Académique Documents
Professionnel Documents
Culture Documents
Page 0 of 14
DIY GEEKS Socializing Technology
Figure 1
Figure 2
Page 1 of 14
DIY GEEKS Socializing Technology
Figure 3
Figure 4
Page 2 of 14
DIY GEEKS Socializing Technology
Figure 5
Figure 6
Page 3 of 14
DIY GEEKS Socializing Technology
Screw down the board using screws and nuts as shown below:
Figure 7
Figure 8
Page 4 of 14
DIY GEEKS Socializing Technology
Figure 9
Figure 10
Page 5 of 14
DIY GEEKS Socializing Technology
Figure 11
Figure 12
Page 6 of 14
DIY GEEKS Socializing Technology
Repeat the same step for the second motor. It should now look like this:
Figure 13
Page 7 of 14
DIY GEEKS Socializing Technology
Figure 14
Figure 15
Page 8 of 14
DIY GEEKS Socializing Technology
Figure 16
Figure 17
Page 9 of 14
DIY GEEKS Socializing Technology
Figure 18
Figure 19
Page 10 of 14
DIY GEEKS Socializing Technology
Figure 20
Page 11 of 14
DIY GEEKS Socializing Technology
Figure 21
Figure 22
Page 12 of 14
DIY GEEKS Socializing Technology
Trig pin is attached to pin 3 and Echo to pin 2, as shown by white and black wire below:
Figure 23
Similarly, VCC of ultrasonic sensor is attached to 5V pin of Arduino UNO and GND
to GND pin.
Figure 24
Page 13 of 14