-01
18 42.8 4.52E-01
19 11.3 4.52E-01
20 12.8 4.28E-01
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00102\G4, 4_P1sv00000 - 470 360 160 299.csv
5 32.2 7.98E-01
6 36.6 7.79E-01
6 7 20.3 7.75E-01
8 31.3 7.72E-01
5 9 32.8 7.62E-01
10 7.8 6.96E-01
4 11 10.0 6.58E-01
12 29.1 6.49E-01
3 13 8.8 6.19E-01
14 26.3 5.83E-01
15 11.3 5.30E-01
3 16 40.3 5.19E-01
17 33.8 5.12E-01
2 18 39.7 4.90E-01
1 19 21.9 4.90E-01
4310 2 7 856
1 11
13 129 16 20 22.5 4.82E-01
15 1920141718
0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00103\G4, 4_P1sv00000 - 470 360 160 299 op.csv
Fig: B.7.2
Spectrum TP: 299 3S Day w/ SS 1000 rpm (Valve Open)
11 Channel: 3 H:DPL-API 618 5th Ed
Date: Jun 03, 2016 10:59
10
Setup:
Note:
9
Freq. Magnitude
8 # Hz psi Pk-Pk
1 16.6 1.67E+00
8
7
Magnitude (psi Pk-Pk)
3
1
2
0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00124\G3, 3_P1sv00000 - Sidestream puls 1000.csv
43 Freq. Magnitude
# Hz psi Pk-Pk
1 33.4 1.13E+01
38 2 66.6 8.07E+00
3 50.3 4.12E+00
4 16.9 4.02E+00
Magnitude (psi Pk-Pk)
32 5 83.1 3.52E+00
6 200.3 2.46E+00
7 116.6 1.87E+00
27
22
16
1
11
2
5 4 3 5
7 6
0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00124\G4, 4_P1sv00000 - Sidestream puls 1000.csv
2
1
1
32
0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00125\G3, 3_P1sv00000 - Sidestream puls 900.csv
43 Freq. Magnitude
# Hz psi Pk-Pk
1 60.9 9.63E+00
38 2 60.0 9.38E+00
3 30.0 9.24E+00
4 75.6 8.07E+00
Magnitude (psi Pk-Pk)
32 5 15.0 3.49E+00
6 45.0 3.29E+00
7 45.9 3.10E+00
27
22
16
11 3 21
4
5 5 67
0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00125\G4, 4_P1sv00000 - Sidestream puls 900.csv
Fig: B.7.3
Spectrum TP: 299 3S Day w/ SS 800 rpm (Valve Open)
11 Channel: 3 H:DPL-API 618 5th Ed
Date: Jun 03, 2016 11:25
10
Setup:
Note:
9
Freq. Magnitude
8 # Hz psi Pk-Pk
1 66.6 1.36E+00
8 2 68.8 1.16E+00
3 67.8 9.87E-01
7 4 53.4 9.44E-01
Magnitude (psi Pk-Pk)
5 47.2 6.78E-01
6 49.1 6.59E-01
6 7 47.8 6.07E-01
8 63.8 5.79E-01
5 9 63.1 5.65E-01
10 44.4 5.02E-01
4 11 62.2 5.01E-01
12 50.9 4.71E-01
3 13 13.1 4.56E-01
14 40.0 4.39E-01
15 50.3 4.35E-01
3 16 61.3 4.10E-01
17 43.4 4.06E-01
2 1 18 70.9 3.80E-01
2 19 41.3 3.74E-01
4 3
1 13
56 98
10715 11 18
12 16
20 42.8 3.72E-01
14
17
19
20
0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00126\G3, 3_P1sv00000 - Sidestream puls 800.csv
43 Freq. Magnitude
# Hz psi Pk-Pk
1 53.4 1.19E+01
38 2 26.6 7.43E+00
3 13.4 5.86E+00
4 66.6 5.29E+00
Magnitude (psi Pk-Pk)
32 5 40.0 4.28E+00
6 80.0 2.37E+00
7 93.4 2.12E+00
27 8 200.0 1.91E+00
22
16
1
11
2
3 4
5 5
6 7 8
0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00126\G4, 4_P1sv00000 - Sidestream puls 800.csv
5 217.2 8.87E-02
4 6 197.2 8.81E-02
7 218.8 8.61E-02
0.09 6 5
7 89 8 270.3 8.58E-02
9 270.9 8.51E-02
10 10 271.9 7.28E-02
11
11 267.5 6.42E-02
12 259.7 5.65E-02
0.06 13 12 13 215.3 5.45E-02
16 14 15
17 14 258.8 5.10E-02
20 18 19 15 299.4 5.05E-02
16 212.5 5.00E-02
0.03 17 284.1 4.77E-02
18 205.6 4.34E-02
19 256.9 4.21E-02
20 32.2 4.17E-02
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00174\G3, 3_P1sv00000 - 210 300 299 460.csv
0.00
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00174\G4, 4_P1sv00000 - 210 300 299 460.csv
Fig: B.7.4
Spectrum TP: 299 3S Night no SS (Valve Open)
11 Channel: 3 H:DPL-API 618 5th Ed
Date: Jun 04, 2016 16:16
10
Setup:
Note:
9
Freq. Magnitude
8 # Hz psi Pk-Pk
1 16.6 1.24E+00
8 2 15.0 6.62E-01
7
Magnitude (psi Pk-Pk)
2
1
1 2
0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00175\G3, 3_P1sv00000 - 210 sg 237 puls.csv
43 Freq. Magnitude
# Hz psi Pk-Pk
1 64.4 2.72E+01
38 2 65.9 1.84E+01
3 53.4 1.81E+01
4 33.1 1.35E+01
Magnitude (psi Pk-Pk)
32 5 70.9 1.32E+01
6 76.3 9.57E+00
1 7 82.8 9.28E+00
27 8 56.3 9.14E+00
9 69.4 9.03E+00
10 29.1 8.30E+00
22 11 59.4 8.11E+00
3 2 12 26.6 6.90E+00
13 80.3 6.73E+00
16 14 86.3 6.17E+00
4 5 15 13.8 5.96E+00
16 41.3 5.76E+00
11 8 96 7 17 43.8 3.99E+00
10 11
12 1314 18 16.6 3.53E+00
15 16
5 19 50.0 3.35E+00
1719
18 20 20 212.2 3.31E+00
0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00175\G4, 4_P1sv00000 - 210 sg 237 puls.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00191\G3, 3_P1sv00000 - 210 300 299 460 closed.csv
0.0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00191\G4, 4_P1sv00000 - 210 300 299 460 closed.csv
Fig: B.7.5
Spectrum TP: 299 3S Night with SS (Valve Open)
11 Channel: 3 H:DPL-API 618 5th Ed
Date: Jun 05, 2016 18:49
10
Setup:
Note:
9
Freq. Magnitude
8 # Hz psi Pk-Pk
1 64.4 1.95E+00
8 2 68.4 1.95E+00
3 63.8 1.94E+00
7 4 58.4 1.73E+00
Magnitude (psi Pk-Pk)
5 16.6 1.58E+00
6 62.2 1.50E+00
6 7 59.4 1.47E+00
8 53.8 1.18E+00
5 9 53.1 1.08E+00
10 55.6 1.03E+00
4 11 60.9 1.02E+00
12 66.9 8.05E-01
3 13 14.7 7.92E-01
14 40.3 7.82E-01
15 41.9 6.81E-01
3 16 44.4 6.55E-01
312 17 43.1 6.34E-01
4
2 5 76 18 45.0 6.16E-01
981011 19 50.6 6.15E-01
13 14 12
1 15
118
17619
20 20 45.9 5.48E-01
0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00192\G3, 3_P1sv00000 - 210sg 237 299 460 open.csv
43 Freq. Magnitude
# Hz psi Pk-Pk
1 64.1 3.13E+01
38 2 33.1 1.58E+01
3 65.9 1.42E+01
4 53.4 1.28E+01
Magnitude (psi Pk-Pk)
32 1 5 69.4 1.21E+01
6 70.9 1.07E+01
7 30.6 9.74E+00
27 8 82.2 8.79E+00
9 55.9 8.66E+00
10 59.4 8.42E+00
22 11 28.4 8.42E+00
12 75.9 7.86E+00
2 13 26.6 7.46E+00
16 14 41.3 6.97E+00
3
4
5 15 80.0 6.94E+00
6 16 13.4 5.32E+00
11 7
17 85.6 5.14E+00
11 910 8
13 14 12
15 18 50.0 4.50E+00
5 16
18
17 19 16.6 4.24E+00
19 20 20 200.6 3.85E+00
0
0 100 200 300 400 500 600 700 800 900 1000
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Torsional.trf\ASCII00192\G4, 4_P1sv00000 - 210sg 237 299 460 open.csv
Figure B.8.1 – Cold Start – Run 58, Waterfall and Time History of Response at Compressor Lube Oil Pump
Figure B.8.2 – Controlled Shutdown – Run 60, Waterfall and Time History of Response at Compressor Lube Oil Pump
Figure B.8.3 – Warm Start – Run 61, Waterfall and Time History of Response at Compressor Lube Oil Pump
Figure B.8.4 – Unloaded Speed Sweep – Run 62, Waterfall and Time History of Response at Compressor Lube Oil Pump
Figure B.8.5 – Loading at 900 rpm – Run 63, Waterfall and Time History of Response at Compressor Lube Oil Pump
Figure B.8.6 – Loaded Speed Sweep – Run 64, Waterfall and Time History of Response at Compressor Lube Oil Pump
First Torsional Natural Frequency (Coupling Mode) is 10.9 Hz (or 654 rpm at 1X).
Fourth Torsional Natural Frequency (Compressor Mode) is 98 Hz (or 840 rpm at 7X, or 980 Hz at 6X)
Figure B.8.7 – Cold Start – Run 177, Waterfall and Time History of Response at Compressor Lube Oil Pump
Figure B.8.8 – Loaded ESD – Run 196, Waterfall and Time History of Response at Compressor Lube Oil Pump
6 100.9 5.05E-03
7 101.9 4.39E-03
0.010 8 45.6 3.03E-03
9 284.4 2.91E-03
10 110.3 2.85E-03
0.008 11 31.6 2.75E-03
2 12 131.6 2.55E-03
4 3 13 82.2 2.32E-03
0.006 14 103.8 2.29E-03
56
7
15 35.6 2.24E-03
16 83.4 2.20E-03
0.004 17 80.9 1.87E-03
8 10 9
11 12 18 247.5 1.86E-03
15 13
16 14
17 20
19 18 19 130.0 1.82E-03
0.002 20 129.4 1.82E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00001\H1, 2_I1sv00000 - s4bot a.csv
9
Date: May 28, 2016 09:08
20 18
160 3 Setup:
7 10 19 Note:
6 12
4
120 5 Freq. Phase
14 # Hz degrees
1 94.1 -176
80 2 88.8 -170
3 100.3 154
4 95.3 123
40 5 96.9 117
Phase (degrees)
6 100.9 131
7 101.9 141
0 8 45.6 -177
9 284.4 163
10 110.3 142
-40 11 31.6 -137
12 131.6 132
13 82.2 -136
-80 14 103.8 104
15 35.6 -175
16 83.4 -138
-120 17 17 80.9 -131
11 13
16
18 247.5 162
-160 19 130.0 137
15 2 20 129.4 161
8 1
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00001\H1, 2_I1sv00000 - s4bot a.csv
7 101.9 9.99E-01
0.50 8 45.6 9.83E-01
9 284.4 9.98E-01
10 110.3 9.99E-01
0.40 11 31.6 9.96E-01
12 131.6 9.97E-01
13 82.2 9.87E-01
0.30 14 103.8 9.99E-01
15 35.6 9.93E-01
16 83.4 9.74E-01
0.20 17 80.9 9.69E-01
18 247.5 9.94E-01
19 130.0 9.96E-01
0.10 20 129.4 9.97E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00001\C1, 2_I1sv00000 - s4bot a.csv
Fig: B.9.2
6 103.8 4.07E-03
7 96.6 3.89E-03
0.010 8 129.1 2.66E-03
9 131.3 2.27E-03
10 114.4 1.72E-03
0.008 11 115.0 1.69E-03
3 12 241.9 1.45E-03
13 284.4 1.37E-03
0.006 14 125.0 1.35E-03
4 5 15 124.1 1.33E-03
7 6 16 35.6 1.29E-03
0.004 17 118.8 1.25E-03
8 18 247.5 1.24E-03
9
19 121.6 1.24E-03
0.002 10
11 1218 13
16 17
2015
14
19 20 120.3 1.21E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00001\H1, 3_I1sv00000 - s4bot a.csv
12
9 6 103.8 116
7 96.6 -100
0 8 129.1 33
18 13
9 131.3 19
10 114.4 99
-40 4
11 115.0 98
5 12 241.9 24
13 284.4 -16
-80 14 125.0 88
7
15 124.1 92
16 35.6 166
-120 17 118.8 93
2
18 247.5 -18
19 121.6 88
-160
20 120.3 93
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00001\H1, 3_I1sv00000 - s4bot a.csv
7 96.6 1.00E+00
0.50 8 129.1 9.98E-01
9 131.3 9.95E-01
10 114.4 9.91E-01
0.40 11 115.0 9.90E-01
12 241.9 9.95E-01
13 284.4 9.98E-01
0.30 14 125.0 1.00E+00
15 124.1 9.99E-01
16 35.6 9.91E-01
0.20 17 118.8 9.98E-01
18 247.5 9.94E-01
0.10 19 121.6 9.96E-01
20 120.3 9.98E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00001\C1, 3_I1sv00000 - s4bot a.csv
Fig: B.9.3
Freq. Amplitude
# Hz ips / lbf
1 94.1 3.00E-02
0.025 2 89.1 1.41E-02
3 95.3 1.19E-02
4 96.9 1.04E-02
5 100.9 6.92E-03
Amplitude (ips / lbf)
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00001\H1, 4_I1sv00000 - s4bot a.csv
6 101.6 73
17 7 45.6 -180
0 8 82.2 -144
9 131.6 128
10 31.6 -140
-40 11 83.4 -138
12 80.9 -139
13 130.0 134
-80 14 35.6 -174
15 129.4 158
16
16 29.1 -113
-120 17 284.4 2
10 11
12
8 18 46.9 150
19
19 76.3 -150
-160 20
14
7 1 20 77.2 -165
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00001\H1, 4_I1sv00000 - s4bot a.csv
19
Date: May 28, 2016 09:08
20
0.90 Setup:
Note:
7 45.6 9.85E-01
0.50 8 82.2 9.84E-01
9 131.6 9.97E-01
10 31.6 9.96E-01
0.40 11 83.4 9.65E-01
12 80.9 9.62E-01
13 130.0 9.96E-01
0.30 14 35.6 9.92E-01
15 129.4 9.97E-01
16 29.1 9.94E-01
0.20 17 284.4 9.98E-01
18 46.9 9.91E-01
0.10 19 76.3 9.07E-01
20 77.2 9.05E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00001\C1, 4_I1sv00000 - s4bot a.csv
Fig: B.9.4
6 336.6 2.11E-03
7 338.4 2.08E-03
0.010 8 94.4 2.00E-03
9 80.9 1.95E-03
10 345.0 1.69E-03
0.008 2 11 345.6 1.67E-03
34 12 448.8 1.63E-03
13 69.1 1.58E-03
0.006 14 242.2 1.55E-03
15 83.4 1.52E-03
16 88.8 1.39E-03
0.004 17 383.1 1.36E-03
5
18 381.9 1.34E-03
9 8 67 19 62.5 1.30E-03
0.002 13 1516 14 10
11
17
12
19 18
20 20 380.0 1.24E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00002\H1, 2_I1sv00000 - s4bot v.csv
120 6
Freq. Phase
19 7 # Hz degrees
13 10
11 1 321.6 158
80 20
18
2 74.7 30
17 3 75.9 1
4 77.5 -31
40 2 5 247.5 -178
Phase (degrees)
12
6 336.6 106
3 7 338.4 100
0 8 94.4 -65
9 80.9 -64
4
10 345.0 92
-40 16 11 345.6 88
9
15
8 12 448.8 11
13 69.1 90
-80 14 242.2 -128
15 83.4 -70
16 88.8 -54
-120 14
17 383.1 61
18 381.9 66
19 62.5 101
-160
5 20 380.0 71
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00002\H1, 2_I1sv00000 - s4bot v.csv
7 338.4 9.97E-01
0.50 8 94.4 9.97E-01
9 80.9 9.96E-01
10 345.0 9.98E-01
0.40 11 345.6 9.98E-01
12 448.8 9.77E-01
13 69.1 9.97E-01
0.30 14 242.2 9.95E-01
15 83.4 9.97E-01
16 88.8 9.97E-01
0.20 17 383.1 9.98E-01
