Académique Documents
Professionnel Documents
Culture Documents
~ SUZUKI
Count on us
MAR
SECURITY ALARM
NCS- 409/509
GA
OWNER'S MANUAL
PRECAUTIONS
LOCK
PANIC
UNLOCK - --,. "'_" "~I_
REMOTE CONTROL
MAIN CONTROL MODULE
GENERAL FEATURES
NOTE: Keyless Lock &Arm/Unlock & Di sarm will not function if any door is open,
* For Lx, Lxi version of the vehicle, Room lamp will turn OFF when IGN, is turned ON,
D
Illuminated Exit:
When key is removed from the cylinder the room lomp will turn ON to facilitate
illuminated exit. If none of the door is opened within 15sec of key removal from cylinder
the room lamp will turn OFF itself
When door is opened to exit the vehicle, the room lamp will turn ON again ( If turned OFF
after 15sec of key removal from key cylinder) and will turn OFF after 15sec of closing all
the doors to facilitate illuminated exit. In between 15sec of all door closure if door is
locked by key or by pressing the lock button on re mote the room lamp will turn OFF
instantly.
3. DOORS/TRUNK/BONNET PROTECTION
This feature provides security for all four doors, trunk & bonnet & also ensures indicator
su pervision.
# Note: All features related to shock sensor is an option . These features will
operate only if it is available in that particular variant.
7. AUTO REARM
System will automatically lock and arm the vehicle if none of the door is opened within
30seconds of unlocking/ disarming the vehicle by remote transmitter.
8. CAR LOCATOR
In a congested/pocked parking area, the vehicle can be located by pressing
the panic button for more than 2sec. The indicator light will flash fO!' 30sec.
Press panic button again to turn OFF the indicator lightfla shing.
9. RADIO FREQUENCY LOCK OUT
17. ANTI-HIJACK
The An ti-Hijack mode can be used to discourage a potential vehicle hijacker from
violating you and your vehicle while you are driving it. If somebod y tries to open the door'
under IGN ON condition (while dri ving) the An ti-Hijack mode gets trigge red .
* For Lx, Lxi version of the vehicle, if drive unlock is programmed by key, then it will work by
IGN. furn OFF.
I
SYSTEM OPERATION
1.1 ALARM ON/ARM /lOCKING
1. Press and release the transmitter LOCK button.
2. One chirp and one indicator lightflash will confirm alarm ON .
3. Doors will get locked and vehicle will get armed.
4. Visible theft warning LED light will flash slowly.
/'
(~~))
PRESS
-=3 8
LOCK BUTTON 1 CHIRP 1 FLASH LOCK /
NOTE: Room lamp if ON with its switch at door position will turn OFF .
/~~) PRESS
-=3($'
" UNLOCK BUTTON 2 CHIRP 2 F~ASH UNLOCK . /
NOTE: Room lamp will turn OI\J if its switch is at door position.
II . '
PRESS FOR
MORE THEN 2. SEC
SIREN ON
FOR 30 SEC.
LIGHT FLASHES
FOR 30 SEC .
D
code acts as a secret key, to emergency disarm the vehicle.
1. Turn the IGN ON, OFF and then ON.
2. Enterthe FIRST digit (for e.g. to enter 2 press and release valet switch twice)
3. Turn the IGN OFF then ON.
4. Enter the SECOND digit.
S. Turn the IGN OFF and then ON.
6. Enterthe THIRD digit.
7. Turn the IGN OFF and then ON.
8. Enterthe LAST digit.
9. Turn the IGN OFF and then ON. The vehicle will get disarmed.
1.5 VALET MODE
To turn off all security features and use the system as keyless entry only there by turning off
all the alarm features (excluding drive lock/ unlack), this feature can be programmed.
Programming va let mode:
1. Close the door.
2. Turn IGN ON-OFF quickly.
3. Press and hold va let switch for 3 sec minimum , LED will turn ON for 1 minute and then wil l
turn OFF permanently.
