Académique Documents
Professionnel Documents
Culture Documents
Contents:
Photo
1. Turn off the power to the control panel.
2. Remove the actuators plastic cover (six#10 hex
head cap screw).
3. Remove the gasket from the mounting plate.
4. Disconnect the potentiometer and motor wires.
5. Remove the gear-motor assembly with the
square tubing bracket, (for - 5/16” screws under the
mounting plate)
6. Remove the ¼” nut, washer, plastic gear and steel
gear from the command shaft. To remove the steel
gear, loosen the socket head set screw, which locks
the gear to the command shaft.
Installation of the optical slide valve actuator.