18 381.9 9.98E-01
0.10 19 62.5 8.84E-01
20 380.0 9.99E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00002\C1, 2_I1sv00000 - s4bot v.csv
Fig: B.9.5
6 247.5 3.81E-03
0.012 23 7 80.9 3.02E-03
4
8 218.4 2.56E-03
0.010 9 336.3 2.51E-03
10 88.8 2.43E-03
11 214.7 2.43E-03
0.008 12 61.3 2.42E-03
13 242.5 2.31E-03
0.006 14 338.4 2.31E-03
15 243.8 2.29E-03
5
16 284.4 2.22E-03
0.004 6 17 69.1 2.20E-03
7 18 83.8 2.08E-03
12 17 10 118 13
15 914
18 19 16 20 19 95.3 2.02E-03
0.002 20 345.0 2.01E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00002\H1, 3_I1sv00000 - s4bot v.csv
120 718
19 9 Freq. Phase
14 20 # Hz degrees
1 321.6 157
80 2 74.7 -150
3 77.5 147
4 75.9 -178
40 5 94.1 170
Phase (degrees)
6 247.5 176
7 80.9 116
0 8 218.4 177
9 336.3 112
10 88.8 133
-40 11 214.7 -142
12 61.3 -116
13 242.5 -143
-80 14 338.4 105
17 15 243.8 -150
12 16 284.4 -168
-120 17 69.1 -105
11 13
2 15 18 83.8 112
19 95.3 108
-160 16
4 20 345.0 102
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00002\H1, 3_I1sv00000 - s4bot v.csv
7 80.9 9.97E-01
0.50 8 218.4 9.92E-01
9 336.3 9.98E-01
10 88.8 9.96E-01
0.40 11 214.7 9.98E-01
12 61.3 9.95E-01
13 242.5 9.95E-01
0.30 14 338.4 9.97E-01
15 243.8 9.97E-01
16 284.4 9.97E-01
0.20 17 69.1 9.93E-01
18 83.8 9.98E-01
0.10 19 95.3 9.97E-01
20 345.0 9.96E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00002\C1, 3_I1sv00000 - s4bot v.csv
Fig: B.9.6
6 88.8 3.49E-03
7 284.4 3.37E-03
0.009 8 285.3 3.33E-03
9 83.4 3.26E-03
10 69.1 3.12E-03
11 247.5 3.08E-03
12 95.3 2.41E-03
0.006 13 66.9 2.31E-03
14 242.2 2.25E-03
4 15 293.4 2.22E-03
6 5 78 16 96.9 2.18E-03
10 9 11 17 194.4 2.15E-03
0.003 12 18 58.4 2.09E-03
13
18 20
19 16 17 14 15
19 66.3 2.09E-03
20 65.6 1.95E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00002\H1, 4_I1sv00000 - s4bot v.csv
6 88.8 -53
2 7 284.4 177
0 8 285.3 155
9 83.4 -71
3 10 69.1 83
-40 6 11 247.5 177
4 5 12 95.3 -78
9
12
16 13 66.9 77
-80 14 242.2 -146
15 293.4 133
16 96.9 -79
-120 17 194.4 -149
17 14 18 58.4 97
19 66.3 82
-160
20 65.6 83
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00002\H1, 4_I1sv00000 - s4bot v.csv
7 284.4 9.99E-01
0.50 8 285.3 9.99E-01
9 83.4 9.97E-01
10 69.1 9.97E-01
0.40 11 247.5 9.87E-01
12 95.3 9.97E-01
13 66.9 8.33E-01
0.30 14 242.2 9.95E-01
15 293.4 9.98E-01
16 96.9 9.96E-01
0.20 17 194.4 9.93E-01
18 58.4 9.66E-01
0.10 19 66.3 9.46E-01
20 65.6 8.76E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00002\C1, 4_I1sv00000 - s4bot v.csv
Fig: B.9.7
6 94.1 1.99E-03
7 58.4 1.62E-03
0.0030 8 185.3 1.49E-03
4
9 321.6 1.42E-03
10 53.8 1.28E-03
5 11 83.8 1.07E-03
6 12 57.5 9.85E-04
0.0020 13 59.4 9.78E-04
7 14 95.3 9.58E-04
8 9 15 183.4 8.86E-04
10
16 52.2 8.86E-04
11
12
13 14 17 96.9 8.17E-04
0.0010 16 18 17 15
18 89.1 8.10E-04
20 19
19 51.3 7.69E-04
20 45.3 7.52E-04
0.0000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00003\H1, 2_I1sv00000 - s4bot h.csv
6 94.1 178
7 58.4 174
0 8 185.3 -179
9 321.6 172
10 53.8 -121
-40 11 83.8 110
12 57.5 -165
13 59.4 128
-80 14 95.3 111
19 15 183.4 -141
16
20 10 16 52.2 -114
-120 17 96.9 109
15
1
18 89.1 109
19 51.3 -108
-160 12
8 20 45.3 -123
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00003\H1, 2_I1sv00000 - s4bot h.csv
7 58.4 9.89E-01
0.50 8 185.3 9.97E-01
9 321.6 9.97E-01
10 53.8 9.98E-01
0.40 11 83.8 9.94E-01
12 57.5 9.98E-01
13 59.4 8.13E-01
0.30 14 95.3 9.94E-01
15 183.4 9.93E-01
16 52.2 9.97E-01
0.20 17 96.9 9.95E-01
18 89.1 9.95E-01
0.10 19 51.3 9.98E-01
20 45.3 9.60E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00003\C1, 2_I1sv00000 - s4bot h.csv
Fig: B.9.8
23 Freq. Amplitude
# Hz ips / lbf
0.0060 1 74.7 6.87E-03
2 76.3 6.23E-03
3 77.5 6.17E-03
0.0050 4 56.6 3.06E-03
5 55.9 2.75E-03
Amplitude (ips / lbf)
6 321.6 2.27E-03
7 450.3 1.86E-03
0.0040 8 449.4 1.85E-03
9 58.4 1.74E-03
10 94.4 1.67E-03
4 11 448.1 1.66E-03
0.0030 5 12 83.8 1.44E-03
13 53.8 1.41E-03
6
14 455.0 1.29E-03
0.0020 9
87 15 408.4 1.25E-03
10 11 16 404.1 1.25E-03
13 12
14 17 395.6 1.22E-03
20 1618
17 15 19
18 406.9 1.19E-03
0.0010 19 446.3 1.18E-03
20 396.9 1.18E-03
0.0000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00003\H1, 3_I1sv00000 - s4bot h.csv
6 321.6 -13
7 450.3 160
0 6 8 449.4 174
9 58.4 174
10 94.4 115
-40 11 448.1 -169
12 83.8 105
13 53.8 -120
-80 14 455.0 129
15 408.4 141
13 16 404.1 157
-120 17 395.6 -175
19 18 406.9 147
1
19 446.3 -149
-160 11
17 20 396.9 173
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00003\H1, 3_I1sv00000 - s4bot h.csv
7 450.3 9.86E-01
0.50 8 449.4 9.81E-01
9 58.4 9.89E-01
10 94.4 9.96E-01
0.40 11 448.1 9.80E-01
12 83.8 9.96E-01
13 53.8 9.97E-01
0.30 14 455.0 9.86E-01
15 408.4 9.94E-01
16 404.1 9.94E-01
0.20 17 395.6 9.95E-01
18 406.9 9.97E-01
0.10 19 446.3 9.77E-01
20 396.9 9.91E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00003\C1, 3_I1sv00000 - s4bot h.csv
Fig: B.9.9
6 131.6 4.04E-03
0.006 3
7 67.2 3.75E-03
8 321.6 3.42E-03
0.005 9 89.1 2.73E-03
4
10 129.4 2.64E-03
5 6 11 121.9 2.38E-03
0.004 7 12 123.4 2.24E-03
8 13 60.3 2.01E-03
0.003 14 185.0 1.73E-03
9 10 15 57.5 1.63E-03
11
12 16 52.5 1.53E-03
13
0.002 14 17 95.3 1.52E-03
1615
18 17 18 50.3 1.39E-03
20 19
19 58.4 1.31E-03
0.001 20 50.9 1.28E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00003\H1, 4_I1sv00000 - s4bot h.csv
5 14 8 6 131.6 129
7 67.2 46
0 8 321.6 14
9 89.1 -54
4 10 129.4 161
-40 9 11 121.9 178
12 123.4 180
13 60.3 30
-80 18 14 185.0 18
20 15 57.5 -154
16 52.5 -126
-120 16
17 95.3 126
18 50.3 -92
15
19 58.4 157
-160 3
2 20 50.9 -104
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00003\H1, 4_I1sv00000 - s4bot h.csv
7 67.2 2.78E-01
0.50 8 321.6 9.96E-01
9 89.1 9.72E-01
10 129.4 9.57E-01
0.40 11 121.9 9.93E-01
12 123.4 9.97E-01
13 60.3 6.66E-01
0.30 7 14 185.0 9.98E-01
15 57.5 9.95E-01
16 52.5 9.88E-01
0.20 17 95.3 9.86E-01
18 50.3 9.84E-01
0.10 19 58.4 9.84E-01
20 50.9 9.92E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00003\C1, 4_I1sv00000 - s4bot h.csv
Fig: B.9.10
6 62.2 6.23E-03
7 165.0 6.22E-03
0.010 8 159.7 6.17E-03
9 159.1 6.06E-03
3 10 260.6 5.99E-03
0.008 11 166.6 5.42E-03
5 4
12 66.9 5.19E-03
6 98 7 10 13 56.6 4.98E-03
0.006 11 14 30.9 4.90E-03
14 13 12
15 144.4 4.35E-03
15
16 30.0 3.03E-03
0.004 17 257.2 2.90E-03
16 17
18
20 19 18 77.2 2.65E-03
19 140.9 2.55E-03
0.002
20 77.8 2.48E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00004\H1, 2_I1sv00000 - s3bot a.csv
6 62.2 -10
12 5 1 15
4
2 7 165.0 -35
0 18
20
36 9 8 159.7 -17
8
10 9 159.1 -8
7 10 260.6 -27
-40 11 166.6 -62
11 12 66.9 10
13 56.6 57
-80 14 30.9 27
15 144.4 7
16 30.0 60
-120 17 257.2 29
18 77.2 -2
19 140.9 28
-160
20 77.8 -3
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00004\H1, 2_I1sv00000 - s3bot a.csv
12 7 165.0 9.98E-01
0.50 8 159.7 9.96E-01
9 159.1 9.96E-01
10 260.6 9.88E-01
0.40 11 166.6 9.99E-01
12 66.9 5.16E-01
13 56.6 9.98E-01
0.30 14 30.9 9.96E-01
15 144.4 9.96E-01
16 30.0 9.95E-01
0.20 17 257.2 9.91E-01
18 77.2 9.15E-01
0.10 19 140.9 9.89E-01
20 77.8 7.46E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00004\C1, 2_I1sv00000 - s3bot a.csv
Fig: B.9.11
Freq. Amplitude
# Hz ips / lbf
1 83.1 1.24E-02
0.010 2 59.1 8.26E-03
3 30.9 8.13E-03
4 260.0 6.84E-03
3 2 5 56.6 5.54E-03
Amplitude (ips / lbf)
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00004\H1, 3_I1sv00000 - s3bot a.csv
3 6 112.8 2
6 7 62.2 -17
0 10 9 1
8 8 33.8 -9
18 27 9 75.9 0
13
10 66.9 -3
-40 11 332.2 178
16
12 467.8 134
20 13 34.4 -43
-80 14 341.3 156
15 340.6 167
16 88.8 -71
-120 17 346.3 127
18 32.8 -22
19 344.1 134
-160 4 20 89.7 -77
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00004\H1, 3_I1sv00000 - s3bot a.csv
10 7 62.2 9.85E-01
0.50 8 33.8 9.97E-01
9 75.9 9.80E-01
10 66.9 5.18E-01
0.40 11 332.2 9.90E-01
12 467.8 8.10E-01
13 34.4 9.93E-01
0.30 14 341.3 9.71E-01
15 340.6 9.62E-01
16 88.8 9.99E-01
0.20 17 346.3 9.80E-01
18 32.8 9.84E-01
0.10 19 344.1 9.68E-01
20 89.7 9.99E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00004\C1, 3_I1sv00000 - s3bot a.csv
Fig: B.9.12
6 33.8 5.24E-03
7 157.2 4.88E-03
0.006 8 144.1 4.72E-03
6 9 165.0 4.61E-03
8
7 10 159.1 4.34E-03
9
10
11 11 159.7 4.34E-03
12 12 34.4 3.98E-03
0.004 13 13 166.6 3.77E-03
14 14 60.3 3.35E-03
15
16 15 260.3 3.08E-03
17 18
19 20 16 32.8 2.89E-03
17 57.5 2.74E-03
0.002 18 140.6 2.69E-03
19 66.9 2.50E-03
20 88.8 2.47E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00004\H1, 4_I1sv00000 - s3bot a.csv
2 6 33.8 -10
1 7 157.2 -155
0 6
17 8 144.1 -155
16 3 19 9 165.0 152
10 159.1 -179
-40 12
11 159.7 172
20
12 34.4 -44
14
13 166.6 122
-80 14 60.3 -72
15 260.3 173
18 16 32.8 -25
-120 17 57.5 -5
18 140.6 -120
8 7
19 66.9 -29
-160 4
10 20 88.8 -70
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00004\H1, 4_I1sv00000 - s3bot a.csv
7 157.2 9.98E-01
0.50 8 144.1 9.98E-01
9 165.0 9.98E-01
10 159.1 9.96E-01
0.40 11 159.7 9.95E-01
12 34.4 9.93E-01
13 166.6 9.99E-01
0.30 14 60.3 7.08E-01
15 260.3 9.84E-01
16 32.8 9.85E-01
0.20 17 57.5 9.83E-01
18 140.6 9.98E-01
0.10 19 66.9 5.39E-01
20 88.8 9.99E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00004\C1, 4_I1sv00000 - s3bot a.csv
Fig: B.9.13
6 248.4 3.92E-03
7 263.4 3.83E-03
0.006 8 257.2 3.80E-03
9 257.8 3.76E-03
2 10 465.9 3.76E-03
3
11 259.4 3.69E-03
5 6 4 12 265.6 3.61E-03
0.004 9 712
811 10 13 227.5 3.49E-03
18 14 13
15 16 19
17
20 14 113.1 3.45E-03
15 226.6 3.43E-03
16 260.3 3.39E-03
17 258.8 3.35E-03
0.002 18 103.8 3.34E-03
19 267.2 3.27E-03
20 225.3 3.23E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00005\H1, 2_I1sv00000 - s3bot v.csv
15 2 6 248.4 38
1 7 263.4 -47
0 14 13 8
8 257.2 -4
916 9 257.8 -21
5 173
11 4
10 465.9 -156
-40 712 11 259.4 -32
19
12 265.6 -48
13 227.5 -4
-80 14 113.1 -2
15 226.6 15
16 260.3 -23
-120 17 258.8 -30
18 103.8 60
10
19 267.2 -57
-160
20 225.3 31
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00005\H1, 2_I1sv00000 - s3bot v.csv
7 263.4 6.67E-01
0.50 8 257.2 9.19E-01
9 257.8 9.38E-01
10 465.9 7.18E-01
0.40 11 259.4 9.02E-01
12 265.6 9.00E-01
13 227.5 9.61E-01
0.30 14 113.1 9.79E-01
15 226.6 9.75E-01
16 260.3 9.00E-01
0.20 17 258.8 9.42E-01
18 103.8 9.84E-01
0.10 19 267.2 8.66E-01
20 225.3 9.60E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00005\C1, 2_I1sv00000 - s3bot v.csv
Fig: B.9.14
Freq. Amplitude
0.0070 # Hz ips / lbf
1 106.3 7.84E-03
2 250.6 5.16E-03
0.0060 3 114.1 4.35E-03
4 248.4 4.28E-03
5 257.2 2.74E-03
Amplitude (ips / lbf)
2
0.0050 6 257.8 2.71E-03
7 262.5 2.68E-03
3 4 8 103.8 2.50E-03
0.0040 9 263.4 2.36E-03
10 259.4 2.29E-03
11 264.7 2.23E-03
12 260.3 2.12E-03
0.0030 56 7 13 261.3 1.98E-03
8 14 265.6 1.92E-03
10911
12
1314
15 274.7 1.86E-03
0.0020 15 16 267.2 1.66E-03
19 18 16 17
20 17 465.9 1.65E-03
18 227.8 1.63E-03
0.0010 19 46.3 1.57E-03
20 266.6 1.55E-03
0.0000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00005\H1, 3_I1sv00000 - s3bot v.csv
2 6 257.8 -26
19 7 262.5 -34
0 5 8 103.8 -119
612
13
9 263.4 -54
107 10 259.4 -35
-40 11 15
914
20
11 264.7 -44
16 12 260.3 -27
13 261.3 -29
-80 14 265.6 -56
15 274.7 -43
8 16 267.2 -64
-120 17 465.9 -161
18 227.8 137
17 19 46.3 0
-160
1 20 266.6 -56
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00005\H1, 3_I1sv00000 - s3bot v.csv