Repeat step 1-3 to come out of Valet mode, 1 chirp sound will indicate VALET MODE OFF.
Passive Mode
1. Open the Door of your vehicle.
2. With your vehicle key in the key cylinder, turn IGN ON and then switch it OFF.
3. Press and release the valet switch ONE time.
4. Press and hold the valet switch.
5. One chirp sound confirms entry into Passive Arming ON/OFF programming mode.
6. Press the transmitter LOCK button (while holding the valet switch), a single chirp sound
confirms Passive Arm ing OFf
7. Two-siren chirp sound confirms the mode changed to Passive Arming ON.
8. Release the valet switch.
9. Turn the ignition ON.
III
U is..l P T - ~ s :s. ,,-.:; ~
2 . Oper. ji e door.
3. Tu rn IGN 0 ihen OFF
4. Within 5 seconds press and release va let switch 5 times. A short chirp followed by long
ch irps confirms entry into PIN CODE programming mode.
5 Press LOCK button on remote transmitter, after a single chirp enter the FIRST digit (with in
1-9) by pressing valet switch (for e.g. to enter 2 press and release valet switch two times).
6. Press LOCK button on remote transmitter, after two chirp enter the SECOND digit (wi th in
1-9) by pressing valet switch.
7. Press LOCK button on remote transmitter, after 3-chirps enter the THIRD digit (with in 1-9)
by pressing valet switch.
8. Press LOCK button o n remote transmitter, after 4-chirps enter the FOURTH d igit (with in 1
9) by pressing valet switch.
1. Remove bock cover and then remove the old battery carefully.
2. Replace with fresh new battery a nd close the back cover.
3. Press any button to check for light flash from LED.
The battery being replaced should be inserted after checking the polarity.
NOTE: Normal battery life is approximately 3 years, but varies depending on usage. For
optimum performance and proper RF range, replace the battery at least once a year. It is
advisable to get battery replaced from any authorized dealer or service centre.
TROUBLE-SHOOTING
NOIDA PUNE
NIPPON AUDIOTRONIX LTD. (Head Office) BHANDARI AUTO CORP.
MUMBAI- NAL
NIPPON AUDIOTRONIX LTD. (Branch Office) RAJKOT
9, Rayfreda Building, Second Floor, Andheri , AMBICA SERVICES
"Yogeshwar", Jagnath Mandir Chowk,
Kurio Rood, Near Holy Family Church, Chokio,
Dr. Yagnik Rood . Tel.: (0281)-2465615
Andheri [East). Tel. : 022 - 65777771 / 72
CHENNAI SURAT
B.N. ELECTRONICS
NIPPON AUDIOTRONIX LTD. (Branch Office) Behind Center Point, Civil Char Rasta,
KOLKATA Sangrampura.
MUMBAI RANCH I
SADHWANI SERVICE CENTRE BABUL ELECTRONICS
NASIK SILIGURI
VIDEO CARE
DASS ELECTRONICS
Tel. : 09896391033
( NORTH ZONE)
INDORE
AGRA AUTO LUXURY
ELECTRONIC HOSPITAL
LG 1, Royal Ratan Building,
Tel.: (0562)-2520398
JABALPUR
ALLAHABAD SEHTA ELECTRONICS
Tel.: (0532)-2609924/2608014
Nr. Prabhu Vandana Talkies .
Tel. : (0761)-4004632
AMRITSAR
VISION CARE CENTRE
JAIPUR
Building No.8, Near Gagan Cinema,
MOTOWORLD INDIA
Batala Road.