7 262.5 8.35E-01
0.50 8 103.8 9.86E-01
9 263.4 7.16E-01
10 259.4 9.28E-01
0.40 11 264.7 8.95E-01
12 260.3 9.32E-01
13 261.3 8.18E-01
0.30 14 265.6 9.12E-01
15 274.7 9.38E-01
16 267.2 8.95E-01
0.20 17 465.9 7.39E-01
18 227.8 9.53E-01
0.10 19 46.3 9.60E-01
20 266.6 8.61E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00005\C1, 3_I1sv00000 - s3bot v.csv
Fig: B.9.15
6 248.4 1.93E-03
0.008 7 66.9 1.83E-03
8 117.8 1.81E-03
0.007 9 82.5 1.70E-03
2 10 110.3 1.66E-03
0.006 11 118.4 1.66E-03
12 70.0 1.61E-03
0.005 13 46.3 1.40E-03
3 14 177.5 1.24E-03
0.004 15 257.8 1.21E-03
16 257.2 1.21E-03
0.003 17 120.9 1.20E-03
4
5 6 18 325.3 1.19E-03
0.002 7
12 9 8
10 11
19 256.6 1.17E-03
13 14
20 17 16
15
19 18
0.001 20 59.1 1.14E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00005\H1, 4_I1sv00000 - s3bot v.csv
4 6 248.4 44
7 66.9 -73
0 13
19
16
8 117.8 103
9 82.5 -127
15
12 10 110.3 140
-40 11 118.4 101
12 70.0 -40
7
13 46.3 -3
-80 14 177.5 69
15 257.8 -31
3 16 257.2 -16
-120 9
17 120.9 102
18 325.3 -165
20 19 256.6 -13
-160 5 18
1 20 59.1 -158
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00005\H1, 4_I1sv00000 - s3bot v.csv
7 66.9 1.85E-01
0.50 8 117.8 9.73E-01
9 82.5 9.92E-01
10 110.3 9.82E-01
0.40 11 118.4 9.66E-01
12 70.0 8.84E-01
13 46.3 9.60E-01
0.30 14 177.5 8.90E-01
15 257.8 9.39E-01
16 257.2 9.14E-01
0.20 7
17 120.9 9.75E-01
18 325.3 8.93E-01
0.10 19 256.6 9.50E-01
20 59.1 7.10E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00005\C1, 4_I1sv00000 - s3bot v.csv
Fig: B.9.16
Freq. Amplitude
0.0070 # Hz ips / lbf
1 106.3 7.75E-03
2 420.0 3.53E-03
0.0060 3 424.1 3.50E-03
4 421.3 3.50E-03
5 422.5 3.49E-03
Amplitude (ips / lbf)
0.0000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00006\H1, 2_I1sv00000 - s3bot h.csv
6 418.4 -105
7 416.3 -108
0 8 433.4 -87
9 417.2 -104
10 419.1 -105
-40 19 16
15 11 425.9 -102
12 114.1 148
13 424.7 -103
-80 8
14 415.6 -111
18
311
7916204513
14
20
15 450.6 -54
17
16 460.3 -48
-120 17 414.1 -114
18 427.2 -100
19 451.6 -50
-160 1 20 414.7 -112
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00006\H1, 2_I1sv00000 - s3bot h.csv
7 416.3 7.02E-01
0.50 8 433.4 5.48E-01
9 417.2 6.87E-01
10 419.1 6.80E-01
0.40 11 425.9 5.88E-01
12 114.1 9.68E-01
13 424.7 6.05E-01
0.30 14 415.6 6.87E-01
15 450.6 6.51E-01
16 460.3 7.05E-01
0.20 17 414.1 6.93E-01
18 427.2 6.00E-01
0.10 19 451.6 6.28E-01
20 414.7 6.97E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00006\C1, 2_I1sv00000 - s3bot h.csv
Fig: B.9.17
6 45.0 9.86E-04
7 60.0 8.81E-04
0.0015 8 43.8 8.80E-04
9 47.5 8.52E-04
3
4 10 59.4 8.35E-04
0.0012 11 76.9 7.92E-04
6 5 12 48.8 7.84E-04
89 7 13 320.0 7.79E-04
0.0009 10
11 14 61.3 7.76E-04
16 12 14
15 13
17 15 61.9 7.71E-04
18 16 42.5 7.57E-04
0.0006 19
20 17 317.5 6.75E-04
18 63.4 5.91E-04
19 66.9 5.14E-04
0.0003
20 64.4 5.00E-04
0.0000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00008\H1, 2_I1sv00000 - Cyl 2 v.csv
6 45.0 53
1 7 60.0 -60
13
0 2 8 43.8 81
9 47.5 47
5 10 59.4 -54
11
-40 10 11 76.9 -41
14
7 19
415
20 12 48.8 37
18
13 320.0 2
-80 14 61.3 -56
15 61.9 -66
16 42.5 94
-120 17 317.5 31
18 63.4 -73
19 66.9 -58
-160
20 64.4 -67
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00008\H1, 2_I1sv00000 - Cyl 2 v.csv
7 60.0 7.33E-01
0.50 8 43.8 9.85E-01
9 47.5 9.87E-01
10 59.4 9.01E-01
0.40 11 76.9 9.16E-01
12 48.8 9.94E-01
13 320.0 9.89E-01
0.30 14 61.3 9.67E-01
15 61.9 9.63E-01
16 42.5 9.67E-01
0.20 17 317.5 9.91E-01
18 63.4 9.89E-01
0.10 19 66.9 9.84E-01
20 64.4 8.94E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00008\C1, 2_I1sv00000 - Cyl 2 v.csv
Fig: B.9.18
6 127.5 3.49E-02
0.07 7 61.3 3.22E-02
8 60.0 3.05E-02
0.06 9 307.2 2.93E-02
10 62.2 2.72E-02
0.05 11 132.5 2.69E-02
12 58.1 2.68E-02
3 4 13 56.9 2.50E-02
0.04 5 6 14 55.9 2.44E-02
7
8 9 15 88.4 2.39E-02
0.03 1210 11 16 110.0 2.25E-02
13
14 15
18 17 16 19
20 17 93.1 2.21E-02
0.02 18 46.6 2.20E-02
19 242.2 2.19E-02
0.01 20 241.6 2.15E-02
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00009\H1, 2_I1sv00000 - 414 h.csv
3
6 127.5 -33
7 61.3 -43
0 17
2 14
13 8 60.0 -24
128
15 9 307.2 -32
1 6 20 9
18 7 19 10 62.2 -54
-40 10
4 11 132.5 -65
11 12 58.1 -22
13 56.9 -14
-80 14 55.9 -10
15 88.4 -28
16 110.0 31
-120 17 93.1 -3
18 46.6 -42
19 242.2 -40
-160
20 241.6 -30
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00009\H1, 2_I1sv00000 - 414 h.csv
7 61.3 9.82E-01
0.50 8 60.0 9.77E-01
9 307.2 9.57E-01
10 62.2 9.88E-01
0.40 11 132.5 9.83E-01
12 58.1 9.80E-01
13 56.9 9.78E-01
0.30 14 55.9 9.76E-01
15 88.4 9.83E-01
16 110.0 9.90E-01
0.20 17 93.1 9.84E-01
18 46.6 9.66E-01
0.10 19 242.2 9.78E-01
20 241.6 9.82E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00009\C1, 2_I1sv00000 - 414 h.csv
Fig: B.9.19
Freq. Amplitude
# Hz ips / lbf
1 120.6 1.18E-01
0.10 2 45.3 4.99E-02
3 129.1 4.43E-02
4 116.3 4.29E-02
5 93.4 3.77E-02
Amplitude (ips / lbf)
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00009\H1, 3_I1sv00000 - 414 h.csv
15 11
6 127.5 156
20
7 132.5 120
0 10 17 8 195.9 -76
9 9 242.2 -24
12 10 241.6 -12
-40 2 11 240.0 12
5
12 88.4 -42
18 8 13 109.7 -106
-80 14 140.9 117
13 15 179.1 15
16 237.5 39
-120 4 17 425.9 -12
18 48.1 -78
19 137.8 123
-160
20 424.1 10
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00009\H1, 3_I1sv00000 - 414 h.csv
7 132.5 9.78E-01
0.50 8 195.9 9.68E-01
9 242.2 9.69E-01
10 241.6 9.78E-01
0.40 11 240.0 9.88E-01
12 88.4 9.86E-01
13 109.7 9.98E-01
0.30 14 140.9 9.82E-01
15 179.1 9.90E-01
16 237.5 9.92E-01
0.20 17 425.9 8.94E-01
18 48.1 9.81E-01
0.10 19 137.8 9.89E-01
20 424.1 8.76E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00009\C1, 3_I1sv00000 - 414 h.csv
Fig: B.9.20
6 240.0 1.25E-02
0.014 45 3
7 424.1 1.18E-02
6 8 422.8 1.07E-02
0.012 7
9 418.1 9.04E-03
8 10 418.8 8.96E-03
0.010 11 428.8 8.19E-03
9
10 12 129.1 8.15E-03
12 11 13 416.3 7.59E-03
0.008 14 13
15 14 52.8 7.54E-03
16
15 127.5 6.69E-03
0.006 17
18
20 19 16 132.5 5.74E-03
17 59.7 5.72E-03
0.004 18 59.1 5.64E-03
19 216.9 5.49E-03
0.002 20 61.3 5.46E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00009\H1, 4_I1sv00000 - 414 h.csv
6 240.0 -10
14 7 7 424.1 8
0 6 3 8 422.8 32
2 9 418.1 77
18 15
17 1 4 11 10 418.8 59
19
-40 20 12 5 11 428.8 -39
16 12 129.1 -47
13 416.3 110
-80 14 52.8 10
15 127.5 -30
16 132.5 -64
-120 17 59.7 -39
18 59.1 -26
19 216.9 -41
-160
20 61.3 -45
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00009\H1, 4_I1sv00000 - 414 h.csv
7 424.1 8.85E-01
0.50 8 422.8 8.46E-01
9 418.1 8.97E-01
10 418.8 9.00E-01
0.40 11 428.8 8.86E-01
12 129.1 9.76E-01
13 416.3 8.94E-01
0.30 14 52.8 9.65E-01
15 127.5 9.87E-01
16 132.5 9.79E-01
0.20 17 59.7 9.67E-01
18 59.1 9.72E-01
0.10 19 216.9 9.57E-01
20 61.3 9.60E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00009\C1, 4_I1sv00000 - 414 h.csv
Fig: B.9.21
6 93.1 1.86E-02
7 193.8 1.74E-02
0.06 8 194.4 1.62E-02
9 55.9 1.45E-02
10 179.7 1.44E-02
11 45.0 1.44E-02
12 81.6 1.43E-02
0.04 32 13 44.4 1.43E-02
4 14 38.8 1.42E-02
5 15 64.1 1.38E-02
16 52.8 1.37E-02
17 74.1 1.34E-02
0.02 6 78
18 127.5 1.34E-02
1413
11 169 15 17 12
19 18 10
20 19 55.0 1.31E-02
20 184.7 1.25E-02
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00010\H1, 2_I1sv00000 - 414 a.csv
1 10 6 93.1 -35
3
7 193.8 -12
0 11
17 18
20 7 8 194.4 -27
8 2
9 55.9 56
12
46 10 179.7 13
-40 11 45.0 -4
15 12 81.6 -32
13 44.4 28
-80 14 38.8 57
15 64.1 -69
16 52.8 45
-120 17 74.1 -10
18 127.5 -8
19 55.0 50
-160
20 184.7 -13
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00010\H1, 2_I1sv00000 - 414 a.csv
7 193.8 9.97E-01
0.50 8 194.4 9.98E-01
9 55.9 9.97E-01
10 179.7 9.97E-01
0.40 11 45.0 9.55E-01
12 81.6 9.94E-01
13 44.4 9.68E-01
0.30 14 38.8 9.96E-01
15 64.1 9.97E-01
16 52.8 9.93E-01
0.20 17 74.1 9.94E-01
18 127.5 9.80E-01
0.10 19 55.0 9.96E-01
20 184.7 9.99E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00010\C1, 2_I1sv00000 - 414 a.csv
Fig: B.9.22
6 41.6 6.09E-03
6 7 88.1 5.82E-03
0.006 7 8 93.1 5.52E-03
8
9 87.2 4.57E-03
10 74.1 4.16E-03
9 11 127.5 4.01E-03
10 12 184.7 3.92E-03
11 12
0.004 14 13
13 240.6 3.84E-03
17 15 16 19 18 20
14 81.6 3.84E-03
15 75.3 3.27E-03
16 185.9 3.22E-03
17 49.4 3.15E-03
0.002 18 321.6 3.14E-03
19 239.1 3.11E-03
20 453.1 3.07E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00010\H1, 3_I1sv00000 - 414 a.csv
6 1 6 41.6 20
3
11 7 88.1 -175
0 10 8 93.1 158
9 87.2 -135
15
4
10 74.1 -12
-40 14 11 127.5 0
12 184.7 165
13 240.6 173
-80 14 81.6 -54
17 15 75.3 -32
16 185.9 131
-120 17 49.4 -109
9
20 18 321.6 170
2 19 19 239.1 -163
-160 7 20 453.1 -148
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00010\H1, 3_I1sv00000 - 414 a.csv
7 88.1 9.91E-01
0.50 8 93.1 9.81E-01
9 87.2 9.95E-01
10 74.1 9.91E-01
0.40 11 127.5 9.74E-01
12 184.7 9.98E-01
13 240.6 9.95E-01
0.30 14 81.6 9.93E-01
15 75.3 9.96E-01
16 185.9 9.94E-01
0.20 17 49.4 9.23E-01
18 321.6 9.72E-01
0.10 19 239.1 9.95E-01
20 453.1 9.15E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00010\C1, 3_I1sv00000 - 414 a.csv
Fig: B.9.23
2 Freq. Amplitude
0.035 # Hz ips / lbf
1 59.7 3.92E-02
3
2 88.4 3.49E-02
0.030 3 93.1 3.00E-02
4 41.6 1.43E-02
5 61.6 1.10E-02
Amplitude (ips / lbf)
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00010\H1, 4_I1sv00000 - 414 a.csv
4 19
1 6 45.0 -25
18
7 127.5 -159
0 9 8 101.3 -71
6 9 76.6 -8
23 10 38.8 50
-40 20 11 96.6 -84
5 12 321.6 176
8
11 13 81.9 35
-80 17 14 33.4 54
15 128.8 -161
16 34.7 44
-120 17 99.4 -91
18 78.8 9
7
15 19 75.3 25
-160
20 46.3 -53
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00010\H1, 4_I1sv00000 - 414 a.csv
7 127.5 9.78E-01
0.50 8 101.3 9.99E-01
9 76.6 9.93E-01
10 38.8 9.93E-01
0.40 11 96.6 9.99E-01
12 321.6 9.76E-01
13 81.9 9.96E-01
0.30 14 33.4 9.98E-01
15 128.8 9.74E-01
16 34.7 9.94E-01
0.20 17 99.4 9.98E-01
18 78.8 9.87E-01
0.10 19 75.3 9.96E-01
20 46.3 9.90E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00010\C1, 4_I1sv00000 - 414 a.csv
Fig: B.9.24
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00011\H1, 2_I1sv00000 - 210 h.csv
6 216.6 -141
7 91.9 168
0 8 42.2 107
9 500.0 -109
10 498.8 -110
-40 11 25.9 -91
12 25.0 -100
13 495.3 -115
-80 11 14 493.8 -115
12
9 15 51.3 113
20 1310
14 16 48.8 132
2
-120 17 50.0 115
6
18 329.1 -174
43 19 330.6 174
-160 18 20 475.0 -114
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00011\H1, 2_I1sv00000 - 210 h.csv
7 91.9 9.95E-01
0.50 8 42.2 9.91E-01
9 500.0 8.98E-01
10 498.8 9.12E-01
0.40 11 25.9 9.90E-01
12 25.0 9.55E-01
13 495.3 9.13E-01
0.30 14 493.8 9.21E-01
15 51.3 9.94E-01
16 48.8 9.82E-01
0.20 17 50.0 9.84E-01
18 329.1 9.57E-01
0.10 19 330.6 9.59E-01
20 475.0 9.24E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00011\C1, 2_I1sv00000 - 210 h.csv
Fig: B.9.25
Freq. Amplitude
0.0035 # Hz ips / lbf
1 71.3 4.06E-03
2 78.1 2.52E-03
0.0030 3 69.1 2.48E-03
4 486.3 2.34E-03
5 487.2 2.34E-03
Amplitude (ips / lbf)
3 2
0.0025 6 485.6 2.31E-03
45 7 484.7 2.26E-03
769 8
121011 8 491.3 2.26E-03
13
14
15
0.0020 16 20 17
18
19 9 488.1 2.24E-03
10 488.8 2.24E-03
11 491.9 2.19E-03
12 483.4 2.19E-03
0.0015 13 481.6 2.06E-03
14 479.7 2.06E-03
15 480.3 2.06E-03
0.0010 16 36.6 1.99E-03
17 453.8 1.98E-03
18 454.4 1.98E-03
0.0005 19 455.0 1.97E-03
20 77.2 1.96E-03
0.0000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00012\H1, 2_I1sv00000 - 210 a.csv
6 485.6 -102
7 484.7 -101
0 8 491.3 -109
9 488.1 -106
10 488.8 -109
-40 11 491.9 -113
12 483.4 -99
13 481.6 -98
-80 14 479.7 -97
14
15
13
12
764
17
18
510
98 15 480.3 -98
19 11
16 36.6 -148
-120 3
17 453.8 -109
16 18 454.4 -112
19 455.0 -115
-160 1 20 77.2 171
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00012\H1, 2_I1sv00000 - 210 a.csv
7 484.7 9.58E-01
0.50 8 491.3 9.48E-01
9 488.1 9.53E-01
10 488.8 9.49E-01
0.40 11 491.9 9.41E-01
12 483.4 9.57E-01
13 481.6 9.55E-01
0.30 14 479.7 9.59E-01
15 480.3 9.52E-01
16 36.6 9.88E-01
0.20 17 453.8 9.68E-01
18 454.4 9.73E-01
0.10 19 455.0 9.66E-01
20 77.2 9.42E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00012\C1, 2_I1sv00000 - 210 a.csv
Fig: B.9.26
Transfer Function TP: 210 Sight Glass (tan) [Hit 210 Sight Glass] (tan)
1.6
Channel: 2
Date: May 31, 2016 00:11
Setup:
1.4 1 Note:
Freq. Amplitude
# Hz ips / lbf
1.2 1 97.8 1.38E+00
2 181.9 1.64E-01
3 91.6 9.23E-02
1.0 4 292.8 8.75E-02
5 293.4 8.56E-02
Amplitude (ips / lbf)
6 195.0 7.33E-02
7 294.1 7.27E-02
0.8
0.6
0.4
0.2 2
3 457
6
0.0
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00013\H1, 2_I1sv00000 - 210 sg.csv
Transfer Function TP: 210 Sight Glass (tan) [Hit 210 Sight Glass] (tan)
200
Channel: 2
2
1
Date: May 31, 2016 00:11
160 Setup:
Note:
7
6 195.0 97
7 294.1 23
0
-40
4
-80 3
-120
-160
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00013\H1, 2_I1sv00000 - 210 sg.csv
Coherence TP: 210 Sight Glass (tan) [Hit 210 Sight Glass] (tan)
Channel: 2 3 1
1.00 2
7 294.1 6.60E-01
0.50 8 0.0 3.71E-01
0.40 8 4
0.30
0.20
0.10
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00013\C1, 2_I1sv00000 - 210 sg.csv
Fig: B.9.27
Transfer Function TP: 450 psv (h) [Hit 450 psv] (h)
0.45
Channel: 2
Date: May 31, 2016 00:17
Setup:
0.40 1 Note:
23
Freq. Amplitude
0.35 # Hz ips / lbf
1 94.1 3.84E-01
2 248.1 3.68E-01
0.30 3 249.1 3.66E-01
4 4 277.8 2.74E-01
5 279.1 2.57E-01
Amplitude (ips / lbf)
65
0.25 7 6 277.2 2.56E-01
7 245.6 2.43E-01
8 276.6 2.04E-01
8
0.20 10 9
11
12
9 244.4 2.00E-01
13 10 212.5 1.97E-01
14
11 281.9 1.93E-01
15
16
17 12 283.1 1.92E-01
0.15 19
20 18
13 90.6 1.86E-01
14 242.2 1.61E-01
15 87.8 1.58E-01
0.10 16 88.8 1.56E-01
17 241.6 1.47E-01
18 284.7 1.43E-01
0.05 19 240.0 1.42E-01
20 240.6 1.39E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00014\H1, 2_I1sv00000 - 450 h.csv
Transfer Function TP: 450 psv (h) [Hit 450 psv] (h)
200
Channel: 2
Date: May 31, 2016 00:17
160 Setup:
Note:
16 5 6 277.2 36
10 7 245.6 41
2
0 13
11
12 8 276.6 50
3
18 9 244.4 50
1 10 212.5 8
-40 11 281.9 -12
12 283.1 -13
13 90.6 -5
-80 14 242.2 51
15 87.8 37
16 88.8 17
-120 17 241.6 57
18 284.7 -28
19 240.0 57
-160
20 240.6 53
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00014\H1, 2_I1sv00000 - 450 h.csv
7 245.6 7.44E-01
0.50 8 276.6 6.51E-01
9 244.4 6.66E-01
10 212.5 8.47E-01
0.40 11 281.9 6.71E-01
12 283.1 6.61E-01
13 90.6 9.96E-01
0.30 14 242.2 5.97E-01
15 87.8 9.97E-01
16 88.8 9.96E-01
0.20 17 241.6 6.25E-01
18 284.7 6.57E-01
0.10 19 240.0 7.32E-01
20 240.6 7.41E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00014\C1, 2_I1sv00000 - 450 h.csv
Fig: B.9.28
6 75.9 9.95E-02
7 86.6 8.84E-02
0.20 8 60.6 6.91E-02
9 260.0 6.32E-02
10 74.4 6.28E-02
0.16 2
11 100.0 6.13E-02
3 12 60.0 5.96E-02
54 13 248.1 5.88E-02
0.12 14 258.4 5.69E-02
6
7
15 259.4 5.56E-02
16 249.1 5.49E-02
0.08 8 17 247.5 5.35E-02
12 10 11 13 9
16 14
17 15
18 18 260.9 5.16E-02
20 19
19 261.6 4.59E-02
0.04
20 245.9 4.42E-02
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00014\H1, 3_I1sv00000 - 450 h.csv
6 4 6 75.9 13
8 7 86.6 47
0 2 8 60.6 3
9 260.0 121
1 10 74.4 49
-40 11 100.0 -87
12 60.0 48
13 248.1 -175
-80 11
14 258.4 -139
15 259.4 173
16 249.1 171
-120 17 247.5 -161
20 14
18 260.9 140
17 19 261.6 137
-160
3 13 20 245.9 -137
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00014\H1, 3_I1sv00000 - 450 h.csv
14 7 86.6 9.74E-01
0.50 8 60.6 5.33E-01
18 9 260.0 3.83E-01
10 74.4 9.89E-01
0.40 9 11 100.0 9.95E-01
12 60.0 2.93E-01
12 13 248.1 5.96E-01
0.30 14 258.4 4.98E-01
15 259.4 1.95E-01
15 16 249.1 5.80E-01
0.20 17 247.5 7.12E-01
18 260.9 4.40E-01
0.10 19 261.6 5.89E-01
20 245.9 6.98E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00014\C1, 3_I1sv00000 - 450 h.csv
Fig: B.9.29
Transfer Function TP: 250 psv (h) [Hit 250 psv] (h)
0.20
Channel: 2
Date: May 31, 2016 00:20
0.18 Setup:
Note:
1
2
0.16 Freq. Amplitude
# Hz ips / lbf
1 60.0 1.66E-01
0.14 2 198.4 1.64E-01
3 62.2 8.58E-02
4 203.1 7.26E-02
0.12 5 59.1 6.54E-02
Amplitude (ips / lbf)
6 62.8 6.06E-02
7 63.4 4.57E-02
0.10 8 60.9 4.03E-02
3 9 390.3 2.87E-02
10 57.5 2.85E-02
0.08 11 88.8 2.55E-02
4
5 12 118.8 2.45E-02
6 13 65.0 2.27E-02
0.06 14 56.6 2.21E-02
7 15 260.0 2.16E-02
8 16 66.9 2.15E-02
0.04 17 211.6 2.12E-02
10 9
11 12 18 213.1 1.89E-02
14 13
16 17 15
18
1920 19 213.8 1.86E-02
0.02
20 216.6 1.84E-02
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00015\H1, 2_I1sv00000 - 250 h.csv
Transfer Function TP: 250 psv (h) [Hit 250 psv] (h)
200
Channel: 2
Date: May 31, 2016 00:20
160 Setup:
Note:
1
9 6 62.8 -99
3 12 2
11 7 63.4 -52
0 8 60.9 -67
9 390.3 13
10 57.5 89
-40 7
16 4 11 88.8 6
13
8 15 12 118.8 7
1920
18
17
13 65.0 -58
-80 14 56.6 93
6
15 260.0 -67
16 66.9 -46
-120 17 211.6 -84
18 213.1 -83
19 213.8 -83
-160
20 216.6 -79
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00015\H1, 2_I1sv00000 - 250 h.csv
7 63.4 4.72E-01
0.50 7 8 60.9 2.99E-01
9 390.3 3.44E-01
6 10 57.5 8.76E-01
0.40 11 88.8 9.92E-01
9 12 118.8 9.80E-01
8 13 65.0 7.48E-01
0.30 14 56.6 8.58E-01
15 260.0 5.45E-01
16 66.9 6.16E-01
0.20 17 211.6 9.72E-01
18 213.1 9.57E-01
0.10 19 213.8 9.61E-01
20 216.6 9.21E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00015\C1, 2_I1sv00000 - 250 h.csv
Fig: B.9.30
Transfer Function TP: 250 mid (h) [Hit 250 psv] (h)
0.11
Channel: 3
Date: May 31, 2016 00:20
0.10 Setup:
1
Note:
0.09 Freq. Amplitude
# Hz ips / lbf
0.08 1 60.0 9.57E-02
2 62.2 4.94E-02
3 59.1 3.73E-02
0.07 4 62.8 3.52E-02
5 63.4 2.65E-02
Amplitude (ips / lbf)
6 60.9 2.36E-02
0.06 7 118.8 1.90E-02
8 88.8 1.61E-02
2 9 57.5 1.60E-02
0.05
10 198.4 1.34E-02
11 66.9 1.33E-02
0.04 3 12 65.0 1.32E-02
4
13 56.6 1.24E-02
0.03 14 97.5 1.22E-02
5 15 121.3 1.16E-02
6
16 109.4 1.12E-02
0.02 7 17 121.9 1.07E-02
9 8
18 141.9 1.05E-02
13 12
11 14 15
10
19 16 20
17 18 19 65.6 1.02E-02
0.01 20 120.3 1.00E-02
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00015\H1, 3_I1sv00000 - 250 h.csv
Transfer Function TP: 250 mid (h) [Hit 250 psv] (h)
200
Channel: 3
Date: May 31, 2016 00:20
160 Setup:
Note:
1
6 60.9 -69
2 8 16 7 10 7 118.8 2
0 14 8 88.8 5
9 57.5 88
20 10 198.4 3
15
-40 11
519 11 66.9 -47
12 17
18 12 65.0 -59
6
13 56.6 90
-80 14 97.5 -10
4
15 121.3 -40
16 109.4 3
-120 17 121.9 -55
18 141.9 -61
19 65.6 -48
-160
20 120.3 -33
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00015\H1, 3_I1sv00000 - 250 h.csv
7 118.8 9.80E-01
0.50 5 8 88.8 9.93E-01
9 57.5 8.73E-01
4 10 198.4 9.90E-01
0.40 11 66.9 6.14E-01
12 65.0 7.54E-01
6 13 56.6 8.53E-01
0.30 14 97.5 8.06E-01
15 121.3 9.58E-01
16 109.4 9.08E-01
0.20 17 121.9 9.43E-01
18 141.9 8.80E-01
0.10 19 65.6 7.06E-01
20 120.3 9.20E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00015\C1, 3_I1sv00000 - 250 h.csv
Fig: B.9.31
6 203.1 1.93E-02
7 165.3 1.60E-02
0.030 8 118.8 1.58E-02
3
9 163.4 1.51E-02
10 63.4 1.50E-02
11 164.1 1.39E-02
4 12 60.9 1.35E-02
5
0.020 6
13 162.2 1.32E-02
8 7 14 161.3 1.24E-02
10 9
12 11
13
15 141.9 1.19E-02
15 14 16 160.6 1.13E-02
18 16 17
19 20 17 167.2 1.11E-02
0.010 18 121.3 1.07E-02
19 109.4 1.06E-02
20 142.5 1.01E-02
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00015\H1, 4_I1sv00000 - 250 h.csv
1
6 203.1 132
3 19 8 7 165.3 -152
0 8 118.8 2
9 163.4 -131
18 10 63.4 -53
-40 10 11 164.1 -140
15 12 60.9 -69
12 20
13 162.2 -109
-80 14 161.3 -109
5 16
14
13 15 141.9 -62
16 160.6 -101
-120 9 17 167.2 178
11
7 18 121.3 -37
19 109.4 6
-160 2
20 142.5 -73
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00015\H1, 4_I1sv00000 - 250 h.csv
7 165.3 9.24E-01
0.50 10 8 118.8 9.80E-01
9 163.4 9.70E-01
5
10 63.4 4.84E-01
0.40 11 164.1 9.44E-01
12 60.9 3.10E-01
12 13 162.2 9.40E-01
0.30 14 161.3 8.30E-01
15 141.9 8.90E-01
16 160.6 9.14E-01
0.20 17 167.2 9.26E-01
18 121.3 9.55E-01
0.10 19 109.4 9.03E-01
20 142.5 9.31E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00015\C1, 4_I1sv00000 - 250 h.csv
Fig: B.9.32
Transfer Function TP: 250 psv (a) [Hit 250 psv] (a)
0.070
Channel: 2
Date: May 31, 2016 00:24
Setup:
0.060 Note:
1
Freq. Amplitude
# Hz ips / lbf
2
1 74.4 5.85E-02
0.050 2 75.3 5.11E-02
3 76.9 4.31E-02
3 4 121.6 4.17E-02
4
5 123.8 3.90E-02
Amplitude (ips / lbf)
0.040 5
6 96.3 2.39E-02
7 118.8 1.88E-02
8 68.8 1.73E-02
9 78.4 1.68E-02
0.030 10 130.6 1.61E-02
11 131.3 1.61E-02
6 12 70.0 1.61E-02
13 116.6 1.52E-02
0.020 7 14 60.0 1.41E-02
8
12 9 10
11 15 198.8 1.36E-02
13
14 15 16 93.8 1.27E-02
1917
18 16
20 17 66.9 1.22E-02
0.010 18 65.9 1.22E-02
19 62.5 1.21E-02
20 63.4 1.19E-02
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00016\H1, 2_I1sv00000 - 250 a.csv
Transfer Function TP: 250 psv (a) [Hit 250 psv] (a)
200
Channel: 2
Date: May 31, 2016 00:24
160 Setup:
Note:
15 6 96.3 -1
1 137
6 7 118.8 7
0 2 4 8 68.8 66
9 78.4 -49
3
5 10 130.6 -48
-40 9 10 11 131.3 -60
11
12 70.0 66
13 116.6 10
-80 14 60.0 55
15 198.8 20
16 93.8 40
-120 17 66.9 84
18 65.9 83
19 62.5 73
-160
20 63.4 103
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00016\H1, 2_I1sv00000 - 250 a.csv
7 118.8 9.90E-01
0.50 8 68.8 9.59E-01
9 78.4 9.26E-01
10 130.6 9.81E-01
0.40 20
11 131.3 9.85E-01
12 70.0 9.71E-01
14
13 116.6 9.94E-01
0.30 14 60.0 3.17E-01
15 198.8 9.48E-01
16 93.8 9.47E-01
0.20 17 66.9 9.40E-01
18 65.9 9.15E-01
0.10 19 62.5 6.66E-01
20 63.4 3.86E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00016\C1, 2_I1sv00000 - 250 a.csv
Fig: B.9.33
Transfer Function TP: 250 mid (a) [Hit 250 psv] (a)
0.030
Channel: 3
Date: May 31, 2016 00:24
0.027 Setup:
1 Note:
6 123.8 1.00E-02
7 390.0 9.67E-03
0.015 8 121.6 9.35E-03
9 258.4 9.24E-03
4 10 391.3 7.85E-03
0.012 5 11 390.6 7.78E-03
6 12 255.9 7.72E-03
8 7
9 13 68.8 7.51E-03
0.009 14 78.4 7.07E-03
13 12 10
11
15 14 15 70.0 6.85E-03
16 16 82.5 5.95E-03
0.006 17
18 20 19 17 65.9 5.37E-03
18 66.9 5.26E-03
19 249.7 4.96E-03
0.003
20 101.9 4.96E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00016\H1, 3_I1sv00000 - 250 a.csv
Transfer Function TP: 250 mid (a) [Hit 250 psv] (a)
200
Channel: 3
Date: May 31, 2016 00:24
160 Setup:
Note:
6 123.8 -47
1 12 7 390.0 -43
0 2 16 4 8 8 121.6 -14
9
9 258.4 -15
3 5
20 7
10 391.3 -88
-40 14 6 11 390.6 -80
12 255.9 8
11 13 68.8 63
-80 10 14 78.4 -49
15 70.0 62
16 82.5 -11
-120 17 65.9 80
18 66.9 81
19 249.7 27
-160
20 101.9 -39
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00016\H1, 3_I1sv00000 - 250 a.csv
7 390.0 8.94E-01
0.50 8 121.6 9.91E-01
9 258.4 9.69E-01
10 391.3 9.51E-01
0.40 11 390.6 8.87E-01
12 255.9 9.85E-01
13 68.8 9.58E-01