B-22 , GOllesh Marg ,
Tel. : (0183)-2276009/2274002
Opp. Jain Temple
Babu Nagar. Tel.: (0141)-2719058
BAREILLY
ALPHA VIDEO CARE
JALANDHAR
106/5, 1st Floor,
ELECTRO CARE
BHATINDA
AUDIO VIDEO CENTRE
Near Gole Diggi , Amrik Singh Road. JAMMU
Tel.: (0164)-3093113 / 09872780615 AAY AAR ELECTRONICS
SUNIL DISTRIBUTORS
Tel.: (0191)-2572884
Tel.: (0755)-5270228
JODHPUR
MELODY ELECTRONICS
BIKANER Bombay Motor Circle,
BHARTI ELECTRON IX Behind Rajasthan Bank.
Pardesio Ki Masjid , So dual Colony Tel.: 09414145724
Opp . Sainik Petrol Pump,
Tel.: 09414283725/09413481350 KANPUR
SERVE N CARE
CHANDiGARH 109/ 330A, Ram Krishan Nogar.
G. V. EL ECTRONICS Tel.: (0512)-2540330/3950190
S.C.O. 58, Sector 20 C.
Tel.: (0172)-3062347
KARNAL
DEHRADU N GUPTA ELECTRONICS
GORAKHPUR
RAGHUVANSH I SYSTEMS CORPORATION
KORBA
1st Floor, Near Reed Sahab Dhoramshala,
SHAKSHI ELECTRONICS
Adj. Petrol Pump, Betiahata. .
1-8-9, Professional Complex,
Tel. : (0551 )-3098961 / 09335717302
New Bus Stand, TP. Nagor.
Tel.:09827489452
GWALIOR
WAVE ENGINEERING
LUCKNOW CHENNAI
VIDEO FRIEND NATIONAL ELECTRONICS
W- 18, Sector-A, Mahanagar. 11/1 A, Leonard Street,
Tel.: (0522)-2321321/2376376 Opp. Pilot Talkies, Royopet\ah.
Tel.: (044)-28132404/28261229
LUDHIANA
RELIABLE SERVICE CENTRE
COCHIN
lind Floor, Walia Complex, Dugri Road .
CP AUTO IMPEX
Tel.: (0161)-3296646/5135984/
33/2380/A5, Near Kerala Auto Garage,
09872400438
Vaishali Bus Stop,
Tel.: (0186)-3098710
16-A, Satyamoorthy Road,
Ram Nagar.
JATIN ELECTRONICS
3-8, Ghuman Colony, HUBLI
Near No. 22 Rail Phatak. ANUROOP ELECTRONICS
Neelingin Road.
Tel.: 09419261389
Opp. Gov!. College.
Tel.: (0824)-2510922
UDAIPUR
NEW TECH SERVICE CENTRE
SECUNDERABAD
Ground Floor, Tak International Hotel,
THE SWASTIKS
Opp. Nashi Electricals, New 8apu Bazar.
Shop No. 27, Shellar Chennoy
Tel.: (0294)-5100530/09828144530
TrQde Cente':,. Park Lane.
Tel.: (040)-5,,228232
VARANASI
YETI T.V.HOUSE & SERVICES DEPOT
S 19/42,Varuna Bridge. TRIVANDRUM
Tel. : (0542)-2506195/2501969 CP AUTO IMPEX
Opp. S.B.T. Kesavadasapuram
Thiruvananthapuram.
AUTHORISED SERVICE CENTERS Tel.: (0471)-2551855
( SOUTH ZONE)
BANGALORE VIJAYWADA
HI-TECH SERVICE POINT SOUND 'N' SOUND
No. 277, 5th Cross, 6th Block Shop No.21, Hilton Tower,
Behind 8ethaney School Raja Gopalachariya Street
Koramangla . Near Upsara Theatre.
Tel.: (080)-51105959 / 09845006909 Tel.: (0866)-2578422
CALICUT VISAKHAPATNAM
SONYC VISION
FRIEDA ELECTRONICS
Wayanad Road.
5th Lane, Dwarakanagar.
Tel.:(0495)-3113667/2761567
Tel.: (0891)-2556575