0.30 14 78.4 9.28E-01
15 70.0 9.67E-01
16 82.5 9.82E-01
0.20 17 65.9 9.08E-01
18 66.9 9.30E-01
0.10 19 249.7 9.83E-01
20 101.9 9.88E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00016\C1, 3_I1sv00000 - 250 a.csv
Fig: B.9.34
6 57
98
10 6 121.6 8.68E-03
0.008 11 12
13 7 371.6 8.67E-03
15 1614
19 18 17
20 8 373.4 8.45E-03
0.007 9 370.9 8.39E-03
10 368.8 7.98E-03
0.006 11 375.0 7.73E-03
12 482.5 7.60E-03
0.005 13 481.9 7.46E-03
14 483.1 7.44E-03
0.004 15 374.4 7.41E-03
16 480.9 7.30E-03
0.003 17 484.7 7.23E-03
18 480.3 7.19E-03
0.002 19 123.8 7.19E-03
0.001 20 485.6 7.09E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00016\H1, 4_I1sv00000 - 250 a.csv
11
6 121.6 -156
1 7 371.6 64
0 8 373.4 36
4 18
16 9 370.9 81
3 13 10 368.8 105
-40 12
14 11 375.0 25
17 12 482.5 -45
20 13 481.9 -38
-80 14 483.1 -53
15 374.4 34
16 480.9 -26
-120 17 484.7 -67
18 480.3 -20
6
19 123.8 -176
-160
19 20 485.6 -78
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00016\H1, 4_I1sv00000 - 250 a.csv
7 371.6 7.33E-01
0.50 8 373.4 7.95E-01
9 370.9 7.16E-01
10 368.8 6.55E-01
0.40 11 375.0 6.76E-01
12 482.5 7.80E-01
13 481.9 7.68E-01
0.30 14 483.1 7.79E-01
15 374.4 6.03E-01
16 480.9 7.95E-01
0.20 17 484.7 7.57E-01
18 480.3 8.06E-01
0.10 19 123.8 9.88E-01
20 485.6 7.51E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00016\C1, 4_I1sv00000 - 250 a.csv
Fig: B.9.35
Freq. Amplitude
# Hz ips / lbf
0.060 1 29.4 6.93E-02
2 480.9 8.70E-03
3 479.7 8.62E-03
0.050 4 321.6 7.87E-03
5 487.8 4.94E-03
Amplitude (ips / lbf)
6 317.2 4.65E-03
7 489.1 4.61E-03
0.040 8 25.3 4.32E-03
9 324.4 4.00E-03
10 492.2 3.93E-03
0.030
0.020
0.010 4 32
8 6 9 5710
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00017\H1, 2_I1sv00000 - 400 a.csv
6 317.2 -149
7 489.1 137
0 8 25.3 -108
9 324.4 123
10 492.2 129
-40
-80
8
-120
1
6
-160 3
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00017\H1, 2_I1sv00000 - 400 a.csv
7 489.1 9.81E-01
0.50 8 25.3 9.78E-01
9 324.4 9.97E-01
10 492.2 9.90E-01
0.40 11 0.0 1.82E-01
0.30
0.20 11
0.10
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00017\C1, 2_I1sv00000 - 400 a.csv
Fig: B.9.36
6 33.8 8.05E-03
7 410.0 6.72E-03
0.020 8 409.4 6.71E-03
9 387.5 6.28E-03
2 10 482.8 6.10E-03
0.016 11 484.1 5.92E-03
3 12 485.3 5.85E-03
13 484.7 5.83E-03
0.012 4
14 486.6 5.68E-03
5
15 487.5 5.50E-03
6 16 342.8 5.33E-03
0.008 87 17 489.4 5.06E-03
9 10
11
13
12
16 14
15 18 414.7 4.95E-03
19 18 1720
19 318.8 4.88E-03
0.004
20 493.8 4.78E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00018\H1, 2_I1sv00000 - 300 a.csv
6 33.8 138
7 410.0 116
0 8 409.4 123
9 387.5 134
10 482.8 101
-40 11 484.1 99
12 485.3 98
13 484.7 98
-80 14 486.6 93
15 487.5 91
16 342.8 -161
-120 17 489.4 92
18 414.7 93
19 16 19 318.8 -160
-160
20 493.8 92
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00018\H1, 2_I1sv00000 - 300 a.csv
7 410.0 9.86E-01
0.50 8 409.4 9.86E-01
9 387.5 9.44E-01
10 482.8 9.72E-01
0.40 11 484.1 9.76E-01
12 485.3 9.83E-01
13 484.7 9.72E-01
0.30 14 486.6 9.74E-01
15 487.5 9.75E-01
16 342.8 9.85E-01
0.20 17 489.4 9.59E-01
18 414.7 9.88E-01
0.10 19 318.8 9.84E-01
20 493.8 9.81E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00018\C1, 2_I1sv00000 - 300 a.csv
Fig: B.9.37
Transfer Function TP: 350 psv (h) [Hit 350 psv] (h)
1.00
Channel: 2
1
Date: May 31, 2016 00:39
0.90 Setup:
Note:
6 138.8 1.45E-01
7 139.7 1.44E-01
0.50 8 264.7 1.41E-01
9 265.6 1.35E-01
10 278.8 1.19E-01
0.40 11 166.9 1.16E-01
12 256.3 1.10E-01
13 256.9 1.10E-01
0.30 14 257.8 1.08E-01
15 165.6 1.08E-01
2 16 255.3 1.07E-01
0.20 3
17 260.0 1.07E-01
4 567 89
10 18 261.3 1.06E-01
11
15 19
20 12
13
1617
1418 19 182.8 1.05E-01
0.10
20 181.9 1.03E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00019\H1, 2_I1sv00000 - 350 H.csv
Transfer Function TP: 350 psv (h) [Hit 350 psv] (h)
200
Channel: 2
Date: May 31, 2016 00:39
160 Setup:
Note:
5
16 6 138.8 11
6 11 3 12
13 7 139.7 -7
14
0 4 7 20
17
18 8 264.7 -24
19
1 2 8 9 265.6 -37
9 10 278.8 -45
-40 10
11 166.9 14
12 256.3 12
13 256.9 7
-80 14 257.8 2
15 165.6 31
16 255.3 20
-120 17 260.0 -5
18 261.3 -9
19 182.8 -15
-160
20 181.9 -11
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00019\H1, 2_I1sv00000 - 350 H.csv
7 139.7 9.84E-01
0.50 8 264.7 9.90E-01
9 265.6 9.95E-01
10 278.8 9.88E-01
0.40 11 166.9 9.91E-01
12 256.3 9.93E-01
13 256.9 9.91E-01
0.30 14 257.8 9.95E-01
15 165.6 9.91E-01
16 255.3 9.93E-01
0.20 17 260.0 9.96E-01
18 261.3 9.96E-01
0.10 19 182.8 9.91E-01
20 181.9 9.91E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00019\C1, 2_I1sv00000 - 350 H.csv
Fig: B.9.38
Transfer Function TP: 350 mid (h) [Hit 350 psv] (h)
0.70
Channel: 3
Date: May 31, 2016 00:39
Setup:
0.60 Note:
1
Freq. Amplitude
# Hz ips / lbf
1 94.7 5.78E-01
0.50 2 68.8 1.21E-01
3 58.8 6.18E-02
4 57.5 6.01E-02
5 479.4 5.79E-02
Amplitude (ips / lbf)
2
0.10
43 5
6
87 12
13 10 9
11
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00019\H1, 3_I1sv00000 - 350 H.csv
Transfer Function TP: 350 mid (h) [Hit 350 psv] (h)
200
Channel: 3
9
11 Date: May 31, 2016 00:39
160 Setup:
Note:
4
6 441.3 -149
7 140.0 -44
0 2
8
8 137.2 -4
3 9 481.9 178
1 13
12 10 180.0 -46
-40 7 10
11 483.1 168
12 167.8 -41
13 167.2 -29
-80
-120
6 5
-160
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00019\H1, 3_I1sv00000 - 350 H.csv
7 140.0 9.84E-01
0.50 8 137.2 9.78E-01
9 481.9 9.88E-01
10 180.0 9.94E-01
0.40 11 483.1 9.88E-01
12 167.8 9.94E-01
13 167.2 9.91E-01
0.30 14 0.0 2.46E-01
14
0.20
0.10
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00019\C1, 3_I1sv00000 - 350 H.csv
Fig: B.9.39
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00019\H1, 4_I1sv00000 - 350 H.csv
4 6 138.8 -140
7 136.9 -120
0 8 139.4 -148
2
3 1 9 480.0 147
10 204.7 146
-40 11 192.5 -165
12 183.8 -164
13 179.1 -135
-80 17
1819 20 14 200.9 158
15 189.4 -157
7 16 188.8 -156
-120 17 106.9 -91
13
6
8 18 107.5 -91
16
15 19 110.6 -92
-160 12 11
20 130.6 -94
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00019\H1, 4_I1sv00000 - 350 H.csv
7 136.9 9.80E-01
0.50 8 139.4 9.84E-01
9 480.0 9.91E-01
10 204.7 9.96E-01
0.40 11 192.5 9.96E-01
12 183.8 9.91E-01
13 179.1 9.94E-01
0.30 14 200.9 9.94E-01
15 189.4 9.95E-01
16 188.8 9.89E-01
0.20 17 106.9 9.66E-01
18 107.5 9.65E-01
0.10 19 110.6 9.72E-01
20 130.6 9.79E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00019\C1, 4_I1sv00000 - 350 H.csv
Fig: B.9.40
Transfer Function TP: 350 psv (a) [Hit 350 psv] (a)
0.24
Channel: 2
Date: May 31, 2016 00:43
Setup:
1 Note:
0.20
Freq. Amplitude
# Hz ips / lbf
1 197.5 2.06E-01
2 181.9 1.02E-01
0.16 3 175.3 8.17E-02
4 202.5 6.37E-02
5 185.0 6.16E-02
Amplitude (ips / lbf)
6 180.3 5.26E-02
7 178.1 4.15E-02
0.12 8 179.1 4.11E-02
9 164.7 4.06E-02
2
10 128.8 3.08E-02
11 135.9 2.84E-02
3 12 168.4 2.74E-02
0.08 13 161.3 2.29E-02
5 4 14 143.8 2.21E-02
15 213.8 2.20E-02
6
16 213.1 2.20E-02
9 78 17 144.4 2.19E-02
0.04 18 228.4 2.17E-02
10 11
12
2014
17 13 16
15 18
19
19 230.3 2.01E-02
20 139.4 2.00E-02
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00020\H1, 2_I1sv00000 - 350 a.csv
Transfer Function TP: 350 psv (a) [Hit 350 psv] (a)
200
Channel: 2
Date: May 31, 2016 00:43
160 Setup:
Note:
8 6 180.3 36
7
2 7 178.1 15
0 1 8 179.1 20
9 164.7 43
5 4 10 128.8 58
-40 18
11 135.9 43
19 12 168.4 50
16
15
13 161.3 69
-80 14 143.8 33
15 213.8 -71
16 213.1 -69
-120 17 144.4 28
18 228.4 -46
19 230.3 -61
-160
20 139.4 47
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00020\H1, 2_I1sv00000 - 350 a.csv
7 178.1 9.94E-01
0.50 8 179.1 9.98E-01
9 164.7 9.98E-01
10 128.8 9.98E-01
0.40 11 135.9 9.94E-01
12 168.4 9.99E-01
13 161.3 9.97E-01
0.30 14 143.8 9.98E-01
15 213.8 9.97E-01
16 213.1 9.99E-01
0.20 17 144.4 9.98E-01
18 228.4 9.83E-01
0.10 19 230.3 9.86E-01
20 139.4 9.93E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00020\C1, 2_I1sv00000 - 350 a.csv
Fig: B.9.41
Transfer Function TP: 350 mid (a) [Hit 350 psv] (a)
0.090
Channel: 3
Date: May 31, 2016 00:43
Setup:
0.080 1
Note:
Freq. Amplitude
0.070 # Hz ips / lbf
1 197.5 7.86E-02
2 181.9 3.88E-02
0.060 3 185.0 3.13E-02
4 175.3 2.75E-02
5 202.8 2.23E-02
Amplitude (ips / lbf)
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00020\H1, 3_I1sv00000 - 350 a.csv
Transfer Function TP: 350 mid (a) [Hit 350 psv] (a)
200
Channel: 3
Date: May 31, 2016 00:43
160 Setup:
Note:
6 180.3 40
2
7 179.1 28
0 1 8 178.1 25
3 9 164.7 49
10 168.8 55
-40 5 11 213.8 -74
13 19
14 18
17 16
12 160.6 72
1115
13 228.4 -55
-80 14 230.3 -67
15 218.4 -71
16 278.8 -70
-120 17 250.9 -70
18 250.0 -64
19 245.9 -55
-160
20 135.6 51
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00020\H1, 3_I1sv00000 - 350 a.csv
7 179.1 9.98E-01
0.50 8 178.1 9.96E-01
9 164.7 9.98E-01
10 168.8 9.98E-01
0.40 11 213.8 9.96E-01
12 160.6 9.98E-01
13 228.4 9.86E-01
0.30 14 230.3 9.89E-01
15 218.4 9.97E-01
16 278.8 9.86E-01
0.20 17 250.9 9.97E-01
18 250.0 9.92E-01
0.10 19 245.9 9.98E-01
20 135.6 9.92E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00020\C1, 3_I1sv00000 - 350 a.csv
Fig: B.9.42
6 129.1 5.68E-03
0.006 6 7 65.9 5.19E-03
7 8 181.9 5.00E-03
9 8
0.005 9 92.8 4.94E-03
10 10 188.8 4.58E-03
11
12 11 65.3 4.27E-03
0.004 14 15 13 12 189.7 4.12E-03
16
17 13 193.8 3.73E-03
18
0.003 20 19 14 67.2 3.60E-03
15 74.1 3.51E-03
16 180.3 3.48E-03
0.002 17 179.1 3.24E-03
18 70.0 3.13E-03
19 176.9 2.96E-03
0.001 20 145.3 2.84E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00020\H1, 4_I1sv00000 - 350 a.csv
7
6 129.1 -146
7 65.9 12
0 8 181.9 31
3
15 9 92.8 -63
18 10 188.8 -76
-40 11 65.3 43
9 12 189.7 -83
14 10 13 193.8 -105
-80 12
2 14 67.2 -76
13 15 74.1 -24
16 180.3 52
-120 17 179.1 59
1 6 4 18 70.0 -42
19 176.9 84
-160
20 145.3 167
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00020\H1, 4_I1sv00000 - 350 a.csv
18 7 65.9 8.62E-01
0.50 8 181.9 9.98E-01
9 92.8 8.33E-01
10 188.8 9.92E-01
0.40 11 65.3 9.00E-01
12 189.7 9.93E-01
13 193.8 9.95E-01
0.30 14 67.2 5.52E-01
15 74.1 9.22E-01
16 180.3 9.98E-01
0.20 17 179.1 9.97E-01
18 70.0 5.16E-01
0.10 19 176.9 9.93E-01
20 145.3 9.97E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00020\C1, 4_I1sv00000 - 350 a.csv
Fig: B.9.43
6 31.9 1.21E-02
7 30.6 1.20E-02
0.020 8 76.6 1.04E-02
3 9 33.8 9.50E-03
10 72.2 8.37E-03
0.016 11 73.4 7.46E-03
12 68.1 6.26E-03
76 4 5 13 313.1 5.18E-03
0.012 14 340.0 5.04E-03
8
9 15 34.7 5.01E-03
10 16 69.4 4.58E-03
0.008 11
17 107.5 4.51E-03
12
15 13 14 18 27.5 4.41E-03
18 19 16 17
20 19 49.1 4.33E-03
0.004
20 113.8 3.97E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00021\H1, 2_I1sv00000 - 314 a.csv
6 6 31.9 17
11 7 30.6 30
16 5
0 2 8 76.6 38
1 9 33.8 -43
9 17 10 72.2 37
-40 4
14 11 73.4 8
15
20 12 68.1 30
13 313.1 38
-80 14 340.0 -48
15 34.7 -57
16 69.4 1
-120 17 107.5 -41
18 27.5 81
19 49.1 43
-160
20 113.8 -62
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00021\H1, 2_I1sv00000 - 314 a.csv
7 30.6 9.94E-01
0.50 8 76.6 9.98E-01
9 33.8 9.97E-01
10 72.2 9.95E-01
0.40 11 73.4 9.94E-01
12 68.1 9.88E-01
13 313.1 9.93E-01
0.30 14 340.0 9.85E-01
15 34.7 9.96E-01
16 69.4 9.10E-01
0.20 17 107.5 9.95E-01
18 27.5 9.98E-01
0.10 19 49.1 9.81E-01
20 113.8 9.95E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00021\C1, 2_I1sv00000 - 314 a.csv
Fig: B.9.44
6 48.8 8.01E-03
0.07 7 261.3 7.93E-03
8 95.9 7.61E-03
0.06 9 263.1 6.86E-03
10 343.8 6.54E-03
0.05 11 344.4 6.35E-03
12 68.4 6.25E-03
2
0.04 13 345.3 6.17E-03
14 345.9 6.14E-03
15 55.3 6.00E-03
0.03 16 347.2 5.73E-03
17 119.1 5.72E-03
0.02
3
4
0.01 6 8 5 79
15 12 17 10
11
13
14
16
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00022\H1, 2_I1sv00000 - 314 h.csv
6 48.8 48
7 261.3 -11
0 8
7 8 95.9 -5
2 4 9 263.1 -47
5
1 10 343.8 -58
-40 9 11 344.4 -60
10
11
13
17
14
16
12 68.4 -74
12
13 345.3 -60
-80 14 345.9 -63
15 55.3 42
16 347.2 -70
-120 17 119.1 -69
-160
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00022\H1, 2_I1sv00000 - 314 h.csv
7 261.3 9.96E-01
0.50 8 95.9 9.91E-01
18 9 263.1 9.92E-01
10 343.8 9.97E-01
0.40 11 344.4 9.95E-01
12 68.4 9.96E-01
13 345.3 9.94E-01
0.30 14 345.9 9.95E-01
15 55.3 9.64E-01
16 347.2 9.96E-01
0.20 17 119.1 9.98E-01
18 0.0 4.45E-01
0.10
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00022\C1, 2_I1sv00000 - 314 h.csv
Fig: B.9.45
6 133.8 1.20E-02
3 7 126.3 1.14E-02
0.015 8 57.5 9.37E-03
4 9 180.0 9.33E-03
5
6 10 148.4 9.16E-03
0.012 7 11 276.6 8.85E-03
12 149.4 8.75E-03
8 10 9 13 45.3 6.90E-03
12 11
0.009 14 44.1 6.46E-03
13 15 60.9 6.37E-03
14 15 16
18 17 16 110.3 6.26E-03
0.006 19 20 17 182.8 5.86E-03
18 43.4 5.82E-03
19 49.4 5.17E-03
0.003
20 157.8 4.92E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00023\H1, 2_I1sv00000 - 336 v.csv
19
6 133.8 -13
1 4
2 7 126.3 48
0 6 8 57.5 34
3 10 11 9 180.0 -37
9 10 148.4 -29
-40 5 12 11 276.6 -26
20
17 12 149.4 -49
13 45.3 31
-80 14 44.1 56
15 60.9 51
16 110.3 54
-120 17 182.8 -68
18 43.4 70
19 49.4 25
-160
20 157.8 -55
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00023\H1, 2_I1sv00000 - 336 v.csv
7 126.3 9.98E-01
0.50 8 57.5 9.92E-01
9 180.0 9.95E-01
10 148.4 9.94E-01
0.40 11 276.6 9.94E-01
12 149.4 9.96E-01
13 45.3 9.96E-01
0.30 14 44.1 9.96E-01
15 60.9 9.72E-01
16 110.3 9.98E-01
0.20 17 182.8 9.94E-01
18 43.4 9.97E-01
0.10 19 49.4 9.97E-01
20 157.8 9.91E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00023\C1, 2_I1sv00000 - 336 v.csv
Fig: B.9.46
6 262.2 4.19E-02
7 163.1 4.03E-02
0.15 8 179.4 3.69E-02
9 161.6 3.30E-02
10 152.8 2.91E-02
0.12 11 25.0 2.73E-02
12 134.7 1.79E-02
13 257.2 1.48E-02
0.09 14 274.4 1.46E-02
3 15 170.9 1.33E-02
16 173.1 1.27E-02
0.06
4
5 6
7 8
9
11 10
0.03
12 13 14
15
16
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00024\H1, 2_I1sv00000 - 399 h.csv
9
15 1 6 262.2 -54
7 16 7 163.1 3
0 8 13 8 179.4 -12
9 161.6 19
2 10 152.8 56
-40 6 11 25.0 26
12 134.7 56
5 13 257.2 -14
-80 14 14 274.4 -93
15 170.9 12
16 173.1 2
-120
-160
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00024\H1, 2_I1sv00000 - 399 h.csv
7 163.1 9.96E-01
0.50 8 179.4 9.74E-01
9 161.6 9.99E-01
10 152.8 9.98E-01
0.40 11 25.0 9.96E-01
12 134.7 9.93E-01
13 257.2 9.96E-01
0.30 14 274.4 9.99E-01
15 170.9 9.96E-01
16 173.1 9.96E-01
0.20 17 0.0 7.30E-02
0.10 17
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00024\C1, 2_I1sv00000 - 399 h.csv
Fig: B.9.47
Freq. Amplitude
# Hz ips / lbf
1 79.4 6.28E-01
0.50 2 86.3 2.76E-01
3 87.2 1.91E-01
4 288.4 9.68E-02
5 287.5 9.49E-02
Amplitude (ips / lbf)
0.20 3
0.10 54
6 7 8 10 9
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00025\H1, 2_I1sv00000 - 399 a.csv
6 6 29.4 22
1 2 7 65.6 60
0 5
8 135.0 -17
8 4
9 296.9 -70
10 233.4 28
-40 3
9
-80
-120
-160
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00025\H1, 2_I1sv00000 - 399 a.csv
7 65.6 9.97E-01
0.50 8 135.0 9.95E-01
9 296.9 9.98E-01
10 233.4 9.97E-01
0.40 11 0.0 4.28E-02
0.30
0.20
0.10
11
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00025\C1, 2_I1sv00000 - 399 a.csv
Fig: B.9.48
Freq. Amplitude
# Hz ips / lbf
1.2 1 51.6 1.42E+00
1.0
Amplitude (ips / lbf)
0.8
0.6
0.4
0.2
0.0
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00026\H1, 2_I1sv00000 - 437 h.csv
40
Phase (degrees)
-40
-80
-120
-160
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00026\H1, 2_I1sv00000 - 437 h.csv
0.60
Magnitude
0.50
0.40
0.30
0.20
0.10
2
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00026\C1, 2_I1sv00000 - 437 h.csv
Fig: B.9.49
Freq. Amplitude
# Hz ips / lbf
0.060 1 113.4 6.67E-02
2 114.7 3.89E-02
3 109.7 3.53E-02
0.050 4 123.8 3.24E-02
5 108.4 2.72E-02
Amplitude (ips / lbf)
6 105.9 2.04E-02
7 117.2 1.79E-02
0.040 2 8 103.4 1.69E-02
3 9 121.9 1.56E-02
4 10 131.3 1.31E-02
0.030 11 101.6 1.17E-02
5 12 120.0 1.13E-02
13 78.1 1.13E-02
6
14 99.4 9.52E-03
0.020 7 15 135.0 8.41E-03
8 16 135.9 8.19E-03
9
10 17 134.4 8.17E-03
13 11 12
14 18 97.8 7.73E-03
0.010 18 15
17
16 19 140.0 6.70E-03
20 19
20 86.3 6.57E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00027\H1, 2_I1sv00000 - 237 v.csv
6 105.9 61
7 117.2 -42
0 8 103.4 68
1
12 9 121.9 -33
94 10 131.3 -64
-40 27
11 101.6 77
10 12 120.0 -27
17
1519 13 78.1 34
16
-80 14 99.4 80
15 135.0 -74
16 135.9 -81
-120 17 134.4 -74
18 97.8 87
19 140.0 -74
-160
20 86.3 39
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00027\H1, 2_I1sv00000 - 237 v.csv
7 117.2 9.98E-01
0.50 8 103.4 9.94E-01
9 121.9 9.84E-01
10 131.3 9.98E-01
0.40 11 101.6 9.95E-01
12 120.0 9.88E-01
13 78.1 9.95E-01
0.30 14 99.4 9.98E-01
15 135.0 9.92E-01
16 135.9 9.83E-01
0.20 17 134.4 9.94E-01
18 97.8 9.97E-01
0.10 19 140.0 9.93E-01
20 86.3 9.87E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00027\C1, 2_I1sv00000 - 237 v.csv
Fig: B.9.50
2.4
Amplitude (ips / lbf)
2.0
1.6
1.2
0.8
0.4
0.0
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00028\H1, 2_I1sv00000 - 212 h.csv
40
Phase (degrees)
-40
-80
-120
-160
1
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00028\H1, 2_I1sv00000 - 212 h.csv
0.60
Magnitude
0.50
0.40
0.30
0.20
0.10
2
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00028\C1, 2_I1sv00000 - 212 h.csv
Fig: B.9.51
6 82.2 8.78E-02
7 63.8 6.00E-02
0.25 8 82.8 5.91E-02
3
4 9 150.0 5.02E-02
10 148.8 4.91E-02
0.20 11 113.1 3.96E-02
12 132.8 3.73E-02
5 13 335.9 3.49E-02
0.15 14 135.6 3.10E-02
15 134.1 3.06E-02
16 177.2 2.56E-02
0.10 6 17 136.9 2.48E-02
7 8
9
10
0.05 11 1214 13
1517 16
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00029\H1, 2_I1sv00000 - 436 h.csv
3 6 82.2 7
68 2 7 63.8 35
0 1 13 8 82.8 10
4 9 150.0 44
10 148.8 43
-40 17
14
15
12 5
11 113.1 70
12 132.8 -50
16 13 335.9 -14
-80 14 135.6 -45
15 134.1 -48
16 177.2 -81
-120 17 136.9 -45
18 0.0 180
-160
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00029\H1, 2_I1sv00000 - 436 h.csv
7 63.8 9.78E-01
0.50 8 82.8 9.96E-01
9 150.0 1.00E+00
10 148.8 1.00E+00
0.40 11 113.1 9.99E-01
12 132.8 9.99E-01
13 335.9 9.87E-01
0.30 14 135.6 9.97E-01
15 134.1 9.99E-01
16 177.2 1.00E+00
0.20 17 136.9 9.99E-01
18 0.0 7.32E-01
0.10
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00029\C1, 2_I1sv00000 - 436 h.csv
Fig: B.9.52
6 33.8 2.92E-03
7 44.7 2.70E-03
0.010 8 45.9 2.55E-03
3
9 47.2 2.37E-03
10 35.3 2.20E-03
0.008 11 51.9 1.58E-03
12 64.1 1.47E-03
13 55.3 1.28E-03
0.006 14 54.7 1.27E-03
4 15 335.9 1.21E-03
16 164.7 1.16E-03
0.004 5
17 163.1 1.09E-03
6 7
8 18 57.5 1.07E-03
10 9
19 82.5 1.04E-03
0.002 11 12
14
13
18 19 16
17 15 20 59.7 9.26E-04
20
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00030\H1, 2_I1sv00000 - 435 a.csv
6 33.8 142
7 44.7 107
0 8 45.9 110
9 47.2 99
10 35.3 150
-40 11 51.9 116
12 64.1 113
13 55.3 95
-80 14 54.7 96
15 335.9 165
2 16 164.7 129
-120 17 163.1 160
18 57.5 94
1 19 82.5 121
-160 3
20 59.7 97
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00030\H1, 2_I1sv00000 - 435 a.csv
3 7 44.7 9.91E-01
0.50 8 45.9 9.95E-01
9 47.2 9.95E-01
10 35.3 9.85E-01
0.40 11 51.9 9.94E-01
12 64.1 9.72E-01
13 55.3 9.98E-01
0.30 14 54.7 9.95E-01
15 335.9 9.92E-01
16 164.7 9.97E-01
0.20 17 163.1 9.94E-01
18 57.5 9.96E-01
0.10 19 82.5 9.93E-01
20 59.7 9.87E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00030\C1, 2_I1sv00000 - 435 a.csv
Fig: B.9.53
6 28.4 3.72E-03
0.006 7 54.1 3.14E-03
43
8 243.1 2.83E-03
0.005 5
9 64.1 2.23E-03
10 51.9 1.74E-03
11 157.5 1.72E-03
0.004 6 12 50.6 1.29E-03
13 23.1 1.09E-03
7
0.003 8 14 256.9 9.84E-04
15 256.3 9.74E-04
9 16 67.2 9.64E-04
0.002 10 11 17 257.8 9.58E-04
12
18 44.7 8.82E-04
13 15
14 19 60.0 8.67E-04
0.001 18 19 16 20 17
20 84.7 8.62E-04
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00031\H1, 2_I1sv00000 - 430 v.csv
12
10 5 6 28.4 58
18 4 7 54.1 -9
0 11
1
7 9 3 8 243.1 -50
9 64.1 -11
19 20 10 51.9 22
-40 8 11 157.5 -3
16
15
14
12 50.6 24
17 13 23.1 95
-80 14 256.9 -70
15 256.3 -67
16 67.2 -57
-120 17 257.8 -76
18 44.7 4
19 60.0 -35
-160
20 84.7 -39
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00031\H1, 2_I1sv00000 - 430 v.csv
7 54.1 9.95E-01
0.50 8 243.1 9.99E-01
9 64.1 9.15E-01
10 51.9 9.91E-01
0.40 11 157.5 9.91E-01
12 50.6 9.96E-01
13 23.1 9.94E-01
0.30 14 256.9 9.97E-01
15 256.3 9.98E-01
16 67.2 9.94E-01
0.20 17 257.8 9.97E-01
18 44.7 9.97E-01
0.10 19 60.0 9.88E-01
20 84.7 9.86E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00031\C1, 2_I1sv00000 - 430 v.csv
Fig: B.9.54
Freq. Amplitude
2 # Hz ips / lbf
1 63.8 3.07E-01
0.25 2 81.9 2.61E-01
3 82.8 2.07E-01
4 51.9 8.37E-02
3
5 30.0 6.63E-02
Amplitude (ips / lbf)
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00032\H1, 2_I1sv00000 - 436 v.csv
19 6 163.1 -22
18 7 163.8 -38
0 5
1 8 91.3 -76
3 11
6 15 9 91.9 -76
4 7 10 66.3 -63
-40 11 156.6 -16
10 12 93.4 -77
14 9
812
13 13 92.8 -78
-80 17
14 67.2 -80
15 339.4 -23
16 27.2 71
-120 17 95.3 -85
18 335.9 8
19 155.0 18
-160
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00032\H1, 2_I1sv00000 - 436 v.csv
7 163.8 9.92E-01
0.50 8 91.3 9.99E-01
9 91.9 9.99E-01
10 66.3 9.97E-01
0.40 11 156.6 8.74E-01
12 93.4 9.96E-01
13 92.8 9.98E-01
0.30 14 67.2 9.91E-01
15 339.4 9.85E-01
16 27.2 9.35E-01
0.20 17 95.3 9.98E-01
18 335.9 9.77E-01
0.10 19 155.0 8.58E-01
20 0.0 7.85E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00032\C1, 2_I1sv00000 - 436 v.csv
Fig: B.9.55
4
6 62.8 1.28E-03
7 64.4 1.15E-03
0.0015 5 8 80.3 1.04E-03
6
9 202.2 1.01E-03
10 110.0 9.91E-04
0.0012 7 11 70.0 9.87E-04
8 9 12 69.4 9.62E-04
11
12 10
13 72.8 7.50E-04
0.0009 14 65.3 7.30E-04
15 14 13 15 42.2 7.00E-04
16
17 16 41.3 6.69E-04
0.0006 18 20 19
17 66.6 5.73E-04
18 43.1 5.68E-04
19 117.2 5.51E-04
0.0003
20 85.3 5.51E-04
0.0000
0 50 100 150 200 250 300 350 400 450 500
FrequencyC:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00033\H1,
(Hz) 2_I1sv00000 - c4 v.csv
18 1 6 62.8 -23
12 7 64.4 -55
0 11 10 9 8 80.3 -33
13
617 4 9 202.2 -11
5 8 10 110.0 -12
-40 14 11 70.0 -11
7
20 19 12 69.4 -1
13 72.8 -18
-80 14 65.3 -49
15 42.2 30
16 41.3 49
-120 17 66.6 -25
18 43.1 14
19 117.2 -62
-160
20 85.3 -64
-200
0 50 100 150 200 250 300 350 400 450 500
FrequencyC:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00033\H1,
(Hz) 2_I1sv00000 - c4 v.csv
7 64.4 7.79E-01
0.50 8 80.3 9.79E-01
9 202.2 9.98E-01
10 110.0 9.50E-01
0.40 11 70.0 9.07E-01
12 69.4 9.86E-01
13 72.8 9.64E-01
0.30 14 65.3 8.52E-01
15 42.2 9.85E-01
16 41.3 9.92E-01
0.20 17 66.6 8.36E-01
18 43.1 9.72E-01
0.10 19 117.2 9.82E-01
20 85.3 9.97E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
FrequencyC:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00033\C1,
(Hz) 2_I1sv00000 - c4 v.csv
Fig: B.9.56
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00034\H1, 2_I1sv00000 - 436 a.csv
1 6 332.8 48
4 12 7 82.2 -15
0 8
13 8 162.8 -14
7 16
113 9 331.9 67
15
20 10 164.4 -48
-40 10 5 17 11 337.5 -27
19 12 150.6 7
13 340.0 -8
-80 14 339.4 34
15 341.3 -34
16 152.8 -19
-120 17 342.5 -46
18 149.4 32
19 344.1 -64
-160
20 341.9 -35
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00034\H1, 2_I1sv00000 - 436 a.csv
2
7 82.2 9.68E-01
0.50 8 162.8 9.77E-01
9 331.9 5.50E-01
10 164.4 9.80E-01
0.40 17
11 337.5 2.32E-01
12 150.6 9.91E-01
19 13 340.0 7.74E-02
0.30 15 14 339.4 4.38E-02
20
5
11 15 341.3 2.80E-01
3
16 152.8 9.84E-01
0.20 17 342.5 3.88E-01
18 149.4 9.92E-01
0.10 19 344.1 3.11E-01
13
20 341.9 2.56E-01
14
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00034\C1, 2_I1sv00000 - 436 a.csv
Fig: B.9.57
6 36.6 1.02E-03
7 25.3 9.27E-04
0.0030 8 82.2 7.73E-04
9 76.9 7.59E-04
10 207.2 7.31E-04
3
11 208.8 6.17E-04
12 81.6 6.11E-04
0.0020 4 13 57.8 6.02E-04
5 14 51.9 5.97E-04
15 86.6 5.73E-04
16 77.8 5.35E-04
6 17 48.4 5.17E-04
0.0010 7
18 89.1 5.02E-04
9 8 10
14 13 1215 11 19 71.6 5.00E-04
17 19 16
20 18
20 80.3 4.68E-04
0.0000
0 50 100 150 200 250 300 350 400 450 500
FrequencyC:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00035\H1,
(Hz) 2_I1sv00000 - c1 a.csv
6 36.6 -72
2 10
19 9 12 7 25.3 82
0 14
4 11 8 82.2 -25
17 208
16 9 76.9 -4
1
10 207.2 11
-40 15
11 208.8 -14
13 18 12 81.6 -2
6
13 57.8 -63
-80 14 51.9 -2
15 86.6 -45
16 77.8 -25
-120 17 48.4 -22
18 89.1 -67
19 71.6 0
-160
20 80.3 -21
-200
0 50 100 150 200 250 300 350 400 450 500
FrequencyC:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00035\H1,
(Hz) 2_I1sv00000 - c1 a.csv
7 25.3 9.98E-01
0.50 8 82.2 9.57E-01
9 76.9 9.45E-01
10 207.2 9.97E-01
0.40 11 208.8 9.98E-01
12 81.6 9.39E-01
13 57.8 8.92E-01
0.30 14 51.9 9.94E-01
15 86.6 9.99E-01
16 77.8 9.77E-01
0.20 17 48.4 9.94E-01
18 89.1 9.96E-01
0.10 19 71.6 7.34E-01
20 80.3 9.57E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
FrequencyC:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00035\C1,
(Hz) 2_I1sv00000 - c1 a.csv
Fig: B.9.58
Transfer Function TP: 450 psv (a) [Hit 450 psv] (a)
0.20
Channel: 2
Date: May 31, 2016 06:45
0.18 Setup:
Note:
1
4 3 6 474.4 1.02E-01
57 6 7 454.4 1.01E-01
0.10 8 8 457.5 9.43E-02
10 9 9 458.4 8.79E-02
1213 11
14 10 452.5 8.63E-02
15
0.08 11 459.4 8.54E-02
16 12 450.3 8.33E-02
17 1819
20 13 453.1 8.16E-02
0.06 14 449.4 8.16E-02
15 455.3 8.01E-02
16 256.3 6.75E-02
0.04 17 448.8 6.32E-02
18 473.1 6.15E-02
19 476.6 6.14E-02
0.02
20 471.3 6.09E-02
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00036\H1, 2_I1sv00000 - 450 a.csv
Transfer Function TP: 450 psv (a) [Hit 450 psv] (a)
200
Channel: 2
Date: May 31, 2016 06:45
160 Setup:
16 Note:
17 6 474.4 -66
5
14
12
10 7 454.4 -31
0 13 8 457.5 -25
38 9 458.4 -57
7
10 452.5 2
-40 15 11 459.4 -64
9 18
11
206
12 450.3 3
19 13 453.1 -6
-80 14 449.4 5
15 455.3 -47
4 16 256.3 142
-120 17 448.8 21
2 18 473.1 -58
19 476.6 -81
-160 1 20 471.3 -71
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00036\H1, 2_I1sv00000 - 450 a.csv
7 454.4 5.46E-01
0.50 8 457.5 3.36E-01
9 458.4 5.36E-01
17 10 452.5 5.46E-01
0.40 11 459.4 5.58E-01
38
15 12 450.3 5.46E-01
13 453.1 5.52E-01
0.30 14 449.4 5.82E-01
15 455.3 3.45E-01
16 256.3 8.34E-01
0.20 17 448.8 4.03E-01
18 473.1 6.64E-01
0.10 19 476.6 6.20E-01
20 471.3 6.64E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00036\C1, 2_I1sv00000 - 450 a.csv
Fig: B.9.59
Transfer Function TP: 450 mid (a) [Hit 450 psv] (a)
0.10
Channel: 3
Date: May 31, 2016 06:45
0.09 1 Setup:
Note:
3
6 474.4 4.49E-02
7 451.6 4.40E-02
0.05 4
8 457.5 4.17E-02
5 6
7 9 458.4 4.00E-02
8 10 459.4 3.89E-02
9
0.04 11 10
1312 11 452.5 3.77E-02
15 1614
1917
20 18 12 455.3 3.66E-02
13 450.3 3.64E-02
0.03 14 453.1 3.60E-02
15 245.6 3.57E-02
16 449.4 3.51E-02
0.02 17 246.3 3.48E-02
18 256.3 3.39E-02
19 243.4 3.38E-02
0.01
20 247.2 3.33E-02
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00036\H1, 3_I1sv00000 - 450 a.csv
Transfer Function TP: 450 mid (a) [Hit 450 psv] (a)
200
Channel: 3
Date: May 31, 2016 06:45
160 Setup:
18 Note:
6 474.4 -71
7
16
13
7 451.6 5
0 11
14 8 457.5 -31
4 9 458.4 -62
58 10 459.4 -69
-40 12 11 452.5 -3
9 12 455.3 -51
10 6
13 450.3 -1
-80 14 453.1 -10
19
15 15 245.6 -109
17 3 16 449.4 2
-120 20
17 246.3 -116
2
18 256.3 144
19 243.4 -105
-160 1 20 247.2 -125
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00036\H1, 3_I1sv00000 - 450 a.csv
1920
17
Date: May 31, 2016 06:45
15 Setup:
0.90 2
31
Note:
18
0.80 Freq. Magnitude
#Hz
1 253.4 8.84E-01
0.70 2 252.5 8.85E-01
6
7 3 250.9 8.72E-01
4 456.6 3.63E-01
0.60 16 10 5 454.4 5.50E-01
13154 9 6 474.4 6.61E-01
Magnitude
11
7 451.6 6.46E-01
0.50 8 457.5 3.44E-01
9 458.4 5.63E-01
10 459.4 5.84E-01
0.40 12 11 452.5 5.32E-01
4
8 12 455.3 3.68E-01
13 450.3 5.56E-01
0.30 14 453.1 5.54E-01
15 245.6 9.00E-01
16 449.4 5.76E-01
0.20 17 246.3 9.07E-01
18 256.3 8.07E-01
0.10 19 243.4 9.08E-01
20 247.2 9.20E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00036\C1, 3_I1sv00000 - 450 a.csv
Fig: B.9.60
6 343.4 1.47E-02
2 3 7 323.1 1.44E-02
54 6
0.015 7 8
9 8 328.4 1.42E-02
10
11 12
13
17 18 1516
20 19
14 9 324.1 1.40E-02
10 354.7 1.37E-02
0.012 11 342.8 1.36E-02
12 354.1 1.35E-02
13 340.6 1.33E-02
0.009 14 451.6 1.33E-02
15 335.6 1.32E-02
16 341.6 1.32E-02
0.006 17 321.9 1.31E-02
18 329.4 1.29E-02
19 368.4 1.29E-02
0.003
20 321.3 1.29E-02
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00036\H1, 4_I1sv00000 - 450 a.csv
6 343.4 11
6
7 323.1 141
0 8 328.4 99
9 324.1 131
12 10 354.7 -64
-40 11 342.8 26
10 12 354.1 -38
13 340.6 42
-80 14 451.6 -153
3 15 335.6 73
19
16 341.6 40
-120 17 321.9 150
14
18 329.4 93
19 368.4 -113
-160
20 321.3 160
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00036\H1, 4_I1sv00000 - 450 a.csv
7 323.1 8.17E-01
0.50 10 8 328.4 7.62E-01
9 324.1 8.25E-01
3 10 354.7 4.69E-01
0.40 11 342.8 6.85E-01
19 12 354.1 6.09E-01
13 340.6 6.89E-01
0.30 14 451.6 6.50E-01
15 335.6 7.57E-01
16 341.6 7.22E-01
0.20 17 321.9 8.05E-01
18 329.4 8.27E-01
0.10 19 368.4 3.49E-01
20 321.3 8.24E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00036\C1, 4_I1sv00000 - 450 a.csv
Fig: B.9.61
0.0000
0 50 100 150 200 250 300 350 400 450 500
FrequencyC:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00037\H1,
(Hz) 2_I1sv00000 - c2 a.csv
6 35.3 -152
7 43.1 -168
0 8 33.8 -133
9 44.7 178
10 50.6 120
-40 11 236.3 152
12 235.6 161
13 63.4 136
-80 14 52.8 115
15 231.3 -167
16 232.5 -177
-120 8 17 231.9 -173
4 18 233.4 176
6
19 59.7 154
-160 7 15
23 17
16 20 60.3 126
-200
0 50 100 150 200 250 300 350 400 450 500
FrequencyC:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00037\H1,
(Hz) 2_I1sv00000 - c2 a.csv
7 43.1 9.97E-01
0.50 8 33.8 9.96E-01
9 44.7 9.97E-01
10 50.6 9.98E-01
0.40 11 236.3 9.98E-01
12 235.6 9.98E-01
13 63.4 9.05E-01
0.30 14 52.8 9.98E-01
15 231.3 9.98E-01
16 232.5 9.97E-01
0.20 17 231.9 9.96E-01
18 233.4 9.98E-01
0.10 19 59.7 9.74E-01
20 60.3 9.13E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
FrequencyC:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00037\C1,
(Hz) 2_I1sv00000 - c2 a.csv
Fig: B.9.62
6 44.7 3.12E-03
0.008 7 33.4 2.98E-03
8 50.6 2.19E-03
0.007 9 54.7 1.89E-03
10 55.6 1.88E-03
0.006 45 11 53.4 1.84E-03
12 63.8 1.82E-03
0.005 13 56.9 1.81E-03
14 58.8 1.67E-03
0.004 15 67.5 1.34E-03
7 6 16 82.2 1.25E-03
0.003 17 84.4 1.21E-03
8
1913
0 12 18 152.5 1.11E-03
0.002 11 14
19 81.6 1.05E-03
15 16
1917 1820 20 156.3 1.00E-03
0.001
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00038\H1, 2_I1sv00000 - 430 a.csv
6 44.7 105
7 33.4 178
0 8 50.6 128
9 54.7 110
10 55.6 110
-40 11 53.4 112
12 63.8 110
13 56.9 108
-80 14 58.8 104
15 67.5 94
16 82.2 122
-120 1 17 84.4 104
18 152.5 164
2
19 81.6 122
-160
20 156.3 135
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00038\H1, 2_I1sv00000 - 430 a.csv
7 33.4 8.07E-01
0.50 1 8 50.6 9.93E-01
9 54.7 9.63E-01
10 55.6 9.49E-01
0.40 11 53.4 9.90E-01
12 63.8 9.93E-01
13 56.9 9.34E-01
0.30 14 58.8 9.34E-01
15 67.5 9.95E-01
16 82.2 9.93E-01
0.20 17 84.4 9.74E-01
18 152.5 9.92E-01
0.10 19 81.6 9.88E-01
20 156.3 9.77E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00038\C1, 2_I1sv00000 - 430 a.csv
Fig: B.9.63
6 41.6 2.79E-03
4 7 45.0 8.58E-04
0.0050 8 155.6 7.50E-04
9 159.7 7.19E-04
10 47.2 6.63E-04
0.0040 5 11 81.3 6.23E-04
12 63.4 5.62E-04
13 278.4 5.60E-04
0.0030 6 14 82.2 5.25E-04
15 50.9 5.14E-04
16 55.0 5.03E-04
0.0020 17 56.3 4.95E-04
18 80.6 4.91E-04
19 161.6 4.78E-04
0.0010 7 89
10
17 12
1520
16 11
14
18 19 13 20 53.8 4.65E-04
0.0000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00038\H1, 3_I1sv00000 - 430 a.csv
120 5
Freq. Phase
# Hz degrees
1 38.1 3
80 2 27.8 -151
3 28.4 174
11
18 4 30.0 134
40 5 33.8 107
Phase (degrees)
12 6 41.6 -59
1 7 45.0 -88
0 14 8 155.6 -120
9 159.7 -149
10 47.2 -86
-40 11 81.3 51
6
12 63.4 15
13 278.4 171
-80 710 14 82.2 -8
15 15 50.9 -107
8 16 55.0 -148
-120 20 17 56.3 -177
2 16 9 18 80.6 50
19 161.6 163
-160
17 20 53.8 -133
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00038\H1, 3_I1sv00000 - 430 a.csv
7 45.0 9.64E-01
0.50 8 155.6 9.51E-01
2
9 159.7 9.64E-01
10 47.2 9.63E-01
0.40 11 81.3 9.68E-01
12 63.4 9.28E-01
13 278.4 9.90E-01
0.30 14 82.2 8.73E-01
15 50.9 9.92E-01
16 55.0 7.99E-01
0.20 17 56.3 6.05E-01
18 80.6 9.51E-01
0.10 19 161.6 9.82E-01
20 53.8 9.39E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00038\C1, 3_I1sv00000 - 430 a.csv
Fig: B.9.64
6 152.5 2.15E-03
7 150.0 2.13E-03
0.010 8 47.2 2.01E-03
9 50.9 1.47E-03
10 53.1 1.31E-03
0.008 11 278.1 1.29E-03
2 12 333.8 1.24E-03
3 13 54.7 1.20E-03
0.006 4 14 63.8 8.99E-04
0.004
5
8 76
0.002 910 11
13 12
14
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00038\H1, 4_I1sv00000 - 430 a.csv
6 152.5 180
7 150.0 -136
0 1
8 47.2 -81
9 50.9 -89
10 53.1 -91
-40 11 278.1 -169
14 12 333.8 172
3 13 54.7 -102
58
-80 910 14 63.8 -65
13
-120
7
-160 11
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00038\H1, 4_I1sv00000 - 430 a.csv
7 150.0 9.91E-01
0.50 8 47.2 9.92E-01
9 50.9 9.97E-01
10 53.1 9.93E-01
0.40 11 278.1 9.93E-01
12 333.8 7.02E-01
13 54.7 9.77E-01
0.30 14 63.8 9.75E-01
15 0.0 6.48E-01
0.20
0.10
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00038\C1, 4_I1sv00000 - 430 a.csv
Fig: B.9.65
6 105.6 2.25E-02
0.06 7 221.3 2.23E-02
8 310.3 2.20E-02
0.05 9 216.6 2.06E-02
10 221.9 2.05E-02
11 223.1 1.86E-02
0.04 12 98.1 1.54E-02
13 324.1 1.51E-02
0.03 2 14 319.1 1.48E-02
3 15 321.3 1.42E-02
5 64 7 8 16 322.8 1.41E-02
9 10
0.02 11 17 322.2 1.40E-02
12 14
1513
16 18 304.1 1.27E-02
18 17
19
20
19 94.4 1.25E-02
0.01 20 96.9 1.21E-02
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00039\H1, 3_I1sv00000 - 105 h.csv
6 105.6 132
7 221.3 177
0 8 310.3 -157
9 216.6 -158
10 221.9 169
-40 11 223.1 155
12 98.1 -119
13 324.1 118
-80 14 319.1 127
5 15 321.3 124
19
212
0 16 322.8 123
-120 17 322.2 124
18 18 304.1 -144
9 8 19 94.4 -117
-160
20 96.9 -118
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00039\H1, 3_I1sv00000 - 105 h.csv
7 221.3 9.94E-01
0.50 8 310.3 9.95E-01
9 216.6 9.95E-01
10 221.9 9.93E-01
0.40 11 223.1 9.97E-01
12 98.1 9.94E-01
13 324.1 9.95E-01
0.30 14 319.1 9.84E-01
15 321.3 9.81E-01
16 322.8 9.84E-01
0.20 17 322.2 9.90E-01
18 304.1 9.92E-01
0.10 19 94.4 9.93E-01
20 96.9 9.93E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00039\C1, 3_I1sv00000 - 105 h.csv
Fig: B.9.66
6 140.6 3.95E-02
0.08 2 7 84.7 2.73E-02
3
8 365.9 1.91E-02
0.07 9 366.6 1.90E-02
4
10 88.4 1.55E-02
0.06 11 371.3 1.35E-02
5 12 371.9 1.35E-02
0.05 13 372.8 1.32E-02
6 14 374.7 1.24E-02
0.04 15 377.2 1.16E-02
16 378.1 1.13E-02
0.03 7
17 90.9 1.10E-02
89 18 91.6 1.10E-02
0.02 10 19 378.8 1.09E-02
11
12
13
14
17
18 15
16
19
20
0.01 20 380.6 1.08E-02
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00040\H1, 3_I1sv00000 - 105 a.csv
120 7
10
89
11
12
13
14
Freq. Phase
18
17 16
19
1520 # Hz degrees
1 77.8 172
80 2 355.3 171
3 354.4 -168
4 81.6 136
40 5 75.3 -122
Phase (degrees)
6 140.6 159
7 84.7 115
0 8 365.9 116
9 366.6 113
10 88.4 107
-40 11 371.3 109
12 371.9 109
13 372.8 107
-80 14 374.7 106
15 377.2 103
5 16 378.1 105
-120 17 90.9 100
18 91.6 101
19 378.8 104
-160 3
20 380.6 103
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00040\H1, 3_I1sv00000 - 105 a.csv
7 84.7 9.98E-01
0.50 8 365.9 9.86E-01
9 366.6 9.85E-01
10 88.4 9.97E-01
0.40 11 371.3 9.82E-01
12 371.9 9.84E-01
13 372.8 9.82E-01
0.30 14 374.7 9.85E-01
15 377.2 9.82E-01
16 378.1 9.83E-01
0.20 17 90.9 9.97E-01
18 91.6 9.97E-01
0.10 19 378.8 9.85E-01
20 380.6 9.75E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00040\C1, 3_I1sv00000 - 105 a.csv
Fig: B.9.67
6 36.6 1.09E-01
7 40.0 1.01E-01
0.30 8 87.8 8.61E-02
9 37.5 7.99E-02
10 39.1 7.63E-02
11 81.6 7.20E-02
12 41.6 6.69E-02
0.20 13 23.4 6.37E-02
14 42.8 5.76E-02
43 15 84.4 4.83E-02
5 16 78.4 4.72E-02
6
7 17 45.9 4.11E-02
0.10 910 8
18 46.9 3.78E-02
12 11
13 14 19 91.6 3.64E-02
17 16 15
18 20 19 20 74.1 3.43E-02
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00041\H1, 2_I1sv00000 - 490 h.csv
6 36.6 106
7 40.0 106
0 8 87.8 138
9 37.5 110
10 39.1 119
-40 11 81.6 171
12 41.6 96
13 23.4 -101
-80 14 42.8 95
13 15 84.4 144
5
16 78.4 -145
-120 17 45.9 95
16 18 46.9 92
19 91.6 109
-160
2 20 74.1 149
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00041\H1, 2_I1sv00000 - 490 h.csv
7 40.0 9.98E-01
0.50 8 87.8 9.99E-01
9 37.5 9.97E-01
10 39.1 9.96E-01
0.40 11 81.6 9.95E-01
12 41.6 9.98E-01
13 23.4 9.99E-01
0.30 14 42.8 9.97E-01
15 84.4 9.99E-01
16 78.4 9.94E-01
0.20 17 45.9 9.99E-01
18 46.9 9.98E-01
0.10 19 91.6 9.99E-01
20 74.1 9.78E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00041\C1, 2_I1sv00000 - 490 h.csv
Fig: B.9.68
6 391.6 2.26E-02
7 339.1 1.93E-02
0.06 8 338.1 1.90E-02
9 170.9 1.75E-02
10 170.3 1.75E-02
11 201.9 1.68E-02
12 399.1 1.67E-02
0.04 13 399.7 1.63E-02
14 398.4 1.61E-02
2 15 400.6 1.61E-02
34 16 394.7 1.59E-02
56
87 17 384.4 1.55E-02
0.02 10
9 11 12
13
14
15 18 396.9 1.54E-02
17 16
19 18
20
19 383.8 1.53E-02
20 395.9 1.50E-02
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00042\H1, 2_I1sv00000 - 390 a.csv
6 391.6 -177
7 339.1 -159
0 8 338.1 -149
9 170.9 -165
10 170.3 -155
-40 11 201.9 173
12 399.1 170
13 399.7 165
-80 14 398.4 174
15 400.6 164
16 394.7 163
-120 19 17 384.4 -138
17
8 3 18 396.9 173
10 2
7 19 383.8 -134
-160 9 4
56 20 395.9 169
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00042\H1, 2_I1sv00000 - 390 a.csv
7 339.1 9.76E-01
0.50 8 338.1 9.79E-01
9 170.9 9.97E-01
10 170.3 9.96E-01
0.40 11 201.9 9.90E-01
12 399.1 9.24E-01
13 399.7 9.44E-01
0.30 14 398.4 9.23E-01
15 400.6 9.37E-01
16 394.7 9.36E-01
0.20 17 384.4 9.20E-01
18 396.9 9.27E-01
0.10 19 383.8 9.20E-01
20 395.9 9.38E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00042\C1, 2_I1sv00000 - 390 a.csv
Fig: B.9.69
Freq. Amplitude
# Hz ips / lbf
0.060 1 32.8 7.08E-02
2 26.9 5.29E-02
32
3 26.3 5.28E-02
0.050 4 69.1 3.93E-02
5 37.5 1.62E-02
Amplitude (ips / lbf)
6 54.4 1.48E-02
7 23.1 1.35E-02
0.040 4
8 73.1 1.30E-02
9 36.3 1.25E-02
10 89.1 1.08E-02
0.030 11 87.8 9.72E-03
12 90.6 9.72E-03
13 21.3 9.64E-03
14 86.9 9.49E-03
0.020 15 76.6 8.95E-03
5
6
16 18.8 7.27E-03
7 9 8 17 390.3 7.07E-03
13
10
1112 18 40.0 7.05E-03
0.010 15 14
16 18 20 17
19 19 391.9 7.04E-03
20 48.1 6.98E-03
0.000
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00043\H1, 2_I1sv00000 - 270 h.csv
3
6 54.4 -33
2 7 23.1 78
20 4
0 8 73.1 -53
17 9 36.3 -74
1 6 14 10 89.1 -53
11 19
-40 8 10 11 87.8 -42
5 15 12 90.6 -69
12
9 13 21.3 82
18
-80 14 86.9 -34
15 76.6 -62
16 18.8 76
-120 17 390.3 -27
18 40.0 -81
19 391.9 -42
-160
20 48.1 1
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00043\H1, 2_I1sv00000 - 270 h.csv
7 23.1 9.99E-01
0.50 8 73.1 9.98E-01
9 36.3 9.97E-01
10 89.1 9.99E-01
0.40 11 87.8 9.99E-01
12 90.6 9.98E-01
13 21.3 9.94E-01
0.30 14 86.9 9.98E-01
15 76.6 9.97E-01
16 18.8 9.99E-01
0.20 17 390.3 8.78E-01
18 40.0 9.97E-01
0.10 19 391.9 9.43E-01
20 48.1 9.85E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00043\C1, 2_I1sv00000 - 270 h.csv
Fig: B.9.70
6 48.4 1.67E-02
7 68.4 1.56E-02
0.05 8 23.1 1.48E-02
9 42.8 1.47E-02
10 420.0 1.34E-02
0.04 11 419.4 1.31E-02
12 21.3 1.20E-02
13 75.0 1.19E-02
0.03 14 74.4 1.17E-02
43 15 77.2 1.07E-02
16 52.8 1.02E-02
0.02 6 5 17 17.5 1.01E-02
8 9 7
12 13
14
10
11 18 72.8 1.01E-02
17 16
20 1815
19 19 78.1 9.56E-03
0.01
20 54.1 9.11E-03
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00044\H1, 2_I1sv00000 - 360 h.csv
6 48.4 136
7 68.4 -169
0 8 23.1 -105
9 42.8 -158
10 420.0 176
-40 11 419.4 -173
12 21.3 -105
13 75.0 132
-80 14 74.4 144
128 15 77.2 124
16 52.8 151
-120 17
17 17.5 -126
18 72.8 148
1 9 19 78.1 114
-160 4 7 11 20 54.1 131
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00044\H1, 2_I1sv00000 - 360 h.csv
7 68.4 9.94E-01
0.50 8 23.1 9.99E-01
9 42.8 9.93E-01
10 420.0 9.66E-01
0.40 11 419.4 9.68E-01
12 21.3 9.99E-01
13 75.0 9.99E-01
0.30 14 74.4 9.98E-01
15 77.2 9.95E-01
16 52.8 9.97E-01
0.20 17 17.5 9.77E-01
18 72.8 9.97E-01
0.10 19 78.1 9.97E-01
20 54.1 9.98E-01
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00044\C1, 2_I1sv00000 - 360 h.csv
Fig: B.9.71
6 21.6 5.21E-02
0.6
0.5
0.4
0.3
0.2
2
0.1 34
6 5
0.0
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00045\H1, 2_I1sv00000 - 470 a.csv
6 21.6 110
7 0.0 180
0
-40
-80
3
-120
2
-160
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00045\H1, 2_I1sv00000 - 470 a.csv
7 0.0 7.01E-01
0.50
0.40
0.30
0.20
0.10
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00045\C1, 2_I1sv00000 - 470 a.csv
Fig: B.9.72
Freq. Amplitude
0.70 # Hz ips / lbf
1 86.6 7.85E-01
2 177.8 3.96E-01
0.60 3 152.5 6.11E-02
4 337.8 5.66E-02
Amplitude (ips / lbf)
0.50
2
0.40
0.30
0.20
0.10
3 4
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00046\H1, 2_I1sv00000 - 408 h.csv
1 3 2
0
4
-40
-80
-120
-160
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00046\H1, 2_I1sv00000 - 408 h.csv
0.50
0.40
0.30
0.20
0.10
5
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00046\C1, 2_I1sv00000 - 408 h.csv
Fig: B.9.73
0.30
0.20
3
0.10
5
6
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00047\H1, 2_I1sv00000 - 438 h.csv
6 89.1 101
0
-40
-80
-120
3
-160
2
-200
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00047\H1, 2_I1sv00000 - 438 h.csv
7 0.0 3.17E-01
0.50
0.40
7
0.30
0.20
0.10
0.00
0 50 100 150 200 250 300 350 400 450 500
Frequency (Hz) C:\projects\US00365\FieldData\US00365_GEOilAndGas_Egypt_Bump.trf\ASCII00047\C1, 2_I1sv00000 - 438 h.csv
C.1 Guidelines
The following four guidelines are useful for assessing the pulsation and vibration levels of a reciprocating
compressor piping system, and vibration levels for the skid.
Care must be taken in applying these vibration guidelines, as the real concern is with stress levels. Vibrations are
only an indirect indication of stress.
Pulsations vary greatly in a piping system depending on the location of the measurement. As a result, measured
pulsations are almost always less than the highest pulsation present in the system. Cylinder side pulsations are
typically highest at the valves, but only occasionally can be measured through the valve cover.
Mechanical resonance can be a problem even if Mechanical Natural Frequencies (MNFs) are at frequencies
above the limits stated below. Experience has shown that the limits shown are an excellent starting point for a
good design. Vibration levels can be acceptable even though MNFs are below the guidelines, but this is seldom
true.
BETA Machinery Analysis Ltd. has other standards for allowable compressor cylinder stretch vibrations. These
must be calculated for the specific operating conditions of each cylinder.
C.3.2 Compressor Side Pulsation Limits (Based on API 618 4th Edition)
Pulsation levels measured at the cylinder flange shall be less than the following:
CPL = 3R with 7% Maximum
Where:
CPL = % allowable unfiltered peak-to-peak pulsation referred to absolute line pressure
R = Stage Compression Ratio
C.6 Vibration Guidelines for Relief Valves and Small Bore Appendages.
Some vibration guidelines are based on overall (unfiltered) vibrations. (Note that measuring overall vibrations
accurately is difficult.)
Figure C.1 – Guidelines for Recip. Compressors (1800 RPM max.) – Vibration Amplitude (in/s Peak)
Check for pipe strain by loosening clamps and determining if any of the scenarios apply. This should be done
when the pipe is near operating temperature. Modifications need to be implemented according to the pipe
strain case.
1. Clamp bolt holes in support should be repositioned or elongated.
2. Sleeper should be lowered
3. Shims should be added (up to a maximum of 3 shims thick). Measure the gap, and then lift the pipe
slightly (with a pry bar) so that the shims can be installed easily. Shims should not be forced into
position.
The goal is to support the pipe in its neutral, hot position, at each support. Bolts for a properly fitting clamp
should be tightened until snug, and then tightened approximately a quarter turn more.
In some installations, a clamp close to the discharge bottle may be designed to be an anchor. In that case, the
anchor should be set cold, and not loosened when the system is hot. Loosening the other clamps when hot will
cause the pipe to expand away from the anchor, as per design.
When “re-torquing” fasteners to achieve adequate preload, it is critical that the fastener be “backed off” and all
mating surfaces dressed and lubricated prior to tightening. Torque must be measured while the fastener is
turning in order for the relationship between torque and preload to be at all valid. There is considerable
resistance to turning once the fastener is at rest (static friction). Static friction will cause the torque reading to
be higher than when the fastener is turning, resulting in a preload that is lower than expected.
If it becomes necessary to further improve the evaluation of preload, installing load-indicating fasteners can be
an effective solution. Some commercial examples include “SmartBolts”, “RotaBolt”, Valley Forge “SPC4” and
“Maxbolt